Download SONY CDX-R3300EE - Service Manual. www.s

CDX-R3300EE
SERVICE MANUAL
East European Model
Ver 1.0 2004. 02
• The tuner and CD sections have no adjustments.
Model Name Using Similar Mechanism
NEW
CD Drive Mechanism Type
MG-611MA-186//Q
Optical Pick-up Name
KSS1000E
SPECIFICATIONS
CD player section
Signal-to-noise ratio
Frequency response
Wow and flutter
Power amplifier section
120 dB
10 – 20,000 Hz
Below measurable limit
Outputs
Speaker outputs
(sure seal connectors)
Speaker impedance
4 – 8 ohms
Maximum power output 50 W × 4 (at 4 ohms)
Tuner section
General
FM
Tuning range
FM1/FM2:
87.5 – 108 MHz
(at 50 kHz step)
FM3:
65 – 74 MHz
(at 30 kHz step)
Aerial terminal
External aerial connector
Intermediate frequency 10.7 MHz/450 kHz
Usable sensitivity
9 dBf
Selectivity
75 dB at 400 kHz
Signal-to-noise ratio
67 dB (stereo),
69 dB (mono)
Harmonic distortion at 1 kHz
0.5% (stereo),
0.3% (mono)
Separation
35 dB at 1 kHz
Frequency response
30 – 15,000 Hz
AM
Tuning range
Aerial terminal
Intermediate frequency
Sensitivity
Outputs
Inputs
Tone controls
Audio outputs terminal
(rear/sub switchable)
Power aerial relay control terminal
Power amplifier control terminal
Telephone ATT control terminal
Remote controller input terminal
Aerial input terminal
Low: ±10 dB at 60 Hz (XPLOD)
Mid: ±10 dB at 1 kHz (XPLOD)
High: ±10 dB at 10 kHz (XPLOD)
– Continued on next page –
531 – 1,602 kHz
External aerial connector
10.7 MHz/450 kHz
AM: 30 µV
FM/AM COMPACT DISC PLAYER
9-877-558-01
Sony Corporation
2004B04-1
e Vehicle Company
Published by Sony Engineering Corporation
© 2004. 02
1
CDX-R3300EE
Power requirements
Dimensions
Mounting dimensions
Mass
Supplied accessories
12 V DC car battery
(negative ground)
Approx. 178 × 50 × 179 mm
(w/h/d)
Approx. 182 × 53 × 161 mm
(w/h/d)
Approx. 1.2 kg
Parts for installation and connections (1 set)
Front panel case (1)
If the optical pick-up block is defective, please replace the whole
optical pick-up block.
Never turn the semi-fixed resistor located at the side of optical
pick-up block.
optical pick-up
Design and specifications are subject to change without
notice.
SERVICE NOTES
This label is located on the bottom of the chassis.
NOTES ON HANDLING THE OPTICAL PICK-UP BLOCK
OR BASE UNIT
The laser diode in the optical pick-up block may suffer electrostatic
breakdown because of the potential difference generated by the
charged electrostatic load, etc. on clothing and the human body.
During repair, pay attention to electrostatic breakdown and also use
the procedure in the printed matter which is included in the repair
parts.
The flexible board is easily damaged and should be handled with
care.
NOTES ON LASER DIODE EMISSION CHECK
The laser beam on this model is concentrated so as to be focused on
the disc reflective surface by the objective lens in the optical pickup block. Therefore, when checking the laser diode emission, observe from more than 30 cm away from the objective lens.
semi-fixed resistor
TEST DISCS
This set can playback CD-R and CD-ROM discs. The following
test discs should be used to check the capability:
CD-R test disc TCD-R082LMT (Part No. J-2502-063-1)
CD-RW test disc TCD-W082L (Part No. J-2502-063-2)
Notes on CD-R/CD-RW discs
• You can play CD-Rs (recordable CDs)/CD-RWs (rewritable CDs)
designed for audio use on this unit.
Look for these marks to distinguish CD-Rs/CD-RWs for audio
use.
Notes on Chip Component Replacement
• Never reuse a disconnected chip component.
• Notice that the minus side of a tantalum capacitor may be damaged by heat.
These marks denote that a disc is not for audio use.
• Some CD-Rs/CD-RWs (depending on the equipment used for
its recording or the condition of the disc) may not play on this
unit.
• You cannot play a CD-R/a CD-RW that is not finalized*.
* A process necessary for a recorded CD-R/CD-RW disc to be
played on the audio CD player.
SAFETY-RELATED COMPONENT WARNING!!
COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINE
WITH MARK 0 ON THE SCHEMATIC DIAGRAMS AND IN
THE PARTS LIST ARE CRITICAL TO SAFE OPERATION.
REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE
PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR
IN SUPPLEMENTS PUBLISHED BY SONY.
2
CDX-R3300EE
z
UNLEADED SOLDER
Boards requiring use of unleaded solder are printed with the lead
free mark (LF) indicating the solder contains no lead.
(Caution: Some printed circuit boards may not come printed with
the lead free mark due to their particular size.)
: LEAD FREE MARK
Unleaded solder has the following characteristics.
• Unleaded solder melts at a temperature about 40°C higher than
ordinary solder.
Ordinary soldering irons can be used but the iron tip has to be
applied to the solder joint for a slightly longer time.
Soldering irons using a temperature regulator should be set to
about 350°C.
Caution: The printed pattern (copper foil) may peel away if the
heated tip is applied for too long, so be careful!
• Strong viscosity
Unleaded solder is more viscous (sticky, less prone to flow)
than ordinary solder so use caution not to let solder bridges
occur such as on IC pins, etc.
• Usable with ordinary solder
It is best to use only unleaded solder but unleaded solder may
also be added to ordinary solder.
EXTENSION CABLE AND SERVICE POSITION
When repairing or servicing this set, connect the jig (extension cable)
as shown below.
• Connect the MAIN board (CN350) and the SERVO board (CN2)
with the extension cable (Part No. J-2502-076-1).
MAIN BOARD
CN350
J-2502-076-1
SERVO BOARD
CN2
3
CDX-R3300EE
TABLE OF CONTENTS
1. GENERAL
Location of controls ................................................................. 5
Connections ............................................................................. 6
2. DISASSEMBLY
2-1. Sub Panel Assy .................................................................... 8
2-2. CD Mechanism Block ......................................................... 9
2-3. Main Board ......................................................................... 9
2-4. Chassis (T) Sub Assy ........................................................ 10
2-5. Roller Arm Assy ................................................................ 10
2-6. Chassis (OP) Assy ............................................................. 11
2-7. Optical Pick-up ................................................................. 11
2-8. SL Motor Assy (M902) ..................................................... 12
2-9. LE Motor Assy (M903) ..................................................... 12
2-10. Servo Board ....................................................................... 13
3. DIAGRAMS
3-1. IC Pin Descriptions ........................................................... 14
3-2. Block Diagram –CD Section– ........................................... 19
3-3. Block Diagram –Tuner Section– ....................................... 20
3-4. Block Diagram –Display Section– .................................... 21
3-5. Printed Wiring Boards –CD Mechanism Section– ............ 22
3-6. Schematic Diagram –CD Mechanism Section (1/2)– ....... 23
3-7. Schematic Diagram –CD Mechanism Section (2/2)– ....... 24
3-8. Printed Wiring Board –Main Section– .............................. 25
3-9. Schematic Diagram –Main Section (1/2)– ........................ 26
3-10. Schematic Diagram –Main Section (2/2)– ........................ 27
3-11. Printed Wiring Board –Key Section– ................................ 28
3-12. Schematic Diagram –Key Section– ................................... 29
3-13. IC Block Diagrams ............................................................ 30
4. EXPLODED VIEWS
4-1.
4-2.
4-3.
4-4.
4-5.
4-6.
Main Section ..................................................................... 32
Front Panel Section ........................................................... 33
CD Mechanism Section (1) ............................................... 34
CD Mechanism Section (2) ............................................... 35
CD Mechanism Section (3) ............................................... 36
CD Mechanism Section (4) ............................................... 37
5. ELECTRICAL PARTS LIST ........................................ 38
4
CDX-R3300EE
SECTION 1
GENERAL
This section is extracted
from instruction manual.
5
CDX-R3300EE
Connections
6
CDX-R3300EE
7
CDX-R3300EE
SECTION 2
DISASSEMBLY
Note : This set can be disassemble according to the following sequence.
SET
2-1.
SUB PANEL ASSY
(Page 8)
2-2.
CD MECHANISM BLOCK
(Page 9)
2-3.
MAIN BOARD
(Page 9)
2-7.
2-4.
CHASSIS (T) SUB ASSY
(Page 10)
2-5.
ROLLER ARM ASSY
(Page 10)
2-6.
CHASSIS (OP) ASSY
(Page 11)
2-8.
SL MOTOR ASSY (M902)
(Page 12)
2-10. SERVO BOARD
(Page 13)
2-9.
OPTICAL PICK-UP
(Page 11)
LE MOTOR ASSY (M903)
(Page 12)
Note : Follow the disassembly procedure in the numerical order given.
2-1. SUB PANEL ASSY
3 two claws
2 two claws
1 two screws
(+PTT 2.6 x 6)
4 sub panel assy
8
CDX-R3300EE
2-2. CD MECHANISM BLOCK
7 bracket (CD)
5 CD mechanism block
6 two screws
(+PTT 2.6 x 4)
2 screw
(+PTT 2.6 x 6)
3
1 screw
(+PTT 2.6 x 6)
4 CN350
2-3. MAIN BOARD
1 three ground point screws
(+PTT 2.6 x 6)
2 two screws
(+PTT 2.6 x 8)
3 MAIN board
4 insulating sheet
9
CDX-R3300EE
2-4. CHASSIS (T) SUB ASSY
4 claw
2 two screws
(+P 1.7 x 2.2)
1 two screws
(+P 1.7 x 2.2)
6 chassis (T) sub assy
5 SENSOR board
3 claw
2-5. ROLLER ARM ASSY
3 washer
5 roller arm assy
4 worm wheel (RA)
2 spring (RAR)
1 spring (RAL)
10
CDX-R3300EE
2-6. CHASSIS (OP) ASSY
8
qa chassis (OP) assy
0 coil spring (damper)
lever (D)
4 washer
6
1 CN1
9 two coil springs (damper)
5 gear (LE1)
7
slider (R)
3 tension coil spring (KF)
2 Remove the six solderings.
2-7. OPTICAL PICK-UP
2 chucking arm sub assy
5 claw
1 tension coil spring (CHKG)
7 optical pick-up
6 main shaft
4 rack (SL)
3 screw
(+B 1.4 x 5)
11
CDX-R3300EE
2-8. SL MOTOR ASSY (M902)
1 screw
(+P 1.4 x 1.8)
2 SL motor assy (M902)
2-9. LE MOTOR ASSY (M903)
0 woam (LEB) assy
8 screw
(+M 1.7 x 2.5)
9 bearing (LEB)
qf two toothed lock screws
(+M 1.4 )
qa screw
(+M 1.7 x 2.5)
2 washer
3 gear (LE1)
lever (D)
4
bracket (LEM)
qs screw
(+M 1.7 x 2.5)
qd
qg LE motor assy
(M903)
5
6 screw
(+P 1.7 x 2.2)
slider (R)
7 leaf spring (LE)
1 Remove the two solderings.
12
CDX-R3300EE
2-10. SERVO BOARD
1 Remove the eight solderings.
6 SERVO board
2 Remove the three solderings.
4 toothed lock screw
(M 1.7)
5 claw
3 CN1
13
CDX-R3300EE
SECTION 3
DIAGRAMS
3-1. IC PIN DESCRIPTIONS
• IC3 CXD3059AR (DIGITAL SERVO/DIGITAL SIGNAL PROCESSOR) (SERVO BOARD (1/2))
Pin No.
Pin Name
I/O
Pin Description
1
MIRR
I/O
Mirror signal input/output (Not used in this set)
14
2
3
DFCT
FOK
I/O
I/O
Defect signal input/output (Not used in this set)
Focus OK signal input/output
4
5
VSS
LOCK
—
I/O
Ground
Lock signal input/output (Not used in this set)
6
7
MDP
SSTP
O
I
Spindle motor servo control signal output
Disc most inner detection signal input (Fixed at L in this set)
8
9
IOVSS1
SFDR
—
O
Digital ground
Sled drive signal output (FWD direction)
10
11
SRDR
TFDR
O
O
Sled drive signal output (REV direction)
Tracking drive signal output (FWD direction)
12
13
TRDR
FFDR
O
O
Tracking drive signal output (REV direction)
Focus drive signal output (FWD direction)
14
15
FRDR
IOVDD1
O
—
Focus drive signal output (REV direction)
Digital power supply pin (+3.3 V)
16
17
AVDD0
AVSS0
—
—
Analog power supply pin (+3.2 V)
Analog ground
18
19
NC
E
—
I
Not used. (Open)
E signal input
20
21
F
TEI
I
I
F signal input
Tracking error signal input
22
23
24
TEO
FEI
FEO
O
I
O
Tracking error signal output
Focus error signal input
Focus error signal output
25
26
VC
A
I/O
I
27
28
B
C
I
I
29
30
D
NC
I
—
D signal input
Not used. (Open)
31
32
AVDD4
RFDCO
—
I/O
Analog power supply pin (+3.2 V)
RFDC signal input/output (Not used in this set)
33
34
PDSENS
AC_SUM
I
O
Reference voltage input (Fixed at L in this set)
RFAC summing amplifier signal output
35
36
EQ_IN
LD
I
O
Equalizer circuit signal input
APC amplifier signal output
37
38
PD
NC
I
—
APC amplifier signal input
Not used. (Open)
39
40
RFC
AVSS4
I
—
EQ cut off frequency adjustment input
Analog ground
41
42
RFACO
RFACI
O
I
RFAC signal output
RFAC signal input
43
44
AVDD3
BIAS
—
I
Analog power supply pin (+3.2 V)
Asymmetry circuit constant current input
45
46
ASYI
ASYO
I
O
Asymmetry comparate voltage input
EFM full swing signal output
47
48
VPCO
VCTL
O
I
Charge pump output
VCO2 control voltage input
49
50
AVSS3
CLTV
—
I
Analog ground
VCO1 control voltage input
51
FILO
O
Filter signal output
VC voltage output/Center voltage input
A signal input
B signal input
C signal input
CDX-R3300EE
Pin No.
52
Pin Name
FILI
I/O
I
Filter signal input
Pin Description
53
54
PCO
AVDD5
O
—
Charge pump output
Analog power supply pin (+3.3 V)
55
56
DDVROUT
DDVRSEN
O
I
DC/DC converter output
DC/DC converter output voltage monitor signal input
57
58
AVSS5
DDCR
—
I
Analog ground
Reset signal input
59
60
NC
BCKI
—
I
Not used. (Open)
D/A interface bit clock signal input
61
62
PCMDI
LRCKI
I
I
D/A interface serial data signal input
D/A interface LR clock signal input
63
64
LRCK
VSS
O
—
D/A interface LR clock signal output
Ground
65
66
PCMD
BCK
O
O
D/A interface serial data signal output
D/A interface bit clock signal output
67
68
VDD
EMPH
—
O
Power supply pin (+2.6 V)
Not used. (Open)
69
70
EMPHI
IOVDD2
I
—
Not used. (Fixed at L in this set)
Digital power supply pin (+3.3 V)
71
72, 73
DOUT
TEST
—
I
Digital out signal output (Not used in this set)
Test pin (Normally, fixed at L)
74
75
IOVSS2
NC
—
—
Digital ground
Not used. (Open)
76
77
78
XVSS
XTAO
XTAI
—
O
I
Ground
Master clock signal output (16.9344 MHz)
Master clock signal input (16.9344 MHz)
79
80
XVDD
AVDD1
—
—
Power supply pin (+2.6 V)
Analog power supply pin (+3.3 V)
81
82
AOUT1
VREFL
O
O
L channel analog signal output
L channel reference voltage output
83, 84
85
AVSS1,AVSS2
VREFR
—
O
Analog ground
R channel reference voltage output
86
87
AOUT2
AVDD2
O
—
R channel analog signal output
Analog power supply pin (+3.3 V)
88
89
NC
IOVDD0
—
—
Not used. (Open)
Digital power supply pin (+3.3 V)
90
91
RMUT
LMUT
O
O
R channel “0” detection flug output
L channel “0” detection flug output
92
93
NC
XTSL
—
I
Not used. (Open)
Sub clock signal input (Fixed at L in this set)
94
95
IOVSS0
XTACN
—
I
Digital ground
Oscillation circuit control signal input (Fixed at H in this set)
96
97
SQSO
SQCK
O
I
Sub 80 bit, PCM peak and level data signal output
Clock signal input
98
99
SBSO
EXCK
O
I
Sub P-W serial data signal output (Not used in this set)
Clock signal input (Not used in this set)
100
101
XRST
SYSM
I
I
System reset signal input
Mute signal input (Fixed at L in this set)
102
103
DATA
VSS
I
—
104
105
XLAT
CLOK
I
I
106
VDD
—
Serial data signal input
Ground
Latch signal input
Serial data transfer clock signal input
Power supply pin (+2.6 V)
15
CDX-R3300EE
Pin No.
107
Pin Name
SENS
I/O
O
SENS signal output
108
109
SCLK
ATSK
I
I/O
Clock signal input
Input/output for anti-shock. (Fixed at L in this set)
110
111
WFCK
XUGF
O
O
WFCK signal output (Not used in this set)
XUGF signal output (Not used in this set)
112
113
XPCK
GFS
O
O
XPCK signal output (Not used in this set)
GFS signal output
114
115
C2PO
SCOR
O
O
C2PO signal output
Sub code sync signal output
116
117
VDD
C4M
—
O
Power supply pin (+2.6 V)
4.2366 MHz signal output (Not used in this set)
118
119
WDCK
COUT
O
I/O
Word clock signal output (Not used in this set)
Track count signal output/output (Not used in this set)
120
NC
—
Not used. (Open)
16
Pin Description
CDX-R3300EE
• IC500 MN101E01KDK (SYSTEM CONTROL) (MAIN BOARD (2/2))
Pin No.
Pin Name
I/O
Pin Description
1
DAVDD
—
D/A converter power supply (+) pin (+3.3 V)
2
3
NCO
DAVSS
O
—
Not used. (Open)
D/A converter power supply (–) pin
4
5
UNISO
UNISI
O
I
SONY-BUS data output (Not used in this set)
SONY-BUS data input (Not used in this set)
6
UNICKO
O
7
RETRA_SW
I
SONY-BUS clock output (Not used in this set)
Retractable CD door open/close detection switch input
8, 9
NCO
O
(L: CD door open, H: CD door close)
Not used. (Open)
10
11
VDD1
MMOD
—
I
Power supply pin (+3.3 V)
Not used. (Fixed at L in this set)
12
13
OSCOUT
OSCIN
O
I
Main clock output (27.648 MHz)
Main clock input (27.648 MHz)
14
15
VSS1
XIN
—
I
Ground
Sub clock input (32.768 kHz)
16
17
XOUT
VDD2
O
—
Sub clock output (32.768 kHz)
Power supply pin (+3.3 V)
18
19
MOD1
RESET
—
I
Not used. (Fixed at H in this set)
Microcomputer reset input
20
21
RCIN1
ACCIN
I
I
Rotary commander SHIFT key input
Accessory power supply detection input
22
23
TESTIN
TELATT
I
I
Test mode detection input
Telephone attenuator detection input
24
25
26
ATT
ADON
NCO
O
O
O
Audio mute control output
A/D converter power supply control output
Not used. (Open)
27
28
KEYACK
TUATTIN
I
I
Key acknowledge detection input
Not used. (Fixed at L in this set)
29
30
CDON
CDMON
I
I
Servo power supply control input from CD system control IC.
Loading 6V power supply control input from CD system control IC.
31
32 to 35
BUIN
NCO
I
O
Backup power supply detection input
Not used. (Open)
36
37
BUSON
SYSRST
O
O
BUS ON output to CD system control IC.
System reset output to CD system control IC.
38 to 41
42
NCO
Z_MUTE
O
I
Not used. (Open)
Mute zero cross detection input from CD system control IC.
43 to 49
50
NCO
BBESEL
O
I
Not used. (Open)
Fixed at H in this set.
51
52
NCO
AREASEL1
O
I
Not used. (Open)
Destination area initial setting input (Fixed at L in this set)
53
54 to 56
AREASEL0
NCO
I
O
Destination area initial setting input (Fixed at H in this set)
Not used. (Open)
57
58
EJECT_OK_SW
PANELSW
O
I
Eject OK output
Front panel detach detection input (L: with front panel, H: without front panel)
59
60
DIAG
VOLATT
I
O
Mode input from power amp IC.
Attenuator control output to electronic volume IC.
61
62
NOSESW
NCO
O
O
Not used. (Open)
Not used. (Open)
63
64
VSS2
TUATT
—
O
Ground
Tuner mute control output
65
66
NCO (TUON)
NSMASK
O
O
Not used. (Open)
Not used. (Open)
17
CDX-R3300EE
Pin No.
67
Pin Name
E2P_CKO
I/O
O
Pin Description
Serial clock output to EEPROM communication.
68
69
E2P_SIO
DOORIND
I/O
O
Serial data input/output with EEPROM communication.
Not used. (Open)
70
71
AMPSTB
NCO
O
O
Standby control output to power amp IC.
Not used. (Open)
72
73
FLS.SO/LCDSO
FLS.SI/LCDCE
O
O
Serial data output to LCD driver IC.
Chip enable output to LCD driver IC.
74
75 to 78
LCDCKO
NCO
O
O
Serial clock output to LCD driver IC.
Not used. (Open)
79
80
I2C_SIO
NCO
I/O
O
I2C bus serial data input/output
Not used. (Open)
81
82
I2C_CKO
DAVN
O
I
I2C bus serial clock output
Not used. (Fixed at L in this set)
83
84
SIRCS
NCO
I
O
SIRCS signal input
Not used. (Open)
85
86 to 88
BEEP
NCO
O
O
Beep output to power amp IC.
Not used. (Open)
89
90
VDD3
NCO
—
O
Power supply pin (+3.3 V)
Not used. (Open)
91
92
VSS3
QUALITY
—
I
Ground
Not used. (Fixed at L in this set)
93
94, 95
VSM
KEYIN1, 0
I
I
S-meter voltage detection input
Key input 1, 0
96
97 to 99
100
RCIN0
NCO
VREF+
I
O
—
18
Rotary commander key input
Not used. (Open)
A/D converter power supply (+) pin (+3.3 V)
PD
LASER DIODE
(TRACKING)
(FOCUS)
2-AXIS DEVICE
PD2
TRK–
TRK+
FCS–
FCS+
PD
LD
F
E
PD1
LD
OPTICAL
PICK-UP BLOCK
(KSS1000E)
F
E
PD2
PD1
DETECTOR
M
M
M
M902
(SLED)
M901
(SPINDLE)
M903
(LOADING)
LD DRIVE
Q1
PD 37
TEO 22
FEO 24
RFACO 41
45 ASYI
6 MDP
VIN4– 32
VIN3+ 25
7 VO4–
8 VO3+
4 VOL–
5 VOL+
SW1
(DOWN)
X2
18.43MHz
41 DRON
42 MEC_LIMIT
45 MEC_INSW
53 MEC_SELFSW
44 MEC EJECT
19
SW4
(LIMIT)
SW3
(DISC IN)
SW2
(SELF)
43 MEC LOAD
19
66
60
61
63
62
65
46 MEC_DSW
80 X0
EJECT OK 61
MECON 63
CDON 64
ZMUTE 66
DEC XMUTE
DEC SSTBY
DEC XRST
DEC STBY
DEC INT
DEC SCL
DEC SDA
EMPH
37
27
28
29
30
31
32
69
DECON 65
CDON CHK 68
+1.5V
VDDT+3.3V
+1.5V
CONTROL
Q2,3
+3.3V
MECH+6V
6 UNICKO
CLCK
SRMSTB
RESET
STANDBY
BUCK
I2C SCL
I2C SDA
BUSO
BCK1A
BCK1B
SD0O
LRCK1A
LRCK1B
SD1O
22
41
2
3
36
7
6
28
15
18
11
16
19
14
AUDIO INTERFACE
IC8
+3.3V
CONTROL
Q5,6
VDD 1
CE 3
+1.5V REG
IC7
EJECK OK SW
CDM ON
CD ON
Z MUTE
5 VOUT
97
30
29
42
4 UNISO
36 BUSON
5 UNISI
BUS ON 50
D601
BU IN
SYS RST
M-ATT
CD-L
SYSTEM CONTROL
IC500 (1/3)
56
25
57
26
58
UNISI
RXD
UNISO
TXD
UNICLK
BU IN 51
RSTX 75
A ATT 60
: CD
• R-ch is omitted due to same as L-ch.
• Signal path
CD
SYSTEM CONTROL
IC4
MECON CHK 67
CD FOK
CD SQSO
CD SQCK
CD XRST
CD DATA
CD XLAT
CD CLOK
CD SENS
CD SCLK
CD GFS
CD C2PO
CD SCOR
81 X1
19
16
18
15
14
13
12
11
10
8
7
52
REV 2
BCK
BCKI
PCMDI
LRCK
LRCKI
PCMD
XTAO 77
XTAI 78
3
96
97
100
102
104
105
107
108
113
114
115
23 CD RMUT
FOK
SQSO
SQCK
XRST
DATA
XLAT
CLOK
SENS
SCLK
GFS
C2PO
SCOR
22 CD LMUT
LMUT 91
X1
16.9344MHz
R-CH
RMUT 90
AOUT2 86
AOUT1 81
FWD 1
MUTE 34
9 SFDR
10 SRDR
VIN4+ 31
6 VO4+
9 VO3–
12 TRDR
11 TFDR
14 FRDR
13 FFDR
RF AMP,DIGITAL SERVO,
DIGITAL SIGNAL PROCESSOR
IC3
ASYO 46
VIN1–B 18
VIN1+B 19
VIN2– 21
VIN2+ 22
21 TEI
23 FEI
42 RFACI
12 VO1+
13 VO1–
10 VO2+
11 VO2–
FOCUS/TRACKING COIL DRIVE,
SLED/SPINDLE/LOADING
MOTOR DRIVE
IC1
36 LD
20 F
19 E
29 D
28 C
27 B
26 A
3-2. BLOCK DIAGRAM — CD SECTION —
I-V AMP
MAIN
SECTION
(Page 20)
MAIN
SECTION
(Page 20)
+3.3V
B
A
CDX-R3300EE
J1
(ANTENNA)
1 ANT
B2
VDD5V 11
B
CD
SECTION
(Page 19)
M-ATT
BU IN
SYS RST
64 TU_ATT
VCC8.3V 10
I2C
BUS
20
RESET 19
SYSRST 37
BUIN 31
DIAG 59
ATT 24
TESTIN 22
ACCIN 21
TELATT 23
AMPSTB 70
BEEP 85
SYSTEM CONTROL
IC500 (2/3)
MUTE
60 VOLATT
29
SDA
31
SCL
30
7
TUN MUTE 7
AUDIO 8.3V
TU-L
68 EEP_SIO
67 EEP_CKO
+5V REG.
Q3
R-CH
E2P-SDA 17
E2P-SCL 16
R-CH
CDR
9
C2
BUS-LCH
93 VSM
79 I2C_SIO
81 I2C_CKO
R 3
L 4
A
CD
(Page 19) SECTION
CDL
CD-L
NC 5
S-METER 6
SDA 14
SCL 13
TUNER UNIT
TU1
3-3. BLOCK DIAGRAM — TUNER SECTION —
D493
CONT.
EVR
20
BATT
TONE
EFFECT
SOUND CONTROL
ELECTRONIC VOLUME
IC400
INPUT SELECTOR
CDX-R3300EE
D351
SUB-L
RL
FL
1 RESET 4
IC502
S103
(RESET)
BACK-UP CHECK/
LOW VOLTAGE
CHECK
Q606,607
LINE MUTE
CONTROL
Q491,492
17
OUTS2
22
OUTR2
23
OUTF2
3.3V
OVER VOLTAGE
DET.
Q605,D602,603
MUTE
Q480
MUTE
Q450
MUTE
Q440
BATT
25 DIAG
B.UP+B 37
PANEL+B 34
MECH 6V 33
SERVO 3.3V 31
AUDIO +B 30
VP 35
ANT-REM 27
AMP-REM 29
MULTIPLE VOLTAGE
REGULATOR
IC300 (2/2)
I2C
BUS
TEL
ATT
Q701
BATT
PANEL+B
MECH 6V
SERVO 3.3V
AUDIO 8.3V
3.3V
D301
D302
VP2 6
VP1 20
9
7
CONT.
5
3
ACC
CHECK
Q702
SDA
2
SCL
4
STB
22
BEEP
16
11
12
POWER AMP
IC300 (1/2)
MUTE
MUTE
F901
10A
L
R
8 GND
J400
AUDIO OUT REAR
16 +B (BATT)
18
17
19
6 ANT-R
5 AMP-R
15 TEST
7 ACC
13 ATT
3 RR+
11 RR-
4 FR+
12 FR-
2 RL+
10 RL-
1 FL+
9 FL-
CN700
-2
-1
• R-ch is omitted due to same as L-ch.
y y y : CD
: AM
: FM
• Signal path
R-CH
R-CH
J561
(REMOTE IN)
PANEL +B
S900-908,
910-922
KEY MATRIX
IC981
IC971
KEY ACK
SWITCH
Q501
X501
32.768kHz
4
REMOTE 3
RECEIVER
4 LCD DRIVE 3
CONTROL
D501
16 XOUT
15 XIN
83 SIRCS
20 RCIN1
96 RCIN0
25 ADON
27 KEYACK
94 KEYIN1
95 KEYIN0
RETRA_SW 7
OSCIN 13
OSCOUT 12
LCDSO 72
LCDCKO 74
LCDCE 73
SYSTEM CONTROL
IC500 (3/3)
3-4. BLOCK DIAGRAM — DISPLAY SECTION —
X500
27.648MHz
DIMMER ON/OFF
SWITCH
Q902
3
|
50
LED
DRIVER
Q901
PANEL +B
KEY
( ILLUMINATION
)
LED902-908,
910-922
LCD
LCD901
D962
D963
S961
OPEN
LED961
(DISC IND)
PANEL +B
LED931,932
(LCD BACK LIGHT)
COM4 51
|
|
COM1 54
SEG3
|
SEG50
PANEL +B
1 DIMMER
DATA
64 DI
CLK
63 CL
62 CE
LCD DRIVER
IC901
21
21
Caution:
Pattern face side:
(Side B)
Parts face side:
(Side A)
Parts on the pattern face side seen from the
pattern face are indicated.
Parts on the parts face side seen from the
parts face are indicated.
for printed wiring boards:
• X : parts extracted from the component side.
• Y : parts extracted from the conductor side.
a
•
: Through hole.
•
: Pattern from the side which enables seeing.
(The other layer’s patterns are not indicated.)
• A : B+ Line.
• Power voltage is dc 14.4V and fed with regulated dc power
supply from ACC and BATT cords.
• Voltages are taken with a VOM (Input impedance 10 M1).
Voltage variations may be noted due to normal production tolerances.
• Waveforms are taken with a oscilloscope.
Voltage variations may be noted due to normal production tolerances.
• Circled numbers refer to waveforms.
• Signal path.
F : FM
f : AM
J : CD
Note: The components identified by mark 0 or dotted line
with mark 0 are critical for safety.
Replace only with part number specified.
for schematic diagram:
• All capacitors are in µF unless otherwise noted. pF: µµF
50 WV or less are not indicated except for electrolytics
and tantalums.
• All resistors are in 1 and 1/4 W or less unless otherwise
specified.
•
%
: indicates tolerance.
f
•
: internal component.
• C : panel designation.
THIS NOTE IS COMMON FOR PRINTED WIRING
BOARDS AND SCHEMATIC DIAGRAMS.
(In addition to this, the necessary note is
printed in each block.)
wa
(TEI)
IC3
IC3
wd
wjwl
whwk
IC3
2
1
2.6Vp-p
qh
(XOUT)
2.8Vp-p
(OSCOUT)
32.768kHz
qs
Approx.
150mVp-p
(B, D)
27.648MHz
IC500
IC500
0V
0V
Approx.
150mVp-p
(A, C)
(FEI)
Approx. 100mVp-p
IC3
Approx. 100mVp-p
— Main Board —
4
3
2
1
(MODE: CD PLAY)
• Waveforms
— Servo Board —
7
6
5
ra
(RFACO)
(XTAO)
IC4
ia
(X1)
18.43MHz
uj
16.9344MHz
IC3
IC3
1Vp-p
2Vp-p
Approx.
0.8Vp-p
CDX-R3300EE
H
G
F
E
D
C
C74
R14
R15
R117
C2
C1
R149
R145
R140
B
R142
R85
R107
R64
C75
C11
C19
C86
C115
C91
R123
R111
R18
R141
R143
C92
IC8
R116
Q3
C33
IC1
R110
IC7
C85
R106
IC4
C58
C54
R109
Q2
R29
C41
R139
R56
R101
C56
R40
C77
R126
C83
R52
C8
R5
R114
C36
C14
R16
C59
X1
C22
C81
R148
R23
C39
R147
R25
R146
C30
R61
C49
C40
C38
C25
C32
C107
C57
R55
R43
R54
X2
R42
R37
R70
R24
R22
C42
R77
C28
C29
C34
R41
Q5
C60
C23
C24
C50
C47
SW1
Q1
R49
R44
R12 R7
C6
FB2
Q6
C44
C43
R46
C65
5
6
22
7
22
C4
8
R1
C37
C27
R68
9
C48
R79
R53
A
C63
C46
C64
R45
R72
4
R13
C55
IC3
R10
C13
R97
BP3
BP2
C53
3
R76
CN2
R6
R78
C10
10
R65
C16
C7
R4
R119
R81
C26
R26
R57
R3
R67
R28
R9
R19
R27
C18
R17
C67
R2
FB1
R87
R108
R8
R20
11
: Uses unleaded solder.
R98
2
R48
R136
C79
R127
1
C5
C45
R59
R60
R50
R92
R91
R47
R80
3-5. PRINTED WIRING BOARDS — CD MECHANISM SECTION — • Refer to page 21 for Common Note for Printed Wiring Boards.
BP1
R86
C21
C51
C110
C3
R99
R144
C109
CDX-R3300EE
R39
R11
R122
C66
C35
R38
R124
R133
C52
FB5
R62
R73
R128
R71
R74
R129
R115
R21
CN
R69
FM
FM
B8
B7
1
12
(Page 25)
SW3
SW2
13
Q1
Q2
Q3
Q5
Q6
C-4
B-2
B-2
A-2
A-2
• Semiconductor
Location
Ref. No. Location
IC1
G-2
IC3
C-10
IC4
E-2
IC7
B-2
IC8
C-2
14
TP35
TP34
TP33
TP32
TP29
TP30
TP28
TP27
TP26
TP24
TP25
TP23
TP22
TP21
C5
R1
C4
Note:
• Voltage is dc with respect to
ground under no-signal conditions.
no mark : CD PLAY
CN1
C25
C24
C23
C22
C29
C6
R23
R22
R64
C27
R29
R6
Q1
R24
BP3
R25
BP2
TP50
TP44
R7
TP61
TP71
TP140
TP60
TP59
R13
C28
TP57
C10
R12
TP45
TP63
TP62
C30
R40
C38
R41
C37
TP97
TP98
R38
TP96
C35
R50
TP94
R149
R48
TP344
TP343
C34
R52
C41
C39
C40
TP65
C33
IC3
R42
23
(Page 24)
R43
TP116
C42
R44
C45
R54
C47
R53
TP141
C46
R59
R55
R56
23
C64
C49
C50
C65
C48
R60
TP137
TP99
C107
R61
TP167
R72
R68
TP175
R70
R71
C53
C52
R79
R76
R78
C57
C55
TP56
TP48
TP49
TP47
TP51
R124
TP40
TP38
TP43
TP39
TP36
TP46
TP132
TP136
TP37
TP41
TP42
R133
TP135
TP133
FB5
R114
FB2
TP55
TP54
R65
TP53
TP128
TP139
TP129
TP72
TP123
R98
R97
C81
C60
R77
TP181
X1
C59
C58 TP180
C54
3-6. SCHEMATIC DIAGRAM — CD MECHANISM SECTION (1/2) — • Refer to page 21 for Common Note on Schematic Diagram and Waveforms.
R49
R46
C43
TP127
R45
C44
R67
CN2
(Page 27)
CDX-R3300EE
M902
M901
M903
SW1
SW2
SW3
TP16
TP15
TP14
TP13
TP18
TP17
TP20
TP19
TP12
TP9
TP11
TP8
C3
C2
C1
C63
R9
C16
C11
R11
R15
C14
R14
IC1
R99
R8
C26
R144
R10
IC B/D
R17
R18
R21
C13
C8
C7
R109
R108
C75
C18
C19
C21
R5
R4
R26 R27
R16
R117
C77
C115
TP230
TP231
C79 TP226
R3
R2
R28
R123
R19
R20
C86
R110
C32
TP249
TP7
X2
24
C91
R111
TP58
R37
IC8
C92
C36
R116
R39
24
R47
IC4
R147
R57
C110
C109
R127
R128
SW4
R136
R126
R146
R107
Q6
R101
R69
C51
Q5
BP1
(Page 23)
R62
• Refer to page 30 for IC Block Diagrams.
R148
R122
C74
TP52
C56
C83
IC B/D
R73
R119
3-7. SCHEMATIC DIAGRAM — CD MECHANISM SECTION (2/2) — • Refer to page 21 for Common Note on Schematic Diagram and Waveforms.
CDX-R3300EE
R129
IC7
R142
R143
R141
R140
R80
TP31
C66
R87
R85
R86
C67
R145
R74
R81
Q2
C85 R106
R139
R115
Q3
FB1
R92
R91
Note:
• Voltage is dc with respect to
ground under no-signal conditions.
no mark : CD PLAY
J
I
H
G
F
E
JW44
JW1
C8
TU1
R4
JW99
R526
R7
R6
JW45
D
JW129
JW2
R527
D108
R115
JW103
JC1
R5
D106
D105
JW47
D107
C2
C5
C6
R9
L1
C404
JW104
L2
R421
R109 R106
R108 R107
JW13
JW42
CN102
D103
D104
R432
C802
C431
C801
R431
R301
JW95
R528 R529
C303
C411
R480
R105
JW51
JW52
R101
C309
R471
JW110
JW111
JW112
C321
C520
C519
C514
D501
C517
C515
JC511
R517
R491
JW88
R492
R523 R524
JW91
JW90
JW89
C481
R481
JC303
C305
JW113
JW109
C310
C471
JW102
JW101
JW108
R430 R450
R470
C317
R102
(Page 28)
D102
D101
JC301
Q420
R404
R420 R440
JW93
JW94
C318
R103
C800
R452
JC423
JC403
R453
R433
Q430
R104
C319
JC504
JW98
JW97
JW96
R10
JW105
JW106
JC401
JC400
R443
C400
Q470
C441
JW40
R423
IC400
R441
C403
JW128
Q3
R302
JW3
C3
JW48
D2
JW49
C7
JW50
C421
JW4
C451
Q480
JW5
JW38
JW8
JC300
IC300
6
JC509
C518
C500
IC500
C492
JW126
C304
Q492
R507
R506
R533
R505
JW16
C316
Q491
R520
D492
D491
D307
Q440
JW39
JW7
Q450
R451
C
J1
JW92
JW115
JW86
B
JW6
C412
C803
JW9
JC304
JW117
D306
C452 C432
JW36
JW12
D305
JC302
C306
JW116
C506
R442 R422
JW11
C308
JW35
C516
C504
R472
JW14
C301
JC501
JW82
JW53
X500
Q701
R511
JC701
R532
X501
25
R112
C312
R704
L357
L355
S103
D301
JW75
F901
CN700
D302
8
L356
C355
L359
R703
R510
R509
R512
JW131
C320
C406
R513
D493
R508
R514
Q501
JC505
JC506
JW85
JW84
JW83
C512
7
JW81
C522
JW119
5
JW15
JW118
D309
C505
JW114
D308
C314
JW87
R530
D310
JC402
JC503
JW120
JW124
R482
C521
D312
C510
C491
JW17
C405
4
C511
D311
JW80
JW55
JW34
C501
JW78
JW56
D351
R708
R707
D601
R702
JW73
JW74
C995
C996
D701
R701
J400
Q702
3
JC502
JW33
JW79
C502
C702
JW121
JW18
JW32
C513
JW57
JC508
JW30
CN350
25
JW20
2
JW31
JW19
R706
JC702
C354
L353
JC703
JW69
JW70
JW71
JW68
R705
JW62
JW26
JW28
JW58
JW59
JW60
JW65
JW127
JC350
JW61
JW22
JW23
R535
JC601
L351
C703
C701
JW67
L352 R351
JW66
L354
C353
L358
JW76
D303
D304
D703
R709
JW125
9
D602
D603
R603
R604
JW64
R616
R615
Q607
Q606
Q605
D702
10
: Uses unleaded solder.
C352
C351
JW29
A
1
IC502
D704
3-8. PRINTED WIRING BOARD — MAIN SECTION — • Refer to page 21 for Common Note on Printed Wiring Boards.
L700
JW123
JW122
R370
R371
J561
JW24
(Page 22)
11
12
• Semiconductor Location
Ref. No.
Ref. No. Location
D602
D2
E-3
D603
D101
I-4
D701
D102
I-4
D702
D103
I-3
D703
D104
H-3
D704
D105
H-3
D106
H-3
IC300
D107
I-2
IC400
D108
I-2
IC500
D301
C-8
IC502
D302
C-8
D303
C-9
Q3
D304
C-9
Q420
D305
C-6
Q430
D306
C-6
Q440
D307
C-6
Q450
D308
C-6
Q470
D309
C-6
Q480
D310
C-6
Q491
D311
D-7
Q492
D312
D-7
Q501
D351
G-8
Q605
D491
E-6
Q606
D492
E-6
Q607
D493
F-7
Q701
D501
I-5
Q702
D601
H-8
13
F-3
B-4
C-4
B-4
C-4
B-3
B-3
E-6
E-6
G-7
F-10
F-10
F-10
G-7
G-8
B-6
E-4
H-6
H-8
Location
E-10
E-10
C-8
E-10
C-9
C-10
14
CDX-R3300EE
F901
CN700
L700
C703
D704
D702
R705
R709
D703
R701
D701
IC B/D
C701
R301
R302
C319
C317
C318
R706
C301
R704
R703
C702 R708
D309
JC300
Q702
Q701
R702
D311 D310
JC703
R707
D312
JC302 JC303
C303
C995
D308
JC702
JC701
C996
C304
D307
IC300
JC304
D306 D305
C800
C802
JC301
D301
D303
R423
R443
C316
26
D304
C305
C306
R453
C803
C506
C504
R433
C801
C321
C310
C309
C314 C320
C312
C308
26
R492
R491
Q491
JC401
JC400
(Page 27)
IC B/D
C405
C406
C403
C404
JC403
C491
C492
C400
JC402
D492
D491
Q450
Q430
Q470
Q480
Q440
Q420
R451
R452
R432
R431
R472
R482
R441
R442
R422
IC400
Q492
3-9. SCHEMATIC DIAGRAM — MAIN SECTION (1/2) — • Refer to page 21 for Common Note on Schematic Diagram and Waveforms.
• Refer to page 30 for IC Block Diagrams.
CDX-R3300EE
D302
D493
C451
C431
C441
C421
R421
JC423
R470
R480
R450
R420
R430
R440
R404
C411
C412
C481
C471
R481
R471
L2
D2
R7
C7
R9
C6
L1
R6
C5
R5
C8
C2
R4
C3
J1
J400
TU1
Note:
• Voltage is dc with respect to ground under no-signal
(detuned) condition.
no mark : FM
(
) : AM
<
> : CD PLAY
R10
Q3
JC1
C432
C452
J561
R370
R371
C353
D351
R351
JC350
L353
L354
C354
C351
L357
L355
L352
L356
C355
Q607
L351
CN350
Q606
(Page 23)
R603
R604
D602
L358
C352
D601
JC601
Q605
D603
R616
L359
R528
R524
JC511
R523
R520
S103
R112
R527
R526
R529
R517
27
27
C520
C515
IC500
C521
C514
R115
R101
R102
R103
R104
R105
R106
R107
R109
C516
C518
R108
C517
R530
C519
D501
R505
JC509
JC502
C500
R514
Q501
JC508
R535
C512
X501
R508
R513
JC504
D103
JC503
D102
JC505
D101
JC506
D106
R615
R533
D105
(Page 26)
D104
C513
R510
R506
R509
3-10. SCHEMATIC DIAGRAM — MAIN SECTION (2/2) — • Refer to page 21 for Common Note on Schematic Diagram and Waveforms.
D107
R511
D108
R532
R507
R512
C502
CN102
C501
C522
X500
C510
C511
IC502
(Page 29)
Note:
• Voltage is dc with respect to ground under no-signal
(detuned) condition.
no mark : FM
(
) : AM
<
> : CD PLAY
JC501
C505
CDX-R3300EE
I
H
G
F
E
D
S904
R905
R904
S901
S903
R906
R902
LED903
R945
S907
D963
S921
R921
LED921
• Semiconductor Location
Ref. No.
Ref. No. Location
IC971
D901
H-11
IC981
D902
G-11
D903
G-13
LED902
D962
H-5
LED903
D963
H-4
LED904
D964
H-5
LED905
D991
H-6
LED906
D992
H-9
LED907
LED908
IC901
H-8
R975
Q901
R974
R922
R907
R946
S908 LED908
LED907
R977
LED904
Q902
C
R903
LED932
D964
LED922
D962
S961
R987
S922
R989
LED905
R950 R949
R988
R951
R942
R991
A-14
D-3
D-2
A-1
B-1
D-4
D-5
R920
LED920
IC981
S920
Location
D-14
H-6
D991
B
R941
C981
S906
C996
S919
Ref. No.
LED910
LED911
LED912
LED913
LED914
LED915
LED916
LED917
LED918
LED919
R997
C991
LED906
C982
S905
28
Location
C-12
B-13
C-13
D-12
D-11
D-10
D-10
D-9
D-8
D-7
R919
LED919
28
G-4
H-4
Q901
Q902
S917
Location
D-6
D-6
C-3
C-11
C-4
B-7
IC901
R918
LED918
Ref. No.
LED920
LED921
LED922
LED931
LED932
LED961
S918
LCD901
LED961
R996
R994
9
S916
R938 R937
LED917
D992
C993 R993
C992
R917
8
R986
7
R984
6
LED916
C995
C994
R992 R985
R916
A
5
R915
R962
4
R961
S915
10
D902
LED915
R925
3
R995
2
R963
R983
CN901
R914
LED914
D901
S914
LED931
11
R957
R981
1
R924
R982
R926
: Uses unleaded solder.
S910
12
R955
R998
(Page 25)
R978
LED913
LED910
S913
R971
R912
R911
R901
D903
S900
S912
LED912
R932
LED911
S911
R913
13
R933
3-11. PRINTED WIRING BOARD — KEY SECTION — • Refer to page 21 for Common Note on Printed Wiring Boards.
R956
14
S902
IC971
R931
CDX-R3300EE
R972
LED902
C971
(Page
27)
CN901
D902
R983
R982
R981
R971
R978
D901
S908
S907
S906
S905
S904
S903
S902
S901
S900
D903
R913
R914
R915
R916
R917
R918
R902
R903
R904
R905
R906
R907
R922
R921
R920
R919
R912
R911
R938
R937
LED916
LED915
LED914
LED913
R901
LED902
LED911
R933
R932
R931
LED912
R941
S922
S921
S920
S919
S918
S917
S916
S915
S914
S913
S912
S911
S910
R942
LED920
LED919
LED918
LED917
R946
R945
LED903
LED907
LED908
LED921
LED905
LED906
R951
R950
R949
LED904
R974
LED922
R957
R956
R955
LED910
R924
29
R926
R925
Q902
Q901
D963
LED932
LED931
R975
D962
29
R977
S961
LED961
R963
R962
R961
D964
3-12. SCHEMATIC DIAGRAM — KEY SECTION — • Refer to page 21 for Common Note on Schematic Diagram.
R989
R988
R987
D991
R998
C971
C994
R993
R991 C981
C995
C996
D992
R992
C991
C993
C992
R997
C982
R972
R985
R986
R984
IC981
IC971
R996
R995
R994
LCD901
Note:
• Voltage is dc with respect to ground under no-signal
(detuned) condition.
no mark : FM
IC901
CDX-R3300EE
AMP-A
L
VIN1/VREF-SW
MUTE
24 VIN3-
25 VIN3+
26 REG-IN
27 REG-OUT
GND
28 VREF-OUT
29 VIN1-SW
30 VREF-IN
31 VIN4+
32 VIN4-
33 VIN4
34 MUTE
35 VCONT
VIN1-B 18
VIN1+A 17
VIN1-A 16
VIN1 15
AMP-B
H
19 VIN1+B
20 VIN2
21 VIN2-
22 VIN2+
BTL-AMP
OUTPUT
ON/OFF
36 S-GND
VCC1 14
LEVEL
SHIFT
LEVEL
SHIFT
LEVEL
SHIFT
LEVEL
SHIFT
OUTPUT
CONTROL
THERMAL SHUTDOWN
23 VIN3
INPUT
VO1- 13
VO1+ 12
VO2- 11
VO2+ 10
GND
VO3- 9
VO3+ 8
VO4- 7
VO4+ 6
VLO+ 5
VLO- 4
VCC2 3
REV 2
FWD 1
IC1 LA6560-TE-L-E
3-13. IC BLOCK DIAGRAMS
30
30
VREF
CURRENT
LIMIT
B.UP+B 37
VP 35
MECH6V 33
SERVO5V 31
AMP-REM 29
ANT-REM 27
DIAG 25
OUT-FR- 23
OUT-FR+ 21
OUT-RR- 19
OUT-RR+ 17
IN-RR 15
S-GND 13
IN-RL 11
OUT-RL+ 9
OUT-RL- 7
OUT-FL+ 5
OUT-FL- 3
TAB 1
BATTERY
DETECTION
REGULATOR
REFERENCE
VOLTAGE
SWITCH
SWITCH
CHIP DETECT/
DIAGNOSTIC
FR
RR
PROTECTION/
DIAGNOSTIC
RL
FL
IC300 TDA8588BJ/N2
CE 3
GND 2
VDD 1
IC7 R1114N151D-TR-FA
MUTE
LOADDUMP
PROTECTION
TEMPERATURE
PROTECTION
STANDBY/
MUTE
MUTE
CDX-R3300EE
REGULATOR
VP
I2C BUS
BACK-UP
SWITCH
ENABLE
LOGIC
4 NC
5 VOUT
36 CBU
34 PANEL+B
32 GND
30 AUDIO8.3V
28 CRES
26 RST
24 PGND1
22 STB
20 VP1
18 PGND2
16 BEEP
14 IN-FR
12 IN-FL
10 SVR
8 PGND3
6 VP2
4 SCL
2 SDA
CDX-R3300EE
DGND
SDA
SCL
MUTE
SEL
ADJ
VCC
OUTF1
OUTR1
OUTF2
OUTR2
DS12
DS22
DS32
OUTS1
OUTS2
IC400 BD3808FS-FE2
32
31
30
29
28
27
26
25
24
23
22
21
20
19
18
17
VCC
I2C BUS
LOGIC
FADER
(0~-58,
-'dB)
VCO
FADER
(0~-58,
-'dB)
FADER
(0~-58,
-'dB)
EFFECT (0dB~
+20dB,2dB STEP)
BASS
fo:60,70,80,100,120,140,160,200Hz
Q:0.5,0.75,1,1.25
FADER
(0~-58,
-'dB)
EFFECT (0dB~
+20dB,2dB STEP)
GAIN+ATT
(+10~-29,
-'dB)
2ND ORDER LPF
fc:OFF,80,120,160Hz
Q: 0.707
2ND ORDER
LPF
MIX
TONE
PASS
TONE
PASS
MIDDLE
fo:500Hz,1kHz
Q:1
BASS,TREBLE, MIDDLE
(-15dB~+15dB,1dB STEP)
BASS,TREBLE, MIDDLE
(-15dB~+15dB,1dB STEP)
TABLE
fo:5,7.5,10,12.5kHz
VOLUME
(+23~-79dB,-'dB
1dB STEP)
VOLUME
(+23~-79dB,-'dB
1dB STEP)
fc:40kHz
fc:40kHz
ANTI-ALIASING
FILTER
ANTI-ALIASING
FILTER
INPUT GAIN
(0~15dB,1dB STEP)
INPUT GAIN
(0~15dB,1dB STEP)
MUTE
MUTE
INPUT SELECTOR
(4 STEREO INCLUDE 1 ISOLATION INPUT)
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
AGND
FIL
AP1
AN
AP2
B1
B2
C1
C2
D1
D2
DS11
DS21
DS31
NC
NC
VCC/2
31
CDX-R3300EE
SECTION 4
EXPLODED VIEWS
NOTE:
• The mechanical parts with no reference
number in the exploded views are not supplied.
• Items marked “*” are not stocked since
they are seldom required for routine service.
Some delay should be anticipated
when ordering these items.
• -XX and -X mean standardized parts, so
they may have some difference from the
original one.
• Color Indication of Appearance Parts
Example :
KNOB, BALANCE (WHITE) ... (RED)
R
R
Parts Color Cabinet’s Color
• Accessories are given in the last of this parts list.
The components identified by
mark 0 or dotted line with mark
0 are critical for safety.
Replace only with part number
specified.
4-1. MAIN SECTION
A
MG-611MA-186//Q
#2
#1
7
B
A
not supplied
F901
4
#6
not supplied
6
5
3
#1
not supplied
TU1
not supplied
B
2
#1
#1
1
Ref. No.
Part No.
Description
1
2
3
4
5
X-3384-176-2
3-042-244-11
X-3383-739-1
3-376-464-11
A-3283-513-A
PANEL SUB ASSY, SUB
SCREW (T)
LOCK ASSY (S)
SCREW (+PTT 2.6X6), GROUND POINT
MAIN BOARD, COMPLETE
6
3-246-481-01 PLATE (TU), GROUND
32
Remark
Ref. No.
Part No.
Description
7
F901
TU1
#1
#2
1-776-527-61
1-532-877-11
A-3220-961-A
7-685-792-09
7-685-790-01
CORD (WITH CONNECTOR) (ISO) (POWER)
FUSE (BLADE TYPE) (AUTO FUSE) 10A
TUNER UNIT (TUX-032//Q3)
SCREW +PTT 2.6X6 (S)
SCREW +PTT 2.6X4 (S)
Remark
#6
7-685-793-09 SCREW +PTT 2.6X8 (S)
CDX-R3300EE
4-2. FRONT PANEL SECTION
61
60
59
58
#3
not supplied
(KEY board)
not supplied
#3
57
LCD901
not supplied
64
55
53
56
51
not supplied
62
not supplied
not supplied
not
supplied
not supplied
54
63
52
not supplied
Ref. No.
Part No.
Description
51
52
53
54
55
X-3384-683-2
3-258-947-01
1-780-096-11
A-3372-541-A
X-3384-380-1
PANEL SUB ASSY, FRONT
FILTER (IR)
CONDUCTIVE BOARD, CONNECTION
RETRACTABLE ASSY
BUTTON ASSY (S)
56
57
58
3-246-479-01 SPRING (RELEASE)
3-258-952-01 SHEET (ILLUMINATOR)
3-258-948-01 PLATE (CD), LIGHT GUIDE
Remark
Ref. No.
59
60
61
62
63
Part No.
Description
3-258-937-01
X-3383-264-2
A-3372-774-A
3-266-165-01
3-266-163-01
PANEL, FRONT BACK
CASE ASSY (for FRONT PANEL)
PANEL COMPLETE ASSY, FRONT
SPACER (B)
SPACER (A)
Remark
64
3-253-896-11 SHEET (H), ADHESIVE
LCD901 1-805-451-11 DISPLAY PANEL, LIQUID CRYSTAL
#3
7-685-106-19 SCREW +P 2X10 TYPE2 NON-SLIT
33
CDX-R3300EE
4-3. CD MECHANISM SECTION (1)
(MG-611MA-186//Q)
not supplied
(SENSOR board)
102
101
109
#4
110
not supplied
not supplied
103
104
106
105
108
107
Ref. No.
Part No.
Description
101
102
103
104
105
A-3372-444-A
3-253-729-11
3-257-892-11
3-257-892-01
3-253-695-11
CHASSIS (T) SUB ASSY
SPRING (LTR), TENSION COIL
SPRING (DAMPER), COIL
SPRING (DAMPER), COIL
SPRING (KF), TENSION COIL
106
3-259-033-01 DAMPER (S)
34
Remark
Ref. No.
107
108
109
110
#4
Part No.
Description
3-352-758-31
A-3283-357-A
X-3384-088-1
X-3384-089-1
7-627-552-87
SCREW (M1.7), TOOTHED LOCK
SERVO BOARD, COMPLETE
LEVER (L) ASSY
LEVER (R) ASSY
SCREW, PRECISION +P 1.7X2.2
Remark
CDX-R3300EE
4-4. CD MECHANISM SECTION (2)
(MG-611MA-186//Q)
155
156
157
154
(including M901)
#5
M902
SW4
158
not supplied
not supplied
not supplied
153
not supplied
151
152
The components identified by
mark 0 or dotted line with mark
0 are critical for safety.
Replace only with part number
specified.
Ref. No.
Part No.
Description
151
152
0 153
154
155
A-3372-445-A
3-316-938-91
8-820-207-02
A-3372-448-A
A-3372-449-A
CHASSIS (OP) COMPLETE ASSY
SCREW (B1.4X5), TAPPING
OPTICAL PICK-UP (KSS1000E/K1RP)
CHASSIS (OP) SUB ASSY (including M901)
ARM SUB ASSY, CHUCKING
156
Remark
Ref. No.
157
158
M902
SW4
#5
Part No.
Description
X-3384-090-2
3-264-165-12
A-3372-447-A
1-571-099-11
7-627-850-77
LEVER (SL) ASSY
SCREW
MOTOR ASSY, SL (SLED)
SWITCH (1 KEY) (LIMIT)
SCREW, PRECISION +P 1.4X1.8
Remark
A-3372-446-A LEVER (SL) SUB ASSY
35
CDX-R3300EE
4-5. CD MECHANISM SECTION (3)
(MG-611MA-186//Q)
203
201
202
207
211
204
209
208
210
205
207
207
M903
#4
206
Ref. No.
Part No.
Description
201
202
203
204
205
3-348-993-01
3-259-024-01
A-3372-441-A
3-259-455-11
3-253-713-11
WASHER
WHEEL (RA), WORM
ARM ASSY, ROLLER
SPRING (RAL)
SPRING (RAR)
206
207
3-259-469-11 SPRING (LE), LEAF
2-134-636-21 SCREW (M1.7X2.5)
36
Remark
Ref. No.
Part No.
Description
208
209
210
211
M903
3-259-467-11
3-345-648-91
A-3372-450-A
3-259-468-11
A-3372-443-A
BRACKET (LEM)
SCREW (M1.4), TOOTHED LOCK
WORM (LEB) ASSY
BEARING (LEB)
MOTOR ASSY, LE (LOADING)
#4
7-627-552-87 SCREW, PRECISION +P 1.7X2.2
Remark
CDX-R3300EE
4-6. CD MECHANISM SECTION (4)
(MG-611MA-186//Q)
254
252
255
252
256
251
253
257
Ref. No.
251
252
253
254
Part No.
Description
3-259-429-11
3-344-223-01
3-259-470-11
3-253-755-12
WHEEL (LE), WORM
WASHER
GEAR (LE1)
LEVER (D)
Remark
Ref. No.
255
256
257
Part No.
Description
Remark
3-899-829-01 WASHER (SLIT)
3-259-032-01 GEAR (LE2)
A-3337-998-A CHASSIS (M) BLOCK ASSY
37
CDX-R3300EE
SECTION 5
ELECTRICAL PARTS LIST
KEY
NOTE:
• Due to standardization, replacements in
the parts list may be different from the
parts specified in the diagrams or the
components used on the set.
• -XX and -X mean standardized parts, so
they may have some difference from the
original one.
• RESISTORS
All resistors are in ohms.
METAL:Metal-film resistor.
METAL OXIDE: Metal oxide-film resistor.
F:nonflammable
Ref. No.
Part No.
• Items marked “*” are not stocked since
they are seldom required for routine service.
Some delay should be anticipated
when ordering these items.
• SEMICONDUCTORS
In each case, u : µ, for example:
uA.. : µA.. uPA.. : µPA..
uPB.. : µPB.. uPC.. : µPC.. uPD.. : µPD..
• CAPACITORS
uF : µF
• COILS
uH : µH
Description
Remark
KEY BOARD
**********
1-780-096-11 CONDUCTIVE BOARD, CONNECTION
3-258-952-01 SHEET (ILLUMINATOR)
< CAPACITOR >
C971
C981
C982
C991
C992
1-135-834-11
1-165-908-11
1-135-834-11
1-164-227-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
2.2uF
1uF
2.2uF
0.022uF
0.1uF
C993
C994
C995
C996
1-107-826-11
1-162-964-11
1-127-715-11
1-165-908-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.001uF
0.22uF
1uF
10%
10%
6.3V
10V
6.3V
25V
16V
10%
10%
10%
10%
16V
50V
16V
10V
10%
< CONNECTOR >
CN901
Ref. No.
The components identified by
mark 0 or dotted line with mark
0 are critical for safety.
Replace only with part number
specified.
When indicating parts by reference
number, please include the board.
Part No.
Description
Remark
LED907
LED908
LED910
LED911
LED912
6-500-450-01
6-500-450-01
6-500-450-01
6-500-450-01
6-500-450-01
LED
LED
LED
LED
LED
CL-195SR-CD-T (MODE)
CL-195SR-CD-T (SEL)
CL-195SR-CD-T (EQ3)
CL-195SR-CD-T (SEEK +/>/M)
CL-195SR-CD-T (SEEK –/./m)
LED913
LED914
LED915
LED916
LED917
6-500-450-01
6-500-450-01
6-500-450-01
6-500-450-01
6-500-450-01
LED
LED
LED
LED
LED
CL-195SR-CD-T (BTM)
CL-195SR-CD-T (SCRL)
CL-195SR-CD-T (SENS)
CL-195SR-CD-T (6)
CL-195SR-CD-T (5)
LED918
LED919
LED920
LED921
LED922
6-500-450-01
6-500-450-01
6-500-450-01
6-500-450-01
6-500-450-01
LED
LED
LED
LED
LED
CL-195SR-CD-T (4/SHUF)
CL-195SR-CD-T (3/REP)
CL-195SR-CD-T (2/ALBUM +)
CL-195SR-CD-T (1/ALBUM –)
CL-195SR-CD-T (DSPL)
LED931 6-500-459-01 LED NSCW505T-ARS (LCD BACK LIGHT R)
LED932 6-500-459-01 LED NSCW505T-ARS (LCD BACK LIGHT L)
LED961 8-719-082-38 LED CL-270SR-C-TS (DISC IND)
1-794-312-11 PIN, CONNECTOR 12P
< TRANSISTOR >
< DIODE >
D901
D902
D903
D962
D963
8-719-085-72
8-719-083-66
8-719-978-33
8-719-072-70
8-719-404-50
DIODE
DIODE
DIODE
DIODE
DIODE
UMZ6.8ENTR
UDZS-TE17-18B
DTZ-TT11-6.8B
MA2ZD14001S0
MA111-TX
D964
D991
D992
8-719-083-66 DIODE UDZS-TE17-18B
8-719-069-54 DIODE UDZS-TE17-5.1B
8-719-404-50 DIODE MA111-TX
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
680
680
680
1K
1.5K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R906
R907
R911
R912
R913
1-216-823-11
1-216-825-11
1-216-819-11
1-216-819-11
1-216-819-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1.5K
2.2K
680
680
680
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
< DIODE >
R914
R915
R916
R917
R918
1-216-821-11
1-216-823-11
1-216-823-11
1-216-825-11
1-216-827-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1.5K
1.5K
2.2K
3.3K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
LED
LED
LED
LED
LED
R919
R920
R921
R922
R924
1-216-829-11
1-218-867-11
1-216-833-11
1-216-835-11
1-216-805-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
4.7K
6.8K
10K
15K
47
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
6-705-180-01 IC LC75827W
6-600-163-01 IC RS-770 (IR)
6-705-374-01 IC MM3033DULE
LCD901 1-805-451-11 DISPLAY PANEL, LIQUID CRYSTAL
38
6-500-450-01
6-500-450-01
6-500-450-01
6-500-450-01
6-500-450-01
< RESISTOR >
1-216-819-11
1-216-819-11
1-216-819-11
1-216-821-11
1-216-823-11
< LIQUID CRYSTAL DISPLAY >
LED902
LED903
LED904
LED905
LED906
8-729-027-58 TRANSISTOR DTC143ZKA-T146
8-729-027-58 TRANSISTOR DTC143ZKA-T146
R901
R902
R903
R904
R905
< IC >
IC901
IC971
IC981
Q901
Q902
CL-195SR-CD-T (OFF)
CL-195SR-CD-T (SOURCE)
CL-195SR-CD-T (– (VOLUME))
CL-195SR-CD-T (ATT)
CL-195SR-CD-T (+ (VOLUME))
CDX-R3300EE
MAIN
KEY
Ref. No.
Part No.
Description
Remark
R925
R926
R931
R932
R933
1-216-807-11
1-216-805-11
1-216-809-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
68
47
100
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R937
R938
R941
R942
R945
1-216-811-11
1-216-803-11
1-216-811-11
1-216-803-11
1-216-811-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
150
33
150
33
150
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R946
R949
R950
R951
R955
1-216-803-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-813-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
33
100
100
100
220
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R956
R957
R961
R962
R963
1-216-811-11
1-216-817-11
1-216-815-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
150
470
330
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R971
R972
R974
R975
R977
1-216-817-11
1-216-817-11
1-216-817-11
1-216-845-11
1-216-864-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
470
470
470
100K
0
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R978
R981
R982
R983
R984
1-216-817-11
1-216-817-11
1-216-817-11
1-216-817-11
1-216-817-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
470
470
470
470
470
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R985
R986
R987
R988
R989
1-216-817-11
1-216-817-11
1-216-811-11
1-216-811-11
1-216-811-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
470
470
150
150
150
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R991
R992
R993
R994
R995
1-216-864-11
1-216-840-11
1-216-857-11
1-216-821-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
0
39K
1M
1K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R996
R997
R998
1-216-821-11 METAL CHIP
1-216-803-11 METAL CHIP
1-216-864-11 METAL CHIP
1K
33
0
5%
5%
5%
1/10W
1/10W
1/10W
< SWITCH >
S900
S901
S902
S903
S904
1-786-653-11
1-786-653-11
1-771-884-31
1-771-884-31
1-771-884-31
SWITCH, TACTILE (EJECT (R))
SWITCH, TACTILE (EJECT (L))
SWITCH, TACTILE (OFF)
SWITCH, TACTILE (SOURCE)
SWITCH, TACTILE (– (VOLUME))
S905
S906
S907
S908
S910
1-771-884-31
1-771-884-31
1-771-884-31
1-771-884-31
1-771-884-31
SWITCH, TACTILE (ATT)
SWITCH, TACTILE (+ (VOLUME))
SWITCH, TACTILE (MODE)
SWITCH, TACTILE (SEL)
SWITCH, TACTILE (EQ3)
S911
S912
S913
1-771-884-31 SWITCH, TACTILE (SEEK +/>/M)
1-771-884-31 SWITCH, TACTILE (SEEK –/./m)
1-771-884-31 SWITCH, TACTILE (BTM)
Ref. No.
S914
S915
S916
S917
S918
Part No.
Description
Remark
1-771-884-31
1-771-884-31
1-771-884-31
1-771-884-31
1-771-884-31
SWITCH, TACTILE (SCRL)
SWITCH, TACTILE (SENS)
SWITCH, TACTILE (6)
SWITCH, TACTILE (5)
SWITCH, TACTILE (4/SHUF)
S919
1-771-884-31 SWITCH, TACTILE (3/REP)
S920
1-771-884-31 SWITCH, TACTILE (2/ALBUM +)
S921
1-771-884-31 SWITCH, TACTILE (1/ALBUM –)
S922
1-771-884-31 SWITCH, TACTILE (DSPL)
S961
1-529-566-61 SWITCH, PUSH (1 KEY) (OPEN)
*************************************************************
A-3283-513-A MAIN BOARD, COMPLETE
*********************
7-685-134-19 SCREW +P 2.6X8 TYPE2 NON-SLIT
7-685-793-09 SCREW +PTT 2.6X8 (S)
7-685-795-09 SCREW +PTT 2.6X12 (S)
< CAPACITOR >
C2
C3
C5
C6
C7
1-126-947-11
1-162-970-11
1-126-947-11
1-162-970-11
1-162-970-11
ELECT
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
47uF
0.01uF
47uF
0.01uF
0.01uF
20%
10%
20%
10%
10%
16V
25V
16V
25V
25V
C8
C301
C303
C304
C305
1-115-412-11
1-115-340-11
1-128-551-11
1-115-340-11
1-125-891-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
680PF
0.22uF
22uF
0.22uF
0.47uF
5%
10%
20%
10%
10%
25V
25V
25V
25V
10V
C306
C308
C309
C310
C312
1-126-964-11
1-126-964-11
1-115-340-11
1-125-837-11
1-164-004-11
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
10uF
10uF
0.22uF
1uF
0.1uF
20%
20%
10%
10%
10%
50V
50V
25V
6.3V
25V
C314
C316
C317
C318
C319
1-126-964-11
1-126-964-11
1-126-961-11
1-162-923-11
1-127-715-11
ELECT
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
10uF
10uF
2.2uF
47PF
0.22uF
20%
20%
20%
5%
10%
50V
50V
50V
50V
16V
C320
C321
C351
C352
C353
1-126-947-11
1-126-964-11
1-128-551-11
1-128-551-11
1-128-551-11
ELECT
ELECT
ELECT
ELECT
ELECT
47uF
10uF
22uF
22uF
22uF
20%
20%
20%
20%
20%
16V
50V
25V
25V
25V
C354
C355
C400
C403
C404
1-162-970-11
1-128-551-11
1-126-964-11
1-127-715-11
1-127-715-11
CERAMIC CHIP
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
0.01uF
22uF
10uF
0.22uF
0.22uF
10%
20%
20%
10%
10%
25V
25V
50V
16V
16V
C405
C406
C411
C412
C421
1-126-960-11
1-126-960-11
1-162-970-11
1-126-947-11
1-126-964-11
ELECT
ELECT
CERAMIC CHIP
ELECT
ELECT
1uF
1uF
0.01uF
47uF
10uF
20%
20%
10%
20%
20%
50V
50V
25V
16V
50V
C431
C432
C441
C451
C452
1-126-964-11
1-163-251-11
1-126-964-11
1-126-964-11
1-163-251-11
ELECT
CERAMIC CHIP
ELECT
ELECT
CERAMIC CHIP
10uF
100PF
10uF
10uF
100PF
20%
5%
20%
20%
5%
50V
50V
50V
50V
50V
39
CDX-R3300EE
MAIN
Ref. No.
Part No.
Description
Remark
C471
C481
C491
C492
C500
1-126-964-11
1-126-964-11
1-126-947-11
1-107-826-11
1-162-970-11
ELECT
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
10uF
10uF
47uF
0.1uF
0.01uF
20%
20%
20%
10%
10%
50V
50V
16V
16V
25V
C501
C502
C504
C505
C506
1-162-970-11
1-104-665-11
1-162-970-11
1-125-710-11
1-126-924-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
DOUBLE LAYERS
ELECT
0.01uF
100uF
0.01uF
0.1F
330uF
10%
20%
10%
C510
C511
C512
C513
C514
1-162-916-11
1-162-917-11
1-162-970-11
1-162-970-11
1-162-970-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
C515
C516
C517
C518
C519
1-216-864-11
1-162-970-11
1-162-964-11
1-162-964-11
1-162-964-11
C520
C521
C522
C701
C702
Ref. No.
Part No.
Description
Remark
D311
D312
D351
D491
D492
8-719-200-82
8-719-200-82
8-719-041-79
8-719-404-50
8-719-036-94
DIODE
DIODE
DIODE
DIODE
DIODE
11ES2
11ES2
MA721WA-TX
MA111-TX
RD5.6SB-T1
20%
25V
10V
25V
5.5V
10V
D493
D501
D601
D602
D603
8-719-040-04
8-719-820-05
8-719-040-04
8-719-056-93
8-719-056-83
DIODE
DIODE
DIODE
DIODE
DIODE
MA721WK-(TX)
1SS181
MA721WK-(TX)
UDZ-TE-17-18B
UDZ-TE-17-6.8B
12PF
15PF
0.01uF
0.01uF
0.01uF
5%
5%
10%
10%
10%
50V
50V
25V
25V
25V
D701
D702
D703
D704
8-719-056-93
8-719-056-93
8-719-056-93
8-719-049-38
DIODE
DIODE
DIODE
DIODE
UDZ-TE-17-18B
UDZ-TE-17-18B
UDZ-TE-17-18B
1N5404TU
METAL CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0
0.01uF
0.001uF
0.001uF
0.001uF
5%
10%
10%
10%
10%
1/10W
25V
50V
50V
50V
1-216-864-11
1-126-964-11
1-125-837-11
1-131-868-81
1-126-961-11
METAL CHIP
ELECT
CERAMIC CHIP
ELECT
ELECT
0
10uF
1uF
3300uF
2.2uF
5%
20%
10%
20%
20%
1/10W
50V
6.3V
16V
50V
C703
C800
C801
C802
C803
1-163-038-11
1-125-891-11
1-125-891-11
1-125-891-11
1-125-891-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.47uF
0.47uF
0.47uF
0.47uF
10%
10%
10%
10%
25V
10V
10V
10V
10V
C995
C996
1-163-009-11 CERAMIC CHIP
1-163-009-11 CERAMIC CHIP
0.001uF
0.001uF
10%
10%
50V
50V
< IC >
< CONNECTOR >
CN102
CN350
CN700
1-794-311-21 PLUG, CONNECTOR 12P
1-817-536-11 CONNECTOR, BOARD TO BOARD 28P
1-774-701-21 PIN, CONNECTOR 16P
< DIODE >
D2
D101
D102
D103
D104
8-719-036-94
8-719-056-83
8-719-056-83
8-719-056-83
8-719-056-83
DIODE
DIODE
DIODE
DIODE
DIODE
RD5.6SB-T1
UDZ-TE-17-6.8B
UDZ-TE-17-6.8B
UDZ-TE-17-6.8B
UDZ-TE-17-6.8B
D105
D106
D107
D108
D301
8-719-056-83
8-719-056-83
8-719-056-83
8-719-056-83
8-719-200-82
DIODE
DIODE
DIODE
DIODE
DIODE
UDZ-TE-17-6.8B
UDZ-TE-17-6.8B
UDZ-TE-17-6.8B
UDZ-TE-17-6.8B
11ES2
D302
D303
D304
D305
D306
8-719-200-82
8-719-200-82
8-719-200-82
8-719-200-82
8-719-200-82
DIODE
DIODE
DIODE
DIODE
DIODE
11ES2
11ES2
11ES2
11ES2
11ES2
D307
D308
D309
D310
8-719-200-82
8-719-200-82
8-719-200-82
8-719-200-82
DIODE
DIODE
DIODE
DIODE
11ES2
11ES2
11ES2
11ES2
40
IC300
IC400
IC500
IC502
6-705-360-01
6-705-372-01
6-804-050-01
8-759-659-13
IC
IC
IC
IC
TDA8588BJ/N2
BD3808FS-FE2
MN101E01KDK
PST3428UL
< JACK >
J1
J400
J561
1-815-185-13 JACK (ANTENNA)
1-774-698-11 JACK, PIN 2P (AUDIO OUT REAR)
1-566-822-41 JACK (REMOTE IN)
< JUMPER RESISTOR >
JC1
JC300
JC301
JC302
JC303
1-216-296-11
1-216-296-11
1-216-296-11
1-216-296-11
1-216-296-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
JC304
JC350
JC400
JC401
JC402
1-216-864-11
1-216-296-11
1-216-864-11
1-216-296-11
1-216-864-11
METAL CHIP
SHORT CHIP
METAL CHIP
SHORT CHIP
METAL CHIP
0
0
0
0
0
5%
1/10W
5%
1/10W
5%
1/10W
JC403
JC423
JC501
JC502
JC503
1-216-864-11
1-216-864-11
1-216-864-11
1-216-296-11
1-216-864-11
METAL CHIP
METAL CHIP
METAL CHIP
SHORT CHIP
METAL CHIP
0
0
0
0
0
5%
5%
5%
1/10W
1/10W
1/10W
5%
1/10W
JC504
JC505
JC506
JC508
JC509
1-216-296-11
1-216-296-11
1-216-296-11
1-216-296-11
1-216-864-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
METAL CHIP
0
0
0
0
0
5%
1/10W
JC511
JC601
JC701
JC702
JC703
1-216-864-11
1-216-864-11
1-216-864-11
1-216-296-11
1-216-296-11
METAL CHIP
METAL CHIP
METAL CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
5%
5%
5%
1/10W
1/10W
1/10W
< COIL >
L1
L2
L351
L352
L353
1-469-844-11
1-469-844-11
1-500-245-11
1-500-245-11
1-469-876-11
INDUCTOR
2.2uH
INDUCTOR
2.2uH
INDUCTOR, FERRITE BEAD
INDUCTOR, FERRITE BEAD
INDUCTOR, FERRITE BEAD
CDX-R3300EE
MAIN
Ref. No.
Part No.
Description
Remark
L354
L355
L356
L357
L358
1-500-245-11
1-469-876-11
1-500-245-11
1-469-876-11
1-469-876-11
INDUCTOR, FERRITE BEAD
INDUCTOR, FERRITE BEAD
INDUCTOR, FERRITE BEAD
INDUCTOR, FERRITE BEAD
INDUCTOR, FERRITE BEAD
L359
L700
1-216-295-11 SHORT CHIP
1-456-617-11 COIL, CHOKE
0
250uH
< TRANSISTOR >
Q3
Q420
Q430
Q440
Q450
8-729-920-85
6-550-752-01
6-550-752-01
6-550-752-01
6-550-752-01
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SD1664-QR
DTC614TKT146
DTC614TKT146
DTC614TKT146
DTC614TKT146
Q470
Q480
Q491
Q492
Q501
6-550-752-01
6-550-752-01
8-729-424-08
8-729-421-19
8-729-424-08
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
DTC614TKT146
DTC614TKT146
UN2111
UN2213
UN2111
Q605
Q606
Q607
Q701
Q702
8-729-421-22
8-729-421-19
8-729-010-25
8-729-010-25
8-729-010-25
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
UN2211
UN2213
MSD601-RT1
MSD601-RT1
MSD601-RT1
Ref. No.
Part No.
Description
Remark
R441
R442
R443
R450
R451
1-216-809-11
1-216-841-11
1-216-864-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
47K
0
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R452
R453
R470
R471
R472
1-216-841-11
1-216-864-11
1-216-809-11
1-216-809-11
1-216-841-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47K
0
100
100
47K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R480
R481
R482
R491
R492
1-216-809-11
1-216-809-11
1-216-841-11
1-216-805-11
1-216-864-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
47K
47
0
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R505
R506
R507
R508
R509
1-216-845-11
1-216-813-11
1-216-864-11
1-216-845-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
220
0
100K
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R510
R511
R512
R513
R514
1-216-845-11
1-216-845-11
1-216-845-11
1-216-845-11
1-216-841-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
100K
100K
100K
47K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R517
R520
R523
R524
R526
1-216-845-11
1-216-845-11
1-216-845-11
1-216-833-11
1-216-825-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
100K
100K
10K
2.2K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R527
R528
R529
R530
R532
1-216-825-11
1-216-845-11
1-216-845-11
1-218-871-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
2.2K
100K
100K
10K
100K
5%
5%
5%
0.5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R533
R535
R603
R604
R615
1-216-845-11
1-216-833-11
1-216-821-11
1-216-821-11
1-216-849-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
10K
1K
1K
220K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R616
R701
R702
R703
R704
1-216-841-11
1-216-821-11
1-216-841-11
1-216-833-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47K
1K
47K
10K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R705
R706
R707
R708
R709
1-249-425-11
1-216-841-11
1-216-841-11
1-216-829-11
1-216-821-11
CARBON
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
4.7K
47K
47K
4.7K
1K
5%
5%
5%
5%
5%
1/4W
1/10W
1/10W
1/10W
1/10W
< RESISTOR >
R4
R5
R6
R7
R9
1-216-839-11
1-216-843-11
1-216-809-11
1-216-809-11
1-216-864-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
33K
68K
100
100
0
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R10
R101
R102
R103
R104
1-216-821-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
100
100
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R105
R106
R107
R108
R109
1-216-809-11
1-216-809-11
1-216-809-11
1-218-871-11
1-218-871-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
100
10K
10K
5%
5%
5%
0.5%
0.5%
1/10W
1/10W
1/10W
1/10W
1/10W
R112
R115
R301
R302
R351
1-216-864-11
1-216-864-11
1-216-809-11
1-216-841-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
0
0
100
47K
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R370
R371
R404
R420
R421
1-216-809-11
1-216-809-11
1-218-881-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
27K
100
100
5%
5%
0.5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R422
R423
R430
R431
R432
1-216-841-11
1-216-864-11
1-216-809-11
1-216-809-11
1-216-841-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47K
0
100
100
47K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R433
R440
1-216-864-11 METAL CHIP
1-216-809-11 METAL CHIP
0
100
5%
5%
1/10W
1/10W
< SWITCH >
S103
1-692-431-21 SWITCH, TACTILE (RESET)
< TUNER >
TU1
A-3220-961-A TUNER UNIT (TUX-032//Q3)
41
CDX-R3300EE
MAIN
Ref. No.
SENSOR
Part No.
SERVO
Description
Remark
< VIBRATOR >
X500
1-813-160-11 VIBRATOR, CERAMIC (27.648MHz)
X501
1-813-202-11 VIBRATOR, CRYSTAL (32.768kHz)
*************************************************************
SENSOR BOARD
**************
< SWITCH >
SW2
1-529-566-61 SWITCH, PUSH (1 KEY) (SELF)
SW3
1-529-566-61 SWITCH, PUSH (1 KEY) (DISC IN)
*************************************************************
A-3283-357-A SERVO BOARD, COMPLETE
**********************
< CAPACITOR >
C1
C2
C3
C4
C5
1-162-970-11
1-162-970-11
1-162-970-11
1-162-970-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.01uF
0.01uF
0.01uF
0.1uF
10%
10%
10%
10%
10%
25V
25V
25V
25V
16V
C6
C7
C8
C10
C11
1-162-970-11
1-162-962-11
1-162-962-11
1-104-609-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
0.01uF
470PF
470PF
100uF
0.1uF
10%
10%
10%
20%
10%
25V
50V
50V
4V
16V
C13
C14
C16
C18
C19
1-162-965-11
1-162-965-11
1-107-826-11
1-164-227-11
1-164-227-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.0015uF
0.0015uF
0.1uF
0.022uF
0.022uF
10%
10%
10%
10%
10%
50V
50V
16V
25V
25V
C21
C22
C23
C24
C25
1-107-826-11
1-162-962-11
1-162-967-11
1-162-962-11
1-162-967-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
470PF
0.0033uF
470PF
0.0033uF
10%
10%
10%
10%
10%
16V
50V
50V
50V
50V
C26
C27
C28
C29
C30
1-162-970-11
1-126-208-21
1-107-826-11
1-164-156-11
1-107-826-11
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
47uF
0.1uF
0.1uF
0.1uF
10%
20%
10%
10%
25V
4V
16V
25V
16V
C32
C33
C34
C35
C36
1-164-156-11
1-164-156-11
1-107-826-11
1-107-826-11
1-162-970-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
0.1uF
0.01uF
10%
10%
10%
25V
25V
16V
16V
25V
C37
C38
C39
C40
C41
1-164-677-11
1-107-826-11
1-162-927-11
1-162-969-11
1-164-156-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.033uF
0.1uF
100PF
0.0068uF
0.1uF
10%
10%
5%
10%
C42
C43
C44
C45
C46
1-162-970-11
1-125-837-11
1-162-970-11
1-162-970-11
1-162-965-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
1uF
0.01uF
0.01uF
0.0015uF
10%
10%
10%
10%
10%
25V
6.3V
25V
25V
50V
C47
1-107-826-11 CERAMIC CHIP
0.1uF
10%
16V
42
16V
16V
50V
25V
25V
Ref. No.
Part No.
Description
Remark
C48
C49
C50
C51
C52
1-104-609-11
1-125-837-11
1-125-837-11
1-164-156-11
1-100-381-11
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
100uF
1uF
1uF
0.1uF
10uF
20%
10%
10%
C53
C54
C55
C56
C57
1-100-381-11
1-164-156-11
1-164-156-11
1-162-970-11
1-164-156-11
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
10uF
0.1uF
0.1uF
0.01uF
0.1uF
20%
C58
C59
C60
C63
C64
1-107-826-11
1-107-826-11
1-100-381-11
1-162-970-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
10uF
0.01uF
0.1uF
10%
10%
20%
10%
10%
16V
16V
16V
25V
16V
C65
C66
C67
C74
C75
1-126-208-21
1-164-156-11
1-107-826-11
1-126-208-21
1-162-970-11
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
47uF
0.1uF
0.1uF
47uF
0.01uF
20%
10%
20%
10%
4V
25V
16V
4V
25V
C77
C79
C81
C83
C85
1-107-826-11
1-107-826-11
1-107-826-11
1-107-826-11
1-125-837-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
0.1uF
1uF
10%
10%
10%
10%
10%
16V
16V
16V
16V
6.3V
C86
C91
C92
C107
C109
1-107-826-11
1-107-826-11
1-107-826-11
1-107-826-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
10%
10%
10%
10%
10%
16V
16V
16V
16V
16V
C110
C115
1-107-826-11 CERAMIC CHIP
1-162-966-11 CERAMIC CHIP
0.1uF
10%
0.0022uF 10%
16V
50V
20%
10%
4V
6.3V
6.3V
25V
16V
16V
25V
25V
25V
25V
< CONNECTOR >
CN1
CN2
1-794-153-21 CONNECTOR, FPC (ZIF) 16P
1-817-275-21 CONNECTOR, BOARD TO BOARD 28P
< JUMPER RESISTOR >
FB1
FB2
FB5
1-216-864-11 METAL CHIP
1-216-864-11 METAL CHIP
1-216-864-11 METAL CHIP
0
0
0
5%
5%
5%
1/10W
1/10W
1/10W
< IC >
IC1
IC3
IC4
IC7
IC8
6-705-366-01
8-753-216-86
6-804-028-01
6-705-364-01
6-705-365-01
IC
IC
IC
IC
IC
LA6560-TE-L-E
CXD3059BR
MB90487PFV-G-105-BNDE1
R1114N151D-TR-FA
TC94A34FG-002
< TRANSISTOR >
Q1
Q2
Q3
Q5
Q6
8-729-904-87
8-729-928-90
8-729-904-87
8-729-904-87
8-729-928-90
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SB1197K-R
DTC114EE
2SB1197K-R
2SB1197K-R
DTC114EE
< RESISTOR >
R1
1-218-941-81 RES-CHIP
100
5%
1/16W
CDX-R3300EE
SERVO
Ref. No.
Part No.
Description
Remark
Ref. No.
Part No.
Description
R2
R3
R4
R5
R6
1-218-971-11
1-218-971-11
1-218-965-11
1-218-965-11
1-218-965-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
33K
33K
10K
10K
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R7
R8
R9
R10
R11
1-208-635-11
1-218-971-11
1-218-971-11
1-218-965-11
1-218-965-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
10
33K
33K
10K
10K
5%
5%
5%
5%
5%
R12
R13
R14
R15
R16
1-208-635-11
1-218-965-11
1-218-990-11
1-218-990-11
1-218-990-11
RES-CHIP
RES-CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
10
10K
0
0
0
R17
R18
R19
R20
R21
1-218-965-11
1-218-965-11
1-218-969-11
1-218-969-11
1-218-990-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
SHORT CHIP
R22
R23
R24
R25
R26
1-218-967-11
1-218-967-11
1-218-953-11
1-218-953-11
1-218-981-11
R27
R28
R29
R37
R38
Remark
R71
R72
R73
R74
R76
1-218-941-81
1-218-990-11
1-218-941-81
1-218-941-81
1-218-941-81
RES-CHIP
SHORT CHIP
RES-CHIP
RES-CHIP
RES-CHIP
100
0
100
100
100
1/16W
1/16W
1/16W
1/16W
1/16W
R77
R78
R79
R80
R81
1-218-990-11
1-218-941-81
1-218-941-81
1-218-977-11
1-218-941-81
SHORT CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
5%
5%
1/16W
1/16W
R85
R86
R87
R91
R92
1-218-973-11
1-218-973-11
1-218-973-11
1-220-200-81
1-218-971-11
10K
10K
22K
22K
0
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
R97
R98
R99
R101
R106
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
15K
15K
1K
1K
220K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
1-218-965-11
1-218-990-11
1-218-977-11
1-218-947-11
1-218-967-11
RES-CHIP
SHORT CHIP
RES-CHIP
RES-CHIP
RES-CHIP
10K
0
100K
330
15K
5%
1/16W
5%
5%
5%
1/16W
1/16W
1/16W
R39
R40
R41
R42
R43
1-218-941-81
1-218-990-11
1-218-985-11
1-218-965-11
1-218-977-11
RES-CHIP
SHORT CHIP
RES-CHIP
RES-CHIP
RES-CHIP
100
0
470K
10K
100K
5%
1/16W
5%
5%
5%
R44
R45
R46
R47
R48
1-218-957-11
1-218-971-11
1-218-957-11
1-218-977-11
1-218-941-81
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
2.2K
33K
2.2K
100K
100
R49
R50
R52
R53
R54
1-218-953-11
1-218-941-81
1-218-941-81
1-218-959-11
1-218-961-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
R55
R56
R57
R59
R60
1-218-953-11
1-218-973-11
1-218-941-81
1-218-941-81
1-218-990-11
R61
R62
R64
R65
R67
1-218-985-11
1-218-965-11
1-218-941-81
1-218-941-81
1-218-941-81
R68
R69
R70
1-218-990-11 SHORT CHIP
1-218-973-11 RES-CHIP
1-218-945-11 RES-CHIP
5%
1/16W
5%
5%
5%
1/16W
1/16W
1/16W
0
100
100
100K
100
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
47K
47K
47K
30K
33K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
1-218-941-81
1-218-941-81
1-218-965-11
1-218-969-11
1-218-969-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
100
100
10K
22K
22K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R107
R108
R109
R110
R111
1-218-965-11
1-218-941-81
1-218-953-11
1-218-945-11
1-218-990-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
SHORT CHIP
10K
100
1K
220
0
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
R114
R115
R116
R117
R119
1-218-941-81
1-218-941-81
1-218-941-81
1-218-990-11
1-218-941-81
RES-CHIP
RES-CHIP
RES-CHIP
SHORT CHIP
RES-CHIP
100
100
100
0
100
5%
5%
5%
1/16W
1/16W
1/16W
5%
1/16W
1-218-965-11
1-218-990-11
1-216-864-11
1-218-965-11
1-218-965-11
RES-CHIP
SHORT CHIP
METAL CHIP
RES-CHIP
RES-CHIP
10K
0
0
10K
10K
5%
1/16W
1/16W
1/16W
1/16W
R122
R123
R124
R126
R127
5%
5%
5%
1/10W
1/16W
1/16W
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R128
R129
R133
R136
R139
1-218-965-11
1-218-965-11
1-216-864-11
1-218-977-11
1-218-957-11
RES-CHIP
RES-CHIP
METAL CHIP
RES-CHIP
RES-CHIP
10K
10K
0
100K
2.2K
5%
5%
5%
5%
5%
1/16W
1/16W
1/10W
1/16W
1/16W
1K
100
100
3.3K
4.7K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R140
R141
R142
R143
R144
1-218-941-81
1-218-941-81
1-218-941-81
1-218-941-81
1-218-965-11
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
100
100
100
100
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
SHORT CHIP
1K
47K
100
100
0
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
R145
R146
R147
R148
R149
1-218-977-11
1-218-941-81
1-218-941-81
1-218-941-81
1-218-941-81
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
100K
100
100
100
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
RES-CHIP
470K
10K
100
100
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
0
47K
220
5%
5%
1/16W
1/16W
< SWITCH >
SW1
1-529-565-61 SWITCH, PUSH (1 KEY) (DOWN)
< VIBRATOR >
X1
1-795-561-21 VIBRATOR, CERAMIC (16.9344MHz)
X2
1-795-822-21 VIBRATOR, CERAMIC (18.43MHz)
*************************************************************
43
CDX-R3300EE
Ref. No.
Part No.
Description
Remark
MISCELLANEOUS
***************
7
0 153
154
F901
M902
1-776-527-61
8-820-207-02
A-3372-448-A
1-532-877-11
A-3372-447-A
CORD (WITH CONNECTOR) (ISO) (POWER)
OPTICAL PICK-UP (KSS1000E/K1RP)
CHASSIS (OP) SUB ASSY (including M901)
FUSE (BLADE TYPE) (AUTO FUSE) 10A
MOTOR ASSY, SL (SLED)
M903
A-3372-443-A MOTOR ASSY, LE (LOADING)
SW4
1-571-099-11 SWITCH (1 KEY) (LIMIT)
*************************************************************
ACCESSORIES
************
3-263-513-11 MANUAL, INSTRUCTION (ENGLISH,RUSSIAN)
3-263-514-11 MANUAL, INSTRUCTION, INSTALL (ENGLISH,
RUSSIAN)
X-3383-264-2 CASE ASSY (for FRONT PANEL)
*************************************************************
PARTS FOR INSTALLATION AND CONNECTIONS
***************************************
301
302
303
304
305
X-3382-647-1
X-3381-154-1
3-349-410-11
3-261-542-01
1-465-459-21
306
307
3-246-471-01 KEY (FRAME)
1-776-527-61 CORD (WITH CONNECTOR) (ISO) (POWER)
301
FRAME ASSY, FITTING
SCREW ASSY (BS4), FITTING
BUSHING
COLLAR
ADAPTOR, ANTENNA
302
303
304
305
306
307
44
The components identified by
mark 0 or dotted line with mark
0 are critical for safety.
Replace only with part number
specified.
www.s-manuals.com