1
Download Manual - Cascade Corporation
Transcript
* mmTP.4 Parts Manual 66F Paper Roll Clamps Serial Numbers 206729 through 206760 Manual Number 207474 R-O cascade@ Cascade is a Registered Trademark of Cascade Corporation How To Use This Manual . Introduction 2. Note the Serial Number This manual illustrates service replacement parts for standard production Cascade 66F Paper Roll Clamps. Record the six-digit Serial Number. See the example, . 3. Refer to Serial Number Index The parts manuals for attachments designed by the Application Engineering Department have an A.E.D. designation on the cover of the manual. Locate your Serial Number in the Serial Number Index on the following page. To locate a service replacement part for a standard attachment, follow these steps. IMPORTANT: DO NOT USE THIS MANUAL TO ORDER PARTS FOR AN A.E.D. ATTACHMENT.’ Contact Cascade Corporation to obtain the correct parts manual. You must supply the serial number and all additional equipment numbers to order the correct manual. 1. Locate the Nameplate 4. Ordering The nameplate is attached to the left side of the faceplate, top or center. If the nameplate is missing, all necessary information is stamped into the faceplate at the same location. Retail Customers - Cascade Service Replacement Parts and Service Literature are sold through authorized lift truck dealers. To order, contact the lift truck dealer of your choice. This standard attachment manual is not interchangeable with an A.E.D. manual since it does not reflect the special engineering of an A.E.D. attachment. Llft Truck Dealers - To order Service Replacement Parts or Service Literature, contact: Nameplate /I I cascade@ Cascade Parts Depot 2501 Sheridan Avenue Springfield, Ohio 45505 Telephone: 513-322-l 199 Telex: 279563 FAX: 513-325-9270 Patent Plate 5. Parts Log We have supplied a parts ordering log located on the last page. Use this log as a permanent record of parts ordered from this manual. A WARNING: For the safety of yourself and others, DO NOT install any parts, unless you have thoroughly reviewed the appropriate installation and service manuals. For additional information, call l-800-CAS-CADE (227-2233) For Technical Assistance call: l-900-CAS-CADE (227-2233) or 5036594300 To Order Parts call: 513-322-1199, FAX: 513-325-9270 207474 Rev. 0 Serial Number Index 1 Frame 1 Common Drive 1 Ho&a Arm 1 Bumper 1 Mountina 1 206729 206730 206731 206732 206733 206734 206735 206736 206753 206754 206755 206756 206757 206758 206759 206760 cascade For Technical Aaelstanco call: l-600-CASCADE (227-2233) or 503-669-6300 To Order Parts call: 513-322-1199. FAX: 513-325-9270 207474 Rev. 0 i Publications cascade' Service Llterature Index and Order Form ..:...:I.,PERATOR’S :: -: GUIDE I’.:. .. :.. .:.. 0 ....*... .. .................. .......... .......................... ................ ................... .................................... ................. ,~.~.~.~.~.~.~.~.~.~.~.~.~.~.~.~.~.~ ,~.~.~.~.~.~.~.~.~.‘.~.~.~.~.~.~,~.~ .................. ................. cascade’ -..--.- .................. .................. .................. ....... L 66F 1 PARTNO. 1 I t 207474 I 674512 674509 674510 677555 678363 680664 679929 673964 ii cascade DESCRIPTION I Parts Manual Service Manual Operators Guide Installation Instructions Driver Training Video-VHS Troubleshooting Video-VHS Servicing Cascade Cylinders-VHS Tool Catalog Literature Index Order Form For Technical Assistance call: 1-600~CASCADE (227-2233) or 503-669-6300 To Order Parts call: 613-322-1199, FAX: 513-325-9270 207474 Rev. 0 Safety Decals 3 ? 99 4 5 CAUTION PRESSURE MAY BE TRAPPED-BLEED CYLINDER BEFORE DISASSEMBLING CAUTION NOHANDHOI.0 Jo vAQuick Change Hooks 6 Dismppdtmnumsgs EflpJdtOCWiWJO I 66F cascade* I DESCRIPTION 1REF 1QlY 1 PART NO. 1 ~1 I Short Arm Rotation Position Decal For Technlcal As&stance call: l-800-CASCADE (227-2233) or 503-569-63~ To Order Parto call: 513-322-1199. FAX: 513-325-9270 207474 Rev. 0 iii Recommended Spare Parts List 66F Paper Roll Clamps PART NUMBER 206764 660200 680651 E:E 676091 ~%Ea 674257 674256 675608 670506 670581 7214 LiG%~ DESCRIPTION FRAME GROUP Bushing COMMON COMPONENTS Shim Pin Pi$fPu~table Bumper Pin Pin Pin Adjustable Bumper Shim Drive Pin ATTACHMENTS SERVICED 1-s 9-19 2(Mo 8 16 16 8 16 16 : 4 E E E !z i DRIVE GROUP Worm Pinion Bearing gw,Rins Drive Motor 206405 668184 675638 675637 656300 Service Kit $i~w$lotor Bearing Service kit Bearing Service kit Gear Lube (4802.) 681585 REVOLVING CONNECTION Shaft Service Kit 1 2 2 555725 557212 SHORT AND LONG ARM CYLINDER Cylinder Service Kit Check Valve 2 2 4 4 4 4 674701 0 SHORT AND LONG ARM Pin Contact Pad 2 0 4 1 4 2 669344 MOUNTING GROUP Stop Kit 1 2 2 685660 PAINT 12 oz. Aerosol Can Heritage White 1 2 2 207474 674512 674510 674509 679929 673964 PUBLICATIONS Parts Manual Service Manual Installation Instruction Operator’s Guide Tool Catalog Literature Index Order Form 1 1 : 1 1 1 1 1 1 1 1 1 1 1 1 1 1 678363 680664 677555 VIDEOS Paper Roll Clamp Troubleshooting Servicing Cascade Cylinders Driver Training 1 1 1 : 1 1 1 1 0 See specific parts page for part number. iv cascade@ For Technlcel As&stance cell: 180%CAS-CADE (227-2233) or 503-669-6300 To Order Porte cell: 513-322-1199. FAX: 513-325-9270 207474 Rev. 0 Frame Group 66F REF QTY I PARTNO. I 206745 ---. 1 206721 - NO. DESCRIPTION t Frame Group- 51’ Roll l 1 Frame Group- 60’ Roll + ate - 51’ Roll + 675636 605761 6290 DESCRIPTION Drive Group Fitting, 6-8 1 Lockwasher I I__.__. na. 8-a Maximum clamp handling capaci V Included in fastener group 20675 5.. l See page 4 for replacement parts breakdown. l cascade For Technical Aeslstanca call: l-800-CASCADE (227-2233) or 503-669-6~ To Order Parts call: 513322-1199, FAX:51X425-9270 207474 Rev. 0 1 Common Components Group 66F REF PART NO. 206763 9 10 11 2 cascade* DESCRIPTION Components Group 16 674257 Shim 4 4 674256 681671 Drive Pin St-mmr For Technlcal Assistance call: l-600-CASCADE (227-2233) or 503-669-6300 To Order Parts call: 513-322-l 199. FAX: 513-325-9270 207474 Rev. 0 Common Components Group Adjustable Bumper 66F REF QTY PARTNO. 206762 cascade@ DESCRIPTION Components Group For Technical Assistance call: l-600-CASCADE (227-2233) or 503-669-6300 To Order Parts call: 513-322-l 199 FAX: 513-325-9270 207474 Rev. 0 3 Drive Group I 66F REF QN 1 n 1 1 6 3 I 1 PARTNO. 1 I I P I Pi I 4 DESCRIPTION 675628 ( 675631 1 ~-607071 670506 cascade@ REF QTY PARTNO. 1 DESCRIPTION Drive Group with Motor D 1 C 670578 675637 Bearing Service Kit (items 21 & 32) 675638 206394 Bearing Service Kit (items 3-7, 11 & 25) Drive Motor Kit (items 11, 14, 18, 19, & 32) Shim Service Kit (items 3-6, 11,25 & 32) For Technical Assistance call: l-800-CAS-CACE (227-2233) or 503-669-6300 To Order Parts call: 513-322-1199. FAX: 513-325-9270 207474 Rev. 0 Drive Motor 66F 206392 Drive Motor 206405 Service Kit Cascade provides service replacement parts for the listed parts only. Due to cost, if others parts need replacement, the complete drive motor should be replaced. W See Nameplate under valve for correct part number of Gerotor Set and Flange. 0 Compatible with water glycol based hydraulic fluids. Check Valve 66F REF QTY cascade PARTNO. DESCRIPTION 670549 Check Valve Assemblv For Technical Asslatance call: l-900-CASCADE (227-2233) or 503-669-6300 To Order Parts call: 513-322-1199. FAX: 513-325-9270 207474 Rev. 0 5 Hosing Groups Fixed Short Arm L&g Arm Cylinder L%g Arm Cylinder 66F PART NO. 206750 206751 DESCRIPTION Hosing Group - 51" Roll Hosing Group - 60" Roll H Maximum clamp handling capacity. 0 See page 8 for replacement parts breakdown. 6 cascade For Technical Asslstanco call: l-900-CASCADE (227-2233) or 503-669-9300 To Order Parts call: 513-322-1199, FAX: 513-325-9270 207474 Rev. 0 Hosing Groups Positioned Short Arm rt Arm nder ‘CArm -.w...r Cylinder Long Arm Cylinder Clamp / Lzg Arm Cylinder 66F 206748 206743 n 0 cascade* Hosing Group - 51" Roll Hosing Group - 60" Roll Maximum clamp handling capacity. See page 9 for replacement parts breakdown. For Technical A&stance call: l-600-CASCADE (227-2233) or 503-669-6300 To Order Parts call: 513-322-1199, FAX:513-325-9270 207474 Rev. 0 7 Revolving Connection Fixed Short Arm c I 66F 1 REF ) QTY 1 PART NO. 1 I , ; l ’ cI 1 L ’ I DESCRIPTION t 687292 ‘68796 &I7301 Revolving RevolvingConnection Connection 1 Camcrew. MBx 358.8 I --r-- - . ..- -- -.- End Block 3 4 604510 Plug, 6 4 1 7341 Snap Ring iaft 681585 -.-.-v 63694 1 10 8 cascade@ I I 1 ki 1 6&ll , Service Kit 1 Plug, 3 >dY , _. rap Ring 1 Fittino 6 For Tochnlcal Asslstancr call: 1-600~CASCADE (227-2233) or 503-669-6300 To Order Part8 call: 513-322-1199, FAX: 513-325-9270 207474 Rev. 0 Revolving Connection Positioned Short Arm 66F DESCRlPTlON 8 1 1 9 1 1 cascade@ ( 687291 Revolving Connection 681585 Service Kit 205031 3138 1 Body 1 Snap Ring (227-2233) or 503-569-5300 For Technical Assistance call: l-903-CASCADE To Order Parts call: 513-322-1199, FAX: 513-325-9270 207474 Rev.0 9 Short Arm Cylinder TEST PORT 66F 51" Roll 60" Roll DESCRIPTION 557365 557362 674843 560997 660769 662462 638295 604511 E;E;FsE7 1 IlAtl. . . I 016 15 I t1 1 17 I 1 . 1 18 1 1 019 ( 1 -20 1 1 I n l 10 cascade@ I !iVi73A -VI,-I 2722 657389 --. --1 I !%f-i717 v-v. .- i 667516 1 669243 t --!iS8835 i725 ‘31 598 I47 191 - ‘24 5551 557: I89 27X P . 555741 u-n,, ,y Back-up Ring Seal Wiper Rod Retainer Piston O-Ring Shell 667516 Check Valve Service Kit 669243 558835 Sea I Loader Spacer I Cylinder Service Kit 555725 , ___.__ 1 1 1 555. -Maximum clamp handlin capacity. Included in Service Kit 585725. For Technical Asslstanco Cylinder Assembly Bearing Nut Bearing Seal Back-up Ring Fitting, 6-6 c , -, .- -. call: l-800-CASCADE (227-2233) or 503-669-6300 To Order Parts call: 513-322-1199, FAX:513-325-9270 207474 Rev. 0 Long Arm Cylinder TEST PORT I 66F 51’ REF 1 . 09 a10 a11 012 QTY 3 Roll n 60’ Roll I n PARTNO. PART NO. 683939 674843 557384 674843 --.-.- --.-.- 2801 562731 554598 628047 2801 56273 1 554598 628047 DESCRIPTION Cylinder Assembly Bearing -..--.. I_.__ O-Ring Back-up Ring Seal Wiper 3Od ---. 016 17 18 019 20 n 0 cascade" 2722 564122 667516 669243 558835 555725 -. 557389 2722 556597 667516 669243 558835 555725 , .qetainer Piston O-Ring Shell Check Valve Service Kit Seal Loader Spacer Cvlinder Service Kit Maximum clamp handling capacity. Included in Service Kit 555725. For Technical Assistance call: l-900-CASCADE (227-2233) or 503-569-5300 To Order Parts call: 513-322-1199, FAX: 513-325-9270 207474 Rev. 0 11 Short Arm Link I 66F REF Q-W 1 1 2 1 1 2 n 12 cascade PARTNO. 1 675959 1 675960 I DESCRIPTION Link - 51’ Roll n Link - 60’ Roll n Maximum clamp handling capacity. For TechnIcal Asslstancm call: 1-8OO-CASCADE (227-2233) or 503-669-6300 To Order Parts call: 513-322-1199. FAX:513-325-9270 207474 Rev. 0 Short Arm Repair Kit Adjustable and Non Adjustable Bumper 66F 51" Roll 60" Roll DESCRIPTION 675918 675921 Arm Assembly 674928 674928 Arm Tip Repair Kit H Maximum clamp handling capacity. cascade* For Tochnlcal Assistance call: l-600-CASCADE (227-2233) or 503-669-6300 To Order Parts call: 513-322-l 199, FAX: 513-325-9270 207474 Rev. 0 13 Long Arm Adjustable Bumper Repair Kit 66F 51" Roll 60" Roll DESCRIPTION I I I 675919 1 I 67597!i 674928 675922 6 _674265 6525 674701 675992 674510 674928 Arm Assembly Arm Link Clevis Pn Cotter Pin Pin Contact Pad Plug Arm Tip Repair Kit H Maximum clamp handling capacity. 14 cascade@ For Tochnlcal Asslstanco call: l-800-CASCADE (227-2233) or 503-669-6300 To Order Parts call: 513-322-1199. FAX: 513-325-9270 207474 Rev. 0 Long Arm Non Adjustable Bumper G” ‘*”g 66F 51" Roll 5 cascade* 60" Roll 680462 680464 Arm Assembly 674928 674928 Arm Tip Repair Kit Maximum clamp handling capacity. (227-2233) or 503-669-6300 For Tochnlcel Assistance call: l-600-CASCADE To Order Parts call: 513-322-1199, FAX: 513-325-9270 207474 Rev. 0 15 Adjustable Bumper Groups 66F 1 REF 1QTY 1 PART NO. 1 DESCRIPTION I 1 2 n 16 cascade@ 2 a 675944 675945 676040 674843 Bumper Group - 51’ Roll n Bumper Group - 60’ Roll n Roller Bearina Maximum clamp handling capacity. For fechnlcal Asslstanco call: I-BOO-CAS-CADE (227-2233) or 503-669-5300 To Order Parts call: 513-322-l 199. FAX: 513-325-9270 207474 Rev. 0 Bolt-On Mounting Group 66F Class lll,O° PART NO. DESCRIPTION 206722 Mounting Group 669344 Stop Kit I Quick Change Mounting Group 66F Class Ill, 0° 1 REF 1QTY 1 PART NO. 1 206741 . 1 . “8 1 6 1 766164 3 1 1 201572 5 1 - ---. 2 6759 669344 cascade@ I TV-7 2 4 DESCRIPTION Mounting Group For Technlcal Assistance call: l-800-CAS-CADE (227-2233) or 503-669-6300 To Order Parts call: 513-322-1199. FAX: 513-325-9270 Stop Kit 207474 Rev. 0 17 Bolt-On Mounting Group 66F Class III, 4° 1 REF 1QTY 1 PART NO. DESCRlPTlON 206737 Mounting Group 669344 Stop Kit I Quick Change Mounting Group 66F Class Ill, 4° REF Q-I-Y PARTNO. 206740 cascade Mounting Group 1 1 674024 3 1 2 i9577 1 675957 Upper Hook - L. H. ) Capscrew I Hook 1 1 Guide 412 18 DESCRIPTION 675958 5 4 781534 Nut 6 7 8 1 779010 669344 Capscrew Stop Kit 8 I 1 I 674025 ( Upper Hook- 9 1 2 1 676832 1 Pin For TechnIcal Asaletence cell: l-900-CAS-CADE (227-2233) or 503-559-6300 To Order Parts cell: 513-322-1199, FAX: 513-325-9270 R. H. 207474Rev.0 I DATE PURCHASE ORDER SERIAL NUMBER PAGE FIEF NO QTY CASCADE PARTNO CUSTOMER PART NO PARTS ORDERING LOG 0 DESCRIPTION a’ PRICE
