Download Motorola PRO2150 Service manual
Transcript
PRO2150™ Portable Radio Detailed Service Manual Table of Contents i User Safety, Training, and General Information..........................................v Chapter 1 1.1 1.2 1.3 1.4 Introduction ......................................................................... 1-1 Scope of Manual............................................................................................................................ 1-1 Warranty and Service Support....................................................................................................... 1-1 1.2.1 Warranty Period and Return Instructions.......................................................................... 1-1 1.2.2 After Warranty Period ....................................................................................................... 1-1 1.2.3 Piece Parts ....................................................................................................................... 1-2 1.2.4 Technical Support ............................................................................................................. 1-2 1.2.5 Parts Identification ............................................................................................................ 1-2 Radio Model Information................................................................................................................ 1-3 Radio Features .............................................................................................................................. 1-4 Chapter 2 Maintenance ........................................................................ 2-1 2.1 2.2 Introduction .................................................................................................................................... 2-1 Preventive Maintenance ................................................................................................................ 2-1 2.2.1 Inspection ......................................................................................................................... 2-1 2.2.2 Cleaning Procedures ........................................................................................................ 2-1 2.3 Safe Handling of CMOS and LDMOS Devices.............................................................................. 2-2 2.4 Repair Procedures and Techniques — General............................................................................ 2-2 2.4.1 Parts Replacement and Substitution ................................................................................ 2-2 2.4.2 Rigid Circuit Boards .......................................................................................................... 2-2 2.4.3 Flexible Circuits ................................................................................................................ 2-3 2.4.4 Chip Components ............................................................................................................. 2-3 2.4.5 Shields .............................................................................................................................. 2-4 2.5 Disassembling and Reassembling the Radio — General.............................................................. 2-4 2.6 Radio Disassembly — Detailed ..................................................................................................... 2-5 2.6.1 Front Cover from Chassis Disassembly ........................................................................... 2-5 2.6.2 Control Board Disassembly .............................................................................................. 2-7 2.6.3 RF Board Disassembly ..................................................................................................... 2-7 2.7 Radio Reassembly — Detailed...................................................................................................... 2-8 2.7.1 RF Board Reassembly...................................................................................................... 2-8 2.7.2 Control Board Reassembly ............................................................................................... 2-8 2.7.3 Chassis and Front Cover Reassembly ............................................................................. 2-8 2.8 Mechanical View and Parts List................................................................................................... 2-12 2.8.1 Exploded View and Parts List ......................................................................................... 2-12 2.9 Service Aids................................................................................................................................. 2-14 2.10 Test Equipment............................................................................................................................ 2-15 2.11 Programming Cable (DSK001C706) ........................................................................................... 2-16 2.12 IF Test Box (DSK001C702) ......................................................................................................... 2-17 99R85452E01-O August 30, 2002 ii Table of Contents Chapter 3 3.1 3.2 3.3 3.4 Introduction .................................................................................................................................... 3-1 Software Tuning Setup .................................................................................................................. 3-1 Affixing Antenna Ground Plate....................................................................................................... 3-2 Hardware Tuning Setup and Procedure ........................................................................................ 3-3 3.4.1 Audio Modulation Tuning .................................................................................................. 3-3 3.4.2 Sub-Audio Modulation Tuning........................................................................................... 3-4 3.4.3 Tuning Frequency ............................................................................................................. 3-4 Chapter 4 4.1 4.2 4.3 4.4 Error Code Displays............................................................ 5-1 Error Codes.................................................................................................................................... 5-1 Chapter 6 6.1 6.2 6.3 6.4 6.5 6.6 6.7 6.8 Radio Programming............................................................ 4-1 Introduction .................................................................................................................................... 4-1 Programming Your Radio .............................................................................................................. 4-1 4.2.1 Overview of the Programming Process ............................................................................ 4-1 4.2.2 Cloning Radio Parameters to User Radios ....................................................................... 4-1 4.2.3 Parameters Which are Cloned.......................................................................................... 4-1 4.2.4 Parameters Which are Not Cloned ................................................................................... 4-1 4.2.5 To Clone a Radio .............................................................................................................. 4-1 4.2.6 Error Conditions ................................................................................................................ 4-2 CPS Programming ......................................................................................................................... 4-2 Programming ................................................................................................................................. 4-3 4.4.1 PL Frequencies and Codes .............................................................................................. 4-3 4.4.2 DPL Codes........................................................................................................................ 4-4 4.4.3 Examples .......................................................................................................................... 4-4 Chapter 5 5.1 Radio Tuning ....................................................................... 3-1 Accessories ......................................................................... 6-1 Antennas........................................................................................................................................ 6-1 Carrying Accessories ..................................................................................................................... 6-1 Carry Cases ................................................................................................................................... 6-1 Chargers ........................................................................................................................................ 6-1 Batteries......................................................................................................................................... 6-1 Audio Accessories ......................................................................................................................... 6-1 Manuals ......................................................................................................................................... 6-2 Software......................................................................................................................................... 6-2 August 30, 2002 99R85452E01-O Table of Contents Chapter 7 7.1 7.2 7.3 7.4 7.5 8.4 8.5 VHF Band Information ........................................................ 7-1 Model Chart ................................................................................................................................... 7-1 Specifications................................................................................................................................. 7-2 Theory of Operation....................................................................................................................... 7-3 7.3.1 General Information .......................................................................................................... 7-3 7.3.2 Power Distribution............................................................................................................. 7-3 7.3.3 Power up Sequence ......................................................................................................... 7-3 7.3.4 CPU / Control Section....................................................................................................... 7-4 7.3.5 VCO / Synthesizer Section ............................................................................................... 7-4 7.3.6 Transmitter Section........................................................................................................... 7-5 7.3.7 Receiver Section............................................................................................................... 7-6 7.3.8 Battery Section ................................................................................................................. 7-7 Block Diagrams.............................................................................................................................. 7-8 7.4.1 Complete .......................................................................................................................... 7-8 7.4.2 Controller .......................................................................................................................... 7-9 7.4.3 VCO .................................................................................................................................. 7-9 7.4.4 Transmitter...................................................................................................................... 7-10 7.4.5 Receiver.......................................................................................................................... 7-10 Troubleshooting Charts ............................................................................................................... 7-11 Chapter 8 8.1 8.2 8.3 iii UHF Band Information ........................................................ 8-1 Model Charts ................................................................................................................................. 8-1 Specifications................................................................................................................................. 8-3 Theory of Operation....................................................................................................................... 8-4 8.3.1 General Information .......................................................................................................... 8-4 8.3.2 Power Distribution............................................................................................................. 8-4 8.3.3 Power up Sequence ......................................................................................................... 8-4 8.3.4 CPU / Control Section....................................................................................................... 8-5 8.3.5 VCO / Synthesizer Section ............................................................................................... 8-5 8.3.6 Transmitter Section........................................................................................................... 8-6 8.3.7 Receiver Section............................................................................................................... 8-7 8.3.8 Battery Section ................................................................................................................. 8-8 Block Diagrams.............................................................................................................................. 8-9 8.4.1 Complete .......................................................................................................................... 8-9 8.4.2 Controller ........................................................................................................................ 8-10 8.4.3 VCO ................................................................................................................................ 8-10 8.4.4 Transmitter...................................................................................................................... 8-11 8.4.5 Receiver.......................................................................................................................... 8-11 Troubleshooting Charts ............................................................................................................... 8-12 99R85452E01-O August 30, 2002 iv Table of Contents This Page Intentionally Left Blank August 30, 2002 99R85452E01-O User Safety, Training, and General Information Product Safety and RF Exposure Compliance CAUTION: Before using this product, read the operating instructions for safe usage contained in the Product Safety and RF Exposure booklet enclosed with your radio. ATTENTION! This radio is restricted to occupational use only to satisfy FCC RF energy exposure requirements. Before using this product, read the RF energy awareness information and operating instructions in the Product Safety and RF Exposure booklet enclosed with your radio (Motorola Publication part number 68P81095C98) to ensure compliance with RF energy exposure limits. For a list of Motorola-approved antennas, batteries, and other accessories, visit the following web site which lists approved accessories: http://www.motorola.com/cgiss/index.shtml. vi : Product Safety and RF Exposure Compliance This Page Intentionally Left Blank August 30, 2002 99R85452E01-O Chapter 1 Introduction 1.1 Scope of Manual This manual is intended for use by service technicians familiar with similar types of equipment. It contains service information required for the equipment described and is current as of the printing date. Changes which occur after the printing date may be incorporated by a complete Manual revision or alternatively as additions. NOTE: Before operating or testing these units, please read the User Safety, Training and General Information Section in the front of this manual. 1.2 Warranty and Service Support Motorola offers long term support for its products. This support includes repair of the product during the warranty period, and service/repair or spare parts support out of warranty. Motorola de Colombia Service Center Carrera 7 No. 71-52 Torre B, Piso 13 Oficina 1301 Bogota - Colombia Phone: 571-376-6990 Motorola de Mexico Service Center Bosques de Alisos #125 Col. Bosques de las Lomas CP 05120 Mexico D.F. Phone: 525-257-6700 1.2.1 Warranty Period and Return Instructions Where the product is covered under warranty, a check of the product should be performed prior to shipping the unit. This is to ensure that the product has been correctly programmed or has not been subjected to damage outside the terms of the warranty. Products should be shipped back in the original packaging, or correctly packaged to ensure no damage occurs in transit. 1.2.2 After Warranty Period After the Warranty period, Motorola continues to support its products in two ways. 1. Motorola’s authorized service centers offer a repair service to both end users and dealers at competitive prices. 2. AAD supplies individual parts and modules that can be purchased by dealers who are technically capable of performing fault analysis and repair. 1-2 1.2.3 Introduction: Warranty and Service Support Piece Parts Some replacement parts, spare parts, and/or product information can be ordered directly. If a complete Motorola part number is assigned to the part, it is available from Motorola’s Accessories and Aftermarket Division (AAD). If no part number is assigned, the part is not normally available from Motorola. If the part number is appended with an asterisk, the part is serviceable by Motorola Depot only. If a parts list is not included, this generally means that no user-serviceable parts are available for that kit or assembly. All orders for parts/information should include the complete Motorola identification number. All part orders should be directed to your local AAD office. Please refer to your latest price pages. To order parts in Latin America and the Caribbean: 7:00 a.m. to 7:00 p.m. (Central Standard Time) Monday through Friday (Chicago, USA) 1-847-538-8023 Motorola Parts (Accessories and Aftermarket Division AAD): Attention: Order Processing 1313 E. Algonquin Road Schaumburg, IL 60196 1.2.4 Technical Support https://businessonline.motorola.com Select: "Contact Us" 1.2.5 Parts Identification 1-847-538-0021 (Voice) 1-847-538-8194 (Fax) August 30, 2002 99R85452E01-O Introduction: Radio Model Information 1.3 1-3 Radio Model Information The model number and serial number are located on a label attached to the back of your radio. You can determine the RF output power, frequency band, protocols, and physical packages. The example below shows one portable radio model number and its specific characteristics. Table 1-1. Radio Model Number (Example: LAH49KDH8AA9) LA Type of Unit Model Series Frequency Band Power Level Physical Packages Channel Spacing Protocol H 49 K (136-174 MHz) D 5W H Full Keypad with Display 8 12.5/25K AA Conventional Q (403-440 MHz) C 4W Feature Level 9 Full Keypad R (435-480 MHz) H = Portable Motorola Internal Use 99R85452E01-O August 30, 2002 1-4 1.4 Introduction: Radio Features Radio Features Feature PRO2150 CPS User Yes Yes Rx/Tx X X Cloning X X Factory Reset X VFO X Squelch Level X X Scan List 1 X X Scan List 2 X X Scan List 3 X X Special PL 1,2,3 X Norm/Inv DPL X TOT X X Battery Saver X X Battery Type X X Alert Tone Volume X X Prime Ch X X Prime Ch Return Hang Time X PTT ID (OFF, PRE, POST, BOTH) X PTT ID Sidetone X PTT Short Sidetone X Tx Pretime X Backlight Status X PTT ID X Button Programmability X Access/Deaccess Code X X Telephone No X X PL/DPL Type X Scan Interval Timer X Scan Hang Timer X Channel On/Off X Rx Freq X Tx Freq X Rx PL/DPL X Accessibility Normal Operation August 30, 2002 X 99R85452E01-O Introduction: Radio Features 1-5 Feature PRO2150 CPS User Tx PL/DPL X TOC X Power Level X BCL X Ch Alias X Ch Spacing X PTT ID On/Off X PL Required for Selcall X Scan Type Select X Scan List Select X Copy Ch X Scan Lower Limit X Scan Upper Limit X Freq Step Size X Rx Freq X Tx Freq X Offset Freq X Repeater Offset X Rx PL/DPL X Tx PL/DPL X TOC X Power Level X BCL X Ch Spacing X PTT ID On/Off X Radio Information X X Radio Configuration X X Conventional Personality X X VFO Status X Scan List X X Phone Information X X Signalling X X Programmable Button X X Reverse Burst X X = Indicates available Blank = Indicates unavailable 99R85452E01-O August 30, 2002 1-6 Introduction: Radio Features This Page Intentionally Left Blank August 30, 2002 99R85452E01-O Chapter 2 Maintenance 2.1 Introduction This chapter provides details about the following: • Preventive Maintenance • Safe Handling of CMOS and LDMOS Devices • General Repair Procedures and Techniques • Disassembling and Reassembling the Radio 2.2 Preventive Maintenance The radio does not require a scheduled preventive maintenance program; however, periodic visual inspection and cleaning is recommended. 2.2.1 Inspection Check that the external surfaces of the radio are clean, and that all external controls and switches are functional. It is not recommended to inspect the interior electronic circuitry. 2.2.2 Cleaning Procedures The following procedures describe the recommended cleaning agents and the methods to be used when cleaning the external and internal surfaces of the radio. External surfaces include the front cover, housing assembly and battery case. These surfaces should be cleaned whenever a periodic visual inspection reveals the presence of smudges, grease, and/or grime. NOTE: Internal surfaces should be cleaned only when the radio is disassembled for service or repair. The only recommended agent for cleaning external radio surfaces is a 0.5% solution of a mild dishwashing detergent in water. The only factory recommended liquid for cleaning printed circuit boards and their components is isopropyl alcohol (70% by volume). CAUTION: The effects of certain chemicals and their vapors can have harmful results on certain plastics. Avoid using aerosol sprays, tuner cleaners, and other chemicals. 2.2.2.1 Cleaning External Plastic Surfaces Apply the 0.5% detergent-water solution sparingly with a stiff, non-metallic, short-bristled brush to work all loose dirt away from the radio. Use a soft, absorbent, lintless cloth or tissue to remove the solution and dry the radio. Make sure that no water remains entrapped near the connectors, cracks, or crevices. 2.2.2.2 Cleaning Internal Circuit Boards and Components Apply Isopropyl alcohol (70%) with a stiff, non-metallic, short-bristled brush to dislodge embedded or caked materials located in hard-to-reach areas. The brush stroke should direct the dislodged material out and away from the inside of the radio. Make sure that controls or tunable components are not soaked with alcohol. Do not use high-pressure air to hasten the drying process since this could cause the liquid to collect in unwanted places. After completing the cleaning process, use a soft, absorbent, lintless cloth to dry the area. Do not brush or apply any isopropyl alcohol to the frame, front cover, or back cover. 2-2 Maintenance: Safe Handling of CMOS and LDMOS Devices NOTE: Always use a fresh supply of alcohol and a clean container to prevent contamination by dissolved material (from previous usage). 2.3 Safe Handling of CMOS and LDMOS Devices Complementary metal-oxide semiconductor (CMOS) devices are used in this family of radios, and are susceptible to damage by electrostatic or high voltage charges. Damage can be latent, resulting in failures occurring weeks or months later. Therefore, special precautions must be taken to prevent device damage during disassembly, troubleshooting, and repair. Handling precautions are mandatory for CMOS circuits and are especially important in low humidity conditions. DO NOT attempt to disassemble the radio without first referring to the following CAUTION statement. CAUTION: This radio contains static-sensitive devices. Do not open the radio unless you are properly grounded. Take the following precautions when working on this unit: • Store and transport all CMOS devices in conductive material so that all exposed leads are shorted together. Do not insert CMOS devices into conventional plastic “snow” trays used for storage and transportation of other semiconductor devices. • Ground the working surface of the service bench to protect the CMOS device. We recommend using the Motorola Static Protection Assembly (part number 0180386A82), which includes a wrist strap, two ground cords, a table mat, and a floor mat. • Wear a conductive wrist strap in series with a 100k resistor to ground. (Replacement wrist straps that connect to the bench top covering are Motorola part number RSX4015.) • Do not wear nylon clothing while handling CMOS devices. • Do not insert or remove CMOS devices with power applied. Check all power supplies used for testing CMOS devices to be certain that there are no voltage transients present. • When straightening CMOS pins, provide ground straps for the apparatus used. • When soldering, use a grounded soldering iron. • If at all possible, handle CMOS devices by the package and not by the leads. Prior to touching the unit, touch an electrical ground to remove any static charge that you may have accumulated. The package and substrate may be electrically common. If so, the reaction of a discharge to the case would cause the same damage as touching the leads. 2.4 Repair Procedures and Techniques — General 2.4.1 Parts Replacement and Substitution When damaged parts are replaced, identical parts should be used. If the identical replacement part is not locally available, check the parts list for the proper Motorola part number and order the part from the nearest Motorola Communications parts center listed in the Piece Parts section of this manual. 2.4.2 Rigid Circuit Boards This radio uses bonded, multi-layer, printed circuit boards. Since the inner layers are not accessible, some special considerations are required when soldering and unsoldering components. The printedthrough holes may interconnect multiple layers of the printed circuit. Therefore, exercise care to avoid pulling the plated circuit out of the hole. August 30, 2002 99R85452E01-O Maintenance: Repair Procedures and Techniques — General 2-3 When soldering near the 20-pin and 40-pin connectors: • Avoid accidentally getting solder in the connector. • Be careful not to form solder bridges between the connector pins. • Examine your work closely for shorts due to solder bridges. 2.4.3 Flexible Circuits The flexible circuits are made from a different material than the rigid boards, and require different soldering techniques. Excessive prolonged heat on a flexible circuit can damage the material. Therefore, avoid excessive heat and excessive bending. For parts replacement, use the ST-1087 Temperature-Controlled Solder Station with a 600-700 degree F tip, and use small diameter solder such as ST-633. The smaller size solder will melt faster and require less heat to be applied to the circuit. To replace a component on a flexible circuit: 1. Grasp with seizers (hemostats) the edge of the flexible circuit near the part to be removed. 2. Pull gently. 3. Apply the tip of the soldering iron to the component connections while pulling with the seizers. NOTE: Do not attempt to puddle-out components. Prolonged application of heat may damage the flexible circuit. 2.4.4 Chip Components Use either the RLN-4062 Hot-Air Repair Station or the Motorola 0180381B45 Repair Station for chip component replacement. When using the 0180381B45 Repair Station, select the TJ-65 minithermojet hand piece. On either unit, adjust the temperature control to 700 degrees F. (370 degrees C), and adjust the airflow to a minimum setting. Airflow can vary due to component density. • To remove a chip component, select a hot-air hand piece and position the nozzle of the hand piece approximately 1/8” above the component to be removed. Begin applying hot air. Once the solder reflows, remove the component using a pair of tweezers. Using solder wick and a soldering iron or a power desoldering station, remove the excess solder from the pads. • To replace a chip component using a soldering iron, select the appropriate micro-tipped soldering iron and apply fresh solder to one of the solder pads. Using a pair of tweezers, position the new chip component in place while heating the fresh solder. Once solder wicks onto the new component, remove the heat from the solder. Heat the remaining pad with the soldering iron and apply solder until it wicks to the component. If necessary, touch up the first side. All solder joints should be smooth and shiny. • To replace a chip component using hot air, select the hot-air hand piece and reflow the solder on the solder pads to smooth it. Apply a drop of solder paste flux to each pad. using a pair of tweezers, position the new component in place. Position the hot-air hand piece approximately 1/8” above the component and begin applying heat. Once the solder wicks to the component, remove the heat and inspect the repair. All joints should be smooth and shiny. 99R85452E01-O August 30, 2002 2-4 2.4.5 Maintenance: Disassembling and Reassembling the Radio — General Shields Removing and replacing shields will be done with the R-1070 station with the temperature control set to approximately 415°F (215°C); 445°F (230°C) max. • To remove the shield, place the circuit board in the R-1070’s holder. Select the proper heat focus head and attach it to the heater chimney. Add solder paste flux around the base of the shield. Position the shield under the heat-focus head. Lower the vacuum tip and attach it to the shield by turning on the vacuum pump. Lower the focus head until it is approximately 1/8” (0.3cm) above the shield. Turn on the heater and wait until the shield lifts off the circuit board. Once the shield is off, turn off the heat, grab the part with a pair of tweezers, and turn off the vacuum pump. Remove the circuit board from the R-1070’s circuit board holder. • To replace the shield, add solder to the shield if necessary, using a micro-tipped soldering iron. Next, rub the soldering iron tip along the edge of the shield to smooth out any excess solder. Use solder wick and a soldering iron to remove excess solder from the solder pads on the circuit board. Place the circuit board back in the R1070’s circuit board holder. Place the shield on the circuit board using a pair of tweezers. Position the heat-focus head over the shield and lower it to approximately 1/8” above the shield. Turn on the heater and wait for the solder to reflow. Once complete, turn off the heat, raise the heat-focus head and wait approximately one minute for the part to cool. Remove the circuit board and inspect the repair. No cleaning should be necessary. 2.5 Disassembling and Reassembling the Radio — General Since these radios may be disassembled and reassembled with the use of only four (board to casting) screws, it is important to pay particular attention to the snaps and tabs, and how parts align with each other. The following tools are required for disassembling the radio: • Phillips screwdriver • 4mm socket wrench If a unit requires more complete testing or service than is customarily performed at the basic level, send this unit to a Motorola Authorized Service Center. August 30, 2002 99R85452E01-O Maintenance: Radio Disassembly — Detailed 2-5 2.6 Radio Disassembly — Detailed 2.6.1 Front Cover from Chassis Disassembly 1. Turn off the radio. 2. Remove the battery: a. Slide the battery clasp away from the radio (See Figure 2-1.). Figure 2-1. b. Slide battery down and away from radio. 3. Remove the antenna. 4. Pull the On/Off Volume knob off of its shaft. 5. Remove the two screws at the back of the rear chassis (See Figure 2-2.). Insert screwdriver here to remove chassis. Figure 2-2. 6. Insert a small flat-head screwdriver at the bottom of the radio, between the chassis and housing (location marked in Figure 2-2), and lift the chassis gently. Be careful not to damage the housing or the O-ring underneath. 99R85452E01-O August 30, 2002 2-6 Maintenance: Radio Disassembly — Detailed 7. Lift the rear chassis away from the front cover (See Figure 2-3.). Be careful not to damage the speaker wire underneath. Figure 2-3. 8. Slide the rear chassis downwards, and away from the front cover. 9. Remove the speaker connector, which connects between RF Board and the internal speaker on the front cover (See Figure 2-4.). Figure 2-4. August 30, 2002 99R85452E01-O Maintenance: Radio Disassembly — Detailed 2.6.2 2-7 Control Board Disassembly 1. Remove the screws which hold the control board to the RF board. 2. Remove the control board which is connected to the RF board through a board-to-board connector (See Figure 2-5.). Board-to-board connector Figure 2-5. 2.6.3 RF Board Disassembly 1. Remove the screws and the stud which hold the RF board to the rear diecast with the Phillips head screwdriver and socket wrench respectively. 2. Gently remove the RF board from rear diecast. The completely disassembled radio is shown in Figure 2-6. Figure 2-6. NOTE: The Control and RF boards are mounted with cross recess screws meeting the Phillips Cross Slot number 1 standard. Using a Phillips 0 will damage the screw recesses as will a poorly fitting Phillips 1 screwdriver. One example of a correct fitting screwdriver is manufactured by PB Baumann (http://www.pbtools.ch/index_e.html) and is available from many electronic tool dealers. The PB Baumann item number is 121/1-70. Other high quality manufacturer's pruducts meeting the Phillips 1 standard are also acceptable. 99R85452E01-O August 30, 2002 2-8 Maintenance: Radio Reassembly — Detailed 2.7 Radio Reassembly — Detailed 2.7.1 RF Board Reassembly 1. Place the RF board on the rear diecast. 2. Tighten the screws and the stud. 2.7.2 Control Board Reassembly 1. Place the control board on the RF board. 2. Connect the control board to the RF board by pressing it firmly downwards at the board-toboard connector (See Figure 2-7.). Board-to-board Connector Figure 2-7. 3. Tighten the screws using a screwdriver to hold the control board in place. 2.7.3 Chassis and Front Cover Reassembly 1. Remove the metal retainer with a small flat head screwdriver (See Figure 2-11.). Retainer Housing tab Figure 2-8. August 30, 2002 99R85452E01-O Maintenance: Radio Reassembly — Detailed 2-9 2. Remove the rubber button insert behind the retainer (See Figure 2-9.). Rubber button Figure 2-9. 3. Push left hand side PTT hook until it releases (See Figure 2-10.). PTT hooks Figure 2-10. 4. Push right hand side PTT hook until PTT button is completely released. 5. Reinstall the rubber insert and metal retainer. 6. Connect the RF board to the internal speaker on the front cover with the speaker connector (See Figure 2-11.). Figure 2-11. 99R85452E01-O August 30, 2002 2-10 Maintenance: Radio Reassembly — Detailed 7. Place the front cover over the tabs on the rear diecast. 8. Insert the On/Off Volume shaft into the front cover opening. 9. Lower the front cover until the bottom edges snap firmly into place on the rear diecast (See Figure 2-12.). Figure 2-12. 10. Tighten the two (2) screws at the bottom of rear diecast using a screwdriver (See Figure 2-13.). Figure 2-13. 11. Reinsert the PTT button (See Figure 2-15.). Large hook side Press to insert Figure 2-14. August 30, 2002 99R85452E01-O Maintenance: Radio Reassembly — Detailed 2-11 12. Attach the battery. 13. Attach the On/Off Volume knob and the antenna. Figure 2-15. 99R85452E01-O August 30, 2002 2-12 Maintenance: Mechanical View and Parts List Mechanical View and Parts List 2.8.1 Exploded View and Parts List 16 8a 13 3b 3a 17 7a 7b 1 7c 7d 9 5 4b 4a 2a 11 6 12 2b 15 8b 2c 10 2d 2e 8c 2f 2g 14 2.8 Figure 2-16. August 30, 2002 99R85452E01-O Maintenance: Mechanical View and Parts List Part Number Item Description 1 DS1M001110 Front Cover Kit 2 DS1M001120 Chassis Hardware Kit 2a Rod (M2) 2b Heatsink Tape 2c DSM4193013 Gasket (Screw M2.6) 2d DSM1B26051 Screw M2.6 2e PCB Bracket 2f Screw M2 Cfims 2g External Tape 3 DS1M001130 Knob Assembly 3a Knob 3b Spring (D4.75) 4 DS1M001140 External Cover Kit 4a External Cover 4b External Cover Cap 5 Model Dependent Controller Board Assembly 6 Model Dependent RF Board Assembly 7 DS1M001170 LCD Kit 7a LCD Bracket 7b LCD 7c Interconnector 7d Reflector 8 99R85452E01-O 2-13 DSM4193042 PRO2150 Nameplate 8a Label Nameplate 8b Label Serial 8c Label Tuning 9 DS1M001190 Speaker Assembly 10 PMNN4046 Battery 11 DSM2192004 Contact Gasket 12 DSM2192005 Main Gasket 13 DSM2192006 Volume Gasket 14 HLN9844_ Beltclip August 30, 2002 2-14 Maintenance: Service Aids Part Number Item Description 15 DSM5190001 Back Housing 16 DSM6189003 PTT Button Frequency dependent. Please see “6.1 Antenna 17 Antennas” on page 6-1 2.9 Service Aids Table 2-1 lists service aids recommended for working on the PRO2150 Portable Radio. While all these items are available from Motorola, most are standard shop equipment items, and any equivalent item capable of the same performance may be substituted for the item listed. Table 2-1. Motorola Part No. Description Application H5197 HKVN4002_ Customer Programming and Tuning Software (CD) Program customer options, channel data, and tuner hardware parameters, front end, power, etc. DSK001C706 Programming Cable (2.5mm) Connects radio and IF Test Box to Computer. AAPMKN4003_ Cloning Cable (2.5mm) To clone programmable information from one radio to another radio. DSK001C704 Test Cable Connects radio to IF Test Box. DSK001C714 Interconnect Service Cable Connects RF board and CPU board. DSK001C702 IF Test Box Enables connection to the audio/accessory jack. Allows switching for radio testing. DSK001C705 Battery Eliminator Interconnects radio to power supply (red-and-black power cable included). DSK001C719 Antenna Ground Plate To improve the grounding while tuning and doing conducted measurement. HLN8262_ BNC Adaptor Adapts radio’s antenna port to BNC cabling of test equipment. August 30, 2002 99R85452E01-O Maintenance: Test Equipment 2-15 2.10 Test Equipment Table 2-2 lists test equipment required to service the PRO2150 Portable Radio and other two-way radios. Table 2-2. Motorola Part No. Description Characteristics Application *R1049 Digital Multimeter Two meters recommended for AC/DC voltage and current measurements *S1100 Audio Oscillator 67 to 200Hz tones Used with service monitor to inject PL tones *S1053, *SKN6009, *SKN6001 AC Voltmeter, Power Cable for meter, Test leads for meter 1 mV to 300 V, 10 Mega Ohm input impedance Audio voltage measurements R1053 Dual-trace Oscilloscope 20 MHz bandwidth, 5 mV/cm - 20 V/cm Waveform measurements *S1350, *ST1215 (VHF) *ST1223 (UHF) *T1013 Wattmeter, Plug-in Elements (VHF & UHF), RF Dummy Load 50-Ohm, ±5% accuracy 10 W, max. 0-1000 MHz, 300 W Transmitter power output measurements S1339 RF Millivolt Meter 100 µV to 3 VRF, 10 kHz to 1.2 GHz RF level measurements *R1013 SINAD Meter S1347 or S1348 (prog) DC Power Supply Receiver sensitivity measurements 0-20 Vdc, 0-5 Amps Bench supply for 7.5Vdc *Frequency/deviation meter and signal generator for wide-range troubleshooting and alignment 99R85452E01-O August 30, 2002 2-16 Maintenance: Programming Cable (DSK001C706) 2.11 Programming Cable (DSK001C706) To: PC RS232C 9PD-SUB D101 1SS362 C101 0.1 1: DCD 2: RXD 3: TXD 4: DTR 5: GND D102 1SS362 6: DSR 7: RTS 8: CTS 9: RI R103 10k R101 10k Q101 UMW1N R104 10k Q102 UMW1N R102 10k PROG GN D Figure 2-17. 5 4 9 3 8 2 7 1 6 Figure 2-18. August 30, 2002 99R85452E01-O Maintenance: IF Test Box (DSK001C702) 2-17 2.12 IF Test Box (DSK001C702) D-Sub 9P 9 Non 8 Non 7 SP + 6 SP - 5 GND 4 Non SP101 3 Mic 2 PRG 1 Non INT_SPEAKER R101 24 ohm S101 Out on/off S102 Spk/Load P101 SPK OUT T101 Balan J101 Mic/Prog Input R102 10k C101 S103 INT_PTT P102 Mic Input 1/25V Figure 2-19. 99R85452E01-O August 30, 2002 2-18 Maintenance: IF Test Box (DSK001C702) This Page Intentionally Left Blank August 30, 2002 99R85452E01-O Chapter 3 Radio Tuning 3.1 Introduction This chapter provides an overview of the software and hardware tuning material available for the PRO2150 Portable Radio. The PRO2150 Portable Radio’s Customer Programming and Tuner Software are designed for use in a Windows 95/98/NT environment. This software covers all the functions of the traditional Radio Service Software (RSS) package. An Installation instruction manual is contained within each kit. Description Kit Number Customer Programming and Tuning Software (CD) 3.2 H5197 HKVN4002_ Software Tuning Setup A Windows 95/98/NT PC (personal computer) and Tuner are required to tune parameters such as power, sensitivity, squelch and RSSI. To perform the tuning procedures, the radio must be connected to the PC and IF Test Set as shown in the figure below. Refer to online help files for specific tuning procedures. See Figure 3-2, how to attach the radio. Ground Contact Finger (Refer to Figure below on how to attach to radio) Antenna Port Acc Jack Radio Test Cable (DSK001C704) IF TEST SET DSK001C702 9 Pin Connector BNC BNC Spk Mic Programming Cable (DSK001C706) N Type TEST EQUIPMENT BNC Input BNC Output Figure 3-1. Comm Port 3-2 3.3 Radio Tuning: Affixing Antenna Ground Plate Affixing Antenna Ground Plate (Strictly for Radio’s Testing and Tuning Purpose Only) 1. Insert the antenna ground plate (DSK001C719) through the antenna adaptor (HLN8262). Antenna Adaptor Ground Plate Figure 3-2. 2. Screw the antenna adaptor into the radio’s antenna jack as shown in Figure 3-3. NOTE: Make sure the antenna ground plate is placed properly before the battery eliminator is inserted to the radio. This is to ensure that the radio has a better grounding. Antenna Adaptor Ground Plate Figure 3-3. August 30, 2002 99R85452E01-O Radio Tuning: Hardware Tuning Setup and Procedure 3.4 3-3 Hardware Tuning Setup and Procedure There is a silver seal on the bottom left of the radio chassis. Remove the seal to expose the two potentiometers for audio and sub-audio (CTCSS) modulation adjustment. RV601, which is slightly higher, is the trimmer potentiometer for audio modulation tuning. The lower trimmer potentiometer (RV602) is meant for sub-audio modulation tuning. RV601 RV602 Figure 3-4. 3.4.1 Audio Modulation Tuning 1. Set the radio to transmit at the appropriate tuning frequency (See “Tuning Frequency” in Table 3-1) with low power. Set Channel Spacing to "CS-25.0" for 25kHz (see “Radio Programming” section). 2. On the test equipment, set it to receive at the appropriate tuning frequency (See “Tuning Frequency” on page 3-4) and with the following configurations: Audio bandwidth: 0.25Hz to 15,000Hz. De-emphasis: OFF 3. Inject a 60mV 1kHz tone to the radio through the external mic connector. 4. Key up the radio. 5. Using a ceramic tuning tool, adjust RV601 to tune the audio modulation deviation to settle between 4.3kHz to 4.5kHz. 99R85452E01-O August 30, 2002 3-4 3.4.2 Radio Tuning: Hardware Tuning Setup and Procedure Sub-Audio Modulation Tuning 1. Set the radio to transmit at the appropriate tuning frequency (See “Tuning Frequency” on table 3-1) with low power and TX PL frequency of 100.0Hz. Set Channel Spacing to "CS25.0" for 25kHz (see “Radio Programming” section). 2. On the test equipment, set it to receive at the appropriate tuning frequency (see “PRO2150 Portable Radio Programming” section) and with the following configurations: Audio bandwidth: 0.25Hz to 3,000Hz. De-emphasis: OFF 3. Do NOT inject any tone to the radio. 4. Key up the radio. 5. Using a ceramic tuning tool, adjust RV602 to tune the sub-audio modulation deviation to settle between 0.65kHz to 0.75kHz. 3.4.3 Tuning Frequency Table 3-1. August 30, 2002 Band Frequency (MHz) VHF 136-174 MHz 155.025 UHF 403-440 MHz 421.5 UHF 435-480 MHz 457.5 99R85452E01-O Chapter 4 Radio Programming 4.1 Introduction The PRO2150 Portable Radio can be programmed by using the Customer Programming Software (CPS). 4.2 Programming Your Radio 4.2.1 Overview of the Programming Process To prepare properly programmed radios for your customers, you should: 1. Program one radio with all the necessary parameters, as required by your customers. 2. Clone these parameters over to all your customer’s radios. 4.2.2 Cloning Radio Parameters to User Radios Cloning duplicates the contents of Radio 1 (master radio) into Radio 2 (slave radio). However, tuning and alignment information are not affected by cloning. 4.2.3 Parameters Which are Cloned • Radio Wide parameters • Channel settings • VFO settings 4.2.4 Parameters Which are Not Cloned • All hardware tuning and alignment parameters • Unit Serial Number 4.2.5 To Clone a Radio Cloning duplicates the contents of your radio (master radio) into your customer’s radio (slave radio). Tuning and alignment information are not affected by cloning. 1. Turn off both the master and slave radios (if any of them are turned on). 2. Connect both radios with the cloning cable through the Programming Port (lower port of the Accessory Connector). 3. Turn on the slave radio. 4. Press and hold the A button, and turn on the master radio. 5. The master radio displays CLONE if cloning can proceed, otherwise an error message is shown. 6. The slave radio displays PROG while it is being programmed. 7. When cloning is completed, the master radio displays END, and the slave radio resets automatically. 8. Disconnect radios from the cloning cable. They are now ready for operation. 4-2 4.2.6 Radio Programming: CPS Programming Error Conditions An error may occur when cloning a radio. When this happens, an error message is displayed. The following is a list of causes and the possible solutions for each error message. Error Message 4.3 Description TIME OUT Data communications time-out. Please ensure that the slave radio is switched on, and the cloning cable is properly connected. BCC ERR Data communications checksum error. TYPE ERR Mismatch in model numbers. Please ensure that the master and slave radios are of the same model number. CMD ERR Data communications command error. CPS Programming The CPS is designed for use in the Windows 95/98/NT environment. An Installation instruction manual is contained within each CPS kit. Description Kit Number PRO2150 Customer Programming and Tuning Software (CD) H5197 HKVN4002_ Refer to online help files for the CPS Programming procedures. Radio Programming Cable (2.5mm) DSK001C706 Comm Port Figure 4-1. August 30, 2002 99R85452E01-O Radio Programming: Programming 4-3 4.4 Programming 4.4.1 PL Frequencies and Codes PL Freq (Hz) Motorola Code Equiv. PL Code PL Freq (Hz) Motorola Code Equiv. PL Code 67 001 XZ 136.5 022 4Z 69.3 002 WZ 141.3 023 4A 71.9 003 XA 146.2 024 4B 74.4 004 WA 151.4 025 5Z 77 005 XB 156.7 026 5A 79.7 006 WB 162.2 027 5B 82.5 007 YZ 167.9 028 6Z 85.4 008 YA 173.8 029 6A 88.5 009 YB 179.9 030 6B 91.5 010 ZZ 186.2 031 7Z 94.8 011 ZA 192.8 032 7A 97.4 012 ZB 203.5 033 M1 100 013 1Z 206.5 034 8Z 103.5 014 1A 210.7 035 M2 107.2 015 1B 218.1 036 M3 110.9 016 2Z 225.7 037 M4 114.8 017 2A 229.1 038 9Z 118.8 018 2B 233.6 039 M5 123 019 3Z 241.8 040 M6 127.3 020 3A 250.3 041 M7 131.8 021 3B 254.1 042 0Z PL1 PL1 PL2 PL2 PL3 PL3 NOTE: PL1, PL2, PL3 are the User Defined PL Frequencies. 99R85452E01-O August 30, 2002 4-4 4.4.2 Radio Programming: Programming DPL Codes DPL Code Motorola Code DPL Code Motorola Code DPL Code Motorola Code DPL Code Motorola Code 23 043 152 065 343 087 606 109 25 044 155 066 346 088 612 110 26 045 156 067 351 089 624 111 31 046 162 068 364 090 627 112 32 047 165 069 365 091 631 113 43 048 172 070 371 092 632 114 47 049 174 071 411 093 645* 115 51 050 205 072 412 094 654 116 54 051 223 073 413 095 662 117 65 052 226 074 423 096 664 118 71 053 243 075 431 097 703 119 72 054 244 076 432 098 712 120 73 055 245 077 445 099 723 121 74 056 251 078 464 100 731 122 114 057 261 079 465 101 732 123 115 058 263 080 466 102 734 124 116 059 265 081 503 103 743 125 125 060 271 082 506 104 754 126 131 061 306 083 516 105 132 062 311 084 532 106 134 063 315 085 546 107 143 064 331 086 565 108 NOTE: The codes marked with an asterisk are not part of the 83 standard EIA/TIA-603 codes. 4.4.3 Examples 4.4.3.1 Setting Up a Scan List Scenario: To setup Scan List 2 with the following channels - CH 008, CH 036, CH 092, CH 083, CH 068. Steps: 1. Enter Programming Mode, by pressing MON and turning on the radio. 2. Press PTT or MON until SCANLST2 is displayed. 3. Press +. The first scan list member holder, 2-01-, will be displayed. Use the keypad to enter 008. August 30, 2002 99R85452E01-O Radio Programming: Programming 4-5 4. Press + again. Enter 036, when 2-02- appears, and subsequently in this manner, enter the other channels. NOTE: If a mistake is made, use + or - to move to the appropriate scan list member holder and press # to erase the channel number. 5. Press PTT or MON, when all the channel numbers have been entered. 6. Turn off your radio, if you have completed the programming, or proceed to the next parameter. 4.4.3.2 Programming a Phone Number/Access Code/De-Access Code Scenario: To program the phone number, 9-72886338 (where “-” represents a Pause digit), at memory location 8. Steps: 1. Enter Programming Mode, by pressing MON and turning on the radio. 2. Press PTT or MON until TELNO-8 is displayed. 3. Press +. The cursor will be placed on the first character. 4. Use the keypad to enter 9. 5. Enter a Pause digit, by entering * followed by #. These two characters will be converted into a Pause, represented by ‘-’. NOTE: Each Pause digit entered shortens the overall length of the code/number by a digit. 6. Use the keypad to enter the rest of the phone number. NOTE: If a mistake is made, use + or - to move to the appropriate location and then re-enter the correct character. To erase the complete phone number/code, enter # 16 times. 7. Press PTT or MON, when the complete phone number has been entered. 8. Turn off your radio, if you have completed the programming, or proceed to the next parameter. 99R85452E01-O August 30, 2002 4-6 Radio Programming: Programming This Page Intentionally Left Blank August 30, 2002 99R85452E01-O Chapter 5 Error Code Displays 5.1 Error Codes The radio performs cursory tests during start-up and during operations to determine if its basic electronics and software are in working order . Problems detected during these tests are presented as error codes on the radio display. The presence of an error code means that a problem exists and that the user should contact a service technician. Use the following table to aid in understanding particular error code displays. Table 5-1. Failure Display Description MEM ERR Defective ROM. EEP ERR Defective external EEPROM. Codeplug data is corrupted. PLL ERR The radio cannot receive or transmit on the programmed frequencies. 5-2 Error Code Displays: Error Codes This Page Intentionally Left Blank August 30, 2002 99R85452E01-O Chapter 6 Accessories 6.1 6.2 6.3 6.4 6.5 Antennas 8504762J01_ 14cm Antenna, 136-155MHz 8504762J02_ 14cm Antenna, 155-174MHz PMAD4012_ 9cm Antenna, 136-155MHz PMAD4013_ 9cm Antenna, 155-174MHz PMAE4010_ 10cm Antenna, 403-440MHz PMAE4011_ 10cm Antenna, 435-480MHz NAE6483_ Whip Antenna, 403-520MHz Carrying Accessories 4285820Z01 Shoulder Strap HLN9844_ Belt Clip (1.5") HLN9985_ Waterproof Bag RLN4815_ Universal RadioPak Carry Case JMZN4020_ Handstrap for Radio Carry Cases PMLN4467_ Carrying Case, Soft Leather Black PMLN4468_ Carrying Holster Case, Neoprene Grey PMLN4469_ Carrying Holster Case, Neoprene Blue Chargers PMTN4047_ Wall Charger (16Hr), 230V, EU PMTN4052_ Wall Charger (16Hr), 230V, UK PMTN4053_ Wall Charger (16Hr), 110V, US HTN9071_ Wall Charger (24Hr), 230V, ARG PMTN4049_ Rapid Charger (3Hr), 230V, EU PMTN4050_ Rapid Charger (3Hr), 240V, UK PMTN4048_ Rapid Charger (3Hr), 110V, US Batteries PMNN4046_ 6.6 Battery Std NiMH Audio Accessories PMLN4442_ MAG ONE Earbud w/In-line PTT/MIC/Vox Switch 6-2 6.7 6.8 Accessories: Manuals PMLN4443_ MAG ONE Ear Receiver w/In-line PTT/MIC/Vox Switch PMLN4444_ MAG ONE Earset Boom Mic w/In-line PTT/Vox Switch PMLN4445_ MAG ONE Ultra-lightweight Headset w/in-line PTT/Vox PMMN4008_ MAG ONE Remote Speaker Mic HMN9030_ Remote Speaker Microphone PMLN4294_ Ear Set Microphone w/PTT PMLN4425_ Earset Boom Mic w/Remote Ring PTT BDN6646_ Ear Mic w/PTT BDN6647_ Lightweight Single Speaker w/Swivel BDN6648_ Hvy-duty Hdset w/Noise Canceling Mic BDN6720_ Flex Rec. Earpiece w/o Volume Control HMN9022_ Medweight Dual Muff Headset (behind) HMN9752_ Earpiece w/Volume Control HMN9787_ Lightweight Headset w/Swivel Boom Mic HMN9013_ Lightweight Headset w/Swivel Boom Mic HMN9021_ Medweight Dual Muff Headset (overhead) HMN9036_ Earbud w/clip Mic and PTT HMN9727_ Earpiece w/o Volume Control Manuals HKLN4197_ PRO2150 Portable Radio User Guide (English, Spanish, and Portuguese) HKLN4204_ PRO2150 Portable Radio Detailed Service Manual (English) Software H5197 2 Year CPS Subscription HKVN4002_ PRO2150 Customer Programming and Tuning Software (CD) August 30, 2002 99R85452E01-O Chapter 7 VHF Band Information 7.1 Model Chart PRO2150 Portable Radio, VHF, 136-174 MHz Model LAH49KDH8AA9_N Description PRO2150, 136-174MHz, 1-5W, 12.5/25K-99ch Item Description X PMUD1738_ _ L PRO2150, 136-174MHz, 1-5W, 12.5/25K X DS1M001110 Front Cover Kit X DS1M001120 Chassis Hardware Kit X DS1M001130 Knob Assembly X DS1M001140 Ext. Cover Kit X DS1M001150 Controller Board Assembly VHF PRO2150 X DS1M001160 RF Board Assembly X DS1M001170 LCD Kit X DS1M001190 Speaker Assembly X DSM1B26051 Screw M2.6 X DSM2192004 Contact Gasket X DSM2192005 Main Gasket X DSM2192006 Volume Gasket X DSM4193013 Gasket (Screw 26) X DSM5190001 Housing, Back X DSM6189003 PTT Button X PMNN4046_ Battery Std NiMH X X X X PMAD4012_ PMAD4013_ PMAD4014_ PMAD4015_ VHF 9cm Antenna, 136-155MHz VHF 9cm Antenna, 155-174MHz VHF 15cm Antenna, 136-155MHz VHF 15 cm Antenna, 155-174MHz X PMTN4053_ Std Wall Charger 110V US X DSM4193042 PRO2150 Nameplate X HLN9844_ Belt Clip X HKLN4197_ PRO2150 Portable Radio User Guide CD (English, Spanish, and Portuguese) x = Indicates one of each is required. 7-2 7.2 Specifications Specifications Receiver General VHF Frequency: Channel Capacity: Power Supply: Dimensions with Standard High Capacity NiMH Battery: Weight: with Standard High Capacity NiMH Battery: Average Battery Life @ (5-5-90 Duty Cycle) Sealing: Shock and Vibration: Dust: Humidity: 136-174 MHz 99 7.5 Volts ±20% 115.5mm x 56mm x 35mm 350 g (Low Power) (High Power) >11 hrs >8 hrs Passes rain testing per IPX4 (EN60529=1991) Meets MIL STD 810C, D and E Meets MIL STD 810C, D and E Weather resistant housing passes EIA RS-316B VHF 12.5 kHz Sensitivity 12dB SINAD: Adjacent Channel Selectivity EIA Intermodulation Spur Rejection: Image Rejection: Hum and Noise Audio Distortion Conducted Emmision Audio Output @ <5% Distortion VHF 25 kHz 0.25 µV 0.25 µV 60 dB 65 dB 60 dB 60 dB 60 dB 40 dB < 5% -57 dBm 65 dB 65 dB 65 dB 500 mW 500 mW All specifications are subject to change without notice. Transmitter VHF RF Output NiMH @ 7.5V: Channel Spacing Freq. Stability (-30°C to +60°C) Spurs/Harmonics: Audio Response: (from 6 dB/oct. PreEmphasis, 300 to 3000Hz) Audio Distortion: @ 1000 Hz, 60% Rated Max. Dev. FM Noise: August 30, 2002 Low 1W 12.5/25 kHz 0.00025% High 5W -26 dBm +1, -3 dB <5% 40 dB 99R85452E01-O VHF Band Information: Theory of Operation 7.3 Theory of Operation 7.3.1 General Information 7-3 Your radio has two printed circuit boards: the Controller board, and the Radio Frequency (RF) board. The Controller board contains the CPU/Control section. The RF board contains the VCO/Synthesizer section, Transmitter section, Receiver section, Transmitter Audio circuitry, Receiver Audio circuitry, and Battery section. 7.3.2 Power Distribution Audio Power AMP Q702 VCO Buffer Q308 PLL IC Q323 Ripple Filter Q330 TX/RX SW Q309,310 TX VCO Q325 RX VCO Q324 RF AMP Q404 RF PA Q411 IF AMP Q408 IF AMP Q506 LPF Q502 HPF Q505 Driver AMP Q412 + SW B Power Switch SW201 Battery Local AMP Q416 SAVE SW Q210 RX SW Q211 5V REG Q204 TX/RX SW Q208,209 RX +5V MIC AMP Q602 Sub Audio LPF Q610 TX Driver Q413,414 RF Power Control Q419 TX REG Q201,202 TX +5V Reset Q105 CPU EEPROM Q101 Q114 Divide by 2 Q122 DA Converter Q121 DTMF Decode Q120 Diode Q126 Figure 7-1. The above figure illustrates the DC distribution throughout the radio board. A battery supplies power directly to the electronic on/off control. Radio power supply is triggered by the Power Switch (On/ Off/Volume control) and +SW B is distributed as show in the figure. Regulator output 5V is supplied to the CPU. +SW B continues to support the Audio Power AMP, 5V Regulator, TX Regulator until the radio is turned off. The radio can be turned off on two ways: 1. Power Switch turned-off 2. Low Battery When a low battery level is detected by the CPU, it stores the radio personality data to EEPROM before turning off the radio. 7.3.3 Power up Sequence 1. Power supply is turned on by the On/Off/Volume Control (Power Switch). 2. Power from battery is supplied to the regulator through the switch. 3. Output (5V) from the regulator is directed to the CPU (Q101). 4. Q105 resets the CPU (Q101). 5. The CPU loads radio personality data from EEPROM after the reset. 6. This personality data is used to initialize the radio. 99R85452E01-O August 30, 2002 7-4 VHF Band Information: Theory of Operation 7. The radio restores last power up state (i.e. state before the radio was turned-off). 8. Power is supplied to PLL circuitry. 9. Power is supplied to Rx and Rx VCO circuitry. 10. CPU sends data to PLL circuitry. If LOCK status is confirmed, radio continues the power-up sequence. Otherwise, PLL ERR is displayed. 11. If the Rx audio level is less than the pre-programmed squelch level, and other unmuting conditions are met, the radio will open squelch. 7.3.4 CPU / Control Section When the radio is turned ON, the CPU (Q101) reads the radio status from the EEPROM Q114. It also monitors the keypad, the PTT line and other inputs such as the squelch detect, etc. continuously. When there is a channel change, the CPU sends the correct frequency information to the synthesizer via pins 1, 2 and 89. The CPU is clocked by the 8.388608MHz oscillator, which is composed of X101, C101, C106, and R158. 7.3.5 VCO / Synthesizer Section This section consists of the Temperature-Compensated Crystal Oscillator (TCXO), Voltage Controlled Oscillator (VCO), Synthesizer and the Loop Filter. These circuits are found on the RF board. 7.3.5.1 Temperature-Compensated Crystal Oscillator (TCXO) The reference oscillator is a temperature compensated crystal-controlled, Pierce type circuit. It utilizes a logic gate within Q323 as a gain element. C335 is used to adjust the oscillator on frequency (14.4MHz) at room temperature (22°C). Temperature variations cause resistance changes in thermistor R330 and R567, which is on the base of Q320, thus varying the voltage applied to varactor Q322. This changes the impedance across crystal X301 in a manner complementary to the temperature drift characteristic of the crystal. In this way, the reference oscillator is held within the specified ±2.5 PPM from -30 to +60°C. 7.3.5.2 Voltage-Controlled Oscillators Only one of the VCOs runs at a time, which is controlled by Q310 and Q101. The receive VCO consists of C344-C351, L302, L305, L306, L312-L314, Q311, and Q324. This VCO oscillates at 45.1 MHz above the programmed receive frequency. The VCO’s oscillating frequency is tuned by the varactor Q311. The tuning voltage is supplied from the output of the Loop Filter. The output of the VCO is AC coupled (C352) to the buffer Q308. The output of the VCO buffer Q308 is AC coupled (C308) to the synthesizer and the output buffer Q416 respectively. When the PTT is pressed, Q101 pin36 goes low (approx. 0V) disabling the receive VCO by the Q310 and biases on Q309 to enable the transmitter VCO. The transmitter VCO consists of C353, C355, C357, C358, L315, L317, L318, Q325, Q326, and Q329. This VCO oscillates on the programmed transmit frequency. The VCO’s oscillating frequency is tuned by the varactor Q326. The tuning voltage is supplied from the output of the Loop Filter. The transmit voltage controlled oscillator is directly frequency-modulated and operates on the carrier frequency. The synthesizer is tuned in 5.00kHz or 6.25kHz steps. 7.3.5.3 Synthesizer The frequency synthesizer is a large-scale monolithic synthesizer integrated circuit Q323. The synthesizer IC contains a dual modulus prescaler, programmable divide-by-N counter, prescale control (swallow) counter, reference oscillator, reference divider, phase detector, charge pump and lock detector. Also, included in Q323 are shift registers and control circuits for frequency controls and general device control. August 30, 2002 99R85452E01-O VHF Band Information: Theory of Operation 7-5 RF output from the active VCO is AC coupled to the synthesizer Q323 prescaler input at Pin 8. The divide counter chain in Q323, consisting of the dual-modulus prescaler, swallow counter and programmable counter, divides the VCO signal down to a frequency very close to 5.00kHz or 6.25kHz which is applied to the phase detector. The phase comparator compares the phase with the 5.00kHz or 6.25kHz reference signal from the reference divider and drives the external charge pump (Q314, Q315 and Q316). The synthesizer unlock detector circuit prevents the operation of the transmitter and receiver, when the phase lock loop (PLL) is unlocked. The following discussion assumes the unit has been placed in the transmit mode. Q323 lock detector Pin 7 goes high when the PLL is locked. This high level is applied to Pin 25 of the CPU Q101. A software timing routing brings the RX/TX line low (Pin 36 of Q101). With the RX/TX line goes low, Q209 is cut off and Q208 is biased on passing +5VTX-B to Q202; it biases on Q201 to pass switched TX-B to the transmitter amplifier string which enables transmission. When the PLL is unlocked, the lock detector at Q323 Pin 7 will begin pulsing low. A RC circuit converts this low pulse to a low level for the CPU. The CPU then changes the RX/TX line to a high, thus signaling the other transistor switches to drive Q201 into cutoff, which disables transmission. Therefore, the transmitter remains disabled while the loop remains out of lock, and “PLL ERR” is displayed. 7.3.5.4 Loop Filter The Loop Filter, a passive lead-lag filter consisting of R314-R317, R356, C323, C369, and C371, integrates the charge pump output to produce the DC turning voltage for the VCO. One parasitic pole, consisting of RF chokes L306/L318, prevent modulation of the VCOs by the 5.00kHz or 6.25kHz reference energy remaining at the output of the loop filter. Direct FM is obtained for modulating frequencies outside the PLL bandwidth by applying the CTCSS/DCS signals and the preemphasized, limited microphone audio to the VCO modulation circuit. The modulation circuit consists of R347 and Q329. 7.3.6 Transmitter Section 7.3.6.1 RF Power Amplifier After the PTT is pressed, the +5VTX-B line switches to approximately 5V. Q309 is turned on, enabling transmit VCO. The VCO buffer, pre-driver, driver and power amplifier are biased on by Q201. Q201 is biased on by the +5VTX-B line switching to 5V. RF output from the transmit VCO(Q325) is applied to the VCO output buffer Q308. Output from Q308 feeds the buffer Q414. The output signal from Q414 feeds the pre-driver amplifier Q413, and feeds the driver amplifier Q412, whose output from the driver stage feeds the final RF power amplifier Q411 to produce the rated output power of 5 watts. The final output is feed to a low-pass filter (C446-C448, C451, C452, L418, and L419) and then to the transmit/receive switch Q410. RF power is then fed to the antenna via the output low-pass filter consisting of C440-C445, L415, and L416. 7.3.6.2 Antenna Switching Switching of the antenna between the transmitter and the receiver is accomplished by the antenna transmit/receive switch consisting of diodes Q409 and Q410. In the transmit mode, switched TX B+ is applied through R419 and RF choke L417, hard forward biasing the two diodes on Q410, thus permitting the flow of RF power from the output of the low-pass filter. L414 and C445 isolate the receiver circuit from the transmitter power input. 99R85452E01-O August 30, 2002 7-6 7.3.6.3 VHF Band Information: Theory of Operation Power Control Output power is controlled by the CPU (Q101), the D/A converter (Q121), the dual Op-Amp (Q419), which is used as a differential amplifier and comparator. Current is sensed by the voltage drop across R445. When the radio is in high power mode, this voltage is compared to the D/A converter voltage at 5-watt. When the radio is in low power mode, this voltage is compared to the D/A converter voltage at 1-watt. The power output is then reduced or increased by varying the applied voltage to the gate of the power amplifier Q411 and Q412. 7.3.6.4 Transmitter Audio Circuits The transmitter audio circuits consist of the audio processing circuits, the CTCSS circuits and the DCS circuits. 7.3.6.4.1 Audio Processing Transmit speech audio is provided by either the internal electric microphone M101 or the external microphone. The audio is pre-emphasized by 6dB per octave by C615 and R655, and then its signal is amplified. The microphone audio is directed to amplifier Q602B, Q602A and low-pass filter Q602C and Q602D. Q602A has limiting function. The modulation adjustment is done by Pot RV601, and directed to a four-pole active low-pass filter. The resulting signal is then limited, and is directed to a low pass filter (18dB per octave roll-off above 3KHz). The audio is then directed through the 25KHz/ 12.5KHz channel spacing SW Q601 to varactor diode Q329 in transmit VCO. By varying the voltage on the varactor diode Q329 at an audio rate, VCO output is frequency-modulated. 7.3.6.4.2 CTCSS Tone Encoder / Digital Code Squelch (DCS) Encoder CTCSS signals and DCS signals are synthesized by CPU Q101 and appear as pulse waveform on I/ O line Pin 7. This I/O line is connected to a digital-to-analog converter network (consisting of C136, C173, R150, R177 and R182), which produces a pseudo-sine wave at its output. The waveform is smoothed by low pass filters Q610B to produce an acceptable sine wave output. The CTCSS tone signal is adjusted to the proper level by RV602. 7.3.7 Receiver Section 7.3.7.1 Receiver Front End In the receive mode, the RF signal enters thorough the antenna, then through the low-pass filter C439-C445, and L414-L416. The diodes Q409 and Q410 are biased off, so that the output of the low-pass filter is coupled (C437, C438, L413 and R418) to the first band-pass filter C401-C406, C408-C410, L401, L402, PCB_L1, Q401, R401, and to the Front End RF overload protection diode pair Q403. The signal from the band-pass filter is directed to the input of the RF amplifier Q404. The output of the RF amplifier is sent to three stages of band-pass filters, consisting of C415-C429, C486, L404-L406, Q405 and R410. The output from the band-pass filter is directed to the mixer’s Q407/L407. 7.3.7.2 Local Oscillator (LO) The Receive VCO (C344-C351, L302, L305, L306, L312-L314, Q311, and Q324) provides the LO signal. The VCO is running at 45.1 MHz above the desired receive frequency and is applied to output Buffer Q308/Q416. The output of the buffer is sent through the low-pass filter C430, C431, L409, and to the mixer Q407/L408. August 30, 2002 99R85452E01-O VHF Band Information: Theory of Operation 7.3.7.3 7-7 Mixer The mixer is a DBM type (L407, Q407, L408). The mixer LO frequency is 45.1 MHz above the desired receiver frequency. When the receiver frequency is present, the mixer output will be a 45.1MHz signal. The mixer output is peaked for 45.1MHz at L410, C432 and R413, and the signal is filtered by crystal filter F402 and amplified by Q408 before being sent to IF IC Q506. The 45.1MHz IF signal and LO frequency of 44.645 MHz (X501) are mixed in Q506. The 455kHz ceramic filter, F501 or F502, filters the second mixer’s output. The resulting signal is the second IF signal. The mixer’s output is then fed to the internal limiting amplifier, and consequently to the FM decoder. 7.3.7.4 FM Detector and Squelch The FM detector output is used for squelch, decoding tones and audio output. The squelch amplifier is inside of Q506, and its output is fed to an internal rectifier and squelch detector. The output on Q506 Pin 14 signals the CPU Q101 with a low (~0V) to unmute the radio. The audio is unmuted by the CPU Q101 Pin 41 switching to a high (5V), thus biasing on Q503. The audio is then routed to the audio amplifier Q702 via the volume control SW201. 7.3.7.5 Receiver Audio Circuit The detector’s audio output also is fed to the tone (CTCSS and DCS) low-pass filter Q505A. Then the output of the low-pass filter is routed to the second stage filter Q505B. The output of Q505B is passed to Q505C. The output of Q505C is directed to the squaring circuit Q505D, and finally to the CPU Q101 Pin22 for decoding. The detector output feeds the audio high-pass filter Q502. The output of the audio high-pass filter feeds the Volume Control SW201 (VOL). From the wiper arm on the Volume Control, the audio is routed to Pin 4, which is the input to the audio power amplifier Q702. The output of the audio power amplifier is routed through the earphone jack J701 to the internal speaker SP701. 7.3.8 Battery Section The battery connects to the contact (CN201). The positive terminal of the battery connects to the ON/OFF Volume control switch (SW201), and the negative terminal connects to PWB ground. Low battery is detected by R127/R128 and voltage regulator Q204. Battery voltage status is monitored by Pin 19 of the CPU Q101 through R127/R128. When the battery voltage goes below the threshold voltage, “LOW BATT" is displayed on LCD LC101. In the BATTERY SAVER Mode, the CPU Q101 generates a square wave signal on Pin 37. The signal’s duty cycle varies according to what the BATTERY SAVE TIMER is set. When the signal goes high (approximately 5 V), Q210 is biased off, and Q211 is cut off, thus turning the supply off to IF IC Q506. 99R85452E01-O August 30, 2002 August 30, 2002 Hamonics Filter C440-445 L415,L416 PTT S102 Key Pad MIC M101 Mon S101 EEPROM Q114 EXT MIC Jack J701(1/2) Over Voltage Protect Q707-710 Power SW SW201 LCD LC101 CPU Q101 + SW B Shift Q102 Divide by 2 Q122 X,tal 8.38MHz X101 SAVE SW Q210 5V REG Q204 REG Q206 Q207 Reset Q105 Buffer AMP Q414 IF AMP Q408 CPU Pin87 RC NETWORK RC NETWORK RX 5V SAVE 5V 5V TX/RX SW Q208 Q209 DC/DC Converter Q301 DTMF Decode Q120 DA Converter Q121 RX SW Q211 TX REG/SW Q201 Q202 TX 5V Pre Driver Q413 2-Pole Crystal Filter F402 CPU Pin21 CPU Pin22 DIODE Q126 DC AMP Q125 TX VCO Q325 Q326 RX VCO Q311 Q324 25 22 15 16 3 4 31 13 35 9 27 CN101 Audio Modulator Q329 CPU Pin36 VCO Buffer Q308 2nd Local 44.654MHz X501 CN701 25 22 15 16 3 4 31 13 35 9 27 DAC TX DAC RX 5V Detect DTMF IN 5V Pin 15 16 6 Pole Ceramic Filter F502 Ripple Filter Q330 Loop Filter Q314-316 TX/RX SW Q309 Q310 6 Pole Ceramic Filter F501 IF IC Q506 (2nd Mix,2nd Local,IF AMP,DISC,Noise AMP) Sub Audio Modulator Q322 TCXO 14.4MHz X301 Q320 Q322 Pin 1 2 LPF (DTMF) Q610A MIC AMP Q602B VOX AMP Q610D ATT Q608 Q609 Pin 11 10 9 Pin 8 PLL Q323 CN701 Pin37 38 39 Detect Sub Audio LPF Q505 De-emphasis Q502A SP701 SPK (1/2) EXT Audio Jack J701 Audio Power AMP Q702 Limitter AMP Q602A LPF (Sub Audio) Q610B DTMF IN Volume SW201 (VR) HPF Q502 Deviation Adj RV601 LPF Q602C,D N/W SW Q601 Complete DAC TX PA Q412 Local Buffer Q416 Mixer Q407 7.4.1 Power Input Final AMP Q411 Coupler R445 DAC RX 2-Pole Band Pass Filter Q405 Block Diagrams Power Control Q419 Matching Network C446-448, 451,452 L418,419 ANT Switch Q409,410 RF AMP Q404 7.4 BATTERY ANT 2-Pole Band Pass Filter Q401 7-8 VHF Band Information: Block Diagrams Figure 7-2. 99R85452E01-O VHF Band Information: Block Diagrams 7.4.2 7-9 Controller CN101 27 MIC M101 Divide by 2 Q122 EEPROM Q114 DTMF Decode Q120 RC NETWORK CPU Q101 Key Pad CPU Pin36 35 9 CPU Pin22 13 31 CPU Pin21 RC NETWORK DIODE Q126 CPU Pin87 Mon S101 LCD LC101 Shift Q102 Xtal 8.38MHz X101 4 3 Reset Q105 PTT S102 DC AMP Q125 DA Converter Q121 15 16 22 25 Figure 7-3. 7.4.3 VCO Power Regulator RX Local Buffer DC/DC Converter Q301 Pin 8 RX VCO Q311 Q324 Loop Filter Q314 Q315 Q316 VCO Buffer Q308 TX VCO Q325 Q326 TX Buffer TX/RX SW Q309 Q310 Audio Modulator Q329 Audio Pin15 16 DATA PLL Q323 Pin 1 2 Pin11 10 9 CN701 Pin37 38 39 TCXO 14.4MHz X301 Q320,322 Ripple Filter Q330 TX/RX SW CONTL 5V Sub Audio Modulator Q322 Sub Audio Figure 7-4. 99R85452E01-O August 30, 2002 7-10 VHF Band Information: Block Diagrams 7.4.4 Transmitter To Receiver Hamonics Filter C440-445,L415,416 ANT Switch Q409,410 TX +B ANT Matching Network C446-448,451,452 L418,419 +B Final AMP Q411 Coupler R445 PA Q412 Power Control Q419 Pre Driver Q413 DAC TX Buffer AMP Q414 P in VCO TX 5V Figure 7-5. 7.4.5 Receiver 2-Pole Band Pass Filter Q401 From ANT Switch RF AMP Q404 2-Pole Band Pass Filter Q405 DAC RX Mixer Q407 2-Pole Crystal Filter F402 Local Buffer Q416 IF AMP Q408 IF IC Q506 (2nd Mix,2nd Local,IF AMP,DISC,Noise AMP) 2nd Local 44.654MHz X501 6 Pole Ceramic Filter F501 6 Pole Ceramic Filter F502 From VCO Figure 7-6. August 30, 2002 99R85452E01-O VHF Band Information: Troubleshooting Charts 7.5 7-11 Troubleshooting Charts Start 1 Very low or no 12 dB SINAD Check IFIC Q506 (see below) Is 2nd LO on freq? Noise at pin 9 of IFIC Q506? NO NO Check VCO/Synth NO YES Check VDC of all IFIC pins Check 2nd LO XTAL and components YES YES Is 1st LO at C431 >2 dBm? Are VDC of pin 1(4.79V), 2(4.17V) and 4(4.88V) of IFIC OK? YES NO Noise at spkr when radio is unsqu’d? NO Are voltages on pins OK? Check IFIC YES Check IFIC (see below) NO YES Check external components connected to IFIC. If OK, replace Q506 Inject on channel signal at RF port, C429 Is 12 dB SINAD -105 dBm? YES Inject 45.1 MHz signal at R413, L411 Is 12 dB SINAD -115 dBm? Inject on channel signal at C402 YES NO NO Is 12 dB SINAD -116 dBm? Check harmonic filter and antenna path YES NO Is Q404 biased properly? Check mixer, Q407 YES NO RF Front & Rear 2 pole filters Inject a 45.1 MHz signal at R467 Is 12 dB SINAD -110 dBm? YES Check external components connected to IFIC Check +5VRX and Q404 bias circuitry Check XTAL filter F402, L411 Troubleshooting Flow Chart for Receiver NO 1 Figure 7-7. 99R85452E01-O August 30, 2002 7-12 VHF Band Information: Troubleshooting Charts Start No Power Is +5VTX and TXB+ OK? Check Q201, Q202, Q206 & Q209 NO YES 1. Check Pin Diodes 2. Check Harmonic Filter YES Is current OK? NO Is DAC TX High or Low? Inspect/Repair TX Output Network Is Power OK? LOW Check Voltages in Power Control Circuit YES Check Voltages in PA Line-up HIGH Check Pin to Q419 Pin 1 NO YES Done Troubleshoot VCO NO Is Pin OK? Troubleshooting Flow Chart for Transmitter Figure 7-8. August 30, 2002 99R85452E01-O VHF Band Information: Troubleshooting Charts 7-13 Start NO Correct Problem Visual check of the Board OK? Check 5V Regulator YES NO Is Q314 Emitter AT=13VDC +5VQ323 at Pins 3, 4 YES Check Q301, L303,C303,R301, C304 & R302 Fix Connection Is Q310 Pin 2 <0.7 VDC in RX & >4.3 VDC in TX? NO YES Are signals at Pins 8 of Q323 ? NO Is 14.4MHz Signal at Q323 Pin 1? NO Check X301,C337,C338,C336 YES NO NO Are Waveforms at Pins 8 of Q323 YES Is Connection between Q310 Pin 2 & CN701 Pin 35 OK? YES NO Is Q330 corrector AT4.65 VDC? YES NO NO Check programming lines between Q323 Pins 9,10 & 11 YES Replace CN701 YES Check R358, C312 C313 Replace Q201 Is RF level at Q324 between -10 & +5 dBm? NO Do Pins 9,10 & 11 of Q323 toggle when channel is changed? YES Is information from µP Q101 correct? NO Check µP Q101 Troubleshooting Chart YES Replace Q323 YES Replace or resolder necessary components NO See VCO Troubleshooting Chart Are Q308, L301 C308, C310, C309 YES Replace Q308 Troubleshooting Flow Chart for Synthesizer Figure 7-9. 99R85452E01-O August 30, 2002 7-14 VHF Band Information: Troubleshooting Charts START APPLY POWER TO RADIO AND TURN ON NO/DON’T KNOW ARE ALERT TONES ENABLED IN SPM NO WAS GOOD OR BAD POWER-ON BEEP PRESENT YES YES USE SPM TO ENABLE TONES NO WAS GOOD POWER-ON BEEP PRESENT INVOKE FACTORY RESET IN SPM YES DONE NO WAS GOOD POWER ON BEEP PRESENT YES DONE MAIN RADIO BOARDS MUST BE REPLACED (RF & CONTROLLER) YES DONE NO WITH POWER CONNECTED TO RADIO AND THE RADIO TURNED ON CHECK THE FOLLOWING: 1) 5V AT PIN 87 OF Q101. IF NONE CHECK Q126. 2) WITH HIGH IMPEDANCE PROBE CHECK FOR 8.388608MHZ AT PIN 13 AND 12 OF Q101, IF NO SIGNAL CHECK/REPLACE X101. 3) CHECK DC AT PIN 9 OF Q121. IF < 4.5VDC CHECK CN101 PIN 15. 4) CHECK FOR TYPICAL VOLTAGES OF Q101 AND Q114 VOLTAGES. NOTE: Q101 is not replaceable. If Q101 is damaged, the controller and RF boards both need to be replaced. ARE TONES PRESENT ON POWER UP AT CN101 PIN 3? YES AUDIO PROBLEM, TROUBLESHOOT AUDIO CKT DONE Troubleshooting Flow Chart for Microcontroller Figure 7-10. August 30, 2002 99R85452E01-O VHF Band Information: Troubleshooting Charts 7-15 TX VCO RX VCO Low or no power at Input to PA Low or no Power at Pin 4 of L408 VisualCheck of Board OK? NO Correct Problem NO YES Visual check of Board OK? Power OK but no Modulation =151 mVrms at Terminal of C311? NO Replace C311 YES YES 4.65 VDC at Q416 collector? NO Make sure Synthesizer is working correctly. NO 4.65 VDC at Q414 collector? NO Supply DC at Q329? Replace R347 YES YES 1.6 VDC at Q308 base ? Replace NO NO R311, R322 YES 0.9 VDC at Q308 emitter ? 1.6 VDC at Q308 Base? YES NO Replace R312 or L301 NO 0.9 VDC at Q308 emitter? YES YES Q324 emitter at 1.0VDC, collector at 4.0VDC, base at 1.7VDC ? If C359 is OK, then replace Q329 NO YES If all parts associated with those Pin’s are OK, then replace Q308 If all parts from Q324 of mixer are OK, then replace Q324 NO Are Q325Pin’s emitter at 2.1VDC, collector at 3.8VDC, base at 2.9VDC? YES If all parts from Q325 Pin 4 to Input of PA are OK, then replace Q325 Note: Test Frequency 158MHz Troubleshooting Flow Chart for VCO Figure 7-11. 99R85452E01-O August 30, 2002 7-16 VHF Band Information: Troubleshooting Charts This Page Intentionally Left Blank August 30, 2002 99R85452E01-O 7-17 Chapter 7 VHF 136-174 MHz Circuit Board/Schematic Diagrams and Parts List 99R85452E01-O August 30, 2002 7-18 Q118 Q119 C140 Q121 Q114 R173 R174 R177 C129 R182 R180 C117 C171 C139 C138 C137 C173 C136 R106 R150 R164 R145 R163 R144 R162 R143 R161 R142 R160 R141 R159 R113 R165 R146 R114 R166 R147 C112 Q126 C114 C108 C115 R112 R115 C107 R148 C111 R154 R155 R156 R103 Q130 R169 X101 R138 R137 R126 R118 Q101 R102 R176 SH101 C104 R104 R119 2 1 R168 R175 R105 Q124 D C DOWN L112 Q123 Q125 R153 S102 UP C167 R128 C157 B A R129 R167 C150 C165 C166 C149 C145 R127 Q127 M101 C105 C156 LC101 C135 C102 C101 R158 C103 R101 C152 C147 R117 R183 C106 C133 C164 C120 C146 C148 Q122 Q120 CN101 C153 C154 R134 C155 R110 Q102 C161 C109 C162 C160 R121 R120 C110 R170 Q105 R136 C159 C132 R116 Q115 R107 C163 C134 C158 R135 C142 C141 R109 R108 Q116 C151 3 C131 R111 C144 R172 8 0 * 0 # Top Side C116 7 C143 R171 C113 6 Q117 5 S101 4 Bottom Side Figure 7-12. VHF 136-174 MHz Controller Board August 30, 2002 99R85452E01-O Q501 C413 C437 L413 C403 C401 C409 C487 C201 C408 Q401 Q201 Q202 C203 Q210 C404 C402 C208 R201 Q204 R212 C204 R202 C405 C406 C410 C425 C424 C423 C428 L406 Q206 R203 L401 C206 Q208 C202 L402 C215 Q209 R209 C427 C429 C213 Q207 C210 R210 C209 C211 R711 C214 C485 R208 C426 R401 C207 C493 C713 Q203 C436 R503 L415 L417 L414 C440 C439 C441 C446 C447 C448 Q418 C430 R207 R206 CN201 R211 C533 R571 Q211 R535 C503 R505 R534 Q407 C505 R506 C508 R411 L409 C324 R502 Q506 C532 R412 C212 C205 R570 C527 C531 R457 C495 C323 R501 R526 L501 C443 Q409 R569 R318 R527 L419 C445 R418 C711 R365 C444 C438 C431 C371 R364 C525 C526 C529 R532 C530 R542 Q508 Q331 R359 R315 R316 Q314 C442 R445 R314 R317 L429 C449 R450 C481 R419 Q419 Q410 C455 C453 C217 Q315 C454 R449 Q417 R451 C484 R469 R466 R454 C494 C471 R456 R446 R448 R430 C483 R452 C482 R429 R455 L428 C478 R439 R436 Q416 R452 C504 Q316 X501 Q507 R431 C502 C519 R437 R440 C470 Q415 C343 C339 R357 R355 R320 C319 C317 R321 R541 R432 L430 C474 L427 C362 R441 R444 C308 R443 L307 Q319 R336 C341 C337 R319 C318 R601 C516 Q323 R537 R540 C547 R550 Q504 R433 C369 R366 C546 Q413 C475 C473 R507 R560 R561 C539 R544 R538 R349 C363 Q614 R622 C509 R531 C606 C513 C510 R322 C469 R434 R447 C480 R323 R511 R438 R356 C601 Q509 C535 R310 R513 C550 Q505 R335 Q414 R312 C309 C477 C476 R435 C310 R311 R602 R510 C551 R548 R350 C476 L301 R604 C517 C520 R607 R605 Q605 C522 C361 R442 Q308 Q330 C604 C602 C515 Q503 Q310 C605 R716 Q502 Q309 R608 R530 R631 C639 R609 R342 C603 Q609 R702 C703 C607 C636 Q608 R549 R703 Q613 C625 Q701 C719 R718 R641 C704 C706 R705 R717 C708 C721 C627 R640 C622 R716 C634 R639 C608 C638 R650 C621 C707 Q616 R651 RV601 R657 R656 R637 R652 C626 R643 R642 R626 C628 R628 C618 C630 R627 R658 Q607 C633 RV602 7-19 CD501 Figure 7-13. VHF 136-174 MHz Main Board Bottom Side 99R85452E01-O August 30, 2002 7-20 Q711 R712 Q709 C709 F402 R467 Q408 C545 R629 C617 R645 C619 C616 Q610 C624 R638 C623 R636 C641 R663 R633 R634 Q510 C521 C518 R704 R519 R521 R522 Q702 R520 R524 R523 R525 C524 C705 R514 C523 R512 C514 R518 C701 R661 R515 C511 R516 R625 C632 R701 R615 C631 C702 C528 C635 R649 R646 R610 R509 J702 R546 C541 R545 R547 R536 CN701 R616 C642 C512 C534 R563 R648 R635 R508 R564 C367 C620 R660 R617 Q601 R327 R325 R654 C612 C312 C313 R358 C629 C615 C335 L318 C336 C381 R621 Q602 R568 R337 Q615 R655 R313 C316 C360 C325 C327 C338 R606 Q511 R551 R468 L431 Q703 R415 C710 R707 R706 Q704 C637 R611 R416 C506 Q706 R620 R612 R517 R567 Q320 R566 R301 R659 X301 R329 R330 R332 Q322 C305 R302 C302 C380 C366 L306 L302 R362 C328 Q326 L315 R361 L317 C311 R347 C351 C344 L314 R339 L312 C355 C368 C304 R459 Q712 L313 C490 C501 R708 L702 R713 R709 Q707 R710 R341 C326 R565 C303 L303 C434 Q705 L305 C359 Q301 R414 L410 C432 R413 L411 C420 R410 C418 C345 R333 C433 L408 C422 C486 Q405 L407 C421 C353 R422 C301 C458 R343 Q311 L424 F401 Q708 SW201 L422 Q412 C350 C357 Q325 L423 L405 C419 R406 R714 C720 R404 L403 Q710 L404 R403 C415 C417 C411 R407 R408 C218 C416 R402 C407 R405 Q404 Q403 R715 C414 R409 C142 C715 C717 R205 R421 Q411 R204 Q329 R363 C468 C467 R425 C464 C349 C354 C460 Q324 R346 C463 C346 C358 C461 L426 C347 R340 C459 R426 R632 R338 C352 C348 C462 R470 R423 C465 L425 C466 R428 R427 R424 L421 C472 C451 C452 L420 C489 J704 L419 R420 C457 C456 J703 L418 C718 J401 C450 C714 C716 TP301 F502 F501 C540 C542 C538 C537 C544 R543 C543 C536 R539 Figure 7-14. VHF 136-174 MHz Main Board Top Side August 30, 2002 99R85452E01-O 7-21 Q115 R107 47 LC101 Q116 Q118 Busy 2.2 LCD TX COM0 COM1 COM2 COM3 SEG0 SEG1 SEG2 SEG3 SEG4 SEG5 SEG6 SEG7 SEG8 SEG9 SEG10 SEG11 SEG12 SEG13 SEG14 SEG15 SEG16 SEG17 SEG18 SEG19 SEG20 SEG21 SEG22 SEG23 SEG24 SEG25 SEG26 SEG27 SEG28 SEG29 SEG30 SEG31 BUSY Q119 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 C113 0.001 COM3 COM2 COM1 COM0 S0 S1 S2 S3 S4 S5 S6 S7 S8 S9 S10 S11 S12 S13 S14 S15 S16 S17 S18 S19 S20 S21 S22 S23 S24 S25 S26 S27 S28 S29 S30 S31 5.0 R109 330 R108 330 Light On 4.5 TX 2.2 C142 0.001 C141 0.001 NOTES : R171 47K R172 47K : RX Mode S1 S2 S3 S4 S5 S6 S7 S8 S9 S10 S11 S12 S13 S14 S15 S16 S17 S18 S19 S20 S21 S22 S23 C108 DC Voltage 0.1 S0 R163 R164 76 77 78 79 COM0 80 COM1 81 COM2 82 COM3 83 84 85 86 87 88 89 90 91 R141 20K 92 R142 20K 93 94 R143 20K 95 R144 20K 96 R145 20K 97 R146 20K 98 R147 20K 99 R148 20K 100 R165 R166 4.5 2 10K 10K 10K + C111 + 47uF 6.3V(T) C112 0.1 20K R160 R159 R161 10K 10K C129 0.01 R162 10K Q114 DAC_TX GND MIC SAVE VDD RESET SU AU OUT GND SQL IN RSSI RX/TX UNLOCK PLL_LE DATA CLOCK GND R120 0 R170 47K C110 0.001 OUT 1 IN 4 Q105 1 5 OUT CD 2 Vdd 3 4 GND NC R114 43K C109 0.1 R121 Not use 22k R182 2.2k 0 OUT 2 GND 3 OUT 1 IN 4 OUT 2 GND 3 OUT 1 IN 4 8 OUT 2 GND 3 A OUT 1 IN 4 6 OUT 2 GND 3 OUT 1 IN 4 7 OUT 2 GND 3 3 OUT 2 GND 3 5 OUT 2 GND 3 OUT 1 IN 4 OUT 1 IN 4 OUT 1 IN 4 2 OUT 1 IN 4 4 OUT 2 GND 3 R115 130K B OUT 1 IN 4 9 OUT 2 GND 3 OUT 2 GND 3 C C105 0.1 R175 4.7K Q127 C106 27pF C101 Q102 OUT 1 IN 4 1 OUT1 IN4 * OUT 2 GND 3 0 OUT2 2 GND 3 OUT 1 IN 4 # OUT 2 GND 3 OUT 2 GND 3 D L112 X101 R158 470K C102 C103 Not Not use use R129 1K OUT 1 IN 4 R101 0 7 2 1 6 D R110 51K 8 Q122 Q 5 R116 18K CLK CL Q' R117 33K R118 100K C132 100p R105 10K R183 47K C145 47pF C149 0.001 C165 0.001 C150 0.001 C156 0.01 C163 0.001 C151 0.001 4. 7 DOWN 3 C133 0.001 C134 0.01 Q120 10 9 8 12 7 13 14 6 15 VDD IN EST PD STD OSC0 ACK OSC1 SD GND 1 R135 10K 2 3 R136 10K R134 1K 4 5 16 17 20 21 22 TP110 TP111 TP112 TP113 TP114 23 24 C171 0.1 25 26 27 C120 28 0.001 1 16 2 15 3 14 4 29 30 5 31 R126 10K DAC_BAIS R177 OUT 2 GND 3 11 19 TEMP IN 0 1 10 18 DAC_RX 0.22uF/10 R150 OUT 2 GND 3 OUT 1 IN 4 OUT 2 GND 3 9 PRO GND NU R106 UP OUT 1 IN 4 R113 22K R102 47K 8 MIC_PTT GND C136 OUT 1 IN 4 OUT 1 IN 4 OUT 2 GND 3 R112 13K 13 Q121 12 6 11 7 10 8 9 32 R154 47K R138 10K 33 5 34 R137 1K 35 36 38 39 40 4 1 Q125 37 TP115 3 R153 10K C139 0.1 TDC SH101 Solder Short C138 0.1 Vdd C131 100pF C137 0.1 Vdd C173 C147 0.001 N/W R176 22K 4 C152 0.001 DETECT IN S24 S25 S26 S27 S28 S29 S30 S31 R111 51K S102 PTT SW 7 C148 0.001 DATA0 SQL_MUTE C107 50 49 48 47 46 45 44 43 42 41 40 39 38 37 36 35 34 33 32 31 30 29 28 27 26 R119 0 C144 0.001 R169 330 5 6 C146 0.001 Vbb 10K 0.01 R174 4.7k 5 C164 0.001 DTMF IN SDA 6 4 C159 47pF TX_MUTE Vss R173 4.7k S23 S22 S21 S20 S19 S18 S17 S16 S15 S14 S13 S12 S11 S10 S9 S8 S7 S6 S5 S4 S3 S2 S1 S0 P73 Q101 22pF C158 47pF MC2 SCL 7 R127 12.4k R128 6.98K C154 0.001 MC1 A2 8 3 C155 0.001 VOX IN MOD_COP TEST 2 C161 0.001 DTMF OUT 1 C160 47pF GND ST_BY C153 0.001 CN101 C162 0.001 4 Vcc A1 C166 47pF 3 A0 C157 0.01 2 C167 47pF 1 S47 V3 V2 V1 COM0 COM1 COM2 COM3 P30 P31 VSS3 VDD3 P32 P33 P34 P35 P00 P01 P02 P03 P04 P05 P06 P07 P10 R167 47K R168 47K C135 2.2uF 6.3V + Q130 1 3 R180 560k C117 1uF 6.3V + C116 47uF/6.3V (T) R104 0 C115 47uF/6.3V (T) C104 100pF C114 47uF/6.3V (T) M101 S46 S45 S44 S43 S42 S41 S40 S39 S38 S37 S36 S35 S34 S33 S32 S31 S30 S29 S28 S27 S26 S25 S24 VSS2 VDD2 75 74 73 72 71 70 69 68 67 66 65 64 63 62 61 60 59 58 57 56 55 54 53 52 51 C143 0.001 P11 P12 P13 TXD P14 RXD P15 P16 P17 RES# XT1 XT2 VSS1 CF1 CF2 VDD1 P80 P81 P82 P83 P84 P85 P86 P87 P70 P71 P72 4.7 Q126 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 R103 Not use : TX Mode S101 MONI SW C140 0.22 R155 Not use 2 R156 47K TP116 Figure 7-15. VHF 136-174 MHz Complete Controller Board Schematic Diagram 99R85452E01-O August 30, 2002 5 2 C518 0.01(ECHU) R524 2.2K R525 10K C524 0.068 R522 NU R523 47K R519 150K 1% R516 29.4K 1% R521 715K 1% R561 634k 1% C517 0.01(ECHU) C516 0.01(ECHU) R513 10K C519 0.01 C521 0.01(ECHU) R515 25.5K 1% C515 0.01(ECHU) C513 27p 4 R510 470K 11 Q502C NJM324V(3/4) VB R548 10K 10 R547 100K Q505D NJM324V(4/4) R550 1K 14 13 C543 0.0047 8 12 2.0 C544 0.22 Q505A NJM324V(1/4) 7 R549 100K 2.0 R544 100K 9 C542 390p 11 3 R546 100K C541 0.1 C539 0.039 4 C536 0.047 C535 0.027 Q505C NJM324V(3/4) 6 R545 100K 5 7.4 R362 22K 22K C368 1u R361 2.5 9 5 6 C339 0.001 7 8 R709 Q705 0.27 (1/8) 1SR154-400 P701 WC-013 J701(2/2) 09R80683Z01(2/2) L702 R707 3.9K + Q319 R708 2.2K C711 0.1 C713 0.1 C341 0.1 C718 100p R710 100 R706 470 390nH C717 100p Q710 UDZ S 20B Q712 1SS355 10K R713 R715 4.7K Q708 2SA1586GR Q704 2SA1586GR C313 15p C312 10p R358 47 C380 8p J702 53047-0210 C705 2.2uF/16V C337 15p C335 10p(TZV02) C338 7p(UJ) SP701 SPEAKER 1 2 1 2 C716 100p 7.4 C719 100p 1SS355 10u6.3V(T) C707 0.001 R717 0(1/8W) C710 0.1 R335 100K 5 3.2 R336 100K C343 6 R703470K C715 100p OUT- C714 100p Vcc IN- Q706 UDZ S 6.8B 10 IN+ C706 R705 0.1 22 7 R711 10k 4 R357 10 R333 100K R332 100K(1%) 11 4.8 Q322 1SV217 X301 C333 0.01 3 12 MB15A02 3 R334 3.3K UMZ2N RV302 Not use 4 Q320 4 R702 1.5K 2 R327 100k 5 C319 47p C318 47p 13 1 2 R328 NU 2 R329 220k(1%) 6 3 GND C709 10u6.3V(T) 14 R325 10K 1 4 15k 1 Q707 2SA1313 Q709 2SA1586GR R712 1K R323 C317 47p 15 14.4MHz C336 33p(UJ) C381 NU R563 2.7k 10K R568 10k R567 10k(TH) 150K(1%) R330 10K(TH) C367 R337 0.01 R324 NU R326 NU R349 1K NU C360 NU 1uH C363 0.001 C327 NU L318 3.2 C703 0.22 R714 10K Q316 UDZ S 7.5B R355 NU R319 10K C370 NU R317 2.2k R366 470 16 2.1 Q330 2SC4116GR Q711 4.7K(CRA168-472J) Q323 4.7K R564 82k(1%) + OUT+ SVR J701(1/2) 09R80683Z01(1/2) R716 0 (1/8W) 8 MO C720 0.001 R318 10K R365 470 C361 470p R350 4.7K R321 6.8k R359 R566 18k C362 2.2u10V(T) 1 C328 L317 47nH L315 47nH C323 2.2u16V(T) R364 2.7k C369 0.22u/35(T) R313 100K C316 0.01 NU L313 47nH C350 L305 47nH 56p C326 NU C325 1uH C344 13p L314 56nH C349 0.1 9p C357 15p C359 Q315 2SC4116GR 3 Q310 UMC4N R347 + 2 1SR154-400 R320 1.5k R316 1.5k C371 1u/16V(T) Q331 2SC4116GR C311 0.001 C358 33p 2.1 R205 50k R342 100K R343 2.2K 2.9 R346 10K C354 1.5p R315 2.7k + 1 C708 0.001 C701 0.001 C702 0.001 C324 10u/16V(T) 12.8 + R314 0 0.02 47K Q702 TDA8541 3 Q314 2SA1586GR R356 4.7k R704 R701 L303 1000uH 2 C355 22p Q325 2SC4226(R24) 2SC5086Y 4 Q329 1SV279 R322 10K 3.8 0.9 L307 BLM21A121S 5 0.1 Q308 C217 0.1 + C211 0.001 5.0 C214 0.001 C213 10u6.3V(T) 10K Q309 2SJ243 C353 1.6 R363 470 R312 220 C310 0.001 R211 C212 0.001 R209 10 R204 47K Q210 2SA1362 0.03 C348 0.01 R341 33K R311 15K R340 22K L306 1uH C351 68p L302 100nH(C2012-R10J) C346 0.1 R339 15 R310 100 L301 C309 0.001 C209 0.001 R208 4.7K 100nH R206 2.2K R207 10K 4.6 0.06 C218 0.001 1.0 C308 10p R210 22 C207 10u6.3V(T) CE GND + 3 4 0.47 5 Vout C208 0.01 Vin NC C206 0.001 CN201 09D86237A 5.0 Q204 XC62HR5002PR 2 1 1 GND C205 0.01 Q203 1SR154-400 2 THERM 4.8 1.7 C347 0.001 C204 0.01 C203 1u16V(T) R203 4.7K C202 10u6.3V(T) C352 1.5p Q207 UMW1N R539 100K 1 2.2K TP301 C345 5p R338 180 L312 R202 2.2K 3 BAT T Q324 2SC4226(R24) 4.0 + 5 C512 0.0022 C509 0.001 C534 2.2u/10V(T) 1.5k R536 R542 22K R531 22K C304 10u/16V(T) Vout 3 2 DK OSC GND C303 0.022 R301 1K Vi n TI + C302 0.1 C301 10u6.3V(T) 1 6.2 C210 0.001 C201 0.01 3 Q202 UMW1N + R543 100K 2 C305 0.22 5 6 + 6.5 2 C520 0.01(ECHU) Q502B VB NJM324V(2/4) VB C704 4.7u6.3V(T) + 7.5 Q201 2SB798 C522 0.01(ECHU) 5 R302 220 4 R442 330 R443 330 Q301 TK11816M R565 R201 10K C215 2.2uF/16V 5.0 Q503 2SJ144Y C546 0.1 3 4 5 R530 22K 3 4 5 R540 22K F502 C523 0.22 12 RX Narro w Wide 0.1 4.5 2 14 C538 0.01 R538 100K C529 0.1 C547 0.1 Q508 DAN235E 1 2.0 13 8 MUTE NOTES: : RX Mode + 0.0 R537 470K Q502D NJM324V(4/4) R520 4.22K 1% 10 Q505B NJM324V(2/4) 4 R212 100 2.0 ALFYM455H 2 1 VB 9 7 3 R512 47K R506 10k C533 47p R534 150K RB521S 6 R518 11.5K 1% R444 22 SW201 TP76N17N 10K.A 1 R511 56K Q510 VB NJM2107 R517 15.8K 1% R514 3.3K 2 C537 0.0027 R503 2.7K 9 C532 220p R532 560k Q507 DAN235E ALFYM455F F501 Q511 8 C530 0.1 R541 22K 1 C510 0.22 C504 0.1 R501 0 C501 0.001 16 1 R527 10K C527 0.001 C528 1u C511 R509 68K 0.1 R508 10K R535 10k 2 3 R507 1K 4 1 UNMUTE R441 1K R440 4.7K R439 15K R438 4.7 Q501 UMC4N 4.17 1uH 1 C526 39p L501 C525 33p X501 44.645MHz(TOP-B) C470 Q415 5p HSC277 L428 100nH 1 TA31136FN R526 0 Q416 2SC5086Y Q502A NJM324V(1/4) 2 C508 470p Q506 1.1 3 5 4.88 4 C514 0.01 C505 100p C531 220p 0.01 C474 0.01 R431 15k 10K R433 4.8 Q414 2SC5086Y R437 680 5p 4.7K C478 C479 0.001 R436 R435 10K R429 470 L430 100nH 0.001 R434 10 C476 C489 0.001 C477 0.001 4 R505 2.2K + C493 R430 100 L427 100nH R432 220 C473 0.001 C465 NU R426 100 C466 0.022 C469 10p R502 47K L431 2.2uH R416 1K C545 33u6.3V(T) C434 NU C432 82p C436 0.01 R413 56 C433 27p 22p C431 L410 150nH R551 0 C502 0.01 Q413 2SC3356(R24) 100K R428 L425 68nH C467 3p C464 NU C460 27p L424 0.3-1.0-5T 4 27K R455 100K R453 C503 0.01 1 R452 100K C482 0.01 F402 45N12A5 0.53 C468 22p L426 0.3-1.0-4T R457 15K 8 3 C484 6.8u6.3V(T) C480 0.001 C461 0.022 C459 R424 12K 0.022 22K C483 0.001 2 R466 1K R451 R450 100K 1% 100K 1% R447 100K 1% R427 12K R421 120 R422 56 R423 220p C453 1u/16 C454 0.0033 C481 0.001 C455 R454 10K F401 NOT USE C475 22p Q412 2SK3475 Q419A NJM2904V(1/2) 7 5 R425 NU R456 1M 100ohm Q408 2SC4215Y 4.79 C463 47p C462 330p R420 100 L420 0.4-1.0-5T C452 150p C451 120p C449 0.022 L429 R445 0.1(1/2W) ZBFS5105-PT Q419B NJM2904V(2/2) R448 100K 1% R446 100K 1% 6 Q411 2SK3476 R459 Not use 3 L408 SMD-0314A L407 SMD-0314A C471 5p L423 0.3-1.0-6T R467 4 22p C430 1 1 6 4 4 R412 NU 3 2 4.6 C458 L422 0.001 0.4-0.9-3T L411 470nH L409 33nH 2 1 3 R411 NU 6 C428 NU 10p C426 C421 NU C423 NU L405 12nH PCB_L2 100p C419 33p 100p C486 2 C420 330p C416 NU R408 1K C414 330p L403 470nH R409 390 PCB_L3 L406 0.3-1.0-4T R414 0 C551 0.01(ECHU) + C485 2.2uF/16V 39nH R449 100K 1% L418 C448 22p 12p C445 R569 1k(1/4W) C443 C425 20p R410 100K C418 C487 NU L419 0.4-0.9-3T 0.3-1.0-7T C444 33p L416 0.3-1.7-5T 24p 12p C440 C410 330p C44718p C442 10p L415 0.3-1.7-5T C450 NU C446 9p L417 1uH J401 02D04852J C441 12p C429 0.022 C457 330p L421 R419 220 C43756p C409 100p C408 120p 120p Q410 HVU131 Q409 HVU131 C438 C422 150p C45622p L414 0.3-1.7-6T C439 7p L413 0.4-0.9-3T C413 0.1 C412 0.022 Q404 2SC5086Y R401 100K R418 39 R407 10 C417 16p L404 12nH R403 3.3K R405 2.2 R402 5.6K C405 NU L402 12nH Q403 1SS362 R406 0 R404 10K C406 150p C407 0.1 PCB_L1 C403 NU C401 13p L401 12nH C404 20p C415 150p 3 C550 0.01(ECHU) 4.9 C506 0.1 + 0.74 C402 150p 2.9 CD501 IFD0455C24E03 C490 100p R415 330K 0.71 C427 47p C424 10p C540 0.0015 3.6 C411 100p R560 5.11K 1% 7-22 : TX Mode C366 10u/10V(T) DC Voltage CN701 AXK6S40545J/P 1 2 R660 Not use VB 2.0 R656 C623 0.01u 9 R642 33K 1% 8 10 + Q610C NJM324V(3/4) + C628 1u16V(T) R648 470K C633 0.01 Q609 UMG2N R663 100K R633 12K R635 1.2M R634 680k R652 680K 11 R651 100K C641 0.22 1 R645 1M R661 10K 7 DTM F I N 12 Vbb DA TA 0 SQL M UTE DETECT I N 14 W/N 15 Vdd 16 17 18 Vdd TDC MC_PTT 19 PRO 20 GND 21 22 23 GND DAC_RX TE MP I N 24 DAC_BAI S 25 DAC_TX 28 C622 0.001 MOD_CMP MC 2 TX_MUTE 11 27 C621 0.001 MC 1 9 13 VB VOX I N 8 10 C620 0.22 Q610D NJM324V(4/4) R631 820K 0.1 Q607 1SS372 26 C635 0.1 Q610A NJM324V(1/4) + R650 100K C632 68p 2.0 R643 22K 1% C626 10u6.3V(T) 2.0 3 2 R637 0 VB C630 0.015 R649 100K C634 0.0018 Q610B NJM324V(2/4) C625 4.7u6.3V(T) R654 10k C631 0.0082 4 RV602 10K.B VB Q615 DAN222 VB R641 680K 6 2.0 R640 150k 7 C624 220p R632 0 5 R639 150k C627 470p R636 0 R638 330k C638 4.7u6.3V(T) R646 1K + 100 Q614 1SS372 Q616 SSM3K03FE C619 R629 NU 1 2 Q602A NJM324V(1/4) 12 6 14 C639 27p 5 R658 820 C642 0.022 11 R615 12K RV601 10K.B R657 0 7 3 C608 --- R626 18K 13 R628 0 1 5 C616 R625 0.027 18K C617 0.0047 2 4 C618 82p C615 0.01 R655 4.7K GND ST_BY 3 R627 680K 3 4 R616 4.7K C629 6 1u R622 0 Q602C NJM324V(3/4) R621 330k Q602B NJM324V(2/4) C637 2.2/6.3 C606 0.047 2.0 VB R609 680K C603 82p 9 10p 100p R617 220k C607 0.1 R608 100K R612 100k 10 R607 100K 8 13 R602 6.8K R606 100K R611 50k 12 R605 100K R659 12k R610 22K R604 6.8K 14 C604 0.0012 C605 680p R601 3.3M C602 Q602D NJM324V(4/4) 0.0033 R620 4.7K C601 0.01 C612 C636 GND MI C SAVE 29 VDD 30 RESET 31 32 33 SU AU OUT GND SQL I N 34 RSSI 35 RX/TX 36 UNLOC K 37 38 39 40 PLL_ LE DA TA CLOCK GND Figure 7-16. VHF 136-174 MHz RF Board Schematic Diagram August 30, 2002 99R85452E01-O 7-23 VHF 136-174 MHz Radio Parts List (Controller Board) Circuit Ref C101 C102 C103 C104 C105 C106 C107 C108 C109 C110 C111 C112 C113 C114 C115 C116 C117 C120 C129 C131 C132 C133 C134 C135 C136 C137 C138 C139 C140 C141 C142 C143 C144 C145 C146 C147 C148 C149 C150 C151 C152 C153 C154 C155 C156 C157 C158 C159 99R85452E01-O Description CAPACITOR 22pF; 50V; +-5% NU 10pF; 50V; +-5% 100pF; 50V; +-5% 0.1uF; 16V; +-10% 27pF; 50V; +-5% 0.01uF; 50V; +-10% 0.1uF; 16V; +-10% 0.1uF; 16V; +-10% 0.001uF; 50V; +-10% 47uF;6.3V;+-20% 0.1uF; 16V; +-10% 0.001uF; 50V; +-10% 47uF;6.3V;+-20% 47uF;6.3V;+-20% 47uF;6.3V;+-20% 1uF; 6.3V; +-10% 0.001uF; 50V; +-10% 0.01uF; 50V; +-10% 33pF; 50V; +-5% 33pF; 50V; +-5% 0.001uF; 50V; +-10% 0.01uF; 50V; +-10% 2.2pF; 6.3V 0.22uF; 10V; +-10% 0.1uF; 16V; +-10% 0.1uF; 16V; +-10% 0.1uF; 16V; +-10% 0.22uF; 10V; +-10% 0.001uF; 50V; +-10% 0.001uF; 50V; +-10% 0.001uF; 50V; +-10% 0.001uF; 50V; +-10% 47pF; 50V; +-5% 0.001uF; 50V; +-10% 0.001uF; 50V; +-10% 0.001uF; 50V; +-10% 0.001uF; 50V; +-10% 0.001uF; 50V; +-10% 0.001uF; 50V; +-10% 0.001uF; 50V; +-10% 0.001uF; 50V; +-10% 0.001uF; 50V; +-10% 0.001uF; 50V; +-10% 0.01uF; 50V; +-10% 0.01uF; 50V; +-10% 47pF; 50V; +-5% 47pF; 50V; +-5% Vendor Vendor Part Number Circuit Ref Motorola Equivalent Part Number Murata GRM39CH220J50PT 2113740F35 Murata Murata Murata Murata Murata Murata Murata Murata NI-CHEMI Murata Murata NI-CHEMI NI-CHEMI NI-CHEMI Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata GRM39CH100J50PT GRM39CH101J50PT GRM39B104K16PT GRM39CH270J50PT GRM39B103K50PT GRM39B104K16PT GRM39B104K16PT GRM39B102K50PT 6MCM476MB2TER GRM39B104K16PT GRM39B102K50PT 6MCM476MB2TER 6MCM476MB2TER 6MCM476MB2TER GRM39B105K6.3PT GRM39B102K50PT GRM39B103K50PT GRM39CH330J50PT GRM39CH330J50PT GRM39B102K50PT GRM39B103K50PT GRM40B225K6.3PT GRM39B224K10PT GRM39B104K16PT GRM39B104K16PT GRM39B104K16PT GRM39B224K10PT GRM39B102K50PT GRM39B102K50PT GRM39B102K50PT GRM39B102K50PT GRM39CH470J50PT GRM39B102K50PT GRM39B102K50PT GRM39B102K50PT GRM39B102K50PT GRM39B102K50PT GRM39B102K50PT GRM39B102K50PT GRM39B102K50PT GRM39B102K50PT GRM39B102K50PT GRM39B103K50PT GRM39B103K50PT GRM39CH470J50PT GRM39CH470J50PT N/A 2113740F51 N/A 2113740F37 N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A 2113928P04 N/A N/A 2113740F39 2113740F39 N/A N/A N/A 2113928G01 N/A N/A N/A 2113928G01 N/A N/A N/A N/A 2113740F43 N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A 2113740F43 2113740F43 C160 C161 C162 C163 C164 C165 C166 C167 C171 C173 C174 C175 C176 C181 C182 C183 C191 Q102 Q117 Q119 Q123 Q124 Q130 Q126 Q127 Q131 Q105 Q114 Q120 Q121 Q122 Q125 Q115 Q116 Q118 L112 CN101 S101 S102 PB101 Q101 LC101 M101 Description 47pF; 50V; +-5% 0.001uF; 50V; +-10% 0.001uF; 50V; +-10% 0.001uF; 50V; +-10% 0.001uF; 50V; +-10% 0.001uF; 50V; +-10% 47pF; 50V; +-5% 47pF; 50V; +-5% 0.1uF; 16V; +-10% NU NU 0.01uF; 50V; +-10% NU 0.22uF; 10V; +-10% 0.22uF; 10V; +-10% 470pF; 50V; +-5% 0.001uF; 50V; +-10% TRANSISTOR: Dual NPN NPN Dual NPN PNP NU FET DIODE: Single Diode Diode INTEGRATED CIRCUIT: IC,CPU Reset IC, EEPROM IC, DTMF Decoder IC, D/A Converter IC, D Flip-flop IC, Op-Amp LIGHT EMITTING DIODE: LED LED Green/Red/Amber COIL: 10uH MISCELLANEOUS: Connector Tact Switch Tact Switch CONTROL-PCB MODULE: CPU LCD Capacitor Microphone Vendor Vendor Part Number Motorola Equivalent Part Number Murata Murata Murata Murata Murata Murata Murata Murata Murata GRM39CH470J50PT GRM39B102K50PT GRM39B102K50PT GRM39B102K50PT GRM39B102K50PT GRM39B102K50PT GRM39CH470J50PT GRM39CH470J50PT GRM39B104K16PT 2113740F43 N/A N/A N/A N/A N/A 2113740F43 2113740F43 N/A Murata GRM39B103K50PT N/A Murata Murata Murata Murata GRM39B224K10PT GRM39B224K10PT GRM39CH471J50PT GRM39B102K50PT 2113928G01 2113928G01 N/A N/A Rohm Rohm Rohm Rohm UMG2N TR DTC114EETL UMH6N TR DTA144EETL N/A N/A 4880439V02 N/A Toshiba SSM3K03FE-TE85L N/A Rohm Rohm Toshiba RB521S-30 TE61 1SS355 TE-17 1SS372-TE85L 4805656W22 4870360C15 N/A Rico Seiko El. Sanyo Fujitsu Toshiba JRC RN5VD30CATR S-24C16AFJ-01 LC73881M MB88347PFV TC7W74FU TE12L NJM2107F (TE1) DSIC076007 DSIC510003 DSIC092007 DSIC042002 DSIC013029 DSIC025016 Citizen Citizen Rohm CL-200G-C-TS CL-200G-C-TS SML-020MLT T86NN N/A N/A 4804810T02 Taiyo Uden LEM2520T100J N/A Matsushita Motorola Motorola Shikibo AXK5S40245J/P Y39A33110FP Y39A33110FP K001C802-12 DSCN097002 4080523Z01 4080523Z01 N/A Sanyo Picvue Bosung LC87F72C8A HT138ZAS OB-22P44 DSIC092009 DSLC170003 DSMI505001 August 30, 2002 7-24 Circuit Ref X101 R101 R102 R103 R104 R105 R106 R107 R108 R109 R110 R111 R112 R113 R114 R115 R116 R117 R118 R119 R120 R121 R126 R127 R128 R129 R134 R135 R136 R137 R138 R141 R142 R143 R144 R145 R146 R147 R148 R150 R153 R154 R155 R156 R157 R158 R159 R160 R161 August 30, 2002 Description CRYSTAL: Filter, 8.388608 MHz RESISTOR: 0 ohm; 0.1W; +-5% 47 Kohm; 0.1W; +-5% NU 0 ohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 0 ohm; 0.1W; +-5% 47 ohm; 0.1W; +-5% 330 ohm; 0.1W; +-5% 330 ohm; 0.1W; +-5% 51 Kohm; 0.1W; +-5% 51 Kohm; 0.1W; +-5% 13 Kohm; 0.1W; +-5% 22 Kohm; 0.1W; +-5% 43 Kohm; 0.1W; +-5% 130 Kohm; 0.1W; +-5% 18 Kohm; 0.1W; +-5% 33 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 0 ohm; 0.1W; +-5% 0 ohm; 0.1W; +-5% NU 10 Kohm; 0.1W; +-5% 12.4 Kohm; 0.1W; +-1% 6.98 Kohm; 0.1W; +-1% 1 Kohm; 0.1W; +-5% 1 Kohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 1 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 20 Kohm; 0.1W; +-5% 20 Kohm; 0.1W; +-5% 20 Kohm; 0.1W; +-5% 20 Kohm; 0.1W; +-5% 20 Kohm; 0.1W; +-5% 20 Kohm; 0.1W; +-5% 20 Kohm; 0.1W; +-5% 20 Kohm; 0.1W; +-5% 22 Kohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 47 Kohm; 0.1W; +-5% NU 47 Kohm; 0.1W; +-5% 220 Kohm; 0.1W; +-5% 470 Kohm; 0.1W; +-5% 20 Kohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% Vendor Vendor Part Number Motorola Equivalent Part Number Daishinkuu AT-38 DSXT182001 Rohm Rohm MCR03 EZHJ 000 MCR03 EZHJ 473 0662057B47 0662057A89 Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm MCR03 EZHJ 000 MCR03 EZHJ 103 MCR03 EZHJ 000 MCR03 EZHJ 470 MCR03 EZHJ 331 MCR03 EZHJ 331 MCR03 EZHJ 513 MCR03 EZHJ 513 MCR03 EZHJ 133 MCR03 EZHJ 223 MCR03 EZHJ 433 MCR03 EZHJ 134 MCR03 EZHJ 183 MCR03 EZHJ 333 MCR03 EZHJ 104 MCR03 EZHJ 000 MCR03 EZHJ 000 0662057B47 0662057A73 0662057B47 0662057A17 0662057A37 0662057A37 0662057A90 0662057A90 0662057A76 0662057A81 0665027A88 0662257B01 0662057A79 0662057A85 0662057A97 0662057B47 0662057B47 Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm MCR03 EZHJ 103 MCR03 EZHF 1242 MCR03 EZHF 6981 MCR03 EZHJ 102 MCR03 EZHJ 102 MCR03 EZHJ 103 MCR03 EZHJ 103 MCR03 EZHJ 102 MCR03 EZHJ 104 MCR03 EZHJ 203 MCR03 EZHJ 203 MCR03 EZHJ 203 MCR03 EZHJ 203 MCR03 EZHJ 203 MCR03 EZHJ 203 MCR03 EZHJ 203 MCR03 EZHJ 203 MCR03 EZHJ 223 MCR03 EZHJ 103 MCR03 EZHJ 473 0662057A73 0662057P69 0662057Y24 0662057A49 0662057A49 0662057A73 0662057A73 0662057A49 0662057A97 0662057A80 0662057A80 0662057A80 0662057A80 0662057A80 0662057A80 0662057A80 0662057A80 0662057A81 0662057A73 0662057A89 Rohm Rohm Rohm Rohm Rohm Rohm MCR03 EZHJ 473 MCR03 EZHJ 224 MCR03 EZHJ 474 MCR03 EZHJ 203 MCR03 EZHJ 103 MCR03 EZHJ 103 0662057A89 N/A 0662057B14 0662057A80 0662057A73 0662057A73 Circuit Ref R162 R163 R164 R165 R166 R167 R168 R169 R170 R171 R172 R173 R174 R175 R176 R177 R180 R182 R183 R184 R185 R186 Description 10 Kohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 47 Kohm; 0.1W; +-5% 47 Kohm; 0.1W; +-5% 330 ohm; 0.1W; +-5% 47 Kohm; 0.1W; +-5% 47 Kohm; 0.1W; +-5% 47 Kohm; 0.1W; +-5% 2.2 Kohm; 0.1W; +-5% 2.2 Kohm; 0.1W; +-5% 4.7 Kohm; 0.1W; +-5% 22 Kohm; 0.1W; +-5% 2.2 Kohm; 0.1W; +-5% 560 Kohm; 0.1W; +-5% 0 ohm; 0.1W; +-5% 47 Kohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 470 ohm; 0.1W; +-5% 0 ohm; 0.1W; +-5% Vendor Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Vendor Part Number MCR03 EZHJ 103 MCR03 EZHJ 103 MCR03 EZHJ 103 MCR03 EZHJ 103 MCR03 EZHJ 103 MCR03 EZHJ 473 MCR03 EZHJ 473 MCR03 EZHJ 331 MCR03 EZHJ 473 MCR03 EZHJ 473 MCR03 EZHJ 473 MCR03 EZHJ 222 MCR03 EZHJ 222 MCR03 EZHJ 472 MCR03 EZHJ 223 MCR03 EZHJ 222 MCR03 EZHJ 564 MCR10 EZHJ 000 MCR03 EZHJ 473 MCR03 EZHJ 103 MCR03 EZHJ 471 MCR03 EZHJ 000 Motorola Equivalent Part Number 0662057A73 0662057A73 0662057A73 0662057A73 0662057A73 0662057A89 0662057A89 0662057A37 0662057A89 0662057A89 0662057A89 0662057A57 0662057A57 0662057A65 0662057A81 0662057A57 N/A N/A 0662057A89 0662057A73 0662057A41 0662057B47 99R85452E01-O 7-25 VHF 136-174 MHz Radio Parts List (RF Board) Circuit Ref C201 C202 C203 C204 C205 C206 C207 C208 C209 C210 C211 C212 C213 C214 C215 C217 C218 C301 C302 C303 C304 C305 C308 C309 C310 C311 C312 C313 C316 C317 C318 C319 C323 C324 C325 C326 C327 C328 C335 C336 C336 C336 C336 C336 C337 C337 C337 C337 99R85452E01-O Description CAPACITOR 0.01uF; 50V; +-10% 10uF; 6.3V; +-20% 1uF; 16V; +-20% 0.01uF; 50V; +-10% 0.01uF; 50V; +-10% 0.001uF; 50V; +-10% 10uF; 6.3V; +-20% 0.01uF; 50V; +-10% 0.001uF; 50V; +-10% 0.001uF; 50V; +-10% 0.001uF; 50V; +-10% 0.001uF; 50V; +-10% 10uF; 6.3V; +-20% 0.001uF; 50V; +-10% 2.2uF; 16V; +80% -20% 0.1uF; 16V; +-10% 0.001uF; 50V; +-10% 10uF; 6.3V; +-20% 0.1uF; 16V; +-10% 0.0022uF; 50V; +-10% 10uF; 16V 0.22uF; 10V; +-10% 0.001uF; 50V; +-10% 0.001uF; 50V; +-10% 0.001uF; 50V; +-10% 0.001uF; 50V; +-10% 10pF; 50V; +-0.5pF 15pF; 50V; +-5% 0.01uF; 50V; +-10% 47pF; 50V; +-5% 47pF; 50V; +-5% 47pF; 50V; +-5% 2.2uF; 16V; +-20% 10uF; 16V NU NU NU NU 10pF 18pF; 50V; +-0.5pF 33pF; 50V; +-5% 33pF; 50V; +-5% 33pF; 50V; +-5% 33pF; 50V; +-5% 8pF; 50V; +-0.5pF 8pF; 50V; +-0.5pF 8pF; 50V ; +-0.5pF 8pF; 50V ; +-0.5pF Vendor Murata NEC NEC Murata Murata Murata NEC Murata Murata Murata Murata Murata NEC Murata Murata Murata Murata NEC Murata Murata NI-CHEMI Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata NEC NI-CHEMI Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Circuit Ref Vendor Part Number GRM39B103K50PT TEMSVA0J106M8R TESVA1C105M1-8R GRM39B103K50PT GRM39B103K50PT GRM39B102K50PT TEMSVA0J106M8R GRM39B103K50PT GRM39B102K50PT GRM39B102K50PT GRM39B102K50PT GRM39B102K50PT TEMSVA0J106M8R GRM39B102K50PT GRM40F225Z16PT GRM39B104K16PT GRM39B102K50PT TEMSVA0J106M8R GRM39B104K16PT GRM39B223K25PT 16MCM106MB2TER GRM39B224K10PT GRM39B102K50PT GRM39B102K50PT GRM39B102K50PT GRM39B102K50PT GRM39CH100D50PT GRM39CH150J50PT GRM39B103K50PT GRM39CH470J50PT GRM39CH470J50PT GRM39CH470J50PT TEMSVA1C225M8R 16MCM106MB2TER TZV02Z100A110T00 GRM39UJ180J50PT GRM39UJ330J50PT GRM39UJ330J50PT GRM39UJ330J50PT GRM39UJ330J50PT GRM39CH080D50PT GRM39CH080D50PT GRM39UJ080D50PT GRM39UJ080D50PT Motorola Equivalent Part Number N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A 2113928G05 N/A N/A N/A N/A 2113740F27 2113740F31 N/A 2113740F43 2113740F43 2113740F43 N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A C337 C338 C338 C338 C338 C338 C339 C341 C343 C344 C345 C346 C347 C348 C349 C350 C351 C352 C353 C354 C355 C357 C358 C359 C360 C361 C362 C363 C366 C367 C368 C369 C371 C380 C381 C401 C402 C403 C404 C405 C406 C407 C408 C409 C410 C411 C412 C413 C414 C415 C416 Description 8pF; 50V ; +-0.5pF 10pF; 50V; +-0.5pF 10pF; 50V; +-0.5pF 10pF; 50V; +-0.5pF 10pF; 50V; +-0.5pF 10pF; 50V; +-0.5pF 0.001uF; 50V; +-10% 0.1uF; 16V; +-10% 10uF; 6.3V; +-20% 13pF; 50V; +-5% 5pF; 50V; +-0.25pF 0.1uF; 16V; +-10% 0.001uF; 50V; +-10% NU NU 56pF; 50V; +-5% 68pF; 50V; +-5% 1.5pF; 50V; +-0.25pF 0.1uF; 16V; +-10% 1.5pF; 50V; +-0.25pF 22pF; 50V; +-5% 15pF; 50V; +-5% 33pF; 50V; +-5% 9pF; 50V; +-0.5pF NU 470pF; 50V; +-10% 2.2uF; 10V; +-20% 0.001uF; 50V; +-10% 10uF; 10V; +-20% 0.01uF; 50V; +-10% 1uF; 6.3V; +-10% 0.22uF; 35V; +-20% 1uF; 16V; +-20% 9pF; 50V; +-0.5pF NU 13pF; 50V; +-5% 150pF; 50V; +-5% NU 20pF; 50V; +-5% NU 150pF; 50V; +-5% 0.1uF; 16V; +-10% 120pF;50V;+-5% 100pF; 50V; +-5% 330pF; 50V; +-10% 100pF; 50V; +-5% 0.0022uF; 50V; +-10% 0.1uF; 16V; +-10% 330pF; 50V; +-10% 150pF; 50V; +-5% NU Vendor Vendor Part Number Motorola Equivalent Part Number Murata Murata Murata Murata Murata Murata Murata Murata NEC Murata Murata Murata Murata GRM39UJ080D50PT GRM39CH100D50PT GRM39CH100D50PT GRM39CH100D50PT GRM39UJ100D50PT GRM39UJ100D50PT GRM39B102K50PT GRM39B104K16PT TEMSVA0J106M8R GRM39CH130J50PT GRM39CH050C50PT GRM39B104K16PT GRM39B102K50PT N/A 2113740F27 2113740F27 2113740F27 N/A N/A N/A N/A N/A 2113740F30 N/A N/A N/A Murata Murata Murata Murata Murata Murata Murata Murata Murata GRM39CH560J50PT GRM39CH680J50PT GRM39CK1R5C50PT GRM39B104K16PT GRM39CK1R5C50PT GRM39CH220J50PT GRM39CH150J50PT GRM39CH330J50PT GRM39CH090D50PT 2113740F45 2113740F47 N/A N/A N/A 2113740F35 2113740F31 2113740F39 N/A Murata NEC Murata NEC Murata Murata NEC NEC Murata GRM39B471K50PT TESVA1A225M1-8R GRM39B102K50PT TESVA1A106M8R GRM39B103K50PT GRM39B105K6.3PT TESVA1V224M8R TESVA1C105M1-8R GRM39CH090D50PT N/A N/A N/A N/A N/A 2113928P04 N/A N/A N/A Murata Murata GRM39CH130J50PT GRM39CH151J50PT 2113740F30 2113740F55 Murata GRM39CH200J50PT 2113740F34 Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata GRM39CH151J50PT GRM39B104K16PT GRM39CH121J50PT GRM39CH101J50PT GRM39B331K50PT GRM39CH101J50PT GRM39B223K25PT GRM39B104K16PT GRM39B331K50PT GRM39CH151J50PT 2113740F55 N/A 2113740F53 2113740F51 N/A 2113740F51 N/A N/A N/A 2113740F55 August 30, 2002 7-26 Circuit Ref C417 C418 C419 C420 C421 C422 C423 C424 C425 C426 C427 C428 C429 C430 C431 C432 C433 C434 C436 C437 C438 C439 C440 C441 C442 C443 C444 C445 C446 C447 C448 C449 C450 C451 C452 C453 C454 C455 C456 C457 C458 C459 C460 C461 C462 C463 C464 C465 C466 C467 C468 August 30, 2002 Description 16pF; 50V; +-5% 100pF; 50V; +-5% 100pF; 50V; +-5% 330pF; 50V; +-10% NU 150pF; 50V; +-5% NU 10pF; 50V; +-0.5pF 20pF; 50V; +-5% 10pF; 50V; +-0.5pF 9pF; 50V; +-0.5pF NU 0.0022uF; 50V; +-10% 10pF; 50V; +-0.5pF 10pF; 50V; +-0.5pF 82pF; 50V; +-5% 24pF; 50V; +-5% NU 0.01uF; 50V; +-10% 56pF; 50V; +-5% 120pF;50V;+-5% 7pF; 50V; +-0.5pF 12pF; 50V; +-5% 12pF; 50V; +-5% 10pF; 50V; +-0.5pF 24pF; 50V; +-5% 47pF; 50V; +-5% 12pF; 50V; +-5% 9pF; 50V; +-0.5pF 18pF; 50V; +-5% 22pF; 50V; +-5% 0.0022uF; 50V; +-10% 3pF; 50V; +-0.25pF 56pF; 50V; +-5% 150pF; 50V; +-5% 1uF; 16V; +-10% 0.0033uF; 50V; +-10% 220pF; 50V; +-10% 22pF; 50V; +-5% 330pF; 50V; +-10% 0.001uF; 50V; +-10% 0.0022uF; 50V; +-10% 27pF; 50V; +-5% 0.0022uF; 50V; +-10% 330pF; 50V; +-10% 47pF; 50V; +-5% NU NU 0.0022uF; 50V; +-10% 3pF; 50V; +-0.25pF 22pF; 50V; +-5% Vendor Vendor Part Number Motorola Equivalent Part Number Murata Murata Murata Murata GRM39CH160J50PT GRM39CH101J50PT GRM39CH101J50PT GRM39B331K50PT 2113740F32 2113740F51 2113740F51 N/A Murata GRM39CH151J50PT 2113740F55 Murata Murata Murata Murata GRM39CH100D50PT GRM39CH200J50PT GRM39CH100D50PT GRM39CH090D50PT 2113740F27 2113740F34 2113740F27 N/A Murata Murata Murata Murata Murata GRM39B223K25PT GRM39CH100D50PT GRM39CH100D50PT GRM39CH820J50PT GRM39CH240J50PT N/A 2113740F27 2113740F27 2113740F49 2113740F36 Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata GRM39B103K50PT GRM39CH560J50PT GRM39CH121J50PT GRM39CH070D50PT GRM39CH120J50PT GRM39CH120J50PT GRM39CH100D50PT GRM39CH240J50PT GRM39CH470J50PT GRM39CH120J50PT GRM39CH090D50PT GRM39CH180J50PT GRM39CH220J50PT GRM39B223K25PT GRM39CH030C50PT GRM39CH560J50PT GRM39CH151J50PT GRM40B105K16PT GRM39B332K50PT GRM39B221K50PT GRM39CH220J50PT GRM39B331K50PT GRM39B102K50PT GRM39B223K25PT GRM39CH270J50PT GRM39B223K25PT GRM39B331K50PT GRM39CH470J50PT N/A 2113740F45 2113740F53 N/A 2113740F29 2113740F29 2113740F27 2113740F36 2113740F43 2113740F29 N/A 2113740F33 2113740F35 N/A 2103689A09 2113740F45 2113740F55 N/A 2155169M15 N/A 2113740F35 N/A N/A N/A 2113740F37 N/A N/A 2113740F43 Murata Murata Murata GRM39B223K25PT GRM39CH030C50PT GRM39CH220J50PT N/A 2103689A09 2113740F35 Circuit Ref C469 C470 C471 C472 C473 C474 C475 C476 C477 C478 C479 C480 C481 C482 C483 C484 C485 C486 C487 C489 C490 C493 C495 C496 C501 C502 C503 C504 C505 C506 C508 C509 C510 C511 C512 C513 C514 C515 C516 C517 C518 C519 C520 C521 C522 C523 C524 C525 C526 C527 C528 Description 10pF; 50V; +-0.5pF 5pF; 50V; +-0.25pF 8pF; 50V; +-0.5pF 56pF; 50V; +-5% 0.001uF; 50V; +-10% 0.01uF; 50V; +-10% 10pF; 50V; +-0.5pF 0.001uF; 50V; +-10% 0.001uF; 50V; +-10% 5pF; 50V; +-0.25pF 0.001uF; 50V; +-10% NU 0.001uF; 50V; +-10% 0.01uF; 50V; +-10% 0.001uF; 50V; +-10% 6.8uF; 6.3V; +-20% 2.2uF; 16V; +80% -20% 33pF; 50V; +-5% NU 0.001uF; 50V; +-10% 100pF; 50V; +-5% 0.01uF; 50V; +-10% 22pF; 50V; +-5% 3pF; 50V; +-0.25pF 0.001uF; 50V; +-10% 0.01uF; 50V; +-10% NU 0.1uF; 16V; +-10% 100pF; 50V; +-5% 0.1uF; 16V; +-10% 470pF; 50V; +-10% 0.001uF; 50V; +-10% 0.22uF; 10V; +-10% 0.1uF; 16V; +-10% 0.0022uF; 50V; +-10% 27pF; 50V; +-5% 0.01uF; 50V; +-10% 0.01uF; 16V; +-2% 0.01uF; 16V; +-2% 0.01uF; 16V; +-2% 0.01uF; 16V; +-2% 0.01uF; 50V; +-10% 0.01uF; 16V; +-2% 0.01uF; 16V; +-2% 0.01uF; 16V; +-2% 0.22uF; 10V; +-10% 0.068uF; 16V; +-10% 33pF; 50V; +-5% 39pF; 50V; +-5% 0.001uF; 50V; +-10% 1uF; 6.3V; +-10% Vendor Vendor Part Number Motorola Equivalent Part Number Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata GRM39CH100D50PT GRM39CH050C50PT GRM39CH080D50PT GRM39CH560J50PT GRM39B102K50PT GRM39B103K50PT GRM39CH100D50PT GRM39B102K50PT GRM39B102K50PT GRM39CH050C50PT GRM39B102K50PT 2113740F27 N/A N/A 2113740F45 N/A N/A 2113740F27 N/A N/A N/A N/A Murata Murata Murata NEC Murata Murata GRM39B102K50PT GRM39B103K50PT GRM39B102K50PT TEMSVA0J685M8R GRM40F225Z16PT GRM39CH330J50PT N/A N/A N/A N/A N/A 2113740F39 Murata Murata Murata Murata Murata Murata Murata GRM39B102K50PT GRM39CH101J50PT GRM39B103K50PT GRM39CH220J50PT GRM39CH030C50PT GRM39B102K50PT GRM39B103K50PT N/A 2113740F51 N/A 2113740F35 2103689A09 N/A N/A Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Panasonic Panasonic Panasonic Panasonic Murata Panasonic Panasonic Panasonic Murata Murata Murata Murata Murata Murata GRM39B104K16PT GRM39CH101J50PT GRM39B104K16PT GRM39B471K50PT GRM39B102K50PT GRM39B224K10PT GRM39B104K16PT GRM39B222K50PT GRM39CH270J50PT GRM39B103K50PT ECHU1C103GX5 ECHU1C103GX5 ECHU1C103GX5 ECHU1C103GX5 GRM39B103K50PT ECHU1C103GX5 ECHU1C103GX5 ECHU1C103GX5 GRM39B224K10PT GRM39B683K16PT GRM39CH330J50PT GRM39CH390J50PT GRM39B102K50PT GRM39B105K6.3PT N/A 2113740F51 N/A N/A N/A 2113928G05 N/A N/A 2113740F37 N/A N/A N/A N/A N/A N/A N/A N/A N/A 2113928G05 N/A 2113740F39 2113740F41 N/A 2113928P04 99R85452E01-O 7-27 Circuit Ref C529 C530 C531 C532 C533 C534 C535 C536 C537 C538 C539 C540 C541 C542 C543 C544 C545 C546 C547 C550 C551 C601 C602 C603 C604 C605 C606 C607 C608 C612 C615 C616 C617 C618 C619 C620 C621 C622 C623 C624 C625 C626 C627 C628 C629 C630 C631 C632 C633 C634 C635 99R85452E01-O Description 0.1uF; 16V; +-10% 0.1uF; 16V; +-10% 220pF; 50V; +-10% 220pF; 50V; +-10% 22pF; 50V; +-5% 2.2uF; 10V; +-20% 0.027uF; 25v; +-10% 0.047uF; 16V; +-10% 0.0027uF; 50V; +-10% 0.01uF; 50V; +-10% 0.039uF; 16v; +-10% 0.015uF; 50V; +-10% 0.1uF; 16V; +-10% 390pF; 50V; +-10% 0.0047uF; 50V; +-10% 0.22uF; 10V; +-10% 33uF; 6.3V; +-20% 0.1uF; 16V; +-10% 0.1uF; 16V; +-10% 0.01uF; 16V; +-2% 0.01uF; 16V; +-2% 330pF; 50V; +-5% 0.0033uF; 50V; +-10% 82pF; 50V; +-5% 0.0012uF; 50V; +-10% 680pF; 50V; +10% 0.047uF; 16V; +-10% 0.1uF; 16V; +-10% NU 10pF; 50V; +-0.5pF 0.01uF; 50V; +-10% 0.027uF; 25v; +-10% 0.0047uF; 50V; +-10% 82pF; 50V; +-5% 0.1uF; 16V; +-10% NU 0.001uF; 50V; +-10% 0.001uF; 50V; +-10% 0.01uF; 50V; +-10% 220pF; 50V; +-10% 4.7uF; 6.3V; +-20% 10uF; 6.3V; +-20% 470pF; 50V; +-10% 1uF; 16V; +-20% 1uF; 6.3V; +-10% 0.01uF; 50V; +-10% 0.0082uF; 50V; +-10% 68pF; 50V; +-5% 0.01uF; 50V; +-10% 0.0018uF; 50V; +-10% 0.1uF; 16V; +-10% Vendor Vendor Part Number Motorola Equivalent Part Number Circuit Ref Murata Murata Murata Murata Murata NEC Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata NEC Murata Murata Panasonic Panasonic Murata Murata Murata Murata Murata Murata Murata GRM39B104K16PT GRM39B104K16PT GRM39B221K50PT GRM39B221K50PT GRM39CH220J50PT TESVA1A225M1-8R GRM39B273K25PT GRM39B473K16PT GRM39B272K50PT GRM39B103K50PT GRM39B393K16PT GRM39B152K50PT GRM39B104K16PT GRM39B391K50PT GRM39B472K50PT GRM39B224K10PT TEMSVB20J336M8R GRM39B104K16PT GRM39B104K16PT ECHU1C103GX5 ECHU1C103GX5 GRM39CH331J50PT GRM39B332K50PT GRM39CH820J50PT GRM39B122K50PT GRM39B681K50PT GRM39B473K16PT GRM39B104K16PT N/A N/A N/A N/A 2113740F35 N/A 2155169N29 N/A N/A N/A N/A 2113932E03 N/A 2113741F15 N/A 2113928G05 N/A N/A N/A N/A N/A N/A 2155169M15 2113740F49 N/A N/A N/A N/A C636 C637 C638 C639 C641 C642 C643 C643 C701 C702 C703 C704 C705 C706 C707 C708 C709 C710 C711 C713 C714 C715 C716 C717 C718 C719 C720 C721 Murata Murata Murata Murata Murata Murata GRM39CH100D50PT GRM39B103K50PT GRM39B273K25PT GRM39B472K50PT GRM39CH820J50PT GRM39B104K16PT 2113740F27 N/A 2155169N29 N/A 2113740F49 N/A Murata Murata Murata Murata NEC NEC Murata NEC Murata Murata Murata Murata Murata Murata Murata GRM39B102K50PT GRM39B102K50PT GRM39B103K50PT GRM39B221K50PT TEMSVA0J475M8R TEMSVA0J106M8R GRM39B471K50PT TESVA1C105M1-8R GRM39B105K6.3PT GRM39B103K50PT GRM39B822K50PT GRM39CH680J50PT GRM39B103K50PT GRM39B182K50PT GRM39B104K16PT N/A N/A N/A N/A N/A N/A N/A N/A 2113928P04 N/A N/A 2113740F47 N/A 2155116E54 N/A Q201 Q202 Q206 Q207 Q208 Q209 Q210 Q211 Q308 Q309 Q310 Q314 Q315 Q320 Q324 Q325 Q330 Q331 Q404 Q408 Q411 Q412 Description 100pF; 50V; +-5% 2.2uF; 16V; +80% -20% 4.7uF; 6.3V; +-20% 27pF; 50V; +-5% 0.22uF; 10V; +-10% 0.015uF; 50V; +-10% NU 1uF; 6.3V; +-10% 0.001uF; 50V; +-10% 0.001uF; 50V; +-10% 0.22uF; 10V; +-10% 4.7uF; 6.3V; +-20% 2.2uF; 16V; +80% -20% 0.1uF; 16V; +-10% 0.001uF; 50V; +-10% 0.001uF; 50V; +-10% 10uF; 6.3V; +-20% 0.1uF; 16V; +-10% 0.1uF; 16V; +-10% 0.1uF; 16V; +-10% 100pF; 50V; +-5% 100pF; 50V; +-5% 100pF; 50V; +-5% 100pF; 50V; +-5% 100pF; 50V; +-5% 220pF; 50V; +-5% 0.001uF; 50V; +-10% 0.1uF; 16V; +-10% TRANSISTOR: PNP Digital transistor PNP Digital transistor PNP PNP PNP PNP NPN FET Digital transistor PNP NPN Transistor NPN NPN NPN NPN NPN NPN FET FET Vendor Vendor Part Number Motorola Equivalent Part Number Murata Murata NEC Murata Murata Murata GRM39CH101J50PT GRM40F225Z16PT TEMSVA0J475M8R GRM39CH270J50PT GRM39B224K10PT GRM39B152K50PT 2113740F51 N/A N/A 2113740F37 2113928G05 2113932E03 Murata Murata Murata Murata NEC Murata Murata Murata Murata NEC Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata GRM39B105K6.3PT GRM39B102K50PT GRM39B102K50PT GRM39B224K10PT TEMSVA0J475M8R GRM40F225Z16PT GRM39B104K16PT GRM39B102K50PT GRM39B102K50PT TEMSVA0J106M8R GRM39B104K16PT GRM39B104K16PT GRM39B104K16PT GRM39CH101J50PT GRM39CH101J50PT GRM39CH101J50PT GRM39CH101J50PT GRM39CH101J50PT GRM39CH221J50PT GRM39B102K50PT GRM39B104K16PT 2113928P04 N/A N/A 2113928G05 N/A N/A N/A N/A N/A N/A N/A N/A N/A 2113740F51 2113740F51 2113740F51 2113740F51 2113740F51 N/A N/A N/A NEC Rohm Rohm Rohm Rohm Rohm Toshiba Rohm Toshiba NEC Rohm Toshiba Toshiba Rohm NEC NEC Toshiba Toshiba Toshiba Toshiba Toshiba Toshiba 2SB798-T1 DK UMW1N TL DTA123YETL UMW1N TL DTA114EETL DTA144EETL 2SA1362-GR TE85L DTA123YETL 2SC5086-Y TE85L 2SJ243-T1 UMC4N TR 2SA1362-GR TE85L 2SC4116-GR TE85L UMZ2N-TR 2SC4226-T1 R24 2SC4226-T1 R24 2SC4116-GR TE85L 2SC4116-GR TE85L 2SC5086-Y TE85L 2SC5086-Y TE85L 2SK3476 2SK3475 N/A N/A N/A N/A 4808317Y01 N/A N/A N/A N/A N/A N/A N/A N/A 4809939C06 N/A N/A N/A N/A N/A N/A DSTR013027 DSTR013026 August 30, 2002 7-28 Circuit Ref Q413 Q414 Q416 Q417 Q418 Q501 Q503 Q504 Q509 Q601 Q605 Q608 Q609 Q613 Q616 Q701 Q703 Q704 Q707 Q708 Q709 Q203 Q311 Q316 Q319 Q322 Q326 Q329 Q401 Q403 Q405 Q407 Q409 Q410 Q415 Q507 Q508 Q511 Q607 Q614 Q615 Q705 Q706 Q710 Q711 Q712 Q204 Q301 Q323 August 30, 2002 Description NPN NPN NPN PNP PNP Digital transistor FET PNP PNP PNP PNP PNP Digital transistor PNP FET PNP PNP PNP PNP PNP PNP DIODE: Single Varactor Zener ;7.6V Single Varactor Varactor Varactor Varactor Dual Varactor Varactor Diode Single Diode Single Dual Dual Diode NU Dual Varactor Dual Single Zener;6.9V Zener;20.39V Single Single INTEGRATED CIRCUIT: IC IC, DC-DC Converter IC, PLL Vendor Vendor Part Number Motorola Equivalent Part Number NEC Toshiba Toshiba Rohm Rohm Rohm Toshiba Rohm Rohm Rohm Rohm Rohm Rohm Rohm Toshiba Rohm Rohm Toshiba Toshiba Toshiba Toshiba 2SC3356-T1B R24 2SC5086-Y TE85L 2SC5086-Y TE85L DTA144EETL DTA144EETL UMC4N TR 2SJ144Y-TE85L DTA144EETL DTA144EETL DTA144EETL DTA144EETL DTA144EETL UMG2N TR DTA144EETL SSM3K03FE-TE85L DTA144EETL DTA144EETL 2SA1362-GR TE85L 2SA1313-Y TE85L 2SA1362-GR TE85L 2SA1362-GR TE85L N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A Rohm Toshiba Rohm Rohm Toshiba Toshiba Toshiba Toshiba Toshiba Toshiba HP Hitachi MA/COM Hitachi Rohm Rohm Rohm 1SR154-400 TE25 1SV217-TPH3 UDZ S 7.5B TE-17 1SS355 TE-17 1SV217-TPH3 1SV217-TPH3 1SV217-TPH3 1SV217-TPH3 1SS362-TE85L 1SV217-TPH3 HSMS-2817 HVU131TRF MA4PH262 HSC277TRF DAN235ETL DAN235ETL RB521S-30 TE61 4842006M02 N/A N/A 4870360C15 N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A Toshiba Rohm Rohm Rohm Rohm Rohm Rohm 1SS362-TE85L DAN222TL 1SR154-400 TE25 UDZ S 6.8B TE-17 UDZ S 20B TE-17 1SR154-400 TE25 1SS355 TE-17 N/A 4809606E02 4842006M02 4842006M03 N/A 4842006M02 4870360C15 TOREX Toko Fujitsu XC62HR5002PR TK11816M MB15A02PFV1-ER DSIC510004 DSIC011011 DSIC042003 Circuit Ref Q419 Q502 Q505 Q506 Q510 Q602 Q610 Q702 L301 L302 L303 L305 L306 L307 L312 L313 L314 L315 L317 L318 L401 L402 L403 L404 L405 L406 L407 L408 L409 L410 L411 L413 L414 L415 L416 L417 L418 L419 L420 L421 L422 L423 L424 L425 L426 L427 L428 L429 L430 L431 Description IC, Op-Amp IC, Op-Amp IC, Op-Amp IC IC, Op-Amp IC, Op-Amp IC, Op-Amp IC COIL: 100nH 100nH 1000uH 47nH 1uH Chip Emifil 1uH 47nH 56nH 47nH 47nH 1uH 12nH 12nH 470nH 12nH 12nH Airwound Coil Coil Coil 33nH 150nH 470nH Airwound Coil Airwound Coil Airwound Coil Airwound Coil 1uH Airwound Coil Airwound Coil Airwound Coil 39nH Airwound Coil Airwound Coil Airwound Coil 68nH Airwound Coil 100nH 100nH Chip Beads 100nH 2.2uH Vendor Vendor Part Number Motorola Equivalent Part Number JRC JRC JRC Toshiba JRC JRC JRC Philips NJM2904V(TE1) NJM324V(TE1) NJM324V(TE1) TA31136FN-TP1 NJM2107F (TE1) NJM324V(TE1) NJM324V(TE1) TDA8541T/N1 DSIC510001 DSIC510002 DSIC510002 DSIC013007 DSIC025016 DSIC510002 DSIC510002 DSIC174004 Toko Sagami Elec TDK Sagami Elec Sagami Elec Murata Toko Sagami Elec Sagami Elec Sagami Elec Sagami Elec Sagami Elec Sagami Elec. Sagami Elec. Toko Sagami Elec. Sagami Elec. Uchida/Letest Latest Latest Toko Sagami Elec Toko Uchida/Letest Uchida/Letest Uchida/Letest Uchida/Letest Toko Uchida/Letest Uchida/Letest Uchida/Letest Sagami Elec Uchida/Letest Uchida/Letest Uchida/Letest Sagami Elec Uchida/Letest Toko Toko TDK Toko TDK LL1608-FSR10J C2012C-R10J NL453232T-102J C2012C-47NG C2520C-1R0J BLM21A121SPT FSLM2520-1R0J C2012C-47NG C2012C-56NG C2012C-47NG C2012C-47NG C2520C-1R0J C2012C-12NJ C2012C-12NJ FSLM2520-R47K C2012C-12NJ C2012C-12NJ E2-0.30-1.0-4TL SMD-0314A SMD-0314A LL2012-FH33NJ C2012C-R15J FSLM2520-R47K E2-0.40-0.9-3TL E2-0.30-1.7-6TL E2-0.30-1.7-5TL E2-0.30-1.7-5TL FSLM2520-1R0J E2-0.30-1.0-7TL E2-0.40-0.9-3TL E2-0.40-1.0-5TL C2012C-39NJ E2-0.40-0.9-3TL E2-0.30-1.0-6TL E2-0.30-1.0-5TL C2012C-68NJ E2-0.30-1.0-4TL LL1608-FSR10J LL1608-FSR10J ZBFS5105-PT LL1608-FSR10J MLF1608A2R2KT 2413926N24 N/A N/A 2413923B12 2462587N68 2480067M02 2485601J13 2413923B12 2413923B18 2413923B12 2413923B12 2462587N68 2462587V23 2462587V23 2485602J33 2462587V23 2462587V23 4880048M03 N/A N/A 2413926N17 2462587V36 2485602J33 N/A N/A N/A N/A 2485601J13 N/A N/A N/A 2462587V29 N/A N/A N/A 2462587V32 4880048M03 2413926N24 2413926N24 N/A 2413926N24 N/A 99R85452E01-O 7-29 Circuit Ref L501 L702 Description Vendor Vendor Part Number Motorola Equivalent Part Number TDK Sagami Elec MLF1608A1R0KT C2012C-R39J N/A 2462587V41 Motorola Matsushita Motorola Motorola 09D86237A AXK6S40545J/P 02D80689C 09R80683Z 0986237A01 DSCN097003 0280689C01 0980683Z01 Samsung IFD0455C24E03 N/A Toko Toko BLFYM455D ALFYM455G N/A N/A F401 F402 1uH 390nH JACK: Connector contact Battery Connector Antenna Jack Audio Jack DISCRIMINATOR Discriminator CERAMIC FILTER: Ceramic filter Ceramic filter CRYSTAL NU Filter , 45.1 MHz HERTZ DSXF137006 X301 Crystal Nikko Denshi X501 Crystal Nikko Denshi 45N12A5 (45.1MHz) UM-5J-SMD TOP-B 14.4MHz RANK-2 TOP-B 44.645MHz +10ppm, +-4ppm J702 P701 SW201 MISCELLANEOUS Connector SP WIRE Assembly Potentiometers CN201 CN701 J401 J701 CD501 F501 F502 SP701 PB201 R201 R202 R203 R204 R205 R206 R207 R208 R209 R210 R211 R212 R301 R302 R310 R311 R312 R313 R314 R315 R316 R317 R318 99R85452E01-O Speaker RF-VHF-PCB RESISTOR: 10 Kohm; 0.1W; +-5% 2.2 Kohm; 0.1W; +-5% 4.7 Kohm; 0.1W; +-5% 4.7 Kohm; 0.1W; +-5% 50K ohm NU 10 Kohm; 0.1W; +-5% 4.7 Kohm; 0.1W; +-5% 10 ohm; 0.1W; +-5% 22 ohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 100 ohm; 0.1W; +-5% 1 Kohm; 0.1W; +-5% 220 ohm; 0.1W; +-5% 100 ohm; 0.1W; +-5% 15 Kohm; 0.1W; +-5% 220 ohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 0 ohm; 0.1W; +-5% 2.7 Kohm; 0.1W; +-5% 1.5 Kohm; 0.1W; +-5% 2.2 Kohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% Molex EU-connector TOCOS DSXT181002 DSXT181006 Orient sound Shikibo 53047-0210 WC-013 TP76N17N A10Kohm 10SK K028NA K001C801-11 DSCN075035 N/A DSVR010008 N/A N/A Rohm Rohm Rohm Rohm Hokuriku MCR03 EZHJ 103 MCR03 EZHJ 222 MCR03 EZHJ 472 MCR03 EZHJ 472 NSM3503J400J 0662057A73 0662057A57 0662057A65 0662057A65 N/A Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm MCR03 EZHJ 103 MCR03 EZHJ 472 MCR03 EZHJ 100 MCR03 EZHJ 220 MCR03 EZHJ 103 MCR03 EZHJ 101 MCR03 EZHJ 102 MCR03 EZHJ 221 MCR03 EZHJ 101 MCR03 EZHJ 153 MCR03 EZHJ 221 MCR03 EZHJ 104 MCR03 EZHJ 000 MCR03 EZHJ 272 MCR03 EZHJ 152 MCR03 EZHJ 222 MCR03 EZHJ 103 0662057A73 0662057A65 0662057A01 0662057A09 0662057A73 0662057A25 0662057A49 0662057A33 0662057A25 0662057A77 0662057A33 0662057A97 0662057B47 0662057A59 0662057A53 0662057A57 0662057A73 Circuit Ref Description Vendor R319 R320 R321 R322 R323 R325 R327 R329 R330 10 Kohm; 0.1W; +-5% 1.5 Kohm; 0.1W; +-5% 6.8 Kohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% Chip network resistor 10 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 220 Kohm; 0.1W; +-1% 10K ohm Rohm Rohm Rohm Rohm Hokuriku Rohm Rohm Rohm Murata R332 R333 R335 R336 R337 R338 R339 R340 R341 R342 R343 R346 R347 R349 R350 R355 R356 R357 R358 R359 R361 R362 R363 R364 R365 R366 R401 R402 R403 R404 R405 R406 R407 R408 R409 R410 R411 R412 R413 R414 R415 100 Kohm; 0.1W; +-1% 100 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 150 Kohm; 0.1W; +-1% 220 ohm; 0.1W; +-5% 15 ohm; 0.1W; +-5% 22 Kohm; 0.1W; +-5% NU 100 Kohm; 0.1W; +-5% 2.2 Kohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 1 Kohm; 0.1W; +-5% 4.7 Kohm; 0.1W; +-5% NU 4.7 Kohm; 0.1W; +-5% 10 ohm; 0.1W; +-5% 47 ohm;0.1W;+-5% 4.7 Kohm; 0.1W; +-5% 22 Kohm; 0.1W; +-5% 22 Kohm; 0.1W; +-5% 470 ohm; 0.1W; +-5% 2.7 Kohm; 0.1W; +-5% 470 ohm; 0.1W; +-5% 470 ohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 5.6 Kohm; 0.1W; +-5% 3.3 Kohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 2.2 ohm; 0.1W; +-5% 0 ohm; 0.1W; +-5% 10 ohm; 0.1W; +-5% 1 Kohm; 0.1W; +-5% 390 ohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% NU NU 56 ohm; 0.1W; +-5% 0 ohm; 0.1W; +-5% 150 Kohm; 0.1W; +-5% Vendor Part Number Motorola Equivalent Part Number 0662057A73 0662057A53 0662057A69 0662057A73 DSRA508001 0662057A73 0662057A97 N/A N/A Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm MCR03 EZHJ 103 MCR03 EZHJ 152 MCR03 EZHJ 682 MCR03 EZHJ 103 CRA168-472J MCR03 EZHJ 103 MCR03 EZHJ 104 MCR03 EZHF 2203 NTH5G16P39A103K07 TH MCR03 EZHF 1003 MCR03 EZHJ 104 MCR03 EZHJ 104 MCR03 EZHJ 104 MCR03 EZHF 1503 MCR03 EZHJ 221 MCR03 EZHJ 150 MCR03 EZHJ 223 Rohm Rohm Rohm Rohm Rohm Rohm MCR03 EZHJ 104 MCR03 EZHJ 222 MCR03 EZHJ 103 MCR03 EZHJ 103 MCR03 EZHJ 102 MCR03 EZHJ 472 0662057A97 0662057A57 0662057A73 0662057A73 0662057A49 0662057A65 Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm MCR03 EZHJ 472 MCR03 EZHJ 100 MCR03 EZHJ 470 MCR03 EZHJ 472 MCR03 EZHJ 223 MCR03 EZHJ 223 MCR03 EZHJ 471 MCR03 EZHJ 272 MCR03 EZHJ 471 MCR03 EZHJ 471 MCR03 EZHJ 104 MCR03 EZHJ 562 MCR03 EZHJ 332 MCR03 EZHJ 103 MCR03 EZHJ 2R2 MCR03 EZHJ 000 MCR03 EZHJ 100 MCR03 EZHJ 102 MCR03 EZHJ 391 MCR03 EZHJ 104 0662057A65 0662057A01 0662057A17 0662057A65 0662057A81 0662057A81 0662057A41 0662057A59 0662057A41 0662057A41 0662057A97 0662057A67 0662057A61 0662057A73 0662057W09 0662057B47 0662057A01 0662057A49 0662057A39 0662057A97 Rohm Rohm Rohm MCR03 EZHJ 560 MCR03 EZHJ 000 MCR03 EZHJ 154 0662057A19 0662057B47 0662057B02 0662057P95 0662057A97 0662057A97 0662057A97 0662057P97 0662057A33 0662057A05 0662057A81 August 30, 2002 7-30 Circuit Ref R416 R418 R419 R420 R421 R422 R423 R424 R425 R426 R427 R428 R429 R430 R431 R432 R433 R434 R435 R436 R437 R438 R439 R440 R441 R442 R443 R444 R445 R446 R447 R448 R449 R450 R451 R452 R453 R454 R455 R456 R457 R459 R466 R467 R468 R470 R501 R502 R503 R505 R506 August 30, 2002 Description 1 Kohm; 0.1W; +-5% 39 ohm;0.1W;+-5% 220 ohm; 0.1W; +-5% 100 ohm; 0.1W; +-5% 120 ohm; 0.1W; +-5% 39 ohm;0.1W;+-5% 22 Kohm; 0.1W; +-5% 12 Kohm; 0.1W; +-5% NU 100 ohm; 0.1W; +-5% 12 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 470 ohm; 0.1W; +-5% 100 ohm; 0.1W; +-5% 15 Kohm; 0.1W; +-5% 220 ohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 10 ohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 4.7 Kohm; 0.1W; +-5% 680 ohm; 0.1W; +-5% 4.7 ohm; 0.1W; +-5% 15 Kohm; 0.1W; +-5% 4.7 Kohm; 0.1W; +-5% 1 Kohm; 0.1W; +-5% 330 ohm; 0.1W; +-5% 330 ohm; 0.1W; +-5% 22 ohm; 0.1W; +-5% 0.1ohm 1W 100 Kohm; 0.1W; +-1% 100 Kohm; 0.1W; +-1% 97.6 Kohm; 0.1W; +-1% 100 Kohm; 0.1W; +-1% 100 Kohm; 0.1W; +-1% 100 Kohm; 0.1W; +-1% 100 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 27 Kohm;0.1W;+-5% 1 Mohm; 0.1W; +-5% 15 Kohm; 0.1W; +-5% NU 1 Kohm; 0.1W; +-5% NU 0 ohm; 0.1W; +-5% 22 ohm; 0.1W; +-5% 0 ohm; 0.1W; +-5% 47 Kohm; 0.1W; +-5% 2.7 Kohm; 0.1W; +-5% 2.2 Kohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% Vendor Vendor Part Number Motorola Equivalent Part Number Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm MCR03 EZHJ 102 MCR03 EZHJ 390 MCR03 EZHJ 221 MCR03 EZHJ 101 MCR03 EZHJ 121 MCR03 EZHJ 390 MCR03 EZHJ 223 MCR03 EZHJ 123 0662057A49 0662057A15 0662057A33 0662057A25 0662057A27 0662057A15 0662057A81 0662057A51 Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Hokuriku Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm MCR03 EZHJ 101 MCR03 EZHJ 123 MCR03 EZHJ 104 MCR03 EZHJ 471 MCR03 EZHJ 101 MCR03 EZHJ 153 MCR03 EZHJ 221 MCR03 EZHJ 103 MCR03 EZHJ 100 MCR03 EZHJ 103 MCR03 EZHJ 472 MCR03 EZHJ 681 MCR03 EZHJ 4R7 MCR03 EZHJ 153 MCR03 EZHJ 472 MCR03 EZHJ 102 MCR03 EZHJ 331 MCR03 EZHJ 331 MCR03 EZHJ 220 LPR1R100FE MCR03 EZHF 1003 MCR03 EZHF 1003 MCR03 EZHF 9762 MCR03 EZHF 1003 MCR03 EZHF 1003 MCR03 EZHF 1003 MCR03 EZHJ 104 MCR03 EZHJ 104 MCR03 EZHJ 103 MCR03 EZHJ 273 MCR03 EZHJ 105 MCR03 EZHJ 153 0662057A25 0662057A51 0662057A97 0662057A41 0662057A25 0662057A77 0662057A33 0662057A73 0662057A01 0662057A73 0662057A65 0662057A45 0662057W17 0662057A77 0662057A65 0662057A49 0662057A37 0662057A37 0662057A09 N/A 0662057P95 0662057P95 N/A 0662057P95 0662057P95 0662057P95 0662057A97 0662057A97 0662057A73 0662057A83 0662057B22 0662057A77 Rohm MCR03 EZHJ 102 0662057A49 Rohm Rohm Rohm Rohm Rohm Rohm Rohm MCR03 EZHJ 000 MCR03 EZHJ 220 MCR03 EZHJ 000 MCR03 EZHJ 473 MCR03 EZHJ 272 MCR03 EZHJ 222 MCR03 EZHJ 103 0662057B47 0662057A09 0662057B47 0662057A89 0662057A59 0662057A57 0662057A73 Circuit Ref Description Vendor Vendor Part Number Motorola Equivalent Part Number R507 R508 R509 R510 R511 R512 R513 R514 R515 R516 R517 R518 R519 R520 R521 R522 R523 R524 R525 R526 R527 R530 R531 R532 R534 R535 R536 R537 R538 R539 R540 R541 R542 R543 R544 R545 R546 R547 R548 R549 R550 R551 R560 R561 R563 R564 R565 R566 R567 1 Kohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 68 Kohm; 0.1W; +-5% 470 Kohm; 0.1W; +-5% 56 Kohm; 0.1W; +-5% 47 Kohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 1 Kohm; 0.1W; +-5% 25.5 Kohm; 0.1W; +-1% 29.4 Kohm; 0.1W; +-1% 15.8 Kohm; 0.1W; +-1% 11.5 Kohm; 0.1W; +-1% 150 Kohm; 0.1W; +-1% 4.22 Kohm; 0.1W; +-1% 715 Kohm; 0.1W; +-1% NU 47 Kohm; 0.1W; +-5% 2.2 Kohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 0 ohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 22 Kohm; 0.1W; +-5% 22 Kohm; 0.1W; +-5% 15 Mohm; 0.1W; +-5% 330 Kohm; 0.1W; +-5% 2.2 Kohm; 0.1W; +-5% 1 Kohm; 0.1W; +-5% 470 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 22 Kohm; 0.1W; +-5% 22 Kohm; 0.1W; +-5% 22 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 1 Kohm; 0.1W; +-5% 0 ohm; 0.1W; +-5% 5.6 Kohm; 0.1W; +-1% 634 Kohm; 0.1W; +-5% 0 ohm; 0.1W; +-5% 82 Kohm; 0.1W; +-1% 18 Kohm; 0.1W; +-5% 6.8 Kohm; 0.1W; +-5% 10K ohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm MCR03 EZHJ 102 MCR03 EZHJ 103 MCR03 EZHJ 683 MCR03 EZHJ 474 MCR03 EZHJ 563 MCR03 EZHJ 473 MCR03 EZHJ 103 MCR03 EZHJ 102 MCR03 EZHF 2552 MCR03 EZHF 2942 MCR03 EZHF 1582 MCR03 EZHF 1152 MCR03 EZHF 1503 MCR03 EZHF 4221 MCR03 EZHF 7153 0662057A49 0662057A73 0662057A93 0662057B14 0662057A91 0662057A89 0662057A73 0662057A49 0662057T92 0662057P29 0662057Z03 0662057Z35 0662057P97 N/A 0662057T99 Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Murata 0662057A89 0662057A57 0662057A73 0662057B47 0662057A73 0662057A81 0662057A81 N/A 0662057B10 0662057A57 0662057A49 0662057B14 0662057A97 0662057A97 0662057A81 0662057A81 0662057A81 0662057A97 0662057A97 0662057A97 0662057A97 0662057A97 0662057A73 0662057A97 0662057A49 0662057B47 N/A N/A 0662057B47 N/A 0662057A79 0662057A69 N/A R568 4.7 Kohm; 0.1W; +-5% Rohm MCR03 EZHJ 473 MCR03 EZHJ 222 MCR03 EZHJ 103 MCR03 EZHJ 000 MCR03 EZHJ 103 MCR03 EZHJ 223 MCR03 EZHJ 223 MCR03 EZHJ 155 MCR03 EZHJ 334 MCR03 EZHJ 222 MCR03 EZHJ 102 MCR03 EZHJ 474 MCR03 EZHJ 104 MCR03 EZHJ 104 MCR03 EZHJ 223 MCR03 EZHJ 223 MCR03 EZHJ 223 MCR03 EZHJ 104 MCR03 EZHJ 104 MCR03 EZHJ 104 MCR03 EZHJ 104 MCR03 EZHJ 104 MCR03 EZHJ 103 MCR03 EZHJ 104 MCR03 EZHJ 102 MCR03 EZHJ 000 MCR03 EZHF 562 MCR03 EZHF 6343 MCR03 EZHJ 000 MCR03 EZHF 8202 MCR03 EZHJ 183 MCR03 EZHJ 682 NTH5G16P39A103K07 TH MCR03 EZHJ 472 0662057A65 99R85452E01-O 7-31 Circuit Ref R569 R570 R571 R601 R602 R604 R605 R606 R607 R608 R609 R610 R611 R612 R615 R616 R617 R620 R621 R622 R625 R626 R627 R628 R629 R631 R632 R633 R634 R635 R636 R637 R638 R639 R640 R641 R642 R643 R645 R646 R648 R649 R650 R651 R652 R654 R655 R656 R657 R658 R659 99R85452E01-O Description 1 Kohm; 0.25W; +-5% 120 Kohm; 0.1W; +-5% 220K ohm 1 Mohm; 0.1W; +-5% 6.8 Kohm; 0.1W; +-5% 6.8 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 680 Kohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 50K ohm 100 Kohm; 0.1W; +-5% 12 Kohm; 0.1W; +-5% 4.7 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 4.7 Kohm; 0.1W; +-5% 330 Kohm; 0.1W; +-5% 0 ohm; 0.1W; +-5% 18 Kohm; 0.1W; +-5% 18 Kohm; 0.1W; +-5% 680 Kohm; 0.1W; +-5% 0 ohm; 0.1W; +-5% NU NU 0 ohm; 0.1W; +-5% 12 Kohm; 0.1W; +-5% 680 Kohm; 0.1W; +-5% 1.2 Mohm;0.1W;+-5% 0 ohm; 0.1W; +-5% 0 ohm; 0.1W; +-5% 330 Kohm; 0.1W; +-5% 150 Kohm; 0.1W; +-5% 150 Kohm; 0.1W; +-5% 680 Kohm; 0.1W; +-5% 33 Kohm; 0.1W; +-1% 22 Kohm; 0.1W; +-1% 1 Mohm; 0.1W; +-5% 1 Kohm; 0.1W; +-5% 470 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 680 Kohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 4.7 Kohm; 0.1W; +-5% 100 ohm; 0.1W; +-5% 0 ohm; 0.1W; +-5% 820 ohm; 0.1W; +-5% 12 Kohm; 0.1W; +-5% Vendor Vendor Part Number Motorola Equivalent Part Number Hokuriku Rohm Murata Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Hokuriku Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm CR1/4-102J MCR03 EZHJ 124 NPC18WM224K03RB MCR03 EZHJ 105 MCR03 EZHJ 682 MCR03 EZHJ 682 MCR03 EZHJ 104 MCR03 EZHJ 104 MCR03 EZHJ 104 MCR03 EZHJ 104 MCR03 EZHJ 684 MCR03 EZHJ 103 NSM3503J400J MCR03 EZHJ 104 MCR03 EZHJ 123 MCR03 EZHJ 472 MCR03 EZHJ 104 MCR03 EZHJ 472 MCR03 EZHJ 334 MCR03 EZHJ 000 MCR03 EZHJ 183 MCR03 EZHJ 183 MCR03 EZHJ 684 MCR03 EZHJ 000 N/A N/A N/A 0662057B22 0662057A69 0662057A69 0662057A97 0662057A97 0662057A97 0662057A97 0662057B18 0662057A73 N/A 0662057A97 0662057A51 0662057A65 0662057A97 0662057A65 0662057B10 0662057B47 0662057A79 0662057A79 0662057B18 0662057B47 Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm MCR03 EZHJ 000 MCR03 EZHJ 123 MCR03 EZHJ 684 MCR03 EZHJ 125 MCR03 EZHJ 000 MCR03 EZHJ 000 MCR03 EZHJ 334 MCR03 EZHJ 154 MCR03 EZHJ 154 MCR03 EZHJ 684 MCR03 EZHF 3302 MCR03 EZHF 2202 MCR03 EZHJ 105 MCR03 EZHJ 102 MCR03 EZHJ 474 MCR03 EZHJ 104 MCR03 EZHJ 104 MCR03 EZHJ 104 MCR03 EZHJ 684 MCR03 EZHJ 103 MCR03 EZHJ 472 MCR03 EZHJ 101 MCR03 EZHJ 000 MCR03 EZHJ 821 MCR03 EZHJ 123 0662057B47 0662057A51 0662057B18 0662057B24 0662057B47 0662057B47 0662057B10 0662057B02 0662057B02 0662057B18 N/A N/A 0662057B22 0662057A49 0662057B14 0662057A97 0662057A97 0662057A97 0662057B18 0662057A73 0662057A65 0662057A25 0662057B47 0662057A47 0662057A51 Circuit Ref R660 R661 R663 R669 R701 R702 R703 R704 R705 R706 R707 R708 R709 R710 R711 R712 R713 R714 R715 R716 R717 R718 R719 RV601 RV602 Description NU 10 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 0 ohm; 0.1W; +-5% 2.2 Kohm; 0.1W; +-5% 1.5 Kohm; 0.1W; +-5% 330 Kohm; 0.1W; +-5% 47 Kohm; 0.1W; +-5% 22 ohm; 0.1W; +-5% 470 ohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 2.2 Kohm; 0.1W; +-5% 0.27 ohm; 0.125W; +-5% 100 ohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 1 Kohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 4.7 Kohm; 0.1W; +-5% 0 ohm; 0.1W; +-5% 0 ohm; 0.1W; +-5% 22 Kohm; 0.1W; +-5% 22 Kohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% Vendor Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Vendor Part Number MCR03 EZHJ 103 MCR03 EZHJ 104 MCR03 EZHJ 000 MCR03 EZHJ 222 MCR03 EZHJ 152 MCR03 EZHJ 334 MCR03 EZHJ 473 MCR03 EZHJ 220 MCR03 EZHJ 471 MCR03 EZHJ 103 MCR03 EZHJ 222 MCR10 EZHJ R27 MCR03 EZHJ 101 MCR03 EZHJ 103 MCR03 EZHJ 102 MCR03 EZHJ 103 MCR03 EZHJ 103 MCR03 EZHJ 472 MCR10 EZH J 000 MCR10 EZH J 000 MCR03 EZHJ 223 MCR03 EZHJ 223 MVR22 HXBR N 103 MVR22 HXBR N 103 Motorola Equivalent Part Number 0662057A73 0662057A97 0662057B47 0662057A57 0662057A53 0662057B10 0662057A89 0662057A09 0662057A41 0662057A73 0662057A57 0662057C02 0662057A25 0662057A73 0662057A49 0662057A73 0662057A73 0662057A65 0662057C01 0662057C01 0662057A81 0662057A81 N/A N/A August 30, 2002 7-32 This Page Intentionally Left Blank August 30, 2002 99R85452E01-O Chapter 8 UHF Band Information 8.1 Model Charts PRO2150 Portable Radio, UHF, 403-440 MHz Model LAH49QCH8AA9_N Description PRO2150, 403-440MHz, 1-4W, 12.5/25K 99ch Item Description X PMUE1809_ _L PRO2150, 403-440MHz, 1-4W, 12.5/25K X DS1M001110 Front Cover Kit X DS1M001120 Chassis Hardware Kit X DS1M001130 Knob Assembly X DS1M001140 Ext. Cover Kit X DS1M011513 Controller Board Assembly, UHF, 403-440MHz PRO2150 X DS1M001161 RF Board Assembly, UHF, 403-440MHz PRO2150 X DS1M001170 LCD Kit X DS1M001190 Speaker Assembly X DSM1B26051 Screw M2.6 X DSM2192004 Contact Gasket X DSM2192005 Main Gasket X DSM2192006 Volume Gasket X DSM4193013 Gasket (Screw 26) X DSM5190001 Housing Back X DSM6189003 PTT Button X PMNN4046_ Battery, Standard NiMH X PMTN4053_ Std. Wall Charger 110V US X DSM4193042 PRO2150 Nameplate X PMAE4010_ Std. 10 cm Antenna, 403-440 MHz X HLN9844_ Belt Clip X HKLN4197_ PRO2150 Portable Radio User Guide CD (English, Spanish, and Portuguese) x = Indicates one of each is required. 8-2 UHF Band Information: Model Charts PRO2150 Portable Radio, UHF, 435-480 MHz Model LAH49RCH8AA9_N Description PRO2150, 435-480MHz, 1-4W, 12.5/25K, 99ch Item Description X PMUE1813_ _L PRO2150, 435-480MHz, 1-4W, 12.5/25K 99Ch X DS1M001110 Front Cover Kit X DS1M001120 Chassis Hardware Kit X DS1M001130 Knob Assembly X DS1M001140 Ext. Cover Kit X DS1M011521 Controller Board Assembly, UHF, 435-480MHz PRO2150 X DS1M001162 RF Board Assembly, UHF, 435-480MHz PRO2150 X DS1M001170 LCD Kit X DS1M001190 Speaker Assembly X DSM1B26051 Screw M2.6 X DSM2192004 Contact Gasket X DSM2192005 Main Gasket X DSM2192006 Volume Gasket X DSM4193013 Gasket (Screw 26) X DSM5190001 Housing, Back X DSM6189003 PTT Button X PMNN4046_ Battery, Standard NiMH X PMTN4053_ Std. Wall Charger 110V US X PMAE4011_ Std. 10 cm Antenna, 435-480 MHz X HLN9844_ Belt Clip X HKLN4197_ PRO2150 Portable Radio User Guide CD (English, Spanish, and Portuguese) X DSM4193042 Nameplate x = Indicates one of each is required. August 30, 2002 99R85452E01-O 8-3 8.2 Specifications Receiver Specifications UHF 12.5kHz General UHF Frequency: Channel Capacity: Power Supply: Dimensions with Standard High Capacity NiMH Battery: Weight: with Standard High Capacity NiMH Battery: Average Battery Life @ (5-5-90 Duty Cycle) Sealing: Shock and Vibration: Dust: Humidity: 403-440 MHz 435-480 MHz 99 7.5 Volts ±20% 115.5mm x 56mm x 35mm 350 g (Low Power) (High Power) >11 hrs >8 hrs Passes rain testing per IPX4 (EN60529=1991) Meets MIL STD 810C, D and E Meets MIL STD 810C, D and E Weather resistant housing passes EIA RS-316B Sensitivity 12dB SINAD: Adjacent Channel Selectivity EIA Intermodulation Spur Rejection: Image Rejection: Hum and Noise Audio Distortion Conducted Emmision Audio Output @ <5% Distortion UHF 25kHz 0.25 µV 0.25 µV 60 dB 65 dB 60 dB 60 dB 60 dB 40 dB < 5% -57 dBm 65 dB 65 dB 65 dB 500 mW 500 mW Transmitter UHF RF Output NiMH @ 7.5V: Channel Spacing Freq. Stability (-30°C to +60°C) Spurs/Harmonics: Audio Response: (from 6 dB/oct. PreEmphasis, 300 to 3000Hz) Audio Distortion: @ 1000 Hz, 60% Rated Max. Dev. FM Noise: August 30, 2002 Low 1W 12.5/25 kHz 0.00025% High 4W -26 dBm +1, -3 dB <5% 40 dB 99R85452E01-O 8-4 UHF Band Information: Theory of Operation 8.3 Theory of Operation 8.3.1 General Information Your radio has two printed circuit boards: the Controller board, and the Radio Frequency (RF) board. The Controller board contains the CPU/Control section. The RF board contains the VCO/Synthesizer section, Transmitter section, Receiver section, Transmitter Audio circuitry, Receiver Audio circuitry, and Battery section. 8.3.2 Power Distribution Audio Power AMP Q702 VCO Buffer Q308 PLL IC Q323 Ripple Filter Q318 TX VCO Q303, Q922 TX/RX SW Q317,916 RX VCO Q302, Q311 RF AMP Q404 RF PA Q411 + SW B Power Switch SW201 Battery Local AMP Q416 IF AMP Q408 IF AMP Q506 LPF Q505 HPF Q502 Driver AMP Q412 SAVE SW Q210 RX SW Q211 5V REG Q204 TX/RX SW Q208,209 RX +5V MIC AMP Q602 Sub Audio LPF Q610 TX Driver Q413,414 RF Power Control Q419 TX REG Q201,202 TX +5V This Page Intentionally Left Blank Reset CPU EEPROM Q105 Q101 Q114 Divide by 2 Q122 DA Converter Q121 DTMF Decode Q120 Diode Q126 Figure 8-1. The above figure illustrates the DC distribution throughout the radio board. A battery supplies power directly to the electronic on/off control. Radio power supply is triggered by the Power Switch (On/ Off/Volume control) and +SW B is distributed as show in the figure. Regulator output 5V is supplied to the CPU. +SW B continues to support the Audio Power AMP, 5V Regulator, TX Regulator until the radio is turned off. The radio can be turned off on two ways: 1. Power Switch turned-off 2. Low Battery When a low battery level is detected by the CPU, it stores the radio personality data to EEPROM before turning off the radio. 8.3.3 Power up Sequence 1. Power supply is turned on by the On/Off/Volume Control (Power Switch). 2. Power from battery is supplied to the regulator through the switch. 3. Output (5V) from the regulator is directed to the CPU (Q101). 4. Q105 resets the CPU (Q101). 5. The CPU loads radio personality data from EEPROM after the reset. August 30, 2002 99R85452E01-O UHF Band Information: Theory of Operation 8-5 6. This personality data is used to initialize the radio. 7. The radio restores last power up state (i.e. state before the radio was turned-off). 8. Power is supplied to PLL circuitry. 9. Power is supplied to Rx and Rx VCO circuitry. 10. CPU sends data to PLL circuitry. If LOCK status is confirmed, radio continues the power-up sequence. Otherwise, PLL ERR is displayed. 11. If the Rx audio level is less than the pre-programmed squelch level, and other unmuting conditions are met, the radio will open squelch. 8.3.4 CPU / Control Section When the radio is turned ON, the CPU (Q101) reads the radio status from the EEPROM Q114. It also monitors the keypad, the PTT line and other inputs such as the squelch detect, etc. continuously. When there is a channel change, the CPU sends the correct frequency information to the synthesizer via pins 1, 2 and 89. The CPU is clocked by the 8.388608MHz oscillator, which is composed of X101, C101, C106, and R158. 8.3.5 VCO / Synthesizer Section This section consists of the Temperature-Compensated Crystal Oscillator(TCXO), Voltage Controlled Oscillator(VCO), Synthesizer and the Loop Filter. These circuits are found on the RF board. 8.3.5.1 Temperature-Compensated Crystal Oscillator (TCXO) The reference oscillator is a temperature compensated crystal-controlled, Pierce type circuit. It utilizes a logic gate within Q323 as a gain element. C335 is used to adjust the oscillator on frequency (14.4MHz) at room temperature (22°C). Temperature variations cause resistance changes in thermistor R330 and R567, which is on the base of Q320, thus varying the voltage applied to varactor Q322. This changes the impedance across crystal X301 in a manner complementary to the temperature drift characteristic of the crystal. In this way, the reference oscillator is held within the specified ±2.5 PPM from -30 to +60°C. 8.3.5.2 Voltage-Controlled Oscillators Only one of the VCOs runs at a time, which is controlled by Q317 and Q101. The receive VCO consists of C311, C314-C316, C913, C940, L302-L306, Q311 and Q302. This VCO oscillates at 45.1 MHz above the programmed receive frequency. The VCO’s oscillating frequency is tuned by the varactor Q311. The tuning voltage is supplied from the output of the Loop Filter. The output of the VCO is AC coupled (C311) to the buffer Q308. The output of the VCO buffer Q308 is AC coupled (C308) to the synthesizer and the output buffer Q416 respectively. When the PTT is pressed, Q101 pin36 goes low (approx. 0V) disabling the receive VCO by the Q317 and biases on Q916 to enable the transmitter VCO. The transmitter VCO consists of C340, C935C937, L308-L310, Q303, Q921 and Q922. This VCO oscillates on the programmed transmit frequency. The VCO’s oscillating frequency is tuned by the varactor Q922. The tuning voltage is supplied from the output of the Loop Filter. The transmit voltage controlled oscillator is directly frequency-modulated and operates on the carrier frequency. The synthesizer is tuned in 5.00kHz or 6.25kHz steps. 99R85452E01-O August 30, 2002 8-6 8.3.5.3 UHF Band Information: Theory of Operation Synthesizer The frequency synthesizer is a large-scale monolithic synthesizer integrated circuit Q323. The synthesizer IC contains a dual modulus prescaler, programmable divide-by-N counter, prescale control (swallow) counter, reference oscillator, reference divider, phase detector, charge pump and lock detector. Also, included in Q323 are shift registers and control circuits for frequency controls and general device control. RF output from the active VCO is AC coupled to the synthesizer Q323 prescaler input at Pin 8. The divide counter chain in Q323, consisting of the dual-modulus prescaler, swallow counter and programmable counter, divides the VCO signal down to a frequency very close to 5.00kHz or 6.25kHz which is applied to the phase detector. The phase comparator compares the phase with the 5.00kHz or 6.25kHz reference signal from the reference divider and drives the external charge pump (Q314, Q315 and Q316). The synthesizer unlock detector circuit prevents the operation of the transmitter and receiver, when the phase lock loop (PLL) is unlocked. The following discussion assumes the unit has been placed in the transmit mode. Q323 lock detector Pin 7 goes high when the PLL is locked. This high level is applied to Pin 25 of the CPU Q101. A software timing routing brings the RX/TX line low (Pin 36 of Q101). With the RX/TX line goes low, Q209 is cut off and Q208 is biased on passing +5VTX-B to Q202; it biases on Q201 to pass switched TX-B to the transmitter amplifier string which enables transmission. When the PLL is unlocked, the lock detector at Q323 Pin 7 will begin pulsing low. A RC circuit converts this low pulse to a low level for the CPU. The CPU then changes the RX/TX line to a high, thus signaling the other transistor switches to drive Q201 into cutoff, which disables transmission. Therefore, the transmitter remains disabled while the loop remains out of lock, and “PLL ERR” is displayed. 8.3.5.4 Loop Filter The Loop Filter, a passive lead-lag filter consisting of R314-R317, R356, C323, C369, and C371, integrates the charge pump output to produce the DC turning voltage for the VCO. One parasitic pole, consisting of RF chokes L306 and L310, prevent modulation of the VCOs by the 5.00kHz or 6.25kHz reference energy remaining at the output of the loop filter. Direct FM is obtained for modulating frequencies outside the PLL bandwidth by applying the CTCSS/DCS signals and the preemphasized, limited microphone audio to the VCO modulation circuit. The modulation circuit consists of R929 and Q921. 8.3.6 Transmitter Section 8.3.6.1 RF Power Amplifier After the PTT is pressed, the +5VTX-B line switches to approximately 5V. Q916 is turned on, enabling transmit VCO. The VCO buffer, pre-driver, driver and power amplifier are biased on by Q201. Q201 is biased on by the +5VTX-B line switching to 5V. RF output from the transmit VCO(Q303) is applied to the VCO output buffer Q308. Output from Q308 feeds the buffer Q414. The output signal from Q414 feeds the pre-driver amplifier Q413, and feeds the driver amplifier Q412, whose output from the driver stage feeds the final RF power amplifier Q411 to produce the rated output power of 5 watts. The final output is feed to a low-pass filter (C435-438, C491-C493, L418, and L430) and then to the transmit/receive switch Q410. RF power is then fed to the antenna via the output low-pass filter consisting of C439-C444, C475, L414, L415 and L416. 8.3.6.2 Antenna Switching Switching of the antenna between the transmitter and the receiver is accomplished by the antenna transmit/receive switch consisting of diodes Q409 and Q410. In the transmit mode, switched TX B+ is applied through R417 and RF choke L417, hard forward biasing the two diodes on Q410, thus permitting the flow of RF power from the output of the low-pass filter. L419 and C433 isolate the receiver circuit from the transmitter power input. August 30, 2002 99R85452E01-O UHF Band Information: Theory of Operation 8.3.6.3 8-7 Power Control Output power is controlled by the CPU (Q101), the D/A converter (Q121), the dual Op-Amp (Q419), which is used as a differential amplifier and comparator. Current is sensed by the voltage drop across R442. When the radio is in high power mode, this voltage is compared to the D/A converter voltage at 5-watt. When the radio is in low power mode, this voltage is compared to the D/A converter voltage at 1-watt. The power output is then reduced or increased by varying the applied voltage to the gate of the power amplifier Q411 and Q412. 8.3.6.4 Transmitter Audio Circuits The transmitter audio circuits consist of the audio processing circuits, the CTCSS circuits and the DCS circuits. 8.3.6.4.1 Audio Processing Transmit speech audio is provided by either the internal electric microphone M101 or the external microphone. The audio is pre-emphasized by 6dB per octave by C615 and R655, and then its signal is amplified. The microphone audio is directed to amplifier Q602B, Q602A and low-pass filter Q602C and Q602D. Q602A has limiting function. The modulation adjustment is done by Pot RV601, and directed to a four-pole active low-pass filter. The resulting signal is then limited, and is directed to a low pass filter (18dB per octave roll-off above 3KHz). The audio is then directed through the 25KHz/ 12.5KHz channel spacing SW Q601 to varactor diode Q329 in transmit VCO. By varying the voltage on the varactor diode Q329 at an audio rate, VCO output is frequency-modulated. 8.3.6.4.2 CTCSS Tone Encoder / Digital Code Squelch (DCS) Encoder CTCSS signals and DCS signals are synthesized by CPU Q101 and appear as pulse waveform on I/ O line Pin 7. This I/O line is connected to a digital-to-analog converter network (consisting of C136, C173, R150 and R182), which produces a pseudo-sine wave at its output. The waveform is smoothed by low pass filters Q610B to produce an acceptable sine wave output. The CTCSS tone signal is adjusted to the proper level by RV602. 8.3.7 Receiver Section 8.3.7.1 Receiver Front End In the receive mode, the RF signal enters thorough the antenna, then through the low-pass filter C439-C445, and L414-L416. The diodes Q409 and Q410 are biased off, so that the output of the low-pass filter is coupled to the first band-pass filter C401-C409, L401, L402, Q401, Q402, R401, R402 and to the Front End RF overload protection diode pair Q403. The signal from the band-pass filter is directed to the input of the RF amplifier Q404. The output of the RF amplifier is sent to three stages of band-pass filters, consisting of C413-C417, C419-C422, C487, L405-L407, Q405, Q406 and R408-R410. The output from the band-pass filter is directed to the mixer’s Q407, L408 and L409. 8.3.7.2 Local Oscillator (LO) The Receive VCO (C311, C314 -C316, C913, C940, L302- L306, L312-L314, Q311, and Q302) provides the LO signal. The VCO is running at 45.1 MHz above the desired receive frequency and is applied to output Buffer Q308 and Q416. The output of the buffer is sent through the low-pass filter C424, C425, L410, L411 and to the mixer Q407, L408 and L409. 99R85452E01-O August 30, 2002 8-8 8.3.7.3 UHF Band Information: Theory of Operation Mixer The mixer is a DBM type (L408, L409, Q407). The mixer LO frequency is 45.1 MHz above the desired receiver frequency. When the receiver frequency is present, the mixer output will be a 45.1MHz signal. The mixer output is peaked for 45.1MHz at L412, C426 and R412, and the signal is filtered by crystal filter F402 and amplified by Q408 before being sent to IF IC Q506. The 45.1MHz IF signal and LO frequency of 44.645 MHz (X501) are mixed in Q506. The 455kHz ceramic filter, F501 or F502, filters the second mixer’s output. The resulting signal is the second IF signal. The mixer’s output is then fed to the internal limiting amplifier, and consequently to the FM decoder. 8.3.7.4 FM Detector and Squelch The FM detector output is used for squelch, decoding tones and audio output. The squelch amplifier is inside of Q506, and its output is fed to an internal rectifier and squelch detector. The output on Q506 Pin 14 signals the CPU Q101 with a low (~0V) to unmute the radio. The audio is unmuted by the CPU Q101 Pin 41 switching to a high (5V), thus biasing on Q503. The audio is then routed to the audio amplifier Q702 via the volume control SW201. 8.3.7.5 Receiver Audio Circuit The detector’s audio output also is fed to the tone (CTCSS and DCS) low-pass filter Q505A. Then the output of the low-pass filter is routed to the second stage filter Q505B. The output of Q505B is passed to Q505C. The output of Q505C is directed to the squaring circuit Q505D, and finally to the CPU Q101 Pin22 for decoding. The detector output feeds the audio high-pass filter Q502. The output of the audio high-pass filter feeds the Volume Control SW201 (VOL). From the wiper arm on the Volume Control, the audio is routed to Pin 4, which is the input to the audio power amplifier Q702. The output of the audio power amplifier is routed through the earphone jack J701 to the internal speaker SP701. 8.3.8 Battery Section The battery connects to the contact (CN201). The positive terminal of the battery connects to the ON/OFF Volume control switch (SW201), and the negative terminal connects to PWB ground. Low battery is detected by R127/R128 and voltage regulator Q204. Battery voltage status is monitored by Pin 19 of the CPU Q101 through R127/R128. When the battery voltage goes below the threshold voltage, “LOW BATT” is displayed on LCD LC101. In the BATTERY SAVER Mode, the CPU Q101 generates a square wave signal on Pin 37. The signal’s duty cycle varies according to what the BATTERY SAVE TIMER is set. When the signal goes high (approximately 5 V), Q210 is biased off, and Q211 is cut off, thus turning the supply off to IF IC Q506. August 30, 2002 99R85452E01-O ANT 99R85452E01-O PTT S102 Key Pad MIC M101 Mon S101 EEPROM Q114 EXT MIC Jack J701(1/2) Over Voltage Protect Q707-710 Power SW SW201 LCD LC101 CPU Q101 + SW B Shift Q102 Divide by 2 Q122 X,tal 8.38MHz X101 SAVE SW Q210 5V REG Q204 REG Q206 Q207 Reset Q105 Buffer AMP Q414 IF AMP Q408 CPU Pin87 RC NETWORK RC NETWORK RX 5V SAVE 5V 5V TX/RX SW Q208 Q209 DC/DC Converter Q301 DTMF Decode Q120 DA Converter Q121 RX SW Q211 TX REG/SW Q201 Q202 TX 5V Pre Driver Q413 2-Pole Crystal Filter F402 DIODE Q126 DC AMP Q125 CPU Pin22 CPU Pin21 TX VCO Q303 Q922 RX VCO Q311 Q302 CN701 22 25 25 15 16 3 4 31 13 35 9 27 DAC TX DAC RX 5V Detect DTMF IN 5V Ripple Filter Q318 Pin15 16 TCXO 14.4MHz X301 Q320 Q322 Pin1 2 PLL Q323 Sub Audio Modulator Q322 6 Pole Ceramic Filter F502 Loop Filter Q314-316 TX/RX SW Q317 Q916 6 Pole Ceramic Filter F501 22 15 16 3 4 31 13 35 9 27 CN101 Audio Modulator Q921 CPU Pin36 VCO Buffer Q308 2nd Local 44.654MHz X501 IF IC Q506 (2nd Mix,2nd Local,IF AMP,DISC,Noise AMP) LPF (DTMF) Q610A MIC AMP Q602B VOX AMP Q617 ATT Q608 Q609 Pin11 10 9 CN701 Pin37 38 39 Detect Sub Audio LPF Q505 De-emphasis Q502A Audio Power AMP Q702 Limitter AMP Q602A LPF (Sub Audio) Q610B,D SP701 SPK (1/2) EXT Audio Jack J701 DTMF IN Volume SW201 (VR) HPF Q502 Deviation Adj RV601 LPF Q602C,D N/W SW Q601 Complete DAC TX PA Q412 Local Buffer Q416 Mixer Q407 8.4.1 Power Input Final AMP Q411 Coupler R442 DAC RX 2-Pole Band Pass Filter Q405,406 Block Diagrams Power Control Q419 Matching Network C491-493, C435-438 L418,430 ANT Switch Q409,410 RF AMP Q404 8.4 BATTERY Hamonics Filter C439,C440-445,C475 L414-416 2-Pole Band Pass Filter Q401,402 UHF Band Information: Block Diagrams 8-9 Figure 8-2. August 30, 2002 8-10 UHF Band Information: Block Diagrams 8.4.2 Controller CN101 27 MIC M101 Divide by 2 Q122 EEPROM Q114 DTMF Decode Q120 RC NETWORK 35 9 CPU Pin22 13 31 CPU Pin21 CPU Q101 Key Pad CPU Pin36 RC NETWORK DIODE Q126 CPU Pin87 Mon S101 LCD LC101 Shift Q102 Xtal 8.38MHz X101 4 3 Reset Q105 PTT S102 DC AMP Q125 DA Converter Q121 15 16 22 25 Figure 8-3. 8.4.3 VCO Power Regulator RX Local Buffer DC/DC Converter Q301 Pin 8 RX VCO Q311 Q324 Loop Filter Q314 Q315 Q316 VCO Buffer Q308 TX VCO Q325 Q326 TX Buffer TX/RX SW Q309 Q310 Audio Modulator Q329 Audio Pin15 16 DATA PLL Q323 Pin 1 2 Pin11 10 9 CN701 Pin37 38 39 TCXO 14.4MHz X301 Q320,322 Ripple Filter Q330 TX/RX SW CONTL 5V Sub Audio Modulator Q322 Sub Audio Figure 8-4. August 30, 2002 99R85452E01-O UHF Band Information: Block Diagrams 8.4.4 8-11 Transmitter To Receiver Hamonics Filter C439, C440-445,C475, L414-416 ANT ANT Switch Q409,410 TX +B Matching Network C491-493,C435-438 L418,430 +B Final AMP Q411 PA Q412 Pre Driver Q413 Power Control Q419 DAC TX TX 5V Coupler R442 Buffer AMP Q414 P in VCO Figure 8-5. 8.4.5 Receiver 2-Pole Band Pass Filter Q401,402 From ANT Switch RF AMP Q404 2-Pole Band Pass Filter Q405,406 DAC RX Mixer Q407 2-Pole Crystal Filter F402 Local Buffer Q416 IF AMP Q408 IF IC Q506 (2nd Mix,2nd Local,IF AMP,DISC,Noise AMP) 2nd Local 44.654MHz X501 6 Pole Ceramic Filter F501 6 Pole Ceramic Filter F502 From VCO Figure 8-6. 99R85452E01-O August 30, 2002 8-12 8.5 UHF Band Information: Troubleshooting Charts Troubleshooting Charts Start 1 Very low or no 12 dB SINAD Check IFIC Q506 (see below) NO Noise at spkr when radio is unsqu’d? Is 2nd LO on freq? NO Noise at pin 9 of IFIC Q506? NO YES Check VDC of all IFIC pins Check 2nd LO XTAL and components YES NO NO OK? YES YES Is 1st LO at C431 >2 dBm? Are VDC of pin 1(4.79V),2(4.17V) and 4(4.88V) of IFIC Are voltages on pins OK? Check IFIC Check VCO/Synth YES Check IFIC (see below) NO YES Check external components connected to IFIC. If OK, replace Q506 Inject on channel signal at RF port, C429 Is 12 dB SINAD -105 dBm? YES Inject 45.1 MHz signal at R413, L411 Is 12 dB SINAD -115 dBm? Inject on channel signal at C402 YES NO NO Is 12 dB SINAD -116 dBm? Check harmonic filter and antenna path YES NO Is Q404 biased properly? Check mixer, Q407 YES NO RF Front & Rear 2 pole filters Inject a 45.1 MHz signal at R467 Is YES 12 dB SINAD -110 dBm? Check external components connected to IFIC Check XTAL filter F402, L411 Check +5VRX and Q404 bias circuitry Troubleshooting Flow Chart for Receiver NO 1 Figure 8-7. August 30, 2002 99R85452E01-O UHF Band Information: Troubleshooting Charts 8-13 Start No Power Is +5VTX and TXB+ OK? Check Q201, Q202,Q206 & Q209 NO YES 1. Check Pin Diodes 2. Check Harmonic Filter YES Is current OK? NO Is DAC TX High or Low? Inspect/Repair TX Output Network LOW Check Voltages in Power Control Circuit YES Check Voltages in PA Line-up HIGH Is Power OK? Check Pin to Q419 Pin 1 NO YES Done Troubleshoot VCO NO Is Pin OK? Troubleshooting Flow Chart for Transmitter Figure 8-8. 99R85452E01-O August 30, 2002 8-14 UHF Band Information: Troubleshooting Charts Start NO Correct Problem Visual check of the Board OK? Check 5V Regulator YES NO Is Q314 Emitter AT=13VDC +5VQ323 at Pins 3, 4 YES Check Q301, L303,C303,R301, C304 & R302 Fix Connection Is Q310 Pin 2 <0.7 VDC in RX & >4.3 VDC in TX? NO Is 14.4MHz Signal at Q323 Pin 1? YES Are signals at Pin’s 8 of Q323 ? NO NO Check X301,C337,C338,C336 YES NO NO Are Waveforms at Pins 8 of Q323 YES YES YES NO Is Connection between Q310 Pin 2 & CN701 Pin 35 OK? NO NO Is Q330 corrector AT4.65 VDC? Check programming lines between Q323 Pins 9,10 & 11 YES Replace CN701 YES Check R358, C312 C313 Replace Q201 Is RF level at Q324 between -10 & +5 dBm? NO Do Pins 9,10 & 11 of Q323toggle when channel is changed? YES Is information from µP Q101 correct? NO Check µP Q101 Troubleshooting Chart YES Replace Q323 YES Replace or resolder necessary components NO See VCO Troubleshooting Chart Are Q308, L301 C308, C310, C309 YES Replace Q308 Troubleshooting Flow Chart for Synthesizer Figure 8-9. August 30, 2002 99R85452E01-O UHF Band Information: Troubleshooting Charts 8-15 START APPLY POWER TO RADIO AND TURN ON NO/DON’T KNOW ARE ALERT TONES ENABLED IN SPM NO WAS GOOD OR BAD POWER-ON BEEP PRESENT YES YES USE SPM TO ENABLE TONES INVOKE FACTORY RESET IN SPM NO WAS GOOD POWER-ON BEEP PRESENT YES DONE NO WAS GOOD POWER ON BEEP PRESENT YES DONE MAIN RADIO BOARDS MUST BE REPLACED (RF & CONTROLLER) YES DONE NO WITH POWER CONNECTED TO RADIO AND THE RADIO TURNED ON CHECK THE FOLLOWING: 1) 5V AT PIN 87 OF Q101. IF NONE CHECK Q126. 2) WITH HIGH IMPEDANCE PROBE CHECK FOR 8.388608MHZ AT PIN 13 AND 12 OF Q101, IF NO SIGNAL CHECK/REPLACE X101. 3) CHECK DC AT PIN 9 OF Q121. IF < 4.5VDC CHECK CN101 PIN 15. 4) CHECK FOR TYPICAL VOLTAGES OF Q101 AND Q114 VOLTAGES. ARE TONES PRESENT ON POWER UP AT CN101 PIN 3? NOTE: Q101 is not replaceable. If Q101 is damaged, the controller and RF boards both need to be replaced. YES AUDIO PROBLEM, TROUBLESHOOT AUDIO CKT DONE Troubleshooting Flow Chart for Microcontroller Figure 8-10. 99R85452E01-O August 30, 2002 8-16 UHF Band Information: Troubleshooting Charts TX VCO RX VCO Low or no power at Input to PA Low or no Power at Pin 4 of L408 VisualCheck of Board OK? NO Correct Problem NO YES Visual check of Board OK? Power OK but no Modulation =151 mVrms at Terminal of C311? NO Replace C311 YES YES 4.65 VDC at Q416 collector? NO Make sure Synthesizer is working correctly. NO 4.65 VDC at Q414 collector? NO Supply DC at Q329? Replace R347 YES YES 1.6 VDC at Q308 base ? Replace R311, R322 NO NO YES 0.9 VDC at Q308 emitter? 1.6 VDC at Q308 Base? YES NO Replace R312 or L301 NO 0.9 VDC at Q308 emitter? YES YES Q324 emitter at 1.0VDC, collector at 4.0VDC, base at 1.7VDC ? If C359 is OK, then replace Q329 NO YES If all parts associated with those Pin’s are OK, then replace Q308 If all parts from Q324 of mixer are OK, then replace Q324 NO Are Q325Pin’s emitter at 2.1VDC, collector at 3.8VDC, base at 2.9VDC? YES If all parts from Q325 Pin 4 to Input of PA are OK, then replace Q325 Note: Test Frequency 158MHz Troubleshooting Flow Chart for VCO Figure 8-11. August 30, 2002 99R85452E01-O 8-17 Chapter 8 UHF 403-440 MHz Circuit Board/Schematic Diagrams and Parts List 99R85452E01-O August 30, 2002 R180 C117 C133 R166 R165 R164 R163 R162 R161 R160 R159 R148 R147 R146 R145 R144 R143 R142 R141 C105 Q120 C108 C162 C166 C149 C145 R127 Q127 Q124 R128 C157 Q125 R153 R112 C167 R154 R155 R156 R176 Q123 R105 C116 S102 R103 C156 R102 R138 R137 CN101 R175 R129 C150 C165 C152 C147 C164 C120 C146 C148 C154 C155 C161 C160 R136 C134 C159 Q101 R158 C103 R101 C104 R104 R119 C143 R171 R134 C115 C144 R172 Q122 C111 C114 C131 R111 C106 Q126 X1C1 R168 R113 R169 L112 R167 C136 R106 R150 C107 Q105 Q130 C102 C101 R121 R120 C110 R170 C158 C151 Q102 C109 C163 R135 R118 R183 R110 R117 R126 R177 C135 C139 C138 C137 Q121 R182 R173 R174 R114 C173 C171 C132 R116 C129 Q114 C140 R115 C112 8-18 C113 Q117 S101 C153 Figure 8-12. UHF 403-440 MHz Controller Board August 30, 2002 99R85452E01-O C142 Q118 Q119 C141 R109 LC101 R107 Q115 8-19 M101 Q116 R108 Figure 8-13. UHF 403-440 MHz Top Side Controller Board 99R85452E01-O August 30, 2002 8-20 Q115 Q116 R107 47 LC101 LCD Q118 TX COM0 COM1 COM2 COM3 SEG0 SEG1 SEG2 SEG3 SEG4 SEG5 SEG6 SEG7 SEG8 SEG9 SEG10 SEG11 SEG12 SEG13 SEG14 SEG15 SEG16 SEG17 SEG18 SEG19 SEG20 SEG21 SEG22 SEG23 SEG24 SEG25 SEG26 SEG27 SEG28 SEG29 SEG30 SEG31 BUSY Q117 Q119 COM3 COM2 COM1 COM0 S0 S1 S2 S3 S4 S5 S6 S7 S8 S9 S10 S11 S12 S13 S14 S15 S16 S17 S18 S19 S20 S21 S22 S23 S24 S25 S26 S27 S28 S29 S30 S31 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 C113 0.001 R109 330 R108 330 C142 0.001 C141 0.001 R171 47K R172 47K S101 S1 S2 S3 S4 S5 S6 S7 S8 S9 S10 S11 S12 S13 S14 S15 S16 S17 S18 S19 S20 S21 S22 S23 C108 0.1 MONI SW R119 0 R111 51K S102 C104 100pF C114 47uF 6.3V (T) Q130 1 2 + C111 47uF 6.3V(T) C112 0.1 C129 0.01 R162 10K Q114 DAC_RX TEMP IN DAC_BAIS DAC_TX GND MIC SAVE VDD RESET SU AU OUT GND SQL IN RSSI RX/TX UNLOCK PLL_LE DATA CLOCK GND C145 47pF C167 47pF C165 0.001 C150 0.001 C156 0.01 C163 0.001 C151 0.001 0.01 C173 C136 Not use R106 0.22u/10 R150 0 22k R112 13K R120 0 R170 47K C110 0.001 R121 Not use R177 2.2k R175 4.7K R182 0 Q127 6 C106 R101 0 27p X101 C101 R158 470K R129 1K C102 Not use Q102 OUT IN 4 OUT 2 GND 3 R114 43K C109 0.1 OUT IN 7 OUT 2 GND 3 1 4 OUT IN 2 OUT IN 5 OUT IN 8 OUT IN 3 1 4 OUT 2 GND 3 1 4 OUT 2 GND 3 1 4 OUT 2 GND 3 1 4 OUT 2 GND 3 1 4 OUT IN DOWN OUT 2 GND 3 1 4 OUT IN Q105 1 5 OUT CD 2 Vdd 3 4 GND NC OUT IN 1 OUT 2 GND 3 1 4 OUT 2 GND 3 1 4 OUT IN R113 22K R102 47K OUT IN UP OUT 2 GND 3 OUT IN 6 1 4 OUT 2 GND 3 A 1 4 OUT 2 GND 3 OUT IN 9 1 4 OUT 2 GND 3 B 1 4 OUT 2 GND 3 C C105 0.1 R169 330 R105 10K 1 4 OUT IN C103 Not use OUT IN 1 4 OUT IN * OUT 2 GND 3 R110 51K 8 7 5 D Q122 Q 1 CLK 6 3 CL Q' 2 7 1 4 OUT IN 0 OUT 2 GND 3 R116 18K 1 4 OUT 2 GND 3 R117 33K OUT IN # 1 4 OUT 2 GND 3 D R118 100K C132 100pF 4 8 Q120 C133 0.001 9 10 10 9 11 8 12 13 7 14 6 15 VDD IN EST PD STD OSC0 ACK OSC1 SD GND 1 C134 0.01(w/DTMF) R135 10K(w/DTMF) R134 1K(w/DTMF) R136 10K(w/DTMF) 2 3 4 5 16 17 18 19 20 21 22 TP110 TP111 TP113 TP112 TP114 23 24 C171 0.1 25 26 27 Q123 C120 0.001 1 16 2 15 3 14 R126 10K GND C107 SH101 SOLDER SHORT 28 4 29 5 30 31 32 R138 10K(w/vox) 33 5 34 R137 1K(w/vox) 35 36 37 38 39 40 3 R154 47K R153 (w/vox) 10K(w/vox) 4 1 2 Q125 R155 Not use C139 0.1 GND 10K C131 100pF C138 0.1 PRO 10K 10K R176 22K C137 0.1 TDC MIC_PTT 5 C147 0.001 Vdd R166 10K S24 S25 S26 S27 S28 S29 S30 S31 PTT SW R115 130K C152 0.001 Vdd R163 R164 R165 50 49 48 47 46 45 44 43 42 41 40 39 38 37 36 35 34 33 32 31 30 29 28 27 26 C144 0.001 5 C148 0.001 N/W SDA C146 0.001 DETECT IN Vss C164 0.001 Vbb DATA0 SQL_MUTE SCL R174 2.2k R173 2.2k 6 22pF C159 47pF DTMF IN A2 7 4 C158 47pF MC2 TX_MUTE TEST R127 12.4k R128 6.98K C154 0.001 MC1 Vcc A1 3 C155 0.001 VOX IN MOD_COP 2 C161 0.001 DTMF OUT 1 C160 47pF GND ST_BY C153 0.001 CN101 C162 0.001 4 A0 C149 0.001 3 C166 47pF 2 8 C157 0.01 1 R141 20K R142 20K R143 20K R144 20K R145 20K R146 20K R147 20K R148 20K R159 R160 20K R161 10K 10K Q101 L112 C135 2.2uF 6.3V S23 S22 S21 S20 S19 S18 S17 S16 S15 S14 S13 S12 S11 S10 S9 S8 S7 S6 S5 S4 S3 S2 S1 S0 P73 AT-38(8.388608MHz) R180 560k + R183 47K 3 C117 1uF 6.3V + C116 47uF 6.3V (T) + C115 47uF 6.3V (T) S47 V3 V2 V1 COM0 COM1 COM2 COM3 P30 P31 VSS3 VDD3 P32 P33 P34 P35 P00 P01 P02 P03 P04 P05 P06 P07 P10 R167 47K R168 47K R104 0 COM0 COM1 COM2 COM3 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 98 99 100 P11 P12 P13 TXD P14 RXD P15 P16 P17 RES# XT1 XT2 VSS1 CF1 CF2 VDD1 P80 P81 P82 P83 P84 P85 P86 P87 P70 P71 P72 S0 Q126 M101 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 R103 Not use S46 S45 S44 S43 S42 S41 S40 S39 S38 S37 S36 S35 S34 S33 S32 S31 S30 S29 S28 S27 S26 S25 S24 VSS2 VDD2 75 74 73 72 71 70 69 68 67 66 65 64 63 62 61 60 59 58 57 56 55 54 53 52 51 C143 0.001 13 Q121 12 6 11 7 10 8 9 C140 0.22 R156 47K(w/vox) Q124 TP115 TP116 Figure 8-14. UHF 403-440 MHz Controller Board Schematic August 30, 2002 99R85452E01-O Q711 Q707 Q408 CN701 C612 R627 C635 C631 R645 C623 R667 R518 R521 R522 Q702 R520 R523 Q511 R546 C541 R536 R545 R547 C540 C542 C524 C528 F501 R704 R519 Q510 R524 R525 F502 C701 C705 R615 C943 R635 R701 C521 C523 C514 R665 R634 C702 C534 R508 C511 R663 R633 R515 R514 C641 R661 C518 R616 C642 R512 R509 R636 R666 R638 R617 C512 Q610 C924 R646 R610 R358 C312 C545 R648 C932 Q602 C335 C336 C381 R325 C367 Q320 R564 C629 R660 R655 R606 R516 R563 C619 C618 R621 Q601 C501 L431 R611 R517 R327 R565 Q615 C637 X301 R330 R329 R626 R649 C368 C338 C380 R333 Q617 R628 R368 R313 C919 C350 C342 R361 Q922 C340 L304 C304 C305 R302 C302 Q301 R629 C351 C315 L305 R929 L307 R362 R567 C303 R468 L428 C352 R332 R551 R415 F402 R459 Q703 L432 C430 C428 L309 L310 C320 R301 F401 C938 R654 R337 L409 R659 R612 Q322 L313 C366 L306 Q311 C918 C937 C936 L303 Q921 L410 C495 R713 C316 Q303 R928 R413 L413 R412 C426 C709 C314 C935 Q412 C940 R566 C912 L308 R422 C301 Q706 C710 R707 R706 Q704 C913 L302 L423 C456 R425 R421 C496 R423 C448 C488 L421 C453 Q302 C311 C427 R712 R709 Q709 Q712 L702 Q705 R708 R710 Q708 SW201 R420 C450 C422 L412 C407 R715 Q710 C720 R455 C408 L402 C401 Q402 R714 C406 C405 C423 C715 R402 L408 C455 R242 C449 R419 L401 C403 C454 C457 C451 Q411 Q401 C404 R401 C493 R205 C717 C402 L420 R914 C458 C459 L422 C751 C492 L430 C437 C491 L418 C436 C752 C435 C218 J701 J401 C714 C718 C716 C498 TP301 8-21 J702 C538 C537 C544 R543 C543 C536 R539 Figure 8-15. UHF 403-440 MHz Main Board Top Side 99R85452E01-O August 30, 2002 C440 C439 L415 C441 C444 C445 R417 C443 C499 L416 Q201 C208 R201 C206 Q204 R212 Q202 C203 Q210 R406 C201 C202 R202 R404 Q403 C416 R203 C411 C409 R405 C413 L403 L406 C487 Q404 C215 Q208 L404 L405 C207 C213 Q209 C204 Q206 C711 Q207 C211 C214 C713 C209 R403 C410 C414 R408 Q405 R407 C210 R206 R209 C219 C220 C506 C485 R208 C212 R535 R534 C533 R207 CN201 C419 L407 R210 Q407 R571 C412 R409 C429 C503 C415 R410 C424 C417 R211 C324 C420 C205 C421 C425 Q406 C323 R505 Q501 Q409 R444 R442 Q211 C217 R506 C532 C432 R364 C505 R503 C508 C531 Q506 C475 R569 C442 R318 C526 R527 L501 C527 L414 L419 R447 Q410 L427 Q203 C525 Q314 R367 Q418 R445 C438 R443 R449 C489 R446 R711 R316 R418 R466 L417 C433 Q419 C446 L411 R315 R453 C468 R452 R451 R469 C497 L426 R450 C467 C494 R429 L425 C478 R436 R314 R317 C529 R532 Q508 R542 R531 R530 C530 Q507 R448 C466 C721 Q315 R320 Q316 R526 C319 C318 R355 X501 R541 C447 Q417 R204 C337 Q331 C469 C371 R366 R570 R356 C369 R454 R430 Q416 C460 C461 R507 Q504 R431 R432 C504 R501 C343 R357 R335 R321 C546 R433 C462 R359 R319 C519 R434 R437 R310 Q319 R323 C317 C470 R438 R440 R311 R913 R426 Q413 C463 R435 R502 C502 R601 R537 R540 C547 L301 C464 R427 R428 L424 C465 Q323 R511 R510 R513 R312 C309 C339 C601 C516 C517 C513 R550 Q415 C308 R441 L312 R336 C313 C310 Q414 C473 C472 C341 R602 C509 R560 R561 C539 R544 R934 Q614 R605 Q509 C535 R538 C328 C353 RV602 R657 R620 Q613 C603 C510 C551 Q505 R935 R604 Q605 C550 Q503 C703 C329 C605 R439 C474 Q308 Q318 R607 C602 C515 R549 R703 C604 C644 Q609 R702 R608 R622 Q502 C704 R705 C719 Q608 R548 C708 C706 R717 R609 C636 R641 Q916 C345 C607 C638 C520 Q701 C622 C608 C606 R637 R625 C625 C621 C707 R640 R930 Q317 R656 C615 C634 R642 C627 R639 C628 R716 R650 RV601 C522 C645 Q616 R651 C626 R668 C617 R643 R664 R652 C616 C620 C639 C633 C630 Q607 R658 R631 8-22 CD501 Figure 8-16. UHF 403-440 MHz Main Board Bottom Side August 30, 2002 99R85452E01-O 8-23 5 Table 1 R515 25.5K 1% 2 R561 634K 1% C541 0.1 7 R547 10 9PF(CH) Not use Rank3 33PF(UJ) 8PF(CH) 10PF(CH) 9PF(CH) Not use Rank4 18PF(UJ) 8PF(CH) 10PF(CH) 9PF(CH) 15PF(CH) Rank5 33PF(UJ) 8PF(UJ) 10PF(CH) 9PF(CH) C523 0.22 Q503 2SJ144Y Not use R524 2.2K R522 N.U R523 47K R521 715K 1% R525 10K C544 0.22 C542 390p R549 100K 12 5 7 R336 100K Q319 R335 100K C380 Table1 R715 4.7K R705 22 1SS355 C718 100p C717 100p R710 100 Q712 Q710 1SS355 UDZ S 20B C720 0.001 R708 2.2K Q704 2SA1586GR R357 10 C335 10p R325 10K C711 0.1 C367 0.001 Q320 UMZ2N 8 R707 10K + C713 0.1 1 3 C337 Table1 C338 Table1 4 6 C343 10u10V(T) Q322 1SV217 5 3 5 2 R327 100K 6 2 4 R333 100K 1 4 J701(2/2) L702 390nH(C2012C) C710 0.1 3 C339 0.001 C341 0.1 2 R709 0.27( 1/8W) 09R80683Z01 R706 470 9 SP701 SPEAKER Q705 1SR154-400 Q706 UDZ S 6.8B 10 C709 10u10V(T) 11 1 2 2.2K R713 2.2K C318 47p C319 47p 12 C313 15p 1 R332 100K 1% C336 Table1 R568 4.7K R567 10k(TH) C329 470p 13 R358 47 C312 10p X301 14.4MHz R566 6.8K R337 150K(1%) 14 Q709 R712 2SA1586GR 1K Q316 UDZ S 7.5B C317 47p R355 N.U R319 10K R366 470 15 1 2 C705 2.2uF/16V Q708 R714 R323 4.7K x 4 R717 0 P701 WC-013 6 J702 53047-0210 470K C716 100p OUT- C715 100p C714 100p Vcc IN- R711 2.2K C702 0.001 IN+ R703 C708 0.001 R7024 1.5K C703 0.22 Q711 1SR154-400 Q323 MB15A02 R563 0 C345 0.001 R934 1K C342 100p R362 22K 16 R329 R565 220K 1% 18K Q318 2SC4116GR R935 4.7K C328 4.7u16V(T) + C323 1u16V(T) + R564 82k(1%) C368 1u R368 Not use 0.0015 C350 R929 10K Q921 1SV279 C935 6p R321 6.8K Q331 2SC4116GR L310 390nH Q922 1SV270 C352 N.U 6p C340 27p C938 5p C937 L308 390nH 1 R930 100K L307 390nH R913 10K 5 J701(1/2) 09R80683Z01 R716 0 8 7 2SA1586GR C324 10u16V(T) R318 10K R367 470 3 Q315 2SC4116GR C381 Table1 L312 BLM21A121S R361 22K Q303 2SK508(K52) + R320 1.5K R316 1.5K R317 3.3K + R315 2.7K R364 6.8K C369 0.1u 35V(T) R314 0 R330 10K(TH) C353 0.001 C316 0.001 Q317 UMC4N Q916 4 2SJ243 L309 22n R928 150 R356 0 C371 1u 16V(T) R313 100K C919 Not use C940 1p L305 390nH C351 N.U 390nH Q314 2SA1586GR 2 C912 0.5p GND C719 100p C918 18p C320 0.001 OUT+ SVR C706 0.1 3 C315 5p R914 150 R310 100 L301 R311 22nH 15K L304 390nH MO C707 0.001 C701 0.001 C305 0.22 C304 10u16V(T) R301 1K Vout R704 47K 2.2K L306 C936 6p C217 0.1 C214 0.001 + C211 0.001 C213 10u10V(T) C212 0.001 R210 22 R204 4.7K 10K 10PF(UJ) R550 1K 14 13 Q702 TDA8541 1 C704 4.7u6.3V(T) 2 R359 4.7K Q308 2SC5086Y R312 220 R211 R209 10 R205 50K(TH) C218 0.001 R664 6.8K 13 C366 + R668 1K C310 0.001 Q210 2SA1362 C208 + 0.01 C207 10u10V(T) GND CE 3 1 4 NC C206 0.001 C645 22p VB Q302 2SK508(K52) C308 5p 5 Vout Vi n C309 0.01 R208 4.7K C209 0.001 C210 0.001 R206 2.2K Q204 XC62HR5002PR 2 C913 7p L302 390nH C204 0.01 Q207 UMW1N R207 10K C205 0.01 C219 0.001u 1 C220 100p Q203 1SR154-400 2 8 100K 1000uH(NL453232) L303 27n C311 1p 3 Not use 8PF(UJ) C546 0.1 C302 0.1 C301 10u10V(T) R202 2.2K CN201 09D86237A 9PF(UJ) 33PF(UJ) Q505D NJM324V(4/4) R548 10K 9 C543 0.0047 C539 0.039 6 R545 100K 5 C540 0.0015 11 R544 100K Q505A NJM324V(1/4) + C203 1u16V(T) R203 4.7K C201 0.01 C202 10u10V(T) 5 VB Q505C NJM324V(3/4) R546 100K R701 C314 5p + C381 10PF(UJ) Rank2 12 8 C521 C522 0.01(ECHU) 0.01(ECHU) R519 150K 1% R516 29.4K 1% C519 R513 0.01 10K 11 4 1 3 C529 0.1 C535 0.027 R539 100K 2 C537 0.0027 C536 0.047 R543 100K DK OSC GND 1 L313 + 220 TP301 + C380 8PF(UJ) Q502D NJM324V(4/4) 14 9 C520 10 7 C518 0.01(ECHU) 0.01 2% VB C336 C524 0.068 C515 0.01 2% C513 27p 4 R510 470K R512 47K C512 0.0022 C510 0.22 C516 0.01 2% VB C303 0.022 3 TI Vi n + Q419A NJM2904V(1/2) 4 5 6 + Q201 2SB798 Q202 UMW1N Q502C R518 11.5K 1% NJM324V(3/4) C338 33PF(UJ) C538 0.01 R302 Q301 TK11816M R201 10K C215 2.2uF/16V R212 100 3 GND 3.3K VB R537 470K C5176 0.01 2% 5 R514 Q707 2SA1313 2 THERM Q502B NJM324V(2/4) R517 15.8K 1% R520 4.22K 1% C337 Rank1 R542 22K R531 22K R530 22K 3 4 5 R540 22K Q508 DAN235E 2 1 Q502A NJM324V(1/4) C534 2.2u10V(T) VB Q505B NJM324V(2/4) 4 BATT C509 0.001 R506 3.3K 56p R536 1k C532 220p Q511 RB521S C550 0.01 2% 13 R511 2 56K 3 4 Q510 NJM2107F R440 22 R441 330 R439 330 R438 1K R437 4.7K C470 Q415 5p HSC277 R435 2.2 C528 1u C508 470p R535 2.2k F502 ALFYM455G 1 Q414 2SC5086Y R436 10K 68K 0.1 C547 2 3 4 5 C527 0.001 Q507 DAN235E F501 BLFYM455D Q416 2SC5086Y SW201 TP76N17N 10K.A 1 C511 0.1 R509 R507 R508 1K 10K R505 2.2K R534 330k C533 8 C530 0.1 1 C526 39p L501 1uH(MLF) R541 22K R527 10K 2 3 R433 10K 220 1 X501 44.645MHz(TOP-B) C462 0.01 R430 100 R431 10K L426 22nH(LL1608) R432 C461 0.001 5p L425 18nH(LL1608) C478 C474 0.001 R434 100 4.7K R429 R428 8.2K C473 0.001 0.001 R427 22 C472 18p C458 C457 1 R426 Not use(R2)470(R1) 100K R425 L422 0.3-1.0-7T R424 1K 5p C455 330p C464 8p 1 R538 100K 1 2 4 R452 33k R448 100K 0.01 C467 Q413 2SC3356(R24) 1.5M R532 C525 33p L424 18nH(LL1608) 1R454 15K R451 100K Not use R422 470 3 8 3 C469 6.8u6.3V(T) C468 0.001 R466 1K R469 2.2K C451 56p C488 N.U C449 100p C450 R419 56 C454 0.022 R449 100K 1% 2 5 C465 0.001 R446 R445 100K 1% 100K 1% R453 1M R450 10K 7 Q412 2SK3475 C459 7p L423 0.4-0.9-3T C489 0.001 C466 0.001 C497 22p L427 R442 0.1(1W) ZBFS5105-PT Q419B NJM2904V(2/2) 2 R423 100 C437 27p 150p C448 0.4-0.9-3T 2 X301 C5513 0.01 2% 1 + C485 2.2uF/16V R447 97.6K 1% R443 100K 1% 6 R444 100K 1% C496 33p L421 R503 2.7K TA31136FN C514 0.01 3 5 9 Q506 C531 220p C545 33u6.3V(T) R468 1K + R526 0 4 C463 5p C494 N.U C453 100p 3 C456 0.022 1 Q411 2SK3476 L420 R421 0.3-1.0-7T 2 22K C447 0.0033 C436 Not Use C446 1u16V L417 390nH R417 220 100p C445 C752 27p C492 7p C498 0.5p C443 L416 0.4-1.0-5T C460 5p C444 7p L415 0.4-1.0-5T C440 9p C475 6p 220p C442 2p 10p L414 0.4-1.0-5T C439 1K(1/4W) R569 J401 02D04852J C493 150p C435 24p 0.3-1.0-4T Q410 MA4PH262 C441 1.5p C438 R418 100p 470 L418 L430 0.4-0.8-2T C491 15p R420 33K C433 Not use C432 4p Q409 HVU131 L419 0.4-1.0-5T CD501 C505 100p Q501 UMC4N 4 IFD0455C24E3 C506 0.1 R502 47K C504 0.1 C502 --- R551 0 L408 SMD-0314A R501 0 C501 100p R570 120k R571 220K(TH) Q408 2SC4215Y F401 --- C503 0.1 16 --- R459 3.3K L432 1uH C495 22p C430 0.01 1 C428 C427 24p 10p L409 SMD-0314A 4 F402 45N12A5 C426 82p 150nH(C2012C) C425 R412 56 L412 24p C424 1 6 3 4 2 C429 - - - 4 2 7p C422 C420 9p C423 15p 6 3 2 1 3 0.01 C421 7p R413 0 L413 470nH(FSLM) L410 L411 15nH(LL2012)15nH(LL2012) L4311uH L428 Not use R409 100K C419 R410 100K Q406 L407 Q405 L406 C412 0.01 C410 100p L402 0.3-1.0-5T R407 470 Q403 1SS362 C417 5p R415 150K 0.3-1.0-5T 1SV279 C416 6p C414 6p C415 10p R406 0 L405 0.3-1.0-7T 0.3-1.0-5T 1SV279 C413 0.01 R408 100K C487 1.5p L404 180nH(C2012C) R405 6.8K R403 12K --- C407 5p L403 Q402 1SV279 C409 0.01 Q404 2SC5086Y R404 4.7K 100p C406 100K Q401 C408 22p C405 N.U R401 C404 6p L401 1SV279 0.3-1.0-5T C403 N.U C402 4p C411 33p R560 5.11K 1% + C401 8p R402 100K R455 100K 14 12 1u16V(T) Q610D NJM324V(4/4) CN701 AXK6 S40545J/P 1 2 R660 --- 0.001 C623 0.022u 5 8 C620 0.22u R631 820K R629 NU 0.1 2 R628 0 C639 27p 2 1 Q607 C619 1SS372-TE85L 9 10 11 12 Q617 NJM2107F 13 14 15 + 100 Q614 1SS372 16 17 Q615 DAN222 18 Q610A NJM324V(1/4) 22 23 24 25 C721 0.001 R651 100K 21 R652 680K R650 100K C634 0.0018 68p 1 2 R646 1K R635 3.3M R634 1.5M VB 3 R649 100K C635 0.1 C631 0.0082 C630 0.015 NJM324V(2/4) 20 VB R661 10K C632 R663 100K 11 R667 1M 4 R665 1M R633 18K R640 180k R666 68K 6 R639 270K R641 100K RV602 10K.B Q610B R638 270K C627 0.0033u 5 7 3 VB R656 C643 0.0033u 7 R626 18K 19 C624 150p R636 0 1 C644 1u R622 0 Q602A NJM324V(1/4) C637 0.001u 11 C642 0.022 R620 4.7K RV601 10K.B 6 4 5 VB R611 50k(TH) C641 R657 0 7 3 Not use C616 R625 0.027 18K C618 82p 3 1 6 C615 0.01 C617 0.0047 4 C608 NJM324V(2/4) 2 Q616 SSM3K03FE R655 4.7K R658 820 Q602C NJM324V(3/4) R616 4.7K 4 5 C629 1u C638 4.7u6.3V(T) Q602D NJM324V(4/4) VB Q602B C606 0.047 R602 6.8K 9 R617 100K R615 12K 10 8 13 C607 0.1 R608 100K R609 680K 14 R607 100K R612 47k R606 100K R610 10K 12 R659 12k C605 680p R604 6.8K R605 100K C604 0.0012 C603 82p R601 3.3M C602 0.0033 R621 330K 3 R627 680K R645 1M C601 0.1 C612 10p C636 100p 26 27 28 29 Q609 + R648 470K C621 0.001 9 R642 33K 1% + Q610C NJM324V(3/4) 10 + C622 0.001 C633 0.01 31 32 33 34 35 36 37 R643 22K 1% 8 C628 1u16V(T) C625 C626 4.7u6.3V(T) 10u10V(T) VB 30 UMG2N R637 0 38 39 40 GND ST_BY DTMF OUT VOX I N MC1 MOD_CMP MC2 TX_MUTE DTMF I N Vbb DATA0 SQL MU TE DETECT I N W/N Vdd Vdd TDC MC_PTT PRO GND GND DAC_RX TEMP I N DAC_BAI S DAC_TX GND MI C SAVE VDD RESET SU AU O UT GND SQL I N RSSI RX/TX UNL OCK PLL_ LE DATA CLOCK GND Figure 8-17. UHF 403-440 MHz RF Schematics Diagram 99R85452E01-O August 30, 2002 8-24 UHF 403-440 MHz Radio Parts List (Controller Board) Circuit Ref C101 C102 C103 C104 C105 C106 C107 C108 C109 C110 C111 C112 C113 C114 C115 C116 C117 C120 C129 C131 C132 C133 C134 C135 C136 C137 C138 C139 C140 C141 C142 C143 C144 C145 C146 C147 C148 C149 C150 C151 C152 C153 C154 C155 C156 C157 C158 C159 C160 August 30, 2002 Description 22pF; 50V; +-5% NU 10pF; 50V; +-5% 100pF; 50V; +-5% 0.1uF; 16V; +-10% 27pF; 50V; +-5% 0.01uF; 50V; +-10% 0.1uF; 16V; +-10% 0.1uF; 16V; +-10% 0.001uF; 50V; +-10% 47uF;6.3V;+-20% 0.1uF; 16V; +-10% 0.001uF; 50V; +-10% 47uF;6.3V;+-20% 47uF;6.3V;+-20% 47uF;6.3V;+-20% NU 0.001uF; 50V; +-10% 0.01uF; 50V; +-10% 33pF; 50V; +-5% 33pF; 50V; +-5% 0.001uF; 50V; +-10% 0.01uF; 50V; +-10% 2.2pF; 6.3V NU 0.1uF; 16V; +-10% 0.1uF; 16V; +-10% 0.1uF; 16V; +-10% 0.22uF; 10V; +-10% 0.001uF; 50V; +-10% 0.001uF; 50V; +-10% 0.001uF; 50V; +-10% 0.001uF; 50V; +-10% 47pF; 50V; +-5% 0.001uF; 50V; +-10% 0.001uF; 50V; +-10% 0.001uF; 50V; +-10% 0.001uF; 50V; +-10% 0.001uF; 50V; +-10% 0.001uF; 50V; +-10% 0.001uF; 50V; +-10% 0.001uF; 50V; +-10% 0.001uF; 50V; +-10% 0.001uF; 50V; +-10% 0.01uF; 50V; +-10% 0.01uF; 50V; +-10% 47pF; 50V; +-5% 47pF; 50V; +-5% 47pF; 50V; +-5% Vendor Vendor Part Number Circuit Ref Motorola Equivalent Part Number Murata GRM39CH220J50PT 2113740F35 Murata Murata Murata Murata Murata Murata Murata Murata NI-CHEMI Murata Murata NI-CHEMI NI-CHEMI NI-CHEMI GRM39CH100J50PT GRM39CH101J50PT GRM39B104K16PT GRM39CH270J50PT GRM39B103K50PT GRM39B104K16PT GRM39B104K16PT GRM39B102K50PT 6MCM476MB2TER GRM39B104K16PT GRM39B102K50PT 6MCM476MB2TER 6MCM476MB2TER 6MCM476MB2TER N/A 2113740F51 N/A 2113740F37 N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A Murata Murata Murata Murata Murata Murata Murata GRM39B102K50PT GRM39B103K50PT GRM39CH330J50PT GRM39CH330J50PT GRM39B102K50PT GRM39B103K50PT GRM40B225K6.3PT N/A N/A 2113740F39 2113740F39 N/A N/A N/A Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata GRM39B104K16PT GRM39B104K16PT GRM39B104K16PT GRM39B224K10PT GRM39B102K50PT GRM39B102K50PT GRM39B102K50PT GRM39B102K50PT GRM39CH470J50PT GRM39B102K50PT GRM39B102K50PT GRM39B102K50PT GRM39B102K50PT GRM39B102K50PT GRM39B102K50PT GRM39B102K50PT GRM39B102K50PT GRM39B102K50PT GRM39B102K50PT GRM39B103K50PT GRM39B103K50PT GRM39CH470J50PT GRM39CH470J50PT GRM39CH470J50PT N/A N/A N/A 2113928G01 N/A N/A N/A N/A 2113740F43 N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A 2113740F43 2113740F43 2113740F43 C161 C162 C163 C164 C165 C166 C167 C171 C173 C174 C175 C176 C181 C182 C183 C191 CN101 L112 LC101 M101 PB101 Q101 Q102 Q105 Q114 Q115 Q116 Q117 Q118 Q119 Q120 Q121 Q122 Q123 Q124 Q125 Q126 Q127 Q130 Q131 R101 R102 R103 R104 R105 R106 R107 R108 R109 R110 R111 Description 0.001uF; 50V; +-10% 0.001uF; 50V; +-10% 0.001uF; 50V; +-10% 0.01uF; 50V; +-10% 0.001uF; 50V; +-10% 47pF; 50V; +-5% 47pF; 50V; +-5% 0.1uF; 16V; +-10% NU 1uF; 6.3V; +-10% 0.01uF; 50V; +-10% 0.1uF; 16V; +-10% 0.22uF; 10V; +-10% 0.22uF; 10V; +-10% 470pF; 50V; +-5% 0.001uF; 50V; +-10% Connector 10uH LCD Capacitor Microphone CONTROL-PCB CPU Dual NPN IC,CPU Reset IC, EEPROM LED LED NPN Green/Red/Amber Dual NPN IC, DTMF Decoder IC, D/A Converter IC, D Flip-flop PNP NU IC, Op-Amp Single Diode FET Diode 0 ohm; 0.1W; +-5% 47 Kohm; 0.1W; +-5% NU 0 ohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 0 ohm; 0.1W; +-5% 47 ohm; 0.1W; +-5% 330 ohm; 0.1W; +-5% 330 ohm; 0.1W; +-5% 51 Kohm; 0.1W; +-5% 51 Kohm; 0.1W; +-5% Vendor Vendor Part Number Motorola Equivalent Part Number Murata Murata Murata Murata Murata Murata Murata Murata GRM39B102K50PT GRM39B102K50PT GRM39B102K50PT GRM39B103K50PT GRM39B102K50PT GRM39CH470J50PT GRM39CH470J50PT GRM39B104K16PT N/A N/A N/A N/A N/A 2113740F43 2113740F43 N/A Murata Murata Murata Murata Murata Murata Murata Matsushita Taiyo Uden Picvue Bosung Shikibo Sanyo Rohm Rico Seiko El. Citizen Citizen Rohm Rohm Rohm Sanyo Fujitsu Toshiba Rohm GRM39B105K6.3PT GRM39B103K50PT GRM39B104K16PT GRM39B224K10PT GRM39B224K10PT GRM39CH471J50PT GRM39B102K50PT AXK5S40245J/P LEM2520T100J HT138ZAS OB-22P44 K001C802-12 LC87F72C8A UMG2N TR RN5VD30CATR S-24C16AFJ-01 CL-200G-C-TS CL-200G-C-TS DTC114EETL SML-020MLT T86NN UMH6N TR LC73881M MB88347PFV TC7W74FU TE12L DTA144EETL 2113928P04 N/A N/A 2113928G01 2113928G01 N/A N/A DSCN097002 N/A DSLC170003 DSMI505001 N/A DSIC092009 N/A DSIC076007 DSIC510003 N/A N/A N/A 4804810T02 4880439V02 DSIC092007 DSIC042002 DSIC013029 N/A JRC Rohm Rohm Toshiba Toshiba Rohm Rohm NJM2107F (TE1) RB521S-30 TE61 1SS355 TE-17 SSM3K03FE-TE85L 1SS372-TE85L MCR03 EZHJ 000 MCR03 EZHJ 473 DSIC025016 4805656W22 4870360C15 N/A N/A 0662057B47 0662057A89 Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm MCR03 EZHJ 000 MCR03 EZHJ 103 MCR03 EZHJ 000 MCR03 EZHJ 470 MCR03 EZHJ 331 MCR03 EZHJ 331 MCR03 EZHJ 513 MCR03 EZHJ 513 0662057B47 0662057A73 0662057B47 0662057A17 0662057A37 0662057A37 0662057A90 0662057A90 99R85452E01-O 8-25 Circuit Ref R112 R113 R114 R115 R116 R117 R118 R119 R120 R121 R126 R127 R128 R129 R134 R135 R136 R137 R138 R141 R142 R143 R144 R145 R146 R147 R148 R150 R153 R154 R155 R156 R157 R158 R159 R160 R161 R162 R163 R164 R165 R166 R167 R168 R169 R170 R171 R172 R173 R174 R175 99R85452E01-O Description 13 Kohm; 0.1W; +-5% 22 Kohm; 0.1W; +-5% 43 Kohm; 0.1W; +-5% 130 Kohm; 0.1W; +-5% 18 Kohm; 0.1W; +-5% 33 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 0 ohm; 0.1W; +-5% 0 ohm; 0.1W; +-5% NU 10 Kohm; 0.1W; +-5% 12.4 Kohm; 0.1W; +-1% 6.98 Kohm; 0.1W; +-1% 1 Kohm; 0.1W; +-5% 1 Kohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 1 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 20 Kohm; 0.1W; +-5% 20 Kohm; 0.1W; +-5% 20 Kohm; 0.1W; +-5% 20 Kohm; 0.1W; +-5% 20 Kohm; 0.1W; +-5% 20 Kohm; 0.1W; +-5% 20 Kohm; 0.1W; +-5% 20 Kohm; 0.1W; +-5% 2.2 Kohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 47 Kohm; 0.1W; +-5% NU 47 Kohm; 0.1W; +-5% 220 Kohm; 0.1W; +-5% 470 Kohm; 0.1W; +-5% 20 Kohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 47 Kohm; 0.1W; +-5% 47 Kohm; 0.1W; +-5% 330 ohm; 0.1W; +-5% 47 Kohm; 0.1W; +-5% 47 Kohm; 0.1W; +-5% 47 Kohm; 0.1W; +-5% 2.2 Kohm; 0.1W; +-5% 2.2 Kohm; 0.1W; +-5% 4.7 Kohm; 0.1W; +-5% Vendor Vendor Part Number Motorola Equivalent Part Number Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm MCR03 EZHJ 133 MCR03 EZHJ 223 MCR03 EZHJ 433 MCR03 EZHJ 134 MCR03 EZHJ 183 MCR03 EZHJ 333 MCR03 EZHJ 104 MCR03 EZHJ 000 MCR03 EZHJ 000 0662057A76 0662057A81 0665027A88 0662257B01 0662057A79 0662057A85 0662057A97 0662057B47 0662057B47 Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm MCR03 EZHJ 103 MCR03 EZHF 1242 MCR03 EZHF 6981 MCR03 EZHJ 102 MCR03 EZHJ 102 MCR03 EZHJ 103 MCR03 EZHJ 103 MCR03 EZHJ 102 MCR03 EZHJ 104 MCR03 EZHJ 203 MCR03 EZHJ 203 MCR03 EZHJ 203 MCR03 EZHJ 203 MCR03 EZHJ 203 MCR03 EZHJ 203 MCR03 EZHJ 203 MCR03 EZHJ 203 MCR03 EZHJ 222 MCR03 EZHJ 103 MCR03 EZHJ 473 0662057A73 0662057P69 0662057Y24 0662057A49 0662057A49 0662057A73 0662057A73 0662057A49 0662057A97 0662057A80 0662057A80 0662057A80 0662057A80 0662057A80 0662057A80 0662057A80 0662057A80 0662057A57 0662057A73 0662057A89 Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm MCR03 EZHJ 473 MCR03 EZHJ 224 MCR03 EZHJ 474 MCR03 EZHJ 203 MCR03 EZHJ 103 MCR03 EZHJ 103 MCR03 EZHJ 103 MCR03 EZHJ 103 MCR03 EZHJ 103 MCR03 EZHJ 103 MCR03 EZHJ 103 MCR03 EZHJ 473 MCR03 EZHJ 473 MCR03 EZHJ 331 MCR03 EZHJ 473 MCR03 EZHJ 473 MCR03 EZHJ 473 MCR03 EZHJ 222 MCR03 EZHJ 222 MCR03 EZHJ 472 0662057A89 N/A 0662057B14 0662057A80 0662057A73 0662057A73 0662057A73 0662057A73 0662057A73 0662057A73 0662057A73 0662057A89 0662057A89 0662057A37 0662057A89 0662057A89 0662057A89 0662057A57 0662057A57 0662057A65 Circuit Ref R176 R177 R180 R182 R183 R184 R185 R186 S101 S102 X101 Description 22 Kohm; 0.1W; +-5% NU 10 Kohm; 0.1W; +-5% 0 ohm; 0.1W; +-5% 47 Kohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 470 ohm; 0.1W; +-5% 0 ohm; 0.1W; +-5% Tact Switch Tact Switch Filter, 8.388608 MHz Vendor Vendor Part Number Motorola Equivalent Part Number Rohm MCR03 EZHJ 223 0662057A81 Rohm Rohm Rohm Rohm Rohm Rohm Motorola Motorola Daishinkuu MCR03 EZHJ 103 MCR10 EZHJ 000 MCR03 EZHJ 473 MCR03 EZHJ 103 MCR03 EZHJ 471 MCR03 EZHJ 000 Y39A33110FP Y39A33110FP AT-38 0662057A73 N/A 0662057A89 0662057A73 0662057A41 0662057B47 4080523Z01 4080523Z01 DSXT182001 August 30, 2002 8-26 UHF 403-440 MHz Radio Parts List (RF Board) Circuit Ref C201 C202 C203 C204 C205 C206 C207 C208 C209 C210 C211 C212 C213 C214 C215 C217 C218 C219 C220 C301 C302 C303 C304 C305 C306 C307 C308 C309 C310 C311 C312 C313 C314 C315 C316 C317 C318 C319 C320 C323 C324 C328 C329 C335 C336 C337 C338 C339 August 30, 2002 Description CAPACITOR 0.01uF; 50V; +-10% 10uF 10V 1uF 16V 0.01uF; 50V; +-10% 0.01uF; 50V; +-10% 0.001uF; 50V; +-10% 10uF 10V 0.01uF; 50V; +-10% 0.001uF; 50V; +-10% 0.001uF; 50V; +-10% 0.001uF; 50V; +-10% 0.001uF; 50V; +-10% 10uF 10V 0.001uF; 50V; +-10% 2.2uF; 16V; +80% -20% 0.1uF; 16V; +-10% 0.001uF; 50V; +-10% 0.001uF; 50V; +-10% 100pF; 50V; +-5% 10uF 10V 0.1uF; 16V; +-10% 0.022uF; 50V; +-10% 10uF; 16V 0.22uF; 10V; +-10% NU NU 5pF; 50V; +-0.25pF 0.01uF; 50V; +-10% 0.001uF; 50V; +-10% 1pF; 50V; +-5% 10pF; 50V; +-0.5pF 15pF; 50V; +-5% 5pF; 50V; +-0.25pF 5pF; 50V; +-0.25pF 0.001uF; 50V; +-10% 47pF; 50V; +-5% 47pF; 50V; +-5% 47pF; 50V; +-5% 0.001uF; 50V; +-10% 1uF 16V 10uF; 16V 4.7uF 16V 470pF; 50V; +-10% 10pF 33pF; 50V; +-5% 8pF; 50V ; +-0.5pF 10pF; 50V; +-0.5pF 0.001uF; 50V; +-10% Vendor Circuit Ref Vendor Part Number Motorola Equivalent Part Number Murata NI-CHEMI NI-CHEMI Murata Murata Murata NI-CHEMI Murata Murata Murata Murata Murata NI-CHEMI Murata Murata Murata Murata Murata Murata NI-CHEMI Murata Murata Ni-Chemi Murata GRM39B103K50PT 10MCM106MATER 16MC105MATER GRM39B103K50PT GRM39B103K50PT GRM39B102K50PT 10MCM106MATER GRM39B103K50PT GRM39B102K50PT GRM39B102K50PT GRM39B102K50PT GRM39B102K50PT 10MCM106MATER GRM39B102K50PT GRM40F225Z16PT GRM39B104K16PT GRM39B102K50PT GRM39B102K50PT GRM39CH101J50PT 10MCM106MATER GRM39B104K16PT GRM39B223K25PT 16MCM106MB2TER GRM39B224K10PT N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A 2113740F51 N/A N/A N/A N/A 2113928G05 Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata NI-CHEMI Ni-Chemi NI-CHEMI Murata Murata Murata Murata Murata Murata GRM39CH050C50PT GRM39B103K50PT GRM39B102K50PT GRM39CK010C50PT GRM39CH100D50PT GRM39CH150J50PT GRM39CH050C50PT GRM39CH050C50PT GRM39B102K50PT GRM39CH470J50PT GRM39CH470J50PT GRM39CH470J50PT GRM39B102K50PT 16MC105MATER 16MCM106MB2TER 16MCM475MATER GRM39B471K50PT TZV02Z100A110T00 GRM39UJ330J50PT GRM39UJ080D50PT GRM39UJ100D50PT GRM39B102K50PT N/A N/A N/A N/A 2113740F27 2113740F31 N/A N/A N/A 2113740F43 2113740F43 2113740F43 N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A C340 C341 C342 C343 C345 C347 C350 C351 C352 C353 C366 C367 C368 C369 C371 C380 C381 C401 C402 C403 C404 C405 C406 C407 C408 C409 C410 C411 C412 C413 C414 C415 C416 C417 C419 C420 C421 C422 C423 C424 C425 C426 C427 C428 C429 C430 C432 C433 C435 C436 C437 Description 15pF; 50V; +-5% 0.1uF; 16V; +-10% 100pF; 50V; +-5% 10uF 10V 0.001uF; 50V; +-10% 0.001uF; 50V; +-10% 0.0015uF; 50V; +-10% NU 2pF; 50V; +-10% 0.001uF; 50V; +-10% 4.7uF 16V 0.001uF; 50V; +-10% 1uF; 6.3V; +-10% 0.1uF; 35V 1uF 16V 9pF; 50V; +-0.5pF NU 8pF; 50V; +-0.5pF 4pF; 50V; +-0.25pF NU 6pF; 50V; +-0.25pF NU 100pF; 50V; +-5% 5pF; 50V; +-5% 22pF; 50V; +-5% 0.01uF; 50V; +-10% 100pF; 50V; +-5% 33pF; 50V; +-5% 0.01uF; 50V; +-10% 0.01uF; 50V; +-10% 6pF; 50V; +-0.25pF 10pF; 50V; +-0.5pF 6pF; 50V; +-0.25pF 4pF; 50V; +-0.25pF 0.01uF; 50V; +-10% 9pF; 50V; +-0.5pF 7pF; 50V; +-0.5pF 7pF; 50V; +-0.5pF 15pF; 50V; +-5% 24pF; 50V; +-5% 10pF; 50V; +-0.5pF 82pF; 50V; +-5% 24pF; 50V; +-5% NU NU 0.01uF; 50V; +-10% 4pF; 50V; +-0.25pF NU 24pF; 50V; +-5% NU 27pF; 50V; +-5% Vendor Vendor Part Number Motorola Equivalent Part Number Murata Murata Murata NI-CHEMI Murata Murata Murata GRM39CH150J50PT GRM39B104K16PT GRM39CH101J50PT 10MCM106MATER GRM39B102K50PT GRM39B102K50PT GRM39B152K50PT 2113740F31 N/A 2113740F51 N/A N/A N/A N/A Murata Murata NI-CHEMI Murata Murata NI-CHEMI NI-CHEMI Murata GRM39CH020C50PT GRM39B102K50PT 16MCM475MATER GRM39B102K50PT GRM39B105K6.3PT 35MC104MATER 16MC105MATER GRM39CH090D50PT N/A N/A N/A N/A 2113928P04 N/A N/A N/A Murata Murata GRM39CH080D50PT GRM39CH040C50PT N/A N/A Murata GRM39CH060C50PT N/A Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata GRM39CH101J50PT GRM39CK050C50PT GRM39CH220J50PT GRM39B103K50PT GRM39CH101J50PT GRM39CH330J50PT GRM39B103K50PT GRM39B103K50PT GRM39CH060C50PT GRM39CH100D50PT GRM39CH060C50PT GRM39CH040C50PT GRM39B103K50PT GRM39CH090D50PT GRM39CH070D50PT GRM39CH070D50PT GRM39CH150J50PT GRM39CH240J50PT GRM39CH100D50PT GRM39CH820J50PT GRM39CH240J50PT 2113740F51 N/A 2113740F35 N/A 2113740F51 2113740F39 N/A N/A N/A 2113740F27 N/A N/A N/A N/A N/A N/A 2113740F31 2113740F36 2113740F27 2113740F49 2113740F36 Murata Murata GRM39B103K50PT GRM39CH040C50PT N/A N/A Murata GRM39CH240J50PT 2113740F36 Murata GRM39CH270J50PT 2113740F37 99R85452E01-O 8-27 Circuit Ref C438 C439 C440 C441 C442 C443 C444 C445 C446 C447 C448 C449 C450 C451 C453 C454 C455 C456 C457 C458 C459 C460 C461 C462 C463 C464 C465 C466 C467 C468 C469 C470 C472 C473 C474 C475 C478 C485 C487 C488 C489 C490 C491 C492 C493 C494 C495 C496 C497 C498 C501 99R85452E01-O Description 100pF; 50V; +-5% 220pF; 50V; +-10% 9pF; 50V; +-0.5pF 1.5pF; 50V; +-5% 2pF; 50V; +-5% 10pF; 50V; +-0.5pF 7pF; 50V; +-0.5pF 100pF; 50V; +-5% 1uF; 16V; +-10% 0.0033uF; 50V; +-10% 150pF; 50V; +-5% 100pF; 50V; +-5% 56pF; 50V; +-5% 10pF; 50V; +-0.5pF 100pF; 50V; +-5% 0.022uF; 50V; +-10% 330pF; 50V; +-10% 1uF; 16V; +-10% NU 18pF; 50V; +-5% 7pF; 50V; +-0.5pF 5pF; 50V; +-0.25pF 0.001uF; 50V; +-10% 0.01uF; 50V; +-10% 5pF; 50V; +-0.25pF 8pF; 50V; +-0.5pF NU 0.001uF; 50V; +-10% 0.01uF; 50V; +-10% 0.001uF; 50V; +-10% 6.8uF; 6.3V 5pF; 50V; +-0.25pF 0.001uF; 50V; +-10% 0.001uF; 50V; +-10% 0.001uF; 50V; +-10% 6pF; 50V; +-0.25pF 5pF; 50V; +-0.25pF 2.2uF; 16V; +80% -20% 2.5pF; 50V; +-10% NU 0.001uF; 50V; +-10% NU 22pF; 50V; +-5% 5pF; 50V; +-0.25pF 150pF; 50V; +-5% NU 22pF; 50V; +-5% 33pF; 50V; +-5% 22pF; 50V; +-5% 0.5pF; 50V; +-5% 100pF; 50V; +-5% Vendor Vendor Part Number Motorola Equivalent Part Number Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata GRM39CH101J50PT GRM39B221K50PT GRM39CH090D50PT GRM39CK1R5C50PT GRM39CK020C50PT GRM39CH100D50PT GRM39CH070D50PT GRM39CH101J50PT GRM40B105K16PT GRM39B332K50PT GRM39CH151J50PT GRM39CH101J50PT GRM39CH560J50PT GRM39CH100D50PT GRM39CH101J50PT GRM39B223K25PT GRM39B331K50PT GRM40B105K16PT 2113740F51 N/A N/A N/A N/A 2113740F27 N/A 2113740F51 N/A 2155169M15 2113740F55 2113740F51 2113740F45 2113740F27 2113740F51 N/A N/A N/A Murata Murata Murata Murata Murata Murata Murata GRM39CH180J50PT GRM39CH070D50PT GRM39CH050C50PT GRM39B102K50PT GRM39B103K50PT GRM39CH050C50PT GRM39CH080D50PT 2113740F33 N/A N/A N/A N/A N/A N/A Murata Murata Murata NI-CHEMI Murata Murata Murata Murata Murata Murata Murata Murata GRM39B102K50PT GRM39B103K50PT GRM39B102K50PT 6MCS685MATER GRM39CH050C50PT GRM39B102K50PT GRM39B102K50PT GRM39B102K50PT GRM39CH060C50PT GRM39CH050C50PT GRM40F225Z16PT GRM39CK2R5C50PT N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A Murata GRM39B102K50PT N/A Murata Murata Murata GRM39CH220J50PT GRM39CH050C50PT GRM39CH151J50PT 2113740F35 N/A 2113740F55 Murata Murata Murata Murata Murata GRM39CH220J50PT GRM39CH330J50PT GRM39CH220J50PT GRM39CH0R5C50PT GRM39CH101J50PT 2113740F35 2113740F39 2113740F35 N/A 2113740F51 Circuit Ref C502 C503 C504 C505 C506 C508 C509 C510 C511 C512 C513 C514 C515 C516 C517 C518 C519 C520 C521 C522 C523 C524 C525 C526 C527 C528 C529 C530 C531 C532 C533 C534 C535 C536 C537 C538 C539 C540 C541 C542 C543 C544 C545 C546 C547 C550 C551 C601 C602 C603 C604 Description NU 0.1uF; 16V; +-10% 0.1uF; 16V; +-10% 100pF; 50V; +-5% 0.1uF; 16V; +-10% 470pF; 50V; +-10% 0.001uF; 50V; +-10% 0.22uF; 10V; +-10% 0.1uF; 16V; +-10% 0.0022uF; 50V; +-10% 27pF; 50V; +-5% 0.01uF; 50V; +-10% 0.01uF; 16V; +-2% 0.01uF; 16V; +-2% 0.01uF; 16V; +-2% 0.01uF; 16V; +-2% 0.01uF; 50V; +-10% 0.01uF; 16V; +-2% 0.01uF; 16V; +-2% 0.01uF; 16V; +-2% 0.22uF; 10V; +-10% 0.068uF; 16V; +-10% 33pF; 50V; +-5% 39pF; 50V; +-5% 0.001uF; 50V; +-10% 1uF; 6.3V; +-10% 0.1uF; 16V; +-10% 0.1uF; 16V; +-10% 220pF; 50V; +-10% 220pF; 50V; +-5% 56pF; 50V; +-5% 2.2uF; 10V 0.027uF; 25v; +-10% 0.047uF; 16V; +-10% 0.0027uF; 50V; +-10% 0.01uF; 50V; +-10% 0.039uF; 16v; +-10% 0.0015uF; 50V; +-10% 0.1uF; 16V; +-10% 390pF; 50V; +-10% 0.0047uF; 50V; +-10% 0.22uF; 10V; +-10% 33uF; 6.3V 0.1uF; 16V; +-10% 0.1uF; 16V; +-10% 0.01uF; 16V; +-2% 0.01uF; 16V; +-2% 0.1uF; 16V; +-10% 0.0033uF; 50V; +-10% 82pF; 50V; +-5% 0.0012uF; 50V; +-10% Vendor Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Panasonic Panasonic Panasonic Panasonic Murata Panasonic Panasonic Panasonic Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata NI-CHEMI Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata NI-CHEMI Murata Murata Panasonic Panasonic Murata Murata Murata Murata Vendor Part Number GRM39B104K16PT GRM39B104K16PT GRM39CH101J50PT GRM39B104K16PT GRM39B471K50PT GRM39B102K50PT GRM39B224K10PT GRM39B104K16PT GRM39B222K50PT GRM39CH270J50PT GRM39B103K50PT ECHU1C103GX5 ECHU1C103GX5 ECHU1C103GX5 ECHU1C103GX5 GRM39B103K50PT ECHU1C103GX5 ECHU1C103GX5 ECHU1C103GX5 GRM39B224K10PT GRM39B683K16PT GRM39CH330J50PT GRM39CH390J50PT GRM39B102K50PT GRM39B105K6.3PT GRM39B104K16PT GRM39B104K16PT GRM39B221K50PT GRM39CH221J50PT GRM39CH560J50PT 10MCS225MATER GRM39B273K25PT GRM39B473K16PT GRM39B272K50PT GRM39B103K50PT GRM39B393K16PT GRM39B152K50PT GRM39B104K16PT GRM39B391K50PT GRM39B472K50PT GRM39B224K10PT 6MCM336MB2TER GRM39B104K16PT GRM39B104K16PT ECHU1C103GX5 ECHU1C103GX5 GRM39B104K16PT GRM39B332K50PT GRM39CH820J50PT GRM39B122K50PT Motorola Equivalent Part Number N/A N/A 2113740F51 N/A N/A N/A 2113928G05 N/A N/A 2113740F37 N/A N/A N/A N/A N/A N/A N/A N/A N/A 2113928G05 N/A 2113740F39 2113740F41 N/A 2113928P04 N/A N/A N/A N/A 2113740F45 N/A 2155169N29 N/A N/A N/A N/A N/A N/A 2113741F15 N/A 2113928G05 N/A N/A N/A N/A N/A N/A 2155169M15 2113740F49 N/A August 30, 2002 8-28 Circuit Ref C605 C606 C607 C608 C612 C615 C616 C617 C618 C619 C620 C621 C622 C623 C624 C625 C626 C627 C628 C629 C630 C631 C632 C633 C634 C635 C636 C637 C638 C639 C641 C642 C643 C644 C645 C701 C702 C703 C704 C705 C706 C707 C708 C709 C710 C711 C713 C714 C715 C716 C717 August 30, 2002 Description 680pF; 50V; +10% 0.1uF; 16V; +-10% 0.1uF; 16V; +-10% NU 10pF; 50V; +-0.5pF 0.01uF; 50V; +-10% 0.027uF; 25v; +-10% 0.0047uF; 50V; +-10% 82pF; 50V; +-5% 0.1uF; 16V; +-10% NU 0.001uF; 50V; +-10% 0.001uF; 50V; +-10% 0.022uF; 50V; +-10% 150pF; 50V; +-5% 4.7uF; 6.3V 10uF 10V 0.0033uF; 50V; +-10% 1uF 16V 1uF; 6.3V; +-10% 0.015uF; 50V; +-10% 0.0082uF; 50V; +-10% 68pF; 50V; +-5% 0.01uF; 50V; +-10% 0.0018uF; 50V; +-10% 0.1uF; 16V; +-10% 100pF; 50V; +-5% 0.001uF; 50V; +-10% 4.7uF; 6.3V 27pF; 50V; +-5% 0.0027uF; 50V; +-10% 0.022uF; 50V; +-10% 0.01uF; 50V; +-10% 1uF; 6.3V; +-10% 22pF; 50V; +-5% 0.001uF; 50V; +-10% 0.001uF; 50V; +-10% 0.22uF; 10V; +-10% 4.7uF; 6.3V 2.2uF; 16V; +80% -20% 0.1uF; 16V; +-10% 0.001uF; 50V; +-10% 0.001uF; 50V; +-10% 10uF 10V 0.1uF; 16V; +-10% 0.1uF; 16V; +-10% 0.1uF; 16V; +-10% 100pF; 50V; +-5% 100pF; 50V; +-5% 100pF; 50V; +-5% 100pF; 50V; +-5% Vendor Vendor Part Number Motorola Equivalent Part Number Murata Murata Murata GRM39B681K50PT GRM39B104K16PT GRM39B104K16PT N/A N/A N/A Murata Murata Murata Murata Murata Murata GRM39CH100D50PT GRM39B103K50PT GRM39B273K25PT GRM39B472K50PT GRM39CH820J50PT GRM39B104K16PT 2113740F27 N/A 2155169N29 N/A 2113740F49 N/A Murata Murata Murata Murata NI-CHEMI NI-CHEMI Murata NI-CHEMI Murata Murata Murata Murata Murata Murata Murata Murata Murata NI-CHEMI Murata Murata Murata Murata Murata Murata Murata Murata Murata NI-CHEMI Murata Murata Murata Murata NI-CHEMI Murata Murata Murata Murata Murata Murata Murata GRM39B102K50PT GRM39B102K50PT GRM39B223K25PT GRM39CH151J50PT 6MCS475MATER 10MCM106MATER GRM39B332K50PT 16MC105MATER GRM39B105K6.3PT GRM39B152K50PT GRM39B822K50PT GRM39CH680J50PT GRM39B103K50PT GRM39B182K50PT GRM39B104K16PT GRM39CH101J50PT GRM39B102K50PT 6MCS475MATER GRM39CH270J50PT GRM39B272K50PT GRM39B223K25PT GRM39B103K50PT GRM39B105K6.3PT GRM39CH220J50PT GRM39B102K50PT GRM39B102K50PT GRM39B224K10PT 6MCS475MATER GRM40F225Z16PT GRM39B104K16PT GRM39B102K50PT GRM39B102K50PT 10MCM106MATER GRM39B104K16PT GRM39B104K16PT GRM39B104K16PT GRM39CH101J50PT GRM39CH101J50PT GRM39CH101J50PT GRM39CH101J50PT N/A N/A N/A 2113740F55 N/A N/A 2155169M15 N/A 2113928P04 2113932E03 N/A 2113740F47 N/A 2155116E54 N/A 2113740F51 N/A N/A 2113740F37 N/A N/A N/A 2113928P04 2113740F35 N/A N/A 2113928G05 N/A N/A N/A N/A N/A N/A N/A N/A N/A 2113740F51 2113740F51 2113740F51 2113740F51 Circuit Ref C718 C719 C720 C721 C752 C912 C913 C917 C918 C919 C935 C936 C937 C938 C939 C940 Q201 Q202 Q206 Q207 Q208 Q209 Q210 Q211 Q302 Q303 Q308 Q314 Q315 Q317 Q318 Q320 Q331 Q404 Q408 Q411 Q412 Q413 Q414 Q416 Q417 Q418 Q501 Q503 Q504 Q509 Q601 Q605 Q608 Q609 Description 100pF; 50V; +-5% 220pF; 50V; +-5% 0.001uF; 50V; +-10% 0.001uF; 50V; +-10% 27pF; 50V; +-5% 0.5pF; 50V; +-5% 7pF; 50V; +-0.5pF NU 18pF; 50V; +-5% 0.022uF; 50V; +-10% 6pF; 50V; +-0.25pF 6pF; 50V; +-0.25pF 6pF; 50V; +-0.25pF 2pF; 50V; +-10% NU 1pF; 50V; +-5% TRANSISTOR: PNP Digital transistor PNP Digital transistor PNP Digital transistor PNP PNP FET FET NPN Transistor NPN Digital transistor NPN Transistor NPN NPN Transistor FET FET NPN NPN NPN Digital transistor Digital transistor Digital transistor FET Digital transistor PNP Digital transistor Digital transistor Digital transistor Digital transistor Vendor Vendor Part Number Motorola Equivalent Part Number Murata Murata Murata Murata Murata Murata Murata GRM39CH101J50PT GRM39CH221J50PT GRM39B102K50PT GRM39B102K50PT GRM39CH270J50PT GRM39CK0R5C50PT GRM39CH070D50PT 2113740F51 N/A N/A N/A 2113740F37 N/A N/A Murata Murata Murata Murata Murata Murata GRM39CH180J50PT GRM39B223K25PT GRM39CH060C50PT GRM39CH060C50PT GRM39CH060C50PT GRM39CH020C50PT 2113740F33 N/A N/A N/A N/A N/A Murata GRM39CK010C50PT N/A NEC Rohm Rohm Rohm Rohm Rohm Toshiba Rohm NEC NEC Toshiba Toshiba Toshiba Rohm Toshiba Rohm Toshiba Toshiba Toshiba Toshiba Toshiba NEC Toshiba Toshiba Rohm Rohm Rohm Toshiba Rohm Rohm Rohm Rohm Rohm Rohm 2SB798-T1 DK UMW1N TL DTA123YETL UMW1N TL DTA114EETL DTC114EETL 2SA1362-GR TE85L DTA123YETL 2SK508-T1B K52 2SK508-T1B K52 2SC5086-Y TE85L 2SA1586-GR TE85L 2SC4116-GR TE85L UMC4N TR 2SC4116-GR TE85L UMZ2N-TR 2SC4116-GR TE85L 2SC5086-Y TE85L 2SC4215-Y TE85L 2SK3476 2SK3475 2SC3356-T1B R24 2SC5086-Y TE85L 2SC5086-Y TE85L DTC114EETL DTC144EETL UMC4N TR 2SJ144Y-TE85L DTC144EETL DTA144EETL DTC144EETL DTC144EETL DTC144EETL UMG2N TR N/A N/A N/A N/A 4808317Y01 N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A 4809939C06 N/A N/A N/A DSTR013027 DSTR013026 N/A N/A N/A N/A 4880048M03 N/A N/A 4880048M03 N/A 4880048M03 4880048M03 4880048M03 N/A 99R85452E01-O 8-29 Circuit Ref Q613 Q616 Q701 Q703 Q704 Q707 Q708 Q709 Q916 Q203 Q311 Q316 Q319 Q322 Q401 Q402 Q403 Q405 Q406 Q407 Q409 Q410 Q415 Q420 Q507 Q508 Q511 Q607 Q614 Q615 Q705 Q706 Q710 Q711 Q712 Q921 Q922 Q204 Q301 Q323 Q419 Q502 Q505 Q506 Q510 Q602 Q610 Q617 Q702 99R85452E01-O Description PNP FET Digital transistor Digital transistor Transistor PNP Transistor Transistor FET DIODE: Single Var. Cap. Diode Zener ;7.6V Single Var. Cap. Diode Var. Cap. Diode Var. Cap. Diode Dual Varactor Var. Cap. Diode Var. Cap. Diode Diode Single Diode Single NU Dual Dual Diode NU Diode Dual Single Zener;6.9V Zener;20.39V Single Single Var. Cap. Diode Var. Cap. Diode INTEGRATED CIRCUIT: IC IC IC IC, Op-Amp IC, Op-Amp IC, Op-Amp IC IC, Op-Amp IC, Op-Amp IC, Op-Amp IC, Op-Amp IC Vendor Vendor Part Number Motorola Equivalent Part Number Rohm Toshiba Rohm Rohm Toshiba Toshiba Toshiba Toshiba NEC DTA144EETL SSM3K03FE-TE85L DTC144EETL DTC144EETL 2SA1586-GR TE85L 2SA1313-Y TE85L 2SA1586-GR TE85L 2SA1586-GR TE85L 2SJ243-T1 N/A N/A 4880048M03 4880048M03 N/A N/A N/A N/A N/A Rohm Toshiba Rohm Rohm Toshiba Toshiba Toshiba Toshiba Toshiba Toshiba HP Hitachi MA/COM Hitachi 1SR154-400 TE25 1SV228-TPH3 UDZ S 7.5B TE-17 1SS355 TE-17 1SV217-TPH3 1SV279-TPH3 1SV279-TPH3 1SS362-TE85L 1SV279-TPH3 1SV279-TPH3 HSMS-2817 HVU131TRF MA4PH262 HSC277TRF 4842006M02 N/A N/A 4870360C15 N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A Rohm Rohm Rohm DAN235ETL DAN235ETL RB521S-30 TE61 N/A N/A N/A Toshiba Rohm Rohm Rohm Rohm Rohm Rohm Toshiba Toshiba 1SS372-TE85L DAN222TL 1SR154-400 TE25 UDZ S 6.8B TE-17 UDZ S 20B TE-17 1SR154-400 TE25 1SS355 TE-17 JDV2S01E-TPH3 1SV270-TPH3 N/A 4809606E02 4842006M02 4842006M03 N/A 4842006M02 4870360C15 N/A N/A Torex TOKO Fujitsu JRC JRC JRC Toshiba JRC JRC JRC JRC Philips XC62HR5002PR TK11816M MB15A02PFV1-ER NJM2904V(TE1) NJM324V(TE1) NJM324V(TE1) TA31136FN-TP1 NJM2107F (TE1) NJM324V(TE1) NJM324V(TE1) NJM2107F (TE1) TDA8541T/N1 DSIC510004 DSIC011011 DSIC042003 DSIC510001 DSIC510002 DSIC510002 DSIC013007 DSIC025016 DSIC510002 DSIC510002 DSIC025016 DSIC174004 Circuit Ref L301 L302 L303 L304 L305 L306 L307 L308 L309 L310 L312 L313 L401 L402 L403 L404 L405 L406 L407 L408 L409 L410 L411 L412 L413 L414 L415 L416 L417 L418 L419 L420 L421 L422 L423 L424 L425 L426 L427 L428 L430 L431 L432 L501 L702 CN201 CN701 J401 J701 Description COIL: 22nH 390nH 27nH 390nH 390nH 390nH 390nH 390nH 22nH 390nH Chip emifil 1000uH Airwound Coil Airwound Coil NU 180nH Airwound Coil Airwound Coil Airwound Coil Coil Coil 15nH 15nH 50nH 470nH Airwound Coil Airwound Coil Airwound Coil 390nH Airwound Coil Airwound Coil Airwound Coil Airwound Coil Airwound Coil Airwound Coil 18nH 18nH 22nH Chip Beads NU Airwound Coil 1uH 1uH 1uH 390nH JACK: Connector contact Battery Connector Antenna Jack Audio Jack Vendor Vendor Part Number Motorola Equivalent Part Number TOKO Sagami Elec Sagami Elec Sagami Elec Sagami Elec Sagami Elec Sagami Elec Sagami Elec Sagami Elec Sagami Elec Murata TDK Uchida/Latest Uchida/Latest LL1608-FS22NJ C2012C-R39J C2012C-27NG C2012C-R39J C2012C-R39J C2012C-R39J C2012C-R39J C2012C-R39J C2012C-22NG C2012C-R39J BLM21A121SPT NL453232T-102J E2-0.30-1.0-5TL E2-0.30-1.0-5TL N/A 2462587V41 N/A 2462587V41 2462587V41 2462587V41 2462587V41 2462587V41 N/A 2462587V41 2480067M02 N/A N/A N/A Sagami Elec Uchida/Latest Uchida/Latest Uchida/Latest Latest Latest TOKO TOKO Sagami Elec Toko Uchida/Latest Uchida/Latest Uchida/Latest Sagami Elec Uchida/Latest Uchida/Latest Uchida/Latest Uchida/Latest Uchida/Latest Uchida/Latest TOKO TOKO TOKO TDK C2012C-R15J E2-0.30-1.0-7TL E2-0.30-1.0-5TL E2-0.30-1.0-5TL SMD-0314A SMD-0314A LL2012-FH15NJ LL2012-FH15NJ C2012C-R15J FSLM2520-R47K E2-0.40-1.0-5TL E2-0.40-1.0-5TL E2-0.40-1.0-5TL C2012C-R39J E2-0.40-0.8-2TL E2-0.40-1.0-5TL E2-0.30-1.0-7TL E2-0.40-0.9-3TL E2-0.30-1.0-7TL E2-0.40-0.9-3TL LL1608-FS18NJ LL1608-FS18NJ LL1608-FS22NJ ZBFS5105-PT 2462587V36 N/A N/A N/A N/A N/A N/A N/A N/A 2485602J33 N/A N/A N/A 2462587V41 N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A Uchida/Latest TDK TDK TDK Sagami Elec E2-0.30-1.0-4TL MLF1608A1R0KT MLF1608A1R0KT MLF1608A1R0KT C2012C-R39J 4880048M03 N/A N/A N/A 2462587V41 Motorola Matsushita Motorola Motorola 09D86237A AXK6S40545J/P 02D80689C 09R80683Z 0986237A01 DSCN097003 0280689C01 0980683Z01 August 30, 2002 8-30 Circuit Ref Description Vendor Vendor Part Number Motorola Equivalent Part Number Toko TOKO BLFYM455D ALFYM455G N/A N/A F402 CERAMIC FILTER: NU Ceramic filter 455Khz CRYSTAL Filter , 45.1 MHz HERTZ DSXF137006 X301 Crystal Nikko Denshi X501 Crystal Nikko Denshi 45N12A5 (45.1MHz) UM-5J-SMD TOP-B 14.4MHz RANK-2 TOP-B 44.645MHz +10ppm, +-4ppm CD501 J702 P701 PB201 SW201 MISCELLANEOUS Discriminator Connector SP WIRE Assembly PCB Potentiometers Samsung Molex EU-connector SHIKIBO Tocos F401 F501 F502 SP701 R201 R202 R203 R204 R205 R206 R207 R208 R209 R210 R211 R212 R301 R302 R310 R311 R312 R313 R314 R315 R316 R317 R318 R319 R320 R321 R323 R325 R327 R329 August 30, 2002 Speaker RESISTOR: 10 Kohm; 0.1W; +-5% 2.2 Kohm; 0.1W; +-5% 4.7 Kohm; 0.1W; +-5% 4.7 Kohm; 0.1W; +-5% 50K ohm NU 10 Kohm; 0.1W; +-5% 4.7 Kohm; 0.1W; +-5% 10 ohm; 0.1W; +-5% 22 ohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 100 ohm; 0.1W; +-5% 1 Kohm; 0.1W; +-5% 220 ohm; 0.1W; +-5% 100 ohm; 0.1W; +-5% 15 Kohm; 0.1W; +-5% 220 ohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 0 ohm; 0.1W; +-5% 2.7 Kohm; 0.1W; +-5% 1.5 Kohm; 0.1W; +-5% 3.3 Kohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 6.8 Kohm; 0.1W; +-5% 6.8 Kohm; 0.1W; +-5% Chip network resistor 10 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 220 Kohm; 0.1W; +-1% DSXT181002 DSXT181006 N/A N/A N/A N/A DSVR010008 Orient sound IFD0455C24E03 53047-0210 WC-013 K001C803-8 TP76N17N A10Kohm 10SK K028NA Rohm Rohm Rohm Rohm Hokuriku MCR03 EZHJ 103 MCR03 EZHJ 222 MCR03 EZHJ 472 MCR03 EZHJ 472 NSM3503J400J 0662057A73 0662057A57 0662057A65 0662057A65 N/A Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Hokuriku Rohm Rohm Rohm MCR03 EZHJ 103 MCR03 EZHJ 472 MCR03 EZHJ 100 MCR03 EZHJ 220 MCR03 EZHJ 103 MCR03 EZHJ 101 MCR03 EZHJ 102 MCR03 EZHJ 221 MCR03 EZHJ 101 MCR03 EZHJ 153 MCR03 EZHJ 221 MCR03 EZHJ 104 MCR03 EZHJ 000 MCR03 EZHJ 272 MCR03 EZHJ 152 MCR03 EZHJ 332 MCR03 EZHJ 103 MCR03 EZHJ 103 MCR03 EZHJ 682 MCR03 EZHJ 682 CRA168-472J MCR03 EZHJ 103 MCR03 EZHJ 104 MCR03 EZHF 2203 0662057A73 0662057A65 0662057A01 0662057A09 0662057A73 0662057A25 0662057A49 0662057A33 0662057A25 0662057A77 0662057A33 0662057A97 0662057B47 0662057A59 0662057A53 0662057A61 0662057A73 0662057A73 0662057A69 0662057A69 DSRA508001 0662057A73 0662057A97 N/A N/A Circuit Ref Description Vendor R330 10K ohm Murata R332 R333 R335 R336 R337 R355 R356 R357 R358 R359 R361 R362 R364 R366 R367 R401 R402 R403 R404 R405 R406 R407 R408 R409 R410 R412 R413 R415 R416 R417 R418 R419 R420 R421 R422 R423 R424 R425 R426 R427 R428 R429 R430 R431 R432 R433 R434 R435 R436 100 Kohm; 0.1W; +-1% 100 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 150 Kohm; 0.1W; +-1% NU 4.7 Kohm; 0.1W; +-5% 10 ohm; 0.1W; +-5% 47 ohm;0.1W;+-5% 4.7 Kohm; 0.1W; +-5% 22 Kohm; 0.1W; +-5% 22 Kohm; 0.1W; +-5% 6.8 Kohm; 0.1W; +-5% 470 ohm; 0.1W; +-5% 470 ohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 12 Kohm; 0.1W; +-5% 4.7 Kohm; 0.1W; +-5% 6.8 Kohm; 0.1W; +-5% 0 ohm; 0.1W; +-5% 470 ohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 56 ohm; 0.1W; +-5% 0 ohm; 0.1W; +-5% 150 Kohm; 0.1W; +-5% NU 220 ohm; 0.1W; +-5% 470 ohm; 0.1W; +-5% 56 ohm; 0.1W; +-5% 33 Kohm;0.1W;+-5% 22 Kohm; 0.1W; +-5% 470 ohm; 0.1W; +-5% 100 ohm; 0.1W; +-5% 33 Kohm;0.1W;+-5% 100 Kohm; 0.1W; +-5% NU 22 ohm; 0.1W; +-5% 820 Kohm; 0.1W; +-5% 4.7 Kohm; 0.1W; +-5% 100 ohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 220 ohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 100 ohm; 0.1W; +-5% 2.2 ohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% Vendor Part Number Motorola Equivalent Part Number N/A Rohm Rohm Rohm Rohm Rohm NTH5G16P39A103K07 TH MCR03 EZHF 1003 MCR03 EZHJ 104 MCR03 EZHJ 104 MCR03 EZHJ 104 MCR03 EZHF 1503 Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm MCR03 EZHJ 472 MCR03 EZHJ 100 MCR03 EZHJ 470 MCR03 EZHJ 472 MCR03 EZHJ 223 MCR03 EZHJ 223 MCR03 EZHJ 682 MCR03 EZHJ 471 MCR03 EZHJ 471 MCR03 EZHJ 104 MCR03 EZHJ 104 MCR03 EZHJ 123 MCR03 EZHJ 472 MCR03 EZHJ 682 MCR03 EZHJ 000 MCR03 EZHJ 471 MCR03 EZHJ 104 MCR03 EZHJ 104 MCR03 EZHJ 104 MCR03 EZHJ 560 MCR03 EZHJ 000 MCR03 EZHJ 154 0662057A65 0662057A01 0662057A17 0662057A65 0662057A81 0662057A81 0662057A69 0662057A41 0662057A41 0662057A97 0662057A97 0662057A51 0662057A65 0662057A69 0662057B47 0662057A41 0662057A97 0662057A97 0662057A97 0662057A19 0662057B47 0662057B02 Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm MCR03 EZHJ 221 MCR03 EZHJ 471 MCR03 EZHJ 560 MCR03 EZHJ 333 MCR03 EZHJ 223 MCR03 EZHJ 471 MCR03 EZHJ 101 MCR03 EZHJ 333 MCR03 EZHJ 104 0662057A33 0662057A41 0662057A19 0662057A85 0662057A81 0662057A41 0662057A25 0662057A85 0662057A97 Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm MCR03 EZHJ 220 MCR03 EZHJ 824 MCR03 EZHJ 472 MCR03 EZHJ 101 MCR03 EZHJ 103 MCR03 EZHJ 221 MCR03 EZHJ 103 MCR03 EZHJ 101 MCR03 EZHJ 2R2 MCR03 EZHJ 103 0662057A09 0662057B20 0662057A65 0662057A25 0662057A73 0662057A33 0662057A73 0662057A25 0662057W09 0662057A73 0662057P95 0662057A97 0662057A97 0662057A97 0662057P97 99R85452E01-O 8-31 Circuit Ref R437 R438 R439 R440 R441 R442 R443 R444 R445 R446 R447 R448 R449 R450 R451 R452 R453 R454 R455 R459 R466 R468 R469 R501 R502 R503 R505 R506 R507 R508 R509 R510 R511 R512 R513 R514 R515 R516 R517 R518 R519 R520 R521 R522 R523 R524 R525 R526 R527 R530 R531 99R85452E01-O Description 4.7 Kohm; 0.1W; +-5% 1 Kohm; 0.1W; +-5% 330 ohm; 0.1W; +-5% 22 ohm; 0.1W; +-5% 330 ohm; 0.1W; +-5% 0.1ohm 1W 100 Kohm; 0.1W; +-1% 100 Kohm; 0.1W; +-1% 100 Kohm; 0.1W; +-1% 100 Kohm; 0.1W; +-1% 97.6 Kohm; 0.1W; +-1% 100 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-1% 10 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 33 Kohm;0.1W;+-5% 1 Mohm; 0.1W; +-5% 15 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 3.3 Kohm; 0.1W; +-5% 1 Kohm; 0.1W; +-5% 1 Kohm; 0.1W; +-5% 2.2 Kohm; 0.1W; +-5% 0 ohm; 0.1W; +-5% 47 Kohm; 0.1W; +-5% 2.7 Kohm; 0.1W; +-5% 2.2 Kohm; 0.1W; +-5% 3.3 Kohm; 0.1W; +-5% 1 Kohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 68 Kohm; 0.1W; +-5% 470 Kohm; 0.1W; +-5% 56 Kohm; 0.1W; +-5% 47 Kohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 1 Kohm; 0.1W; +-5% 25.5 Kohm; 0.1W; +-1% 29.4 Kohm; 0.1W; +-1% 15.8 Kohm; 0.1W; +-1% 11.5 Kohm; 0.1W; +-1% 150 Kohm; 0.1W; +-1% 4.22 Kohm; 0.1W; +-1% 715 Kohm; 0.1W; +-1% NU 47 Kohm; 0.1W; +-5% 2.2 Kohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 0 ohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 22 Kohm; 0.1W; +-5% 22 Kohm; 0.1W; +-5% Vendor Vendor Part Number Motorola Equivalent Part Number Rohm Rohm Rohm Rohm Rohm Hokuriku Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm MCR03 EZHJ 472 MCR03 EZHJ 102 MCR03 EZHJ 331 MCR03 EZHJ 220 MCR03 EZHJ 331 LPR1R100FE MCR03 EZHF 1003 MCR03 EZHF 1003 MCR03 EZHF 1003 MCR03 EZHF 1003 MCR03 EZHF 9762 MCR03 EZHJ 104 MCR03 EZHF 1003 MCR03 EZHJ 103 MCR03 EZHJ 104 MCR03 EZHJ 333 MCR03 EZHJ 105 MCR03 EZHJ 153 MCR03 EZHJ 104 MCR03 EZHJ 332 MCR03 EZHJ 102 MCR03 EZHJ 102 MCR03 EZHJ 222 MCR03 EZHJ 000 MCR03 EZHJ 473 MCR03 EZHJ 272 MCR03 EZHJ 222 MCR03 EZHJ 332 MCR03 EZHJ 102 MCR03 EZHJ 103 MCR03 EZHJ 683 MCR03 EZHJ 474 MCR03 EZHJ 563 MCR03 EZHJ 473 MCR03 EZHJ 103 MCR03 EZHJ 102 MCR03 EZHF 2552 MCR03 EZHF 2942 MCR03 EZHF 1582 MCR03 EZHF 1152 MCR03 EZHF 1503 MCR03 EZHF 4221 MCR03 EZHF 7153 0662057A65 0662057A49 0662057A37 0662057A09 0662057A37 N/A 0662057P95 0662057P95 0662057P95 0662057P95 N/A 0662057A97 0662057P95 0662057A73 0662057A97 0662057A85 0662057B22 0662057A77 0662057A97 0662057A61 0662057A49 0662057A49 0662057A57 0662057B47 0662057A89 0662057A59 0662057A57 0662057A61 0662057A49 0662057A73 0662057A93 0662057B14 0662057A91 0662057A89 0662057A73 0662057A49 0662057T92 0662057P29 0662057Z03 0662057Z35 0662057P97 N/A 0662057T99 Rohm Rohm Rohm Rohm Rohm Rohm Rohm MCR03 EZHJ 473 MCR03 EZHJ 222 MCR03 EZHJ 103 MCR03 EZHJ 000 MCR03 EZHJ 103 MCR03 EZHJ 223 MCR03 EZHJ 223 0662057A89 0662057A57 0662057A73 0662057B47 0662057A73 0662057A81 0662057A81 Circuit Ref Description Vendor R532 R534 R535 R536 R537 R538 R539 R540 R541 R542 R543 R544 R545 R546 R547 R548 R549 R550 R551 R560 R561 R563 R564 R565 R566 R567 1.5 Mohm;0.1W;+-5% 330 Kohm; 0.1W; +-5% 2.2 Kohm; 0.1W; +-5% 1 Kohm; 0.1W; +-5% 470 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 22 Kohm; 0.1W; +-5% 22 Kohm; 0.1W; +-5% 22 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 1 Kohm; 0.1W; +-5% 0 ohm; 0.1W; +-5% 5.6 Kohm; 0.1W; +-1% 634 Kohm; 0.1W; +-5% 0 ohm; 0.1W; +-5% 82 Kohm; 0.1W; +-1% 18 Kohm; 0.1W; +-5% 6.8 Kohm; 0.1W; +-5% 10K ohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Murata R568 R569 R570 R571 R601 R602 R604 R605 R606 R607 R608 R609 R610 R611 R612 R615 R616 R617 R620 R621 R622 R625 R626 R627 4.7 Kohm; 0.1W; +-5% 1 Kohm; 0.25W; +-5% 120 Kohm; 0.1W; +-5% 220 Kohm 1 Mohm; 0.1W; +-5% 6.8 Kohm; 0.1W; +-5% 6.8 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 680 Kohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 50K ohm 47 Kohm; 0.1W; +-5% 12 Kohm; 0.1W; +-5% 4.7 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 4.7 Kohm; 0.1W; +-5% 330 Kohm; 0.1W; +-5% 0 ohm; 0.1W; +-5% 18 Kohm; 0.1W; +-5% 18 Kohm; 0.1W; +-5% 680 Kohm; 0.1W; +-5% Rohm Hokuriku Rohm MURATA Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Hokuriku Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Vendor Part Number MCR03 EZHJ 155 MCR03 EZHJ 334 MCR03 EZHJ 222 MCR03 EZHJ 102 MCR03 EZHJ 474 MCR03 EZHJ 104 MCR03 EZHJ 104 MCR03 EZHJ 223 MCR03 EZHJ 223 MCR03 EZHJ 223 MCR03 EZHJ 104 MCR03 EZHJ 104 MCR03 EZHJ 104 MCR03 EZHJ 104 MCR03 EZHJ 104 MCR03 EZHJ 103 MCR03 EZHJ 104 MCR03 EZHJ 102 MCR03 EZHJ 000 MCR03 EZHF 562 MCR03 EZHF 6343 MCR03 EZHJ 000 MCR03 EZHF 8202 MCR03 EZHJ 183 MCR03 EZHJ 682 NTH5G16P39A103K07 TH MCR03 EZHJ 472 CR1/4-102J MCR03 EZHJ 124 NCP18WM224K03RB MCR03 EZHJ 105 MCR03 EZHJ 682 MCR03 EZHJ 682 MCR03 EZHJ 104 MCR03 EZHJ 104 MCR03 EZHJ 104 MCR03 EZHJ 104 MCR03 EZHJ 684 MCR03 EZHJ 103 NSM3503J400J MCR03 EZHJ 473 MCR03 EZHJ 123 MCR03 EZHJ 472 MCR03 EZHJ 104 MCR03 EZHJ 472 MCR03 EZHJ 334 MCR03 EZHJ 000 MCR03 EZHJ 183 MCR03 EZHJ 183 MCR03 EZHJ 684 Motorola Equivalent Part Number N/A 0662057B10 0662057A57 0662057A49 0662057B14 0662057A97 0662057A97 0662057A81 0662057A81 0662057A81 0662057A97 0662057A97 0662057A97 0662057A97 0662057A97 0662057A73 0662057A97 0662057A49 0662057B47 N/A N/A 0662057B47 N/A 0662057A79 0662057A69 N/A 0662057A65 N/A N/A N/A 0662057B22 0662057A69 0662057A69 0662057A97 0662057A97 0662057A97 0662057A97 0662057B18 0662057A73 N/A 0662057A89 0662057A51 0662057A65 0662057A97 0662057A65 0662057B10 0662057B47 0662057A79 0662057A79 0662057B18 August 30, 2002 8-32 Circuit Ref R628 R629 R631 R633 R634 R635 R636 R637 R638 R639 R640 R641 R642 R643 R645 R646 R648 R649 R650 R651 R652 R655 R656 R657 R658 R659 R660 R661 R663 R664 R665 R666 R667 R668 R669 R701 R702 R703 R704 R705 R706 R707 R708 R709 R710 R711 R712 R713 R714 R715 R716 August 30, 2002 Description 0 ohm; 0.1W; +-5% NU NU 18 Kohm; 0.1W; +-5% 470 Kohm; 0.1W; +-5% 1 Mohm; 0.1W; +-5% 0 ohm; 0.1W; +-5% 0 ohm; 0.1W; +-5% 270 Kohm; 0.1W; +-5% 270 Kohm; 0.1W; +-5% 220 Kohm; 0.1W; +-5% 47 Kohm; 0.1W; +-5% 33 Kohm; 0.1W; +-1% 22 Kohm; 0.1W; +-1% 1 Mohm; 0.1W; +-5% 1 Kohm; 0.1W; +-5% 470 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 680 Kohm; 0.1W; +-5% 4.7 Kohm; 0.1W; +-5% 100 ohm; 0.1W; +-5% 0 ohm; 0.1W; +-5% 820 ohm; 0.1W; +-5% 12 Kohm; 0.1W; +-5% NU 10 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 6.8 Kohm; 0.1W; +-5% 1 Mohm; 0.1W; +-5% 68 Kohm; 0.1W; +-5% 330 Kohm; 0.1W; +-5% 1 Kohm; 0.1W; +-5% 0 ohm; 0.1W; +-5% 2.2 Kohm; 0.1W; +-5% 1.5 Kohm; 0.1W; +-5% 330 Kohm; 0.1W; +-5% 47 Kohm; 0.1W; +-5% 22 ohm; 0.1W; +-5% 470 ohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 2.2 Kohm; 0.1W; +-5% 0.27 ohm; 0.125W; +-5% 100 ohm; 0.1W; +-5% 2.2 Kohm; 0.1W; +-5% 1 Kohm; 0.1W; +-5% 2.2 Kohm; 0.1W; +-5% 2.2 Kohm; 0.1W; +-5% 4.7 Kohm; 0.1W; +-5% 0 ohm; 0.1W; +-5% Vendor Vendor Part Number Motorola Equivalent Part Number Rohm MCR03 EZHJ 000 0662057B47 Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm MCR03 EZHJ 183 MCR03 EZHJ 474 MCR03 EZHJ 105 MCR03 EZHJ 000 MCR03 EZHJ 000 MCR03 EZHJ 274 MCR03 EZHJ 274 MCR03 EZHJ 224 MCR03 EZHJ 473 MCR03 EZHF 3302 MCR03 EZHF 2202 MCR03 EZHJ 105 MCR03 EZHJ 102 MCR03 EZHJ 474 MCR03 EZHJ 104 MCR03 EZHJ 104 MCR03 EZHJ 104 MCR03 EZHJ 684 MCR03 EZHJ 472 MCR03 EZHJ 101 MCR03 EZHJ 000 MCR03 EZHJ 821 MCR03 EZHJ 123 0662057A79 0662057B14 0662057B22 0662057B47 0662057B47 NA NA N/A 0662057A89 N/A N/A 0662057B22 0662057A49 0662057B14 0662057A97 0662057A97 0662057A97 0662057B18 0662057A65 0662057A25 0662057B47 0662057A47 0662057A51 Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm MCR03 EZHJ 103 MCR03 EZHJ 104 MCR03 EZHJ 682 MCR03 EZHJ 105 MCR03 EZHJ 683 MCR03 EZHJ 334 MCR03 EZHJ 102 MCR03 EZHJ 000 MCR03 EZHJ 222 MCR03 EZHJ 152 MCR03 EZHJ 334 MCR03 EZHJ 473 MCR03 EZHJ 220 MCR03 EZHJ 471 MCR03 EZHJ 103 MCR03 EZHJ 222 MCR10 EZHJ R27 MCR03 EZHJ 101 MCR03 EZHJ 222 MCR03 EZHJ 102 MCR03 EZHJ 222 MCR03 EZHJ 222 MCR03 EZHJ 472 MCR10 EZH J 000 0662057A73 0662057A97 0662057A69 0662057B22 0662057A93 0662057B10 0662057A49 0662057B47 0662057A57 0662057A53 0662057B10 0662057A89 0662057A09 0662057A41 0662057A73 0662057A57 0662057C02 0662057A25 0662057A57 0662057A49 0662057A57 0662057A57 0662057A65 0662057C01 Circuit Ref R717 R913 R914 R928 R929 R930 R934 R935 RV601 RV602 Description 0 ohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 150 Kohm; 0.1W; +-5% 150 Kohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 1 Kohm; 0.1W; +-5% 4.7 Kohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% Vendor Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Vendor Part Number MCR10 EZH J 000 MCR03 EZHJ 103 MCR03 EZHJ 151 MCR03 EZHJ 151 MCR03 EZHJ 103 MCR03 EZHJ 104 MCR03 EZHJ 102 MCR03 EZHJ 472 MVR22 HXBR N 103 MVR22 HXBR N 103 Motorola Equivalent Part Number 0662057C01 0662057A73 N/A N/A 0662057A73 0662057A97 0662057A49 0662057A65 N/A N/A 99R85452E01-O 8-33 Chapter 8 UHF 435-480 MHz Circuit Board/Schematic Diagrams and Parts List 99R85452E01-O August 30, 2002 8-34 Q118 Q119 C140 Q121 R173 R174 Q114 C171 C139 C138 C137 R169 R177 C129 R182 Q130 C173 C136 R106 R150 R165 R146 R164 R145 R163 R144 R162 R143 R161 R142 R160 R141 R159 R113 R166 R147 C112 Q126 C111 C114 C108 C104 R104 R119 C115 R112 R115 C107 R148 R114 Q101 R102 R176 Q124 Q125 R153 S102 R154 R155 R156 R103 C135 R180 C117 X1C1 Q123 R138 R137 R118 R168 L112 R175 R105 C167 R128 C157 R129 R167 C150 C165 C166 C149 C145 R127 Q127 M101 C105 C156 LC101 R117 C102 C101 R158 C103 R101 C152 C147 R183 C106 C133 C164 C120 C146 C148 Q122 Q120 CN101 C153 C154 R134 C155 R110 Q102 C161 C109 C162 C160 Q105 R136 C159 R121 R120 C110 R170 R126 Q115 C132 R116 R107 C163 C134 C158 R135 C142 C141 R109 R108 Q116 C151 C131 R111 C144 R172 C113 Q117 S101 Top Side C116 C143 R171 Bottom Side Figure 8-18. UHF 435-480 MHz Controller Board August 30, 2002 99R85452E01-O Q418 C440 C439 L415 C441 C444 C445 R417 C443 C442 C432 L416 C413 R404 Q403 C416 R406 C201 C202 Q201 R203 C208 C203 R201 C206 Q204 R212 Q202 R202 Q210 C409 R405 L406 C487 C411 L403 L405 Q404 C215 Q208 L404 R407 C207 C213 Q209 C204 Q206 C711 Q207 C211 C214 C713 C209 R403 C410 C414 R408 Q405 C412 C210 R206 R209 C219 C220 C506 C485 R208 C212 R535 R534 C533 Q203 C721 R204 R570 R505 R207 CN201 C419 L407 R210 Q407 R571 C415 R409 C429 C503 C417 R211 C324 C424 Q406 C205 C420 C323 C421 C425 R410 C371 R442 R364 C505 R503 Q501 C475 R569 Q409 R447 Q410 L427 L414 L419 R445 C438 R443 R449 C489 R446 C497 C466 R444 R418 R466 Q417 C499 R469 L417 C433 Q419 C446 Q211 C217 C532 Q506 R506 C531 R453 C468 R452 R429 L425 C478 R451 C467 C494 L426 R450 R448 R318 C526 R527 L501 C527 C508 C529 R532 Q508 R542 R531 C530 Q507 C447 R711 R367 C469 L411 R315 R316 Q314 Q331 R314 R317 C525 Q316 C369 R454 R430 Q416 C460 C461 R507 Q504 R431 R432 C504 R501 Q315 R320 C319 R355 X501 R541 R436 R434 R437 R366 C337 R526 C519 C318 C317 C470 R438 R356 R321 C546 R433 C462 R359 C343 R357 R336 R310 R319 R530 R537 Q415 R440 C308 R441 L312 R335 Q323 R511 R510 R513 R540 C547 C309 R913 R426 Q413 R502 C502 C516 C517 C513 R311 R428 L424 C464 C463 R435 Q319 R323 C509 R550 L301 C339 C601 C510 R560 R561 C539 C313 R312 R427 C465 R602 Q509 C535 R538 R934 Q614 R605 R601 Q605 C551 Q505 C328 C353 RV602 R657 R620 Q613 C603 C310 Q414 C473 C472 C341 R604 C550 R544 C703 R549 R703 R935 C602 C515 R702 C329 C605 R439 C474 Q308 Q318 R607 R622 Q609 Q503 C719 C604 C644 Q502 C704 R705 Q608 R548 C708 C706 R717 R608 C638 C520 Q701 C622 R609 C636 R641 Q916 C345 C607 R656 C606 R637 R625 C625 C621 C707 R640 R930 Q317 C608 C615 C634 R642 C627 R639 C628 R716 R650 RV601 C522 C645 C617 C626 R668 Q616 R651 R643 R664 R652 C616 C620 C639 C633 C630 Q607 R658 R631 8-35 CD501 Figure 8-19. UHF 435-480 MHz Main Board Top Side 99R85452E01-O August 30, 2002 Q711 Q707 C495 R713 Q408 CN701 C612 C545 R627 C631 R645 C514 C943 R635 R667 R518 R704 R521 R522 Q702 R520 R523 Q511 R546 C541 R536 R545 R547 C540 C542 C524 C528 F501 C701 R519 Q510 R524 R525 F502 R665 R634 C705 C521 R615 R633 R701 C534 C511 R663 C702 R514 C641 R661 C523 R512 R509 R636 R666 C623 C518 R616 C642 C512 Q610 R638 R515 R325 R508 R564 R646 R610 R358 C335 C336 C381 C338 C312 Q320 R516 R563 C635 C924 R617 R517 C367 R565 C629 R660 R648 C932 Q602 X301 R327 R329 R330 R333 C619 C618 R606 Q601 C501 L431 R621 R649 C368 R332 Q615 R655 R313 C919 C350 R362 R626 C637 R611 R368 C342 R361 Q922 C340 R929 L307 C380 C305 R302 C304 R629 C351 L305 C315 L304 C937 C352 R567 R468 L428 L309 R551 R415 F402 R459 Q703 L432 C430 C428 C303 R301 F401 C938 L310 Q617 R628 R612 R654 R337 L409 R659 C320 Q301 C366 L306 Q311 C918 Q322 L313 L303 Q921 L410 R413 L413 R412 C426 C709 C935 R928 C936 C940 R566 C912 L308 Q412 C316 Q303 C301 Q706 C710 R707 R708 R706 Q704 C913 L302 L423 C456 R425 C496 R422 C314 C302 C488 L421 C453 Q302 C311 R423 C448 R421 L422 R242 C427 R712 R709 Q709 Q712 Q705 L702 R710 Q708 SW201 R420 C450 C422 L412 C407 R715 Q710 C720 R455 C408 L402 C401 Q402 R714 C406 C405 C423 C715 R402 L408 C455 C457 C449 R419 L401 C403 C454 R914 C458 C459 C451 Q411 Q401 C404 R401 L420 R205 C717 C402 C493 L430 C751 C492 C437 C491 L418 C436 C752 C435 C218 J701 J401 C714 C718 C716 C498 TP301 8-36 J702 C538 C537 C544 R543 C543 C536 R539 Figure 8-20. UHF 435-480 MHz Main Board Bottom Side August 30, 2002 99R85452E01-O 8-37 Q115 Q116 R107 47 LC101 LCD Q118 TX COM0 COM1 COM2 COM3 SEG0 SEG1 SEG2 SEG3 SEG4 SEG5 SEG6 SEG7 SEG8 SEG9 SEG10 SEG11 SEG12 SEG13 SEG14 SEG15 SEG16 SEG17 SEG18 SEG19 SEG20 SEG21 SEG22 SEG23 SEG24 SEG25 SEG26 SEG27 SEG28 SEG29 SEG30 SEG31 BUSY Q117 Q119 COM3 COM2 COM1 COM0 S0 S1 S2 S3 S4 S5 S6 S7 S8 S9 S10 S11 S12 S13 S14 S15 S16 S17 S18 S19 S20 S21 S22 S23 S24 S25 S26 S27 S28 S29 S30 S31 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 C113 0.001 R109 330 R108 330 C142 0.001 C141 0.001 R171 47K R172 47K S101 S1 S2 S3 S4 S5 S6 S7 S8 S9 S10 S11 S12 S13 S14 S15 S16 S17 S18 S19 S20 S21 S22 S23 C108 0.1 MONI SW R119 0 R111 51K S102 C104 100pF C114 47uF 6.3V (T) Q130 1 2 + C111 47uF 6.3V(T) C112 0.1 C129 0.01 R162 10K Q114 DAC_TX GND MIC SAVE VDD RESET SU AU OUT GND SQL IN RSSI RX/TX UNLOCK PLL_LE DATA CLOCK GND C145 47pF C167 47pF C165 0.001 C150 0.001 C156 0.01 C163 0.001 C151 0.001 C136 Not use R106 0.22u/10 R150 0 22k R120 0 R170 47K C110 0.001 R121 Not use R177 2.2k R175 4.7K R182 0 Q127 C106 R101 0 27p X101 C101 R158 470K R129 1K C102 Not use Q102 OUT IN 4 OUT 2 GND 3 R114 43K C109 0.1 OUT IN 7 OUT 2 GND 3 OUT IN 2 OUT IN 5 OUT IN 8 OUT IN 3 1 4 OUT 2 GND 3 1 4 OUT 2 GND 3 1 4 OUT 2 GND 3 1 4 OUT 2 GND 3 1 4 OUT IN 1 4 OUT 2 GND 3 1 4 OUT IN Q105 1 5 OUT CD 2 Vdd 3 4 GND NC OUT IN 1 OUT 2 GND 3 DOWN OUT IN 6 1 4 OUT 2 GND 3 A 1 4 OUT 2 GND 3 OUT IN 9 1 4 OUT 2 GND 3 B 1 4 OUT 2 GND 3 C C105 0.1 R169 330 R105 10K 1 4 OUT IN R113 22K 1 4 OUT 2 GND 3 C103 Not use OUT IN 1 4 OUT IN * OUT 2 GND 3 R110 51K 8 7 5 D Q122 Q 1 CLK 3 6 Q' CL 2 1 4 OUT IN 0 OUT 2 GND 3 R117 33K R116 18K 1 4 OUT 2 GND 3 OUT IN # 1 4 OUT 2 GND 3 D R118 100K C132 100pF 4 Q120 C133 0.001 9 10 10 9 11 8 12 13 7 14 6 15 VDD IN EST PD STD OSC0 ACK SD OSC1 GND 1 C134 0.01(w/DTMF) R135 10K(w/DTMF) R134 1K(w/DTMF) R136 10K(w/DTMF) 2 3 4 5 16 17 18 19 20 21 22 TP110 TP111 TP113 TP112 TP114 23 24 C171 0.1 25 26 27 Q123 C120 0.001 1 16 2 15 3 14 R126 10K TEMP IN DAC_BAIS R112 13K R102 47K OUT IN UP OUT 2 GND 3 28 4 29 5 30 31 32 R138 10K(w/vox) 33 5 34 R137 1K(w/vox) 35 36 37 38 39 40 3 R154 47K R153 (w/vox) 10K(w/vox) 4 1 2 Q125 R155 Not use C139 0.1 GND DAC_RX C173 1 4 OUT IN C138 0.1 PRO GND 0.01 SH101 SOLDER SHORT C137 0.1 TDC MIC_PTT C107 C131 100pF 8 C147 0.001 Vdd 10K R176 22K R115 130K C152 0.001 Vdd 10K 10K S24 S25 S26 S27 S28 S29 S30 S31 PTT SW 7 C148 0.001 N/W 10K 50 49 48 47 46 45 44 43 42 41 40 39 38 37 36 35 34 33 32 31 30 29 28 27 26 C144 0.001 5 6 C146 0.001 DETECT IN R174 2.2k 5 C164 0.001 DATA0 SQL_MUTE SDA R173 2.2k 6 R166 22pF C159 47pF Vbb Vss 7 R127 12.4k R128 6.98K C158 47pF DTMF IN SCL 4 C154 0.001 MC2 TX_MUTE TEST A2 R163 R164 R165 3 C155 0.001 MC1 2 C161 0.001 VOX IN MOD_COP 1 C160 47pF GND ST_BY DTMF OUT C153 0.001 CN101 C162 0.001 4 A1 8 C149 0.001 3 Vcc C166 47pF 2 A0 C157 0.01 1 R141 20K R142 20K R143 20K R144 20K R145 20K R146 20K R147 20K R148 20K R159 R160 20K R161 10K 10K Q101 L112 C135 2.2uF 6.3V S23 S22 S21 S20 S19 S18 S17 S16 S15 S14 S13 S12 S11 S10 S9 S8 S7 S6 S5 S4 S3 S2 S1 S0 P73 AT-38(8.388608MHz) R180 560k COM0 COM1 COM2 COM3 + R183 47K 3 C117 1uF 6.3V + C116 47uF 6.3V (T) + C115 47uF 6.3V (T) S47 V3 V2 V1 COM0 COM1 COM2 COM3 P30 P31 VSS3 VDD3 P32 P33 P34 P35 P00 P01 P02 P03 P04 P05 P06 P07 P10 R167 47K R168 47K R104 0 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 98 99 100 S46 S45 S44 S43 S42 S41 S40 S39 S38 S37 S36 S35 S34 S33 S32 S31 S30 S29 S28 S27 S26 S25 S24 VSS2 VDD2 75 74 73 72 71 70 69 68 67 66 65 64 63 62 61 60 59 58 57 56 55 54 53 52 51 C143 0.001 P11 P12 P13 TXD P14 RXD P15 P16 P17 RES# XT1 XT2 VSS1 CF1 CF2 VDD1 P80 P81 P82 P83 P84 P85 P86 P87 P70 P71 P72 S0 Q126 M101 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 R103 Not use 13 Q121 12 6 11 7 10 8 9 C140 0.22 R156 47K(w/vox) Q124 TP115 TP116 Figure 8-21. UHF 435-480 MHz Complete Controller Board Schematic Diagram 99R85452E01-O August 30, 2002 5 8-38 11 C537 0.0027 Q505A NJM324V(1/4) 7 C524 0.068 R522 N.U R523 47K Q505D NJM324V(4/4) R548 10K 9 8 R547 10 100K R550 1K 14 13 12 Q504 DTC144EE C546 0.1 P701 WC-013 C716 100p 1 2 R705 22 Q708 R715 4.7K R709 0.27( 1/8W) J701(2/2) 09R80683Z01 2.2K R707 10K + 100K Q319 R708 2.2K Q704 2SA1586GR 1SS355 C711 0.1 C713 0.1 Q703 DTC144EE C718 100p R710 100 L702 390nH(C2012C) C720 0.001 Q710 UDZ S 20B Q712 1SS355 R713 2.2K SP701 SPEAKER Q705 1SR154-400 Q706 UDZ S 6.8B C717 100p R336 1 2 C705 2.2uF/16V C710 0.1 8 C341 0.1 R335 100K C335 10p R325 10K R327 100K C380 Table1 R357 10 C337 Table1 Q322 1SV217 7 C312 10p 6 C313 Not use(R2) 15p(R1) 5 R717 0 J702 53047-0210 5 C719 100p R706 470 9 C715 100p C714 100p 6 C708 0.001 470K C706 0.1 OUT- C709 10u10V(T) 10 R358 47 4 C343 10u10V(T) Q320 UMZ2N Vcc IN- 7 J701(1/2) 09R80683Z01 R716 0 8 R711 2.2K C702 0.001 11 C367 0.0022(R2) 0.001(R1) 3 1 4 R333 100K 5 3 R329 R565 220K 1% 18K 6 2 12 MB15A02 2 3 C336 Table1 C381 Table1 R568 4.7K 1 C319 47p C318 47p 13 C339 0.001 4 IN+ 1.5K R714 Q709 2SA1586GR R323 4.7K x 4 C317 47p 14 2 GND R703 R702 4 R712 1K Q316 UDZ S 7.5B R355 N.U R319 10K R366 470 C324 10u16V(T) R318 10K R367 470 C323 1u16V(T) R317 3.3K R337 150K(1%) 1 X301 14.4MHz R563 0 R567 10k(TH) C329 470p R935 4.7K C328 4.7u16V(T) 15 3 OUT+ 2SA1586GR Q323 Q318 2SC4116GR C345 0.001 C342 100p R362 22K + 16 SVR C703 0.22 Q711 1SR154-400 C338 Table1 C368 1u R368 Not use + R566 6.8K R934 1K Q922 1SV270 R930 100K L307 390nH L310 390nH R361 6.8K(R2) 22K(R1) C350 R929 10K C340 39p(R2) 27p(R1) 0.0015 5p(R2) 6p(R1) Q921 1SV279 C937 C935 4p(R2) 6p(R1) C938 12p(R2) 5p(R1) L309 18n(R2) 22n(R1) C912 0.5p 1 R321 6.8K Q331 2SC4116GR 3 5 + Q315 2SC4116GR R332 100K 1% L312 BLM21A121S R316 1.5K R315 3.3K(R2) 2.7K(R1) R364 15K(R2) 6.8K(R1) C369 0.1u 35V(T) + C371 1u 16V(T) R313 100K C919 Not use R314 0 R330 10K(TH) R564 82k(1%) Q317 UMC4N C352 N.U C936 4p(R2) 6p(R1) R928 150 L308 390nH R356 0 R320 1.5K MO C707 0.001 C701 0.001 C305 0.22 C304 10u16V(T) R301 1K Vout C351 N.U Q311 1SV228 Q314 2SA1586GR R359 4.7K C353 0.001 L305 390nH C940 N.U(R2) 1p(R1) L304 390nH C316 0.001 C315 5p(R2)6p(R1) C913 6p(R2) 7p(R1) R914 150 L302 390nH L301 R311 22nH 15K 390nH C320 0.001 R913 10K R312 220 C310 0.001 L306 2 Q303 2SK508(K52) R704 47K Q702 TDA8541 1 C704 4.7u6.3V(T) 2 1000uH(NL453232) Q916 4 2SJ243 C217 0.1 C214 0.001 Q211 DTA123YE + C211 0.001 Q209 DTC114EE R205 50K(TH) 10K C213 10u10V(T) C212 0.001 R210 22 R204 4.7K R668 1K C309 0.01 0.001 C210 C209 0.001 R208 4.7K R207 10K R211 DTA114EE C218 0.001 C645 22p VB R310 100 R206 2.2K C204 0.01 Q210 2SA1362 R209 10 C541 0.1 6 R545 100K 5 Q707 2SA1313 Q308 2SC5086Y Q208 C208 + 0.01 C207 10u10V(T) CE GND Vout Q302 2SK508(K52) C308 5p 5 3 Vin 1 C220 100p C219 0.001u Q207 UMW1N Q204 XC62HR5002PR 2 NC 1 GND 4 2 THERM C206 0.001 Q203 1SR154-400 BATT C205 0.01 3 R525 10K C544 0.22 R544 100K Q505C NJM324V(3/4) R546 100K 2.2K L303 C918 22n(R2) 27n(R1) 18p C311 1p CN201 09D86237A VB C543 0.0047 1 3 DK Vin C302 0.1 C301 10u10V(T) R202 2.2K + R524 2.2K R549 100K 2 R701 C314 5p Q206 DTA123YE C203 1u16V(T) 5 R203 4.7K C201 0.01 C202 10u10V(T) 3 C521 C522 0.01(ECHU) 0.01(ECHU) C542 390p R543 100K R539 100K C535 0.027 C539 0.039 4 C536 0.047 R538 100K 2 C303 0.022 3 1 L313 + 4 5 6 TI OSC GND + Q419A NJM2904V(1/2) 220 + TP301 + Q503 2SJ144Y C523 0.22 12 R521 715K 1% VB 14 8 C518 0.01(ECHU) 0.01 2% VB R516 29.4K 1% C519 R513 0.01 10K 11 C516 0.01 2% 9 C520 10 7 Q505B NJM324V(2/4) + Q202 UMW1N Q502D NJM324V(4/4) Q701 DTC144EE R201 10K C215 2.2uF/16V 2 Q201 2SB798 R520 4.22K 1% Q502C NJM324V(3/4) R519 150K 1% R514 4 R212 100 R518 11.5K 1% C538 0.01 R302 Q301 TK11816M SW201 TP76N17N 10K.A 1 2 R561 634K 1% R515 25.5K 1% C515 0.01 2% C513 27p 4 R510 470K NJM324V(1/4) C529 0.1 R531 22K C517 6 0.01 2% 5 3.3K VB R537 470K R535 3.9K(R2)2.2k(R1) R542 22K 2 1 Q502A 3 Q502B NJM324V(2/4) 13 2 R512 47K C512 0.0022 C534 2.2u10V(T) R536 680(R2)1k(R1) C510 0.22 C509 0.001 R506 3.3K C533 22p(R2) 56p(R1) R534 150K(R2)330k(R1) Q511 RB521S 56K Q510 NJM2107F VB R517 15.8K 1% C540 0.0015 R503 2.7K CD501 8 220p C531 C528 1u C508 470p 0.1 Q508 DAN235E 3 4 5 R530 22K 68K R511 4 R440 22 R441 330 R439 330 R438 1K R437 4.7K R436 10K R508 10K C511 0.1 R509 R507 1K Q509 DTA144EE Q414 2SC5086Y C470 Q415 5p HSC277 R435 2.2 1 3 4 5 R540 22K ALFYM455F(R2) BLFYM455D(R1) 1 180p(R2) 220p(R1) F502 ALFYM455 H(R2)G(R1) 2 F501 Q416 2SC5086Y 2 R505 2.2K C532 C547 R527 10K Q507 DAN235E 1 C514 0.01 3 5 9 C530 0.1 1 L501 1uH(MLF) 1 3 C527 0.001 R433 10K 220 R432 C526 39p X501 44.645MHz(TOP-B) C462 0.01 R430 100 R431 10K L426 22nH(LL1608) N.U C494 C461 0.001 5p C478 C474 0.001 L425 18nH(LL1608) 4.7K R429 R428 8.2K C473 0.001 0.001 R427 22 Q413 C464 2SC3356(R24) 6p(R2) 8p(R1) C472 R426 Not use(R2)470(R1) C458 15p(R2) 18p(R1) R422 470 C457 R423 100 C456 0.022 1 100K R425 R424 1K L422 0.3-1.0-7T 5p C455 330p C489 0.001 4 2 R541 22K L424 18nH(LL1608) Q418 DTC144EE 1 R454 15K R452 33k R448 100K 0.01 C467 C451 47p(R2) 56p(R1) C454 0.022 C450 C488 N.U 8 3 R451 100K R469 2.2K R446 R445 100K 1% 100K 1% 2 Q412 2SK3475 C459 L423 0.4-0.9-3T 6p(R2) 7p(R1) Not use 3 R466 1K C465 0.001 R453 1M R450 10K 2 C525 33p 4 C463 5p R434 100 5 R444 100K 1% Q417 DTC114EE 0.4-0.9-3T C469 6.8u6.3V(T) 7 C496 L421 18p(R2) 33p(R1) C449 100p C437 150p 27p(R2) 27p(R1) 6 C453 100p Q419B NJM2904V(2/2) C468 0.001 R443 100K 1% L420 R421 22K 0.3-1.0-7T 2 C448 C466 0.001 R447 97.6K 1% C460 5p Q411 2SK3476 3 R449 100K 1% C497 22p L427 ZBFS5105-PT R442 0.1(1/2) R417 220 C446 1u16V C436 Not Use C752 C447 0.0033 27p(R2) 20p(R1) 1 C438 R418 100p 470 4 TA31136FN R526 0 Q501 UMC4N C550 0.01 2% + C485 2.2uF/16V C435 18p(R2) 24p(R1) 0.3-1.0-4T L417 390nH C498 2p(R2) 0.5p(R1) 100p 10p C444 6p(R2) 7p(R1) C445 L416 0.4-1.0-5T C443 C440 10p(R2) 9p(R1) L415 0.4-1.0-5T C475 5p(R2) 6p(R1) R569 1K(1/4W) L414 0.4-1.0-5T C439 100p(R2) 220p(R1) C492 2p(R2) 7p(R1) Q410 MA4PH262 C441 C442 1.5p 1p(R2) 2p(R1) J401 02D04852J L418 C493 L430 0.4-0.8-2T 150p(R2) 150p(R1) C491 15p(R2) 15p(R1) R420 33K R419 56 C433 Not use C432 4p Q409 HVU131 L419 0.4-1.0-5T IFD0455C24E3 C506 0.1 C504 0.1 R501 0 Q506 R532 + C545 33u6.3V(T) R468 1K C505 100p 680K(R2) 1.5M(R1) R551 0 F401 - - - R502 47K C501 100p R570 120k C502 --- 16 Q408 2SC4215Y L408 SMD-0314A C503 0.1 R571 220K(TH) L428 Not use C495 22p L432 1uH --- L431 1uH C430 0.01 1 C428 C427 24p 10p L409 SMD-0314A 4 F402 45N12A5 C426 82p 150nH(C2012C) C425 R412 56 L412 C424 C429 - - - C423 1 6 4 3 20p(R2) 24p(R1) 4 15p 2 1 3 2 7p C422 C420 3p(R2) 9p(R1) Q406 1SV279 L407 0.3-1.0-5T L406 0.3-1.0-5T Q405 1SV279 6 2 L413 470nH(FSLM) L410 L411 15nH(LL2012) 15nH(LL2012) 3 0.01 C419 R410 100K HSMS-2817(B7) C421 9p(R2) 7p(R1) R413 0 R459 3.3K R409 100K Q407 C417 5p(R2) 4p(R1) C412 0.01 C410 100p C415 6p(R2) 10p(R1) R406 0 C416 5p(R2) 6p(R1) L404 180nH(C2012C) 12K R405 6.8K C414 L405 0.3-1.0-7T 7p(R2) 6p(R1) R407 470 Q403 1SS362 R408 100K C413 0.01 R403 --- C407 2p(R2) 5p(R1) L403 Q402 1SV279 L402 0.3-1.0-5T C487 1p(R2) 1.5p(R1) R404 4.7K 100p R402 100K C406 R401 100K C405 N.U C403 N.U Q404 2SC5086Y C408 22p(R2) 22p(R1) C409 0.01 L401 0.3-1.0-5T Q401 1SV279 C402 5p(R2) 4p(R1) C404 6p(R2) 6p(R1) R415 150K + C401 8p(R2) 8p(R1) C411 33p C551 3 0.01 2% 1 R560 5.11K 1% R455 100K R664 6.8K 13 C366 + 14 12 1u16V(T) Q610D NJM324V(4/4) CN701 AXK6S40545J/P 1 2 R660 --- R629 NU 0.1 7 8 C620 0.22u Q607 C619 1SS372-TE85L R631 820K 5 1 2 C617 0.0047 3 4 C639 27p 2 6 3 9 10 11 12 Q617 NJM2107F 13 14 R645 1M 16 17 Q615 DAN222 18 19 20 Q610A NJM324V(1/4) R652 680K 21 22 23 C721 0.001 2 R651 R650 100K 100K C635 0.1 R635 1.5M(R2) 3.3M(R1) Q608 DTC144EE 3 1 R649 100K C634 0.0018 R634 680k(R2) 1.5M(R1) C630 0.015 11 C631 0.0082 68p VB R626 18K VB R661 10K C632 R663 100K 4 NJM324V(2/4) Q614 1SS372 R646 1K 6 R667 1M C616 R625 0.027 18K 15 + 100 Q613 DTA144EE R633 18K RV602 10K.B Q610B R665 1M C643 0.0033u C615 0.01 VB R656 R666 68K 7 R640 R639 270K 180k C627 0.0033u 5 C624 150p R636 0 R638 270K R641 100K C623 0.022u C644 1u VB 1 R658 820 Q602A NJM324V(1/4) R611 50k(TH) C641 0.0012(R2) 0.001(R1) 5 5 C637 0.001u 11 R615 12K RV601 10K.B Q605 C642 DTC144EE 0.022 4 C618 82p Q616 SSM3K03FE R655 4.7K 7 3 Not use C629 1u R628 0 4 1 6 C638 4.7u6.3V(T) Q602C NJM324V(3/4) R612 47k R609 680K VB Q602B NJM324V(2/4) 2 R622 0 Q602D NJM324V(4/4) C605 680p 9 R621 330K R617 100K R616 4.7K C608 R620 4.7K Q601 DTC144EE 10 C607 0.1 R608 100K 8 14 13 R602 6.8K R606 100K R659 12k R607 100K C606 0.047 12 C603 82p R604 6.8K C604 0.0012 R605 100K R610 10K C601 0.1 R601 3.3M C602 0.0033 3 R627 680K R657 0 C612 10p C636 100p 24 25 26 27 28 29 Q609 + R648 470K C621 0.001 9 R642 33K 1% + 10 Q610C NJM324V(3/4) + C622 0.001 C633 0.01 31 32 33 34 35 36 37 R643 22K 1% 8 C628 1u16V(T) C625 4.7u6.3V(T) C626 10u10V(T) VB 30 UMG2N R637 0 38 39 40 Figure 8-22. UHF 435-480 MHz Main Board August 30, 2002 99R85452E01-O 8-39 UHF 435-480 MHz Radio Parts List (Controller Board) Circuit Ref C101 C102 C103 C104 C105 C106 C107 C108 C109 C110 C111 C112 C113 C114 C115 C116 C117 C120 C129 C131 C132 C133 C134 C135 C136 C137 C138 C139 C140 C141 C142 C143 C144 C145 C146 C147 C148 C149 C150 C151 C152 C153 C154 C155 C156 C157 C158 C159 C160 99R85452E01-O Description 22pF; 50V; +-5% NU 10pF; 50V; +-5% 100pF; 50V; +-5% 0.1uF; 16V; +-10% 27pF; 50V; +-5% 0.01uF; 50V; +-10% 0.1uF; 16V; +-10% 0.1uF; 16V; +-10% 0.001uF; 50V; +-10% 47uF;6.3V;+-20% 0.1uF; 16V; +-10% 0.001uF; 50V; +-10% 47uF;6.3V;+-20% 47uF;6.3V;+-20% 47uF;6.3V;+-20% NU 0.001uF; 50V; +-10% 0.01uF; 50V; +-10% 33pF; 50V; +-5% 33pF; 50V; +-5% 0.001uF; 50V; +-10% 0.01uF; 50V; +-10% 2.2pF; 6.3V NU 0.1uF; 16V; +-10% 0.1uF; 16V; +-10% 0.1uF; 16V; +-10% 0.22uF; 10V; +-10% 0.001uF; 50V; +-10% 0.001uF; 50V; +-10% 0.001uF; 50V; +-10% 0.001uF; 50V; +-10% 47pF; 50V; +-5% 0.001uF; 50V; +-10% 0.001uF; 50V; +-10% 0.001uF; 50V; +-10% 0.001uF; 50V; +-10% 0.001uF; 50V; +-10% 0.001uF; 50V; +-10% 0.001uF; 50V; +-10% 0.001uF; 50V; +-10% 0.001uF; 50V; +-10% 0.001uF; 50V; +-10% 0.01uF; 50V; +-10% 0.01uF; 50V; +-10% 47pF; 50V; +-5% 47pF; 50V; +-5% 47pF; 50V; +-5% Vendor Vendor Part Number Circuit Ref Motorola Equivalent Part Number Murata GRM39CH220J50PT 2113740F35 Murata Murata Murata Murata Murata Murata Murata Murata NI-CHEMI Murata Murata NI-CHEMI NI-CHEMI NI-CHEMI GRM39CH100J50PT GRM39CH101J50PT GRM39B104K16PT GRM39CH270J50PT GRM39B103K50PT GRM39B104K16PT GRM39B104K16PT GRM39B102K50PT 6MCM476MB2TER GRM39B104K16PT GRM39B102K50PT 6MCM476MB2TER 6MCM476MB2TER 6MCM476MB2TER N/A 2113740F51 N/A 2113740F37 N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A Murata Murata Murata Murata Murata Murata Murata GRM39B102K50PT GRM39B103K50PT GRM39CH330J50PT GRM39CH330J50PT GRM39B102K50PT GRM39B103K50PT GRM40B225K6.3PT N/A N/A 2113740F39 2113740F39 N/A N/A N/A Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata GRM39B104K16PT GRM39B104K16PT GRM39B104K16PT GRM39B224K10PT GRM39B102K50PT GRM39B102K50PT GRM39B102K50PT GRM39B102K50PT GRM39CH470J50PT GRM39B102K50PT GRM39B102K50PT GRM39B102K50PT GRM39B102K50PT GRM39B102K50PT GRM39B102K50PT GRM39B102K50PT GRM39B102K50PT GRM39B102K50PT GRM39B102K50PT GRM39B103K50PT GRM39B103K50PT GRM39CH470J50PT GRM39CH470J50PT GRM39CH470J50PT N/A N/A N/A 2113928G01 N/A N/A N/A N/A 2113740F43 N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A 2113740F43 2113740F43 2113740F43 C161 C162 C163 C164 C165 C166 C167 C171 C173 C174 C175 C176 C181 C182 C183 C191 CN101 L112 LC101 M101 PB101 Q101 Q102 Q105 Q114 Q115 Q116 Q117 Q118 Q119 Q120 Q121 Q122 Q123 Q124 Q125 Q126 Q127 Q130 Q131 R101 R102 R103 R104 R105 R106 R107 R108 R109 R110 R111 Description 0.001uF; 50V; +-10% 0.001uF; 50V; +-10% 0.001uF; 50V; +-10% 0.01uF; 50V; +-10% 0.001uF; 50V; +-10% 47pF; 50V; +-5% 47pF; 50V; +-5% 0.1uF; 16V; +-10% NU 1uF; 6.3V; +-10% 0.01uF; 50V; +-10% 0.1uF; 16V; +-10% 0.22uF; 10V; +-10% 0.22uF; 10V; +-10% 470pF; 50V; +-5% 0.001uF; 50V; +-10% Connector 10uH LCD Capacitor Microphone CONTROL-PCB CPU Dual NPN IC,CPU Reset IC, EEPROM LED LED NPN Green/Red/Amber Dual NPN IC, DTMF Decoder IC, D/A Converter IC, D Flip-flop PNP NU IC, Op-Amp Single Diode FET Diode 0 ohm; 0.1W; +-5% 47 Kohm; 0.1W; +-5% NU 0 ohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 0 ohm; 0.1W; +-5% 47 ohm; 0.1W; +-5% 330 ohm; 0.1W; +-5% 330 ohm; 0.1W; +-5% 51 Kohm; 0.1W; +-5% 51 Kohm; 0.1W; +-5% Vendor Vendor Part Number Motorola Equivalent Part Number Murata Murata Murata Murata Murata Murata Murata Murata GRM39B102K50PT GRM39B102K50PT GRM39B102K50PT GRM39B103K50PT GRM39B102K50PT GRM39CH470J50PT GRM39CH470J50PT GRM39B104K16PT N/A N/A N/A N/A N/A 2113740F43 2113740F43 N/A Murata Murata Murata Murata Murata Murata Murata Matsushita Taiyo Uden Picvue Bosung Shikibo Sanyo Rohm Rico Seiko El. Citizen Citizen Rohm Rohm Rohm Sanyo Fujitsu Toshiba Rohm GRM39B105K6.3PT GRM39B103K50PT GRM39B104K16PT GRM39B224K10PT GRM39B224K10PT GRM39CH471J50PT GRM39B102K50PT AXK5S40245J/P LEM2520T100J HT138ZAS OB-22P44 K001C802-12 LC87F72C8A UMG2N TR RN5VD30CATR S-24C16AFJ-01 CL-200G-C-TS CL-200G-C-TS DTC114EETL SML-020MLT T86NN UMH6N TR LC73881M MB88347PFV TC7W74FU TE12L DTA144EETL 2113928P04 N/A N/A 2113928G01 2113928G01 N/A N/A DSCN097002 N/A DSLC170003 DSMI505001 N/A DSIC092009 N/A DSIC076007 DSIC510003 N/A N/A N/A 4804810T02 4880439V02 DSIC092007 DSIC042002 DSIC013029 N/A JRC Rohm Rohm Toshiba Toshiba Rohm Rohm NJM2107F (TE1) RB521S-30 TE61 1SS355 TE-17 SSM3K03FE-TE85L 1SS372-TE85L MCR03 EZHJ 000 MCR03 EZHJ 473 DSIC025016 4805656W22 4870360C15 N/A N/A 0662057B47 0662057A89 Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm MCR03 EZHJ 000 MCR03 EZHJ 103 MCR03 EZHJ 000 MCR03 EZHJ 470 MCR03 EZHJ 331 MCR03 EZHJ 331 MCR03 EZHJ 513 MCR03 EZHJ 513 0662057B47 0662057A73 0662057B47 0662057A17 0662057A37 0662057A37 0662057A90 0662057A90 August 30, 2002 8-40 Circuit Ref R112 R113 R114 R115 R116 R117 R118 R119 R120 R121 R126 R127 R128 R129 R134 R135 R136 R137 R138 R141 R142 R143 R144 R145 R146 R147 R148 R150 R153 R154 R155 R156 R157 R158 R159 R160 R161 R162 R163 R164 R165 R166 R167 R168 R169 R170 R171 R172 R173 R174 R175 August 30, 2002 Description 13 Kohm; 0.1W; +-5% 22 Kohm; 0.1W; +-5% 43 Kohm; 0.1W; +-5% 130 Kohm; 0.1W; +-5% 18 Kohm; 0.1W; +-5% 33 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 0 ohm; 0.1W; +-5% 0 ohm; 0.1W; +-5% NU 10 Kohm; 0.1W; +-5% 12.4 Kohm; 0.1W; +-1% 6.98 Kohm; 0.1W; +-1% 1 Kohm; 0.1W; +-5% 1 Kohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 1 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 20 Kohm; 0.1W; +-5% 20 Kohm; 0.1W; +-5% 20 Kohm; 0.1W; +-5% 20 Kohm; 0.1W; +-5% 20 Kohm; 0.1W; +-5% 20 Kohm; 0.1W; +-5% 20 Kohm; 0.1W; +-5% 20 Kohm; 0.1W; +-5% 2.2 Kohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 47 Kohm; 0.1W; +-5% NU 47 Kohm; 0.1W; +-5% 220 Kohm; 0.1W; +-5% 470 Kohm; 0.1W; +-5% 20 Kohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 47 Kohm; 0.1W; +-5% 47 Kohm; 0.1W; +-5% 330 ohm; 0.1W; +-5% 47 Kohm; 0.1W; +-5% 47 Kohm; 0.1W; +-5% 47 Kohm; 0.1W; +-5% 2.2 Kohm; 0.1W; +-5% 2.2 Kohm; 0.1W; +-5% 4.7 Kohm; 0.1W; +-5% Vendor Vendor Part Number Motorola Equivalent Part Number Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm MCR03 EZHJ 133 MCR03 EZHJ 223 MCR03 EZHJ 433 MCR03 EZHJ 134 MCR03 EZHJ 183 MCR03 EZHJ 333 MCR03 EZHJ 104 MCR03 EZHJ 000 MCR03 EZHJ 000 0662057A76 0662057A81 0665027A88 0662257B01 0662057A79 0662057A85 0662057A97 0662057B47 0662057B47 Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm MCR03 EZHJ 103 MCR03 EZHF 1242 MCR03 EZHF 6981 MCR03 EZHJ 102 MCR03 EZHJ 102 MCR03 EZHJ 103 MCR03 EZHJ 103 MCR03 EZHJ 102 MCR03 EZHJ 104 MCR03 EZHJ 203 MCR03 EZHJ 203 MCR03 EZHJ 203 MCR03 EZHJ 203 MCR03 EZHJ 203 MCR03 EZHJ 203 MCR03 EZHJ 203 MCR03 EZHJ 203 MCR03 EZHJ 222 MCR03 EZHJ 103 MCR03 EZHJ 473 0662057A73 0662057P69 0662057Y24 0662057A49 0662057A49 0662057A73 0662057A73 0662057A49 0662057A97 0662057A80 0662057A80 0662057A80 0662057A80 0662057A80 0662057A80 0662057A80 0662057A80 0662057A57 0662057A73 0662057A89 Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm MCR03 EZHJ 473 MCR03 EZHJ 224 MCR03 EZHJ 474 MCR03 EZHJ 203 MCR03 EZHJ 103 MCR03 EZHJ 103 MCR03 EZHJ 103 MCR03 EZHJ 103 MCR03 EZHJ 103 MCR03 EZHJ 103 MCR03 EZHJ 103 MCR03 EZHJ 473 MCR03 EZHJ 473 MCR03 EZHJ 331 MCR03 EZHJ 473 MCR03 EZHJ 473 MCR03 EZHJ 473 MCR03 EZHJ 222 MCR03 EZHJ 222 MCR03 EZHJ 472 0662057A89 N/A 0662057B14 0662057A80 0662057A73 0662057A73 0662057A73 0662057A73 0662057A73 0662057A73 0662057A73 0662057A89 0662057A89 0662057A37 0662057A89 0662057A89 0662057A89 0662057A57 0662057A57 0662057A65 Circuit Ref R176 R177 R180 R182 R183 R184 R185 R186 S101 S102 X101 Description 22 Kohm; 0.1W; +-5% NU 10 Kohm; 0.1W; +-5% 0 ohm; 0.1W; +-5% 47 Kohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 470 ohm; 0.1W; +-5% 0 ohm; 0.1W; +-5% Tact Switch Tact Switch Filter, 8.388608 MHz Vendor Vendor Part Number Motorola Equivalent Part Number Rohm MCR03 EZHJ 223 0662057A81 Rohm Rohm Rohm Rohm Rohm Rohm Motorola Motorola Daishinkuu MCR03 EZHJ 103 MCR10 EZHJ 000 MCR03 EZHJ 473 MCR03 EZHJ 103 MCR03 EZHJ 471 MCR03 EZHJ 000 Y39A33110FP Y39A33110FP AT-38 0662057A73 N/A 0662057A89 0662057A73 0662057A41 0662057B47 4080523Z01 4080523Z01 DSXT182001 99R85452E01-O 8-41 UHF 435-480 MHz Radio Parts List (RF Board) Circuit Ref C201 C202 C203 C204 C205 C206 C207 C208 C209 C210 C211 C212 C213 C214 C215 C217 C218 C219 C220 C301 C302 C303 C304 C305 C306 C307 C308 C309 C310 C311 C312 C314 C315 C316 C317 C318 C319 C320 C323 C324 C328 C329 C335 C336 C337 C338 C339 C340 C341 99R85452E01-O Description 0.01uF; 50V; +-10% 10uF 10V 1uF 16V 0.01uF; 50V; +-10% 0.01uF; 50V; +-10% 0.001uF; 50V; +-10% 10uF 10V 0.01uF; 50V; +-10% 0.001uF; 50V; +-10% 0.001uF; 50V; +-10% 0.001uF; 50V; +-10% 0.001uF; 50V; +-10% 10uF 10V 0.001uF; 50V; +-10% 2.2uF; 16V; +80% -20% 0.1uF; 16V; +-10% 0.001uF; 50V; +-10% 0.001uF; 50V; +-10% 100pF; 50V; +-5% 10uF 10V 0.1uF; 16V; +-10% 0.022uF; 50V; +-10% 10uF; 16V 0.22uF; 10V; +-10% NU NU 5pF; 50V; +-0.25pF 0.01uF; 50V; +-10% 0.001uF; 50V; +-10% 1pF; 50V; +-5% 10pF; 50V; +-0.5pF 3pF; 50V; +-0.25pF 6pF; 50V; +-0.25pF 0.001uF; 50V; +-10% 47pF; 50V; +-5% 47pF; 50V; +-5% 47pF; 50V; +-5% 0.001uF; 50V; +-10% 1uF 16V 10uF; 16V 4.7uF 16V 470pF; 50V; +-10% 10pF 33pF; 50V; +-5% 8pF; 50V ; +-0.5pF 10pF; 50V; +-0.5pF 0.001uF; 50V; +-10% 47pF; 50V; +-5% 0.1uF; 16V; +-10% Vendor Circuit Ref Vendor Part Number Motorola Equivalent Part Number Murata NI-CHEMI NI-CHEMI Murata Murata Murata NI-CHEMI Murata Murata Murata Murata Murata NI-CHEMI Murata Murata Murata Murata Murata Murata NI-CHEMI Murata Murata Ni-Chemi Murata GRM39B103K50PT 10MCM106MATER 16MC105MATER GRM39B103K50PT GRM39B103K50PT GRM39B102K50PT 10MCM106MATER GRM39B103K50PT GRM39B102K50PT GRM39B102K50PT GRM39B102K50PT GRM39B102K50PT 10MCM106MATER GRM39B102K50PT GRM40F225Z16PT GRM39B104K16PT GRM39B102K50PT GRM39B102K50PT GRM39CH101J50PT 10MCM106MATER GRM39B104K16PT GRM39B223K25PT 16MCM106MB2TER GRM39B224K10PT N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A 2113740F51 N/A N/A N/A N/A 2113928G05 Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata NI-CHEMI Ni-Chemi NI-CHEMI Murata Murata Murata Murata Murata Murata Murata Murata GRM39CH050C50PT GRM39B103K50PT GRM39B102K50PT GRM39CK010C50PT GRM39CH100D50PT GRM39CH030C50PT GRM39CH060C50PT GRM39B102K50PT GRM39CH470J50PT GRM39CH470J50PT GRM39CH470J50PT GRM39B102K50PT 16MC105MATER 16MCM106MB2TER 16MCM475MATER GRM39B471K50PT TZV02Z100A110T00 GRM39UJ330J50PT GRM39UJ080D50PT GRM39UJ100D50PT GRM39B102K50PT GRM39CH470J50PT GRM39B104K16PT N/A N/A N/A N/A 2113740F27 2103689A09 N/A N/A 2113740F43 2113740F43 2113740F43 N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A 2113740F43 N/A C342 C343 C345 C347 C350 C351 C352 C353 C366 C367 C368 C369 C371 C380 C381 C401 C402 C403 C404 C405 C406 C407 C408 C409 C410 C411 C412 C413 C414 C415 C416 C417 C419 C420 C421 C422 C423 C424 C425 C426 C427 C428 C429 C430 C432 C433 C435 C436 C437 C438 C439 Description 100pF; 50V; +-5% 10uF 10V 0.001uF; 50V; +-10% 0.001uF; 50V; +-10% 0.0015uF; 50V; +-10% NU 2pF; 50V; +-10% 0.001uF; 50V; +-10% 1uF 16V 0.0022uF; 50V; +-10% 1uF; 6.3V; +-10% 0.1uF; 35V 1uF 16V 9pF; 50V ; +-0.5pF NU 8pF; 50V; +-0.5pF 5pF; 50V; +-0.25pF NU 6pF; 50V; +-0.25pF NU 100pF; 50V; +-5% 2pF; 50V; +-5% 22pF; 50V; +-5% 0.01uF; 50V; +-10% 100pF; 50V; +-5% 33pF; 50V; +-5% 0.01uF; 50V; +-10% 0.01uF; 50V; +-10% 7pF; 50V; +-0.5pF 6pF; 50V; +-0.25pF 5pF; 50V; +-0.25pF 5pF; 50V; +-0.25pF 0.01uF; 50V; +-10% 3pF; 50V; +-0.25pF 9pF; 50V; +-0.5pF 7pF; 50V; +-0.5pF 3pF; 50V; +-0.25pF NU NU 82pF; 50V; +-5% 24pF; 50V; +-5% NU NU 0.01uF; 50V; +-10% 4pF; 50V; +-0.25pF NU 16pF;50V;+-5% NU 27pF; 50V; +-5% 100pF; 50V; +-5% 100pF; 50V; +-5% Vendor Vendor Part Number Motorola Equivalent Part Number Murata NI-CHEMI Murata Murata Murata GRM39CH101J50PT 10MCM106MATER GRM39B102K50PT GRM39B102K50PT GRM39B152K50PT 2113740F51 N/A N/A N/A N/A Murata Murata NI-CHEMI Murata Murata NI-CHEMI NI-CHEMI Murata GRM39CH020C50PT GRM39B102K50PT 16MC105MATER GRM39B222K50PT GRM39B105K6.3PT 35MC104MATER 16MC105MATER GRM39UJ090D50PT N/A N/A N/A N/A 2113928P04 N/A N/A N/A Murata Murata GRM39CH080D50PT GRM39CH050C50PT N/A N/A Murata GRM39CH060C50PT N/A Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata GRM39CH101J50PT GRM39CK020C50PT GRM39CH220J50PT GRM39B103K50PT GRM39CH101J50PT GRM39CH330J50PT GRM39B103K50PT GRM39B103K50PT GRM39CH070D50PT GRM39CH060C50PT GRM39CH050C50PT GRM39CH050C50PT GRM39B103K50PT GRM39CH030C50PT GRM39CH090D50PT GRM39CH070D50PT GRM39CH030C50PT 2113740F51 N/A 2113740F35 N/A 2113740F51 2113740F39 N/A N/A N/A N/A N/A N/A N/A 2103689A09 N/A N/A 2103689A09 Murata Murata GRM39CH820J50PT GRM39CH240J50PT 2113740F49 2113740F36 Murata Murata GRM39B103K50PT GRM39CH040C50PT N/A N/A Murata GRM39CH160J50PT 2113740F32 Murata Murata Murata GRM39CH270J50PT GRM39CH101J50PT GRM39CH101J50PT 2113740F37 2113740F51 2113740F51 August 30, 2002 8-42 Circuit Ref C440 C441 C442 C443 C444 C445 C446 C447 C448 C449 C450 C451 C451 C453 C454 C455 C456 C457 C458 C459 C460 C461 C462 C463 C464 C465 C466 C467 C468 C469 C470 C472 C473 C474 C475 C478 C485 C487 C488 C489 C490 C491 C492 C493 C494 C495 C496 C497 C498 C501 C502 August 30, 2002 Description 10pF; 50V; +-0.5pF 1.5pF; 50V; +-5% 1pF; 50V; +-5% 10pF; 50V; +-0.5pF 6pF; 50V; +-0.25pF 100pF; 50V; +-5% 1uF; 16V; +-10% 0.0033uF; 50V; +-10% 150pF; 50V; +-5% 100pF; 50V; +-5% 47pF; 50V; +-5% 10pF; 50V; +-0.5pF 10pF; 50V; +-0.5pF 100pF; 50V; +-5% 0.022uF; 50V; +-10% 330pF; 50V; +-10% 1uF; 50V; +-10% NU 15pF; 50V; +-5% 6pF; 50V; +-0.25pF 5pF; 50V; +-0.25pF 0.001uF; 50V; +-10% 0.01uF; 50V; +-10% 5pF; 50V; +-0.25pF 6pF; 50V; +-0.25pF NU 0.001uF; 50V; +-10% 0.01uF; 50V; +-10% 0.001uF; 50V; +-10% 6.8uF; 6.3V 5pF; 50V; +-0.25pF 0.001uF; 50V; +-10% 0.001uF; 50V; +-10% 0.001uF; 50V; +-10% 5pF; 50V; +-0.25pF 5pF; 50V; +-0.25pF 2.2uF; 16V; +80% -20% 1pF; 50V; +-5% NU 0.001uF; 50V; +-10% NU 15pF; 50V; +-5% 2pF; 50V; +-10% 150pF; 50V; +-5% 3pF; 50V; +-0.25pF 22pF; 50V; +-5% 18pF; 50V; +-5% 22pF; 50V; +-5% 2pF; 50V; +-10% 100pF; 50V; +-5% NU Vendor Vendor Part Number Motorola Equivalent Part Number Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata GRM39CH100D50PT GRM39CK1R5C50PT GRM39CK010C50PT GRM39CH100D50PT GRM39CH060C50PT GRM39CH101J50PT GRM40B105K16PT GRM39B332K50PT GRM39CH151J50PT GRM39CH101J50PT GRM39CH470J50PT GRM39CH100D50PT GRM39CH100D50PT GRM39CH101J50PT GRM39B223K25PT GRM39B331K50PT GRM39B105K6.3PT 2113740F27 N/A N/A 2113740F27 N/A 2113740F51 N/A 2155169M15 2113740F55 2113740F51 2113740F43 2113740F27 2113740F27 2113740F51 N/A N/A 2113928P04 Murata Murata Murata Murata Murata Murata Murata GRM39CH150J50PT GRM39CH060C50PT GRM39CH050C50PT GRM39B102K50PT GRM39B103K50PT GRM39CH050C50PT GRM39CH060C50PT 2113740F31 N/A N/A N/A N/A N/A N/A Murata Murata Murata NI-CHEMI Murata Murata Murata Murata Murata Murata Murata Murata GRM39B102K50PT GRM39B103K50PT GRM39B102K50PT 6MCS685MATER GRM39CH050C50PT GRM39B102K50PT GRM39B102K50PT GRM39B102K50PT GRM39CH050C50PT GRM39CH050C50PT GRM40F225Z16PT GRM39CK010C50PT N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A Murata GRM39B102K50PT N/A Murata Murata Murata Murata Murata Murata Murata Murata Murata GRM39CH150J50PT GRM39CH020C50PT GRM39CH151J50PT GRM39CH030C50PT GRM39CH220J50PT GRM39CH180J50PT GRM39CH220J50PT GRM39CH020C50PT GRM39CH101J50PT 2113740F31 N/A 2113740F55 2103689A09 2113740F35 2113740F33 2113740F35 N/A 2113740F51 Circuit Ref C503 C504 C505 C506 C508 C509 C510 C511 C512 C513 C514 C515 C516 C517 C518 C519 C520 C521 C522 C523 C524 C525 C526 C527 C528 C529 C530 C531 C532 C533 C534 C535 C536 C537 C538 C539 C540 C541 C542 C543 C544 C545 C546 C547 C550 C551 C601 C602 C603 C604 C605 Description 0.1uF; 16V; +-10% 0.1uF; 16V; +-10% 100pF; 50V; +-5% 0.1uF; 16V; +-10% 470pF; 50V; +-10% 0.001uF; 50V; +-10% 0.22uF; 10V; +-10% 0.1uF; 16V; +-10% 0.0022uF; 50V; +-10% 27pF; 50V; +-5% 0.01uF; 50V; +-10% 0.01uF; 16V; +-2% 0.01uF; 16V; +-2% 0.01uF; 16V; +-2% 0.01uF; 16V; +-2% 0.01uF; 50V; +-10% 0.01uF; 16V; +-2% 0.01uF; 16V; +-2% 0.01uF; 16V; +-2% 0.22uF; 10V; +-10% 0.068uF; 16V; +-10% 33pF; 50V; +-5% 39pF; 50V; +-5% 0.001uF; 50V; +-10% 1uF; 6.3V; +-10% 0.1uF; 16V; +-10% 0.1uF; 16V; +-10% 220pF; 50V; +-10% 220pF; 50V; +-5% 56pF; 50V; +-5% 2.2uF; 10V 0.027uF; 25v; +-10% 0.047uF; 16V; +-10% 0.0027uF; 50V; +-10% 0.01uF; 50V; +-10% 0.039uF; 16v; +-10% 0.0015uF; 50V; +-10% 0.1uF; 16V; +-10% 390pF; 50V; +-10% 0.0047uF; 50V; +-10% 0.22uF; 10V; +-10% 33uF; 6.3V 0.1uF; 16V; +-10% 0.1uF; 16V; +-10% 0.01uF; 16V; +-2% 0.01uF; 16V; +-2% 100pF; 50V; +-5% 0.0033uF; 50V; +-10% 82pF; 50V; +-5% 0.0012uF; 50V; +-10% 680pF; 50V; +10% Vendor Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Panasonic Panasonic Panasonic Panasonic Murata Panasonic Panasonic Panasonic Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata NI-CHEMI Murata Murata Murata Murata Murata Murata Murata Murata Murata Murata NI-CHEMI Murata Murata Panasonic Panasonic Murata Murata Murata Murata Murata Vendor Part Number GRM39B104K16PT GRM39B104K16PT GRM39CH101J50PT GRM39B104K16PT GRM39B471K50PT GRM39B102K50PT GRM39B224K10PT GRM39B104K16PT GRM39B222K50PT GRM39CH270J50PT GRM39B103K50PT ECHU1C103GX5 ECHU1C103GX5 ECHU1C103GX5 ECHU1C103GX5 GRM39B103K50PT ECHU1C103GX5 ECHU1C103GX5 ECHU1C103GX5 GRM39B224K10PT GRM39B683K16PT GRM39CH330J50PT GRM39CH390J50PT GRM39B102K50PT GRM39B105K6.3PT GRM39B104K16PT GRM39B104K16PT GRM39B221K50PT GRM39CH221J50PT GRM39CH560J50PT 10MCS225MATER GRM39B273K25PT GRM39B473K16PT GRM39B272K50PT GRM39B103K50PT GRM39B393K16PT GRM39B152K50PT GRM39B104K16PT GRM39B391K50PT GRM39B472K50PT GRM39B224K10PT 6MCM336MB2TER GRM39B104K16PT GRM39B104K16PT ECHU1C103GX5 ECHU1C103GX5 GRM39CH101J50PT GRM39B332K50PT GRM39CH820J50PT GRM39B122K50PT GRM39B681K50PT Motorola Equivalent Part Number N/A N/A 2113740F51 N/A N/A N/A 2113928G05 N/A N/A 2113740F37 N/A N/A N/A N/A N/A N/A N/A N/A N/A 2113928G05 N/A 2113740F39 2113740F41 N/A 2113928P04 N/A N/A N/A N/A 2113740F45 N/A 2155169N29 N/A N/A N/A N/A N/A N/A 2113741F15 N/A 2113928G05 N/A N/A N/A N/A N/A 2113740F51 2155169M15 2113740F49 N/A N/A 99R85452E01-O 8-43 Circuit Ref C606 C607 C608 C612 C615 C616 C617 C618 C619 C620 C621 C622 C623 C624 C625 C626 C627 C628 C629 C630 C631 C632 C633 C634 C635 C636 C637 C638 C639 C641 C642 C643 C644 C645 C701 C702 C703 C704 C705 C706 C707 C708 C709 C710 C711 C713 C714 C715 C716 C717 C718 99R85452E01-O Description 0.1uF; 16V; +-10% 0.1uF; 16V; +-10% NU 10pF; 50V; +-0.5pF 0.01uF; 50V; +-10% 0.027uF; 25v; +-10% 0.0047uF; 50V; +-10% 82pF; 50V; +-5% 0.1uF; 16V; +-10% NU 0.001uF; 50V; +-10% 0.001uF; 50V; +-10% 0.022uF; 50V; +-10% 150pF; 50V; +-5% 4.7uF; 6.3V 10uF 10V 0.0033uF; 50V; +-10% 1uF 16V 1uF; 6.3V; +-10% 0.015uF; 50V; +-10% 0.0082uF; 50V; +-10% 68pF; 50V; +-5% 0.01uF; 50V; +-10% 0.0018uF; 50V; +-10% 0.1uF; 16V; +-10% 100pF; 50V; +-5% 0.001uF; 50V; +-10% 4.7uF; 6.3V 27pF; 50V; +-5% 0.0012uF; 50V; +-10% 0.022uF; 50V; +-10% 0.0033uF; 50V; +-10% 1uF; 6.3V; +-10% 22pF; 50V; +-5% 0.001uF; 50V; +-10% 0.001uF; 50V; +-10% 0.22uF; 10V; +-10% 4.7uF; 6.3V 2.2uF; 16V; +80% -20% 0.1uF; 16V; +-10% 0.001uF; 50V; +-10% 0.001uF; 50V; +-10% 10uF 10V 0.1uF; 16V; +-10% 0.1uF; 16V; +-10% 0.1uF; 16V; +-10% 100pF; 50V; +-5% 100pF; 50V; +-5% 100pF; 50V; +-5% 100pF; 50V; +-5% 100pF; 50V; +-5% Vendor Vendor Part Number Motorola Equivalent Part Number Murata Murata GRM39B104K16PT GRM39B104K16PT N/A N/A Murata Murata Murata Murata Murata Murata GRM39CH100D50PT GRM39B103K50PT GRM39B273K25PT GRM39B472K50PT GRM39CH820J50PT GRM39B104K16PT 2113740F27 N/A 2155169N29 N/A 2113740F49 N/A Murata Murata Murata Murata NI-CHEMI NI-CHEMI Murata NI-CHEMI Murata Murata Murata Murata Murata Murata Murata Murata Murata NI-CHEMI Murata Murata Murata Murata Murata Murata Murata Murata Murata NI-CHEMI Murata Murata Murata Murata NI-CHEMI Murata Murata Murata Murata Murata Murata Murata Murata GRM39B102K50PT GRM39B102K50PT GRM39B223K25PT GRM39CH151J50PT 6MCS475MATER 10MCM106MATER GRM39B332K50PT 16MC105MATER GRM39B105K6.3PT GRM39B152K50PT GRM39B822K50PT GRM39CH680J50PT GRM39B103K50PT GRM39B182K50PT GRM39B104K16PT GRM39CH101J50PT GRM39B102K50PT 6MCS475MATER GRM39CH270J50PT GRM39B122K50PT GRM39B223K25PT GRM39B332K50PT GRM39B105K6.3PT GRM39CH220J50PT GRM39B102K50PT GRM39B102K50PT GRM39B224K10PT 6MCS475MATER GRM40F225Z16PT GRM39B104K16PT GRM39B102K50PT GRM39B102K50PT 10MCM106MATER GRM39B104K16PT GRM39B104K16PT GRM39B104K16PT GRM39CH101J50PT GRM39CH101J50PT GRM39CH101J50PT GRM39CH101J50PT GRM39CH101J50PT N/A N/A N/A 2113740F55 N/A N/A 2155169M15 N/A 2113928P04 2113932E03 N/A 2113740F47 N/A 2155116E54 N/A 2113740F51 N/A N/A 2113740F37 N/A N/A 2155169M15 2113928P04 2113740F35 N/A N/A 2113928G05 N/A N/A N/A N/A N/A N/A N/A N/A N/A 2113740F51 2113740F51 2113740F51 2113740F51 2113740F51 Circuit Ref Description C719 C720 C721 C752 C912 C913 C917 C918 C919 C935 C936 C937 C938 C939 C940 CD501 CN201 CN701 F401 F402 220pF; 50V; +-5% 0.001uF; 50V; +-10% 0.001uF; 50V; +-10% 20pF;50V;+-5% 1pF; 50V; +-5% 3pF; 50V; +-0.25pF NU 100pF; 50V; +-5% 0.022uF; 50V; +-10% 6pF; 50V; +-0.25pF 6pF; 50V; +-0.25pF 6pF; 50V; +-0.25pF 2pF; 50V; +-10% NU NU Discriminator Connector contact Battery Connector NU Filter , 45.1 MHz F501 F502 J401 J701 J702 L301 L302 L303 L304 L305 L306 L307 L308 L309 L310 L312 L313 L401 L402 L403 L404 L405 L406 L407 L408 L409 L410 L411 L412 L413 Ceramic filter 455Khz Antenna Jack Audio Jack Connector 22nH 390nH 18nH 390nH 390nH 390nH 390nH 390nH 18nH 390nH Chip emifil 1000uH Airwound Coil Airwound Coil NU 180nH Airwound Coil Airwound Coil Airwound Coil Coil Coil 15nH 0 ohm; 0.1W; +-5% 150nH 470nH Vendor Vendor Part Number Motorola Equivalent Part Number Murata Murata Murata Murata Murata Murata GRM39CH221J50PT GRM39B102K50PT GRM39B102K50PT GRM39CH200J50PT GRM39CK010C50PT GRM39CH030C50PT N/A N/A N/A 2113740F34 N/A 2103689A09 Murata Murata Murata Murata Murata Murata GRM39CH101J50PT GRM39B223K25PT GRM39CH060C50PT GRM39CH060C50PT GRM39CH060C50PT GRM39CH020C50PT 2113740F51 N/A N/A N/A N/A N/A Samsung Motorola Matsushita IFD0455C24E03 09D86237A AXK6S40545J/P N/A 0986237A01 DSCN097003 HERTZ DSXF137006 Toko TOKO Motorola Motorola Molex TOKO Sagami Elec Sagami Elec Sagami Elec Sagami Elec Sagami Elec Sagami Elec Sagami Elec Sagami Elec Sagami Elec Murata TDK Uchida/Latest Uchida/Latest 45N12A5 (45.1MHz) UM-5J-SMD BLFYM455D ALFYM455G 02D80689C 09R80683Z 53047-0210 LL1608-FS22NJ C2012C-R39J C2012C-18NG C2012C-R39J C2012C-R39J C2012C-R39J C2012C-R39J C2012C-R39J C2012C-18NG C2012C-R39J BLM21A121SPT NL453232T-102J E2-0.30-1.0-5TL E2-0.30-1.0-5TL N/A N/A 0280689C01 0980683Z01 N/A N/A 2462587V41 N/A 2462587V41 2462587V41 2462587V41 2462587V41 2462587V41 N/A 2462587V41 2480067M02 N/A N/A N/A Sagami Elec Uchida/Latest Uchida/Latest Uchida/Latest Latest Latest TOKO Rohm Sagami Elec Toko C2012C-R15J E2-0.30-1.0-7TL E2-0.30-1.0-5TL E2-0.30-1.0-5TL SMD-0314A SMD-0314A LL2012-FH15NJ MCR10 EZH J 000 C2012C-R15J (150nH) FSLM2520-R47K 2462587V36 N/A N/A N/A N/A N/A N/A 0662057C01 N/A 2485602J33 August 30, 2002 8-44 Circuit Ref L414 L415 L416 L417 L418 L419 L420 L421 L422 L423 L424 L425 L426 L427 L428 L430 L431 L432 L501 L702 P701 PB201 Q201 Q202 Q203 Q204 Q206 Q207 Q208 Q209 Q210 Q211 Q301 Q302 Q303 Q308 Q311 Q314 Q315 Q316 Q317 Q318 Q319 Q320 Q322 Q323 Q331 Q401 Q402 Q403 Q404 August 30, 2002 Description Airwound Coil Airwound Coil Airwound Coil 390nH Airwound Coil Airwound Coil Airwound Coil Airwound Coil Airwound Coil Airwound Coil 18nH 18nH 22nH Chip Beads NU Airwound Coil 1uH 1uH 1uH 390nH SP WIRE Assembly RF-VHF-PCB PNP Digital transistor Single IC PNP Digital transistor PNP Digital transistor PNP PNP IC FET FET NPN Var. Cap. Diode Transistor NPN Zener ;7.6V Digital transistor NPN Single Transistor Var. Cap. Diode IC NPN Var. Cap. Diode Var. Cap. Diode Dual Varactor NPN Vendor Vendor Part Number Motorola Equivalent Part Number Uchida/Latest Uchida/Latest Uchida/Latest Sagami Elec Uchida/Latest Uchida/Latest Uchida/Latest Uchida/Latest Uchida/Latest Uchida/Latest TOKO TOKO TOKO TDK E2-0.40-1.0-5TL E2-0.40-1.0-5TL E2-0.40-1.0-5TL C2012C-R39J E2-0.40-0.8-2TL E2-0.40-1.0-5TL E2-0.30-1.0-7TL E2-0.40-0.9-3TL E2-0.30-1.0-7TL E2-0.40-0.9-3TL LL1608-FS18NJ LL1608-FS18NJ LL1608-FS22NJ ZBFS5105-PT N/A N/A N/A 2462587V41 N/A N/A N/A N/A N/A N/A N/A N/A N/A N/A Uchida/Latest TDK TDK TDK Sagami Elec EU-connector Shikibo NEC Rohm Rohm Torex Rohm Rohm Rohm Rohm Toshiba Rohm TOKO NEC NEC Toshiba Toshiba Toshiba Toshiba Rohm Rohm Toshiba Rohm Rohm Toshiba Fujitsu Toshiba Toshiba Toshiba Toshiba Toshiba E2-0.30-1.0-4TL MLF1608A1R0KT MLF1608A1R0KT MLF1608A1R0KT C2012C-R39J WC-013 K001C803-6 2SB798-T1 DK UMW1N TL 1SR154-400 TE25 XC62HR5002PR DTA123YETL UMW1N TL DTA114EETL DTC114EETL 2SA1362-GR TE85L DTA123YETL TK11816M 2SK508-T1B K52 2SK508-T1B K52 2SC5086-Y TE85L 1SV228-TPH3 2SA1586-GR TE85L 2SC4116-GR TE85L UDZ S 7.5B TE-17 UMC4N TR 2SC4116-GR TE85L 1SS355 TE-17 UMZ2N-TR 1SV217-TPH3 MB15A02PFV1-ER 2SC4116-GR TE85L 1SV279-TPH3 1SV279-TPH3 1SS362-TE85L 2SC5086-Y TE85L 4880048M03 N/A N/A N/A 2462587V41 N/A N/A N/A N/A 4842006M02 DSIC510004 N/A N/A 4808317Y01 N/A N/A N/A DSIC011011 N/A N/A N/A N/A N/A N/A N/A N/A N/A 4870360C15 4809939C06 N/A DSIC042003 N/A N/A N/A N/A N/A Circuit Ref Q405 Q406 Q407 Q408 Q409 Q410 Q411 Q412 Q413 Q414 Q415 Q416 Q417 Q418 Q419 Q420 Q501 Q502 Q503 Q504 Q505 Q506 Q507 Q508 Q509 Q510 Q511 Q601 Q602 Q605 Q607 Q608 Q609 Q610 Q613 Q614 Q615 Q616 Q617 Q701 Q702 Q703 Q704 Q705 Q706 Q707 Q708 Q709 Q710 Q711 Q712 Description Var. Cap. Diode Var. Cap. Diode Diode Transistor Single Diode FET FET NPN NPN Single NPN Digital transistor Digital transistor IC, Op-Amp NU Digital transistor IC, Op-Amp FET Digital transistor IC, Op-Amp IC Dual Dual PNP IC, Op-Amp Diode Digital transistor IC, Op-Amp Digital transistor NU Digital transistor Digital transistor IC, Op-Amp PNP Diode Dual FET IC, Op-Amp Digital transistor IC Digital transistor Transistor Single Zener;6.9V PNP Transistor Transistor Zener;20.39V Single Single Vendor Vendor Part Number Motorola Equivalent Part Number Toshiba Toshiba HP Toshiba Hitachi MA/COM Toshiba Toshiba NEC Toshiba Hitachi Toshiba Rohm Rohm JRC 1SV279-TPH3 1SV279-TPH3 HSMS-2817 2SC4215-Y TE85L HVU131TRF MA4PH262 2SK3476 2SK3475 2SC3356-T1B R24 2SC5086-Y TE85L HSC277TRF 2SC5086-Y TE85L DTC114EETL DTC144EETL NJM2904V(TE1) N/A N/A N/A N/A N/A N/A DSTR013027 DSTR013026 N/A N/A N/A N/A N/A 4880048M03 DSIC510001 Rohm JRC Toshiba Rohm JRC Toshiba Rohm Rohm Rohm JRC Rohm Rohm JRC Rohm UMC4N TR NJM324V(TE1) 2SJ144Y-TE85L DTC144EETL NJM324V(TE1) TA31136FN-TP1 DAN235ETL DAN235ETL DTA144EETL NJM2107F (TE1) RB521S-30 TE61 DTC144EETL NJM324V(TE1) DTC144EETL N/A DSIC510002 N/A 4880048M03 DSIC510002 DSIC013007 N/A N/A N/A DSIC025016 N/A 4880048M03 DSIC510002 4880048M03 Rohm Rohm JRC Rohm Toshiba Rohm Toshiba JRC Rohm Philips Rohm Toshiba Rohm Rohm Toshiba Toshiba Toshiba Rohm Rohm Rohm DTC144EETL UMG2N TR NJM324V(TE1) DTA144EETL 1SS372-TE85L DAN222TL SSM3K03FE-TE85L NJM2107F (TE1) DTC144EETL TDA8541T/N1 DTC144EETL 2SA1586-GR TE85L 1SR154-400 TE25 UDZ S 6.8B TE-17 2SA1313-Y TE85L 2SA1586-GR TE85L 2SA1586-GR TE85L UDZ S 20B TE-17 1SR154-400 TE25 1SS355 TE-17 4880048M03 N/A DSIC510002 N/A N/A 4809606E02 N/A DSIC025016 4880048M03 DSIC174004 4880048M03 N/A 4842006M02 4842006M03 N/A N/A N/A N/A 4842006M02 4870360C15 99R85452E01-O 8-45 Circuit Ref Description Vendor Vendor Part Number Motorola Equivalent Part Number Q916 Q921 Q922 R201 R202 R203 R204 R205 R206 R207 R208 R209 R210 R211 R212 R301 R302 R310 R311 R312 R313 R314 R315 R316 R317 R318 R319 R320 R321 R323 R325 R327 R329 R330 FET Var. Cap. Diode Var. Cap. Diode 10 Kohm; 0.1W; +-5% 2.2 Kohm; 0.1W; +-5% 4.7 Kohm; 0.1W; +-5% 4.7 Kohm; 0.1W; +-5% 50K ohm NU 10 Kohm; 0.1W; +-5% 4.7 Kohm; 0.1W; +-5% 10 ohm; 0.1W; +-5% 22 ohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 100 ohm; 0.1W; +-5% 1 Kohm; 0.1W; +-5% 220 ohm; 0.1W; +-5% 100 ohm; 0.1W; +-5% 15 Kohm; 0.1W; +-5% 220 ohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 0 ohm; 0.1W; +-5% 3.3 Kohm; 0.1W; +-5% 2.7 Kohm; 0.1W; +-5% 3.3 Kohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 6.8 Kohm; 0.1W; +-5% 6.8 Kohm; 0.1W; +-5% Chip network resistor 10 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 220 Kohm; 0.1W; +-1% 10K ohm NEC Toshiba Toshiba Rohm Rohm Rohm Rohm Hokuriku 2SJ243-T1 JDV2S01E-TPH3 1SV270-TPH3 MCR03 EZHJ 103 MCR03 EZHJ 222 MCR03 EZHJ 472 MCR03 EZHJ 472 NSM3503J400J N/A N/A N/A 0662057A73 0662057A57 0662057A65 0662057A65 N/A Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Hokuriku Rohm Rohm Rohm Murata 0662057A73 0662057A65 0662057A01 0662057A09 0662057A73 0662057A25 0662057A49 0662057A33 0662057A25 0662057A77 0662057A33 0662057A97 0662057B47 0662057A61 0662057A59 0662057A61 0662057A73 0662057A73 0662057A69 0662057A69 DSRA508001 0662057A73 0662057A97 N/A N/A R332 R333 R335 R336 R337 R355 R356 R357 R358 R359 R361 R362 R364 R366 R367 R368 100 Kohm; 0.1W; +-1% 100 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 150 Kohm; 0.1W; +-1% NU 4.7 Kohm; 0.1W; +-5% 10 ohm; 0.1W; +-5% 47 ohm;0.1W;+-5% 4.7 Kohm; 0.1W; +-5% 22 Kohm; 0.1W; +-5% 22 Kohm; 0.1W; +-5% 6.8 Kohm; 0.1W; +-5% 470 ohm; 0.1W; +-5% 470 ohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% Rohm Rohm Rohm Rohm Rohm MCR03 EZHJ 103 MCR03 EZHJ 472 MCR03 EZHJ 100 MCR03 EZHJ 220 MCR03 EZHJ 103 MCR03 EZHJ 101 MCR03 EZHJ 102 MCR03 EZHJ 221 MCR03 EZHJ 101 MCR03 EZHJ 153 MCR03 EZHJ 221 MCR03 EZHJ 104 MCR03 EZHJ 000 MCR03 EZHJ 332 MCR03 EZHJ 272 MCR03 EZHJ 332 MCR03 EZHJ 103 MCR03 EZHJ 103 MCR03 EZHJ 682 MCR03 EZHJ 682 CRA168-472J MCR03 EZHJ 103 MCR03 EZHJ 104 MCR03 EZHF 2203 NTH5G16P39A103K07 TH MCR03 EZHF 1003 MCR03 EZHJ 104 MCR03 EZHJ 104 MCR03 EZHJ 104 MCR03 EZHF 1503 Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm MCR03 EZHJ 472 MCR03 EZHJ 100 MCR03 EZHJ 470 MCR03 EZHJ 472 MCR03 EZHJ 223 MCR03 EZHJ 223 MCR03 EZHJ 682 MCR03 EZHJ 471 MCR03 EZHJ 471 MCR03 EZHJ 104 0662057A65 0662057A01 0662057A17 0662057A65 0662057A81 0662057A81 0662057A69 0662057A41 0662057A41 0662057A97 99R85452E01-O 0662057P95 0662057A97 0662057A97 0662057A97 0662057P97 Circuit Ref R401 R402 R403 R404 R405 R406 R407 R408 R409 R410 R412 R413 R415 R416 R417 R418 R419 R420 R421 R422 R423 R424 R425 R426 R427 R428 R429 R430 R431 R432 R433 R434 R435 R436 R437 R438 R439 R440 R441 R442 R443 R444 R445 R446 R447 R448 R449 R450 R451 R452 R453 Description 100 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 12 Kohm; 0.1W; +-5% 4.7 Kohm; 0.1W; +-5% 6.8 Kohm; 0.1W; +-5% 0 ohm; 0.1W; +-5% 470 ohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 56 ohm; 0.1W; +-5% 0 ohm; 0.1W; +-5% 150 Kohm; 0.1W; +-5% NU 220 ohm; 0.1W; +-5% 470 ohm; 0.1W; +-5% 56 ohm; 0.1W; +-5% 33 Kohm;0.1W;+-5% 22 Kohm; 0.1W; +-5% 470 ohm; 0.1W; +-5% 100 ohm; 0.1W; +-5% 1 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% NU 22 ohm; 0.1W; +-5% 820 Kohm; 0.1W; +-5% 4.7 Kohm; 0.1W; +-5% 100 ohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 220 ohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 100 ohm; 0.1W; +-5% 2.2 ohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 4.7 Kohm; 0.1W; +-5% 1 Kohm; 0.1W; +-5% 330 ohm; 0.1W; +-5% 22 ohm; 0.1W; +-5% 330 ohm; 0.1W; +-5% 0.1ohm 1W 100 Kohm; 0.1W; +-1% 100 Kohm; 0.1W; +-1% 100 Kohm; 0.1W; +-1% 100 Kohm; 0.1W; +-1% 97.6 Kohm; 0.1W; +-1% 100 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-1% 10 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 33 Kohm;0.1W;+-5% 1 Mohm; 0.1W; +-5% Vendor Vendor Part Number Motorola Equivalent Part Number Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm MCR03 EZHJ 104 MCR03 EZHJ 104 MCR03 EZHJ 123 MCR03 EZHJ 472 MCR03 EZHJ 682 MCR03 EZHJ 000 MCR03 EZHJ 471 MCR03 EZHJ 104 MCR03 EZHJ 104 MCR03 EZHJ 104 MCR03 EZHJ 560 MCR03 EZHJ 000 MCR03 EZHJ 154 0662057A97 0662057A97 0662057A51 0662057A65 0662057A69 0662057B47 0662057A41 0662057A97 0662057A97 0662057A97 0662057A19 0662057B47 0662057B02 Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm MCR03 EZHJ 221 MCR03 EZHJ 471 MCR03 EZHJ 560 MCR03 EZHJ 333 MCR03 EZHJ 223 MCR03 EZHJ 471 MCR03 EZHJ 101 MCR03 EZHJ 102 MCR03 EZHJ 104 0662057A33 0662057A41 0662057A19 0662057A85 0662057A81 0662057A41 0662057A25 0662057A49 0662057A97 Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Hokuriku Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm MCR03 EZHJ 220 MCR03 EZHJ 824 MCR03 EZHJ 472 MCR03 EZHJ 101 MCR03 EZHJ 103 MCR03 EZHJ 221 MCR03 EZHJ 103 MCR03 EZHJ 101 MCR03 EZHJ 2R2 MCR03 EZHJ 103 MCR03 EZHJ 472 MCR03 EZHJ 102 MCR03 EZHJ 331 MCR03 EZHJ 220 MCR03 EZHJ 331 LPR1R100FE MCR03 EZHF 1003 MCR03 EZHF 1003 MCR03 EZHF 1003 MCR03 EZHF 1003 MCR03 EZHF 9762 MCR03 EZHJ 104 MCR03 EZHF 1003 MCR03 EZHJ 103 MCR03 EZHJ 104 MCR03 EZHJ 333 MCR03 EZHJ 105 0662057A09 0662057B20 0662057A65 0662057A25 0662057A73 0662057A33 0662057A73 0662057A25 0662057W09 0662057A73 0662057A65 0662057A49 0662057A37 0662057A09 0662057A37 N/A 0662057P95 0662057P95 0662057P95 0662057P95 N/A 0662057A97 0662057P95 0662057A73 0662057A97 0662057A85 0662057B22 August 30, 2002 8-46 Circuit Ref R454 R455 R459 R466 R468 R469 R501 R502 R503 R505 R506 R507 R508 R509 R510 R511 R512 R513 R514 R515 R516 R517 R518 R519 R520 R521 R522 R523 R524 R525 R526 R527 R530 R531 R532 R534 R535 R536 R537 R538 R539 R540 R541 R542 R543 R544 R545 R546 R547 R548 R549 August 30, 2002 Description 15 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 3.3 Kohm; 0.1W; +-5% 1 Kohm; 0.1W; +-5% 1 Kohm; 0.1W; +-5% 2.2 Kohm; 0.1W; +-5% 0 ohm; 0.1W; +-5% 47 Kohm; 0.1W; +-5% 2.7 Kohm; 0.1W; +-5% 2.2 Kohm; 0.1W; +-5% 3.3 Kohm; 0.1W; +-5% 1 Kohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 68 Kohm; 0.1W; +-5% 470 Kohm; 0.1W; +-5% 56 Kohm; 0.1W; +-5% 47 Kohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 1 Kohm; 0.1W; +-5% 25.5 Kohm; 0.1W; +-1% 29.4 Kohm; 0.1W; +-1% 15.8 Kohm; 0.1W; +-1% 11.5 Kohm; 0.1W; +-1% 150 Kohm; 0.1W; +-1% 4.22 Kohm; 0.1W; +-1% 715 Kohm; 0.1W; +-1% NU 47 Kohm; 0.1W; +-5% 2.2 Kohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 0 ohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 22 Kohm; 0.1W; +-5% 22 Kohm; 0.1W; +-5% 1.5 Mohm;0.1W;+-5% 330 Kohm; 0.1W; +-5% 2.2 Kohm; 0.1W; +-5% 1 Kohm; 0.1W; +-5% 470 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 22 Kohm; 0.1W; +-5% 22 Kohm; 0.1W; +-5% 22 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% Vendor Vendor Part Number Motorola Equivalent Part Number Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm MCR03 EZHJ 153 MCR03 EZHJ 104 MCR03 EZHJ 332 MCR03 EZHJ 102 MCR03 EZHJ 102 MCR03 EZHJ 222 MCR03 EZHJ 000 MCR03 EZHJ 473 MCR03 EZHJ 272 MCR03 EZHJ 222 MCR03 EZHJ 332 MCR03 EZHJ 102 MCR03 EZHJ 103 MCR03 EZHJ 683 MCR03 EZHJ 474 MCR03 EZHJ 563 MCR03 EZHJ 473 MCR03 EZHJ 103 MCR03 EZHJ 102 MCR03 EZHF 2552 MCR03 EZHF 2942 MCR03 EZHF 1582 MCR03 EZHF 1152 MCR03 EZHF 1503 MCR03 EZHF 4221 MCR03 EZHF 7153 0662057A77 0662057A97 0662057A61 0662057A49 0662057A49 0662057A57 0662057B47 0662057A89 0662057A59 0662057A57 0662057A61 0662057A49 0662057A73 0662057A93 0662057B14 0662057A91 0662057A89 0662057A73 0662057A49 0662057T92 0662057P29 0662057Z03 0662057Z35 0662057P97 N/A 0662057T99 Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm MCR03 EZHJ 473 MCR03 EZHJ 222 MCR03 EZHJ 103 MCR03 EZHJ 000 MCR03 EZHJ 103 MCR03 EZHJ 223 MCR03 EZHJ 223 MCR03 EZHJ 155 MCR03 EZHJ 334 MCR03 EZHJ 222 MCR03 EZHJ 102 MCR03 EZHJ 474 MCR03 EZHJ 104 MCR03 EZHJ 104 MCR03 EZHJ 223 MCR03 EZHJ 223 MCR03 EZHJ 223 MCR03 EZHJ 104 MCR03 EZHJ 104 MCR03 EZHJ 104 MCR03 EZHJ 104 MCR03 EZHJ 104 MCR03 EZHJ 103 MCR03 EZHJ 104 0662057A89 0662057A57 0662057A73 0662057B47 0662057A73 0662057A81 0662057A81 N/A 0662057B10 0662057A57 0662057A49 0662057B14 0662057A97 0662057A97 0662057A81 0662057A81 0662057A81 0662057A97 0662057A97 0662057A97 0662057A97 0662057A97 0662057A73 0662057A97 Circuit Ref Description Vendor R550 R551 R560 R561 R563 R564 R565 R566 R567 1 Kohm; 0.1W; +-5% 0 ohm; 0.1W; +-5% 5.6 Kohm; 0.1W; +-1% 634 Kohm; 0.1W; +-5% 0 ohm; 0.1W; +-5% 82 Kohm; 0.1W; +-1% 18 Kohm; 0.1W; +-5% 6.8 Kohm; 0.1W; +-5% 10K ohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Murata R568 R569 R570 R571 R601 R602 R604 R605 R606 R607 R608 R609 R610 R611 R612 R615 R616 R617 R620 R621 R622 R625 R626 R627 R628 R629 R631 R633 R634 R635 R635 R636 R637 R638 R639 R640 R641 R642 R643 R645 R646 4.7 Kohm; 0.1W; +-5% 1 Kohm; 0.25W; +-5% 120 Kohm; 0.1W; +-5% 220 Kohm 2.2 Mohm;0.1W;+-5% 6.8 Kohm; 0.1W; +-5% 6.8 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 680 Kohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 50K ohm 47 Kohm; 0.1W; +-5% 12 Kohm; 0.1W; +-5% 4.7 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 4.7 Kohm; 0.1W; +-5% 330 Kohm; 0.1W; +-5% 0 ohm; 0.1W; +-5% 18 Kohm; 0.1W; +-5% 18 Kohm; 0.1W; +-5% 680 Kohm; 0.1W; +-5% 0 ohm; 0.1W; +-5% NU NU 18 Kohm; 0.1W; +-5% 680 Kohm; 0.1W; +-5% 1.5 Mohm;0.1W;+-5% 3.3 Mohm;0.1W;+-5% 0 ohm; 0.1W; +-5% 0 ohm; 0.1W; +-5% 270 Kohm; 0.1W; +-5% 270 Kohm; 0.1W; +-5% 180 Kohm;0.1W;+-5% 100 Kohm; 0.1W; +-5% 33 Kohm; 0.1W; +-1% 22 Kohm; 0.1W; +-1% 1 Mohm; 0.1W; +-5% 1 Kohm; 0.1W; +-5% Vendor Part Number Motorola Equivalent Part Number 0662057A49 0662057B47 N/A N/A 0662057B47 N/A 0662057A79 0662057A69 N/A Rohm Hokuriku Rohm MURATA Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Hokuriku Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm MCR03 EZHJ 102 MCR03 EZHJ 000 MCR03 EZHF 562 MCR03 EZHF 6343 MCR03 EZHJ 000 MCR03 EZHF 8202 MCR03 EZHJ 183 MCR03 EZHJ 682 NTH5G16P39A103K07 TH MCR03 EZHJ 472 CR1/4-102J MCR03 EZHJ 124 NCP18WM224K03RB MCR03 EZHJ 225 MCR03 EZHJ 682 MCR03 EZHJ 682 MCR03 EZHJ 104 MCR03 EZHJ 104 MCR03 EZHJ 104 MCR03 EZHJ 104 MCR03 EZHJ 684 MCR03 EZHJ 103 NSM3503J400J MCR03 EZHJ 473 MCR03 EZHJ 123 MCR03 EZHJ 472 MCR03 EZHJ 104 MCR03 EZHJ 472 MCR03 EZHJ 334 MCR03 EZHJ 000 MCR03 EZHJ 183 MCR03 EZHJ 183 MCR03 EZHJ 684 MCR03 EZHJ 000 Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm MCR03 EZHJ 183 MCR03 EZHJ 684 MCR03 EZHJ 155 MCR03 EZHJ 335 MCR03 EZHJ 000 MCR03 EZHJ 000 MCR03 EZHJ 274 MCR03 EZHJ 274 MCR03 EZHJ 184 MCR03 EZHJ 104 MCR03 EZHF 3302 MCR03 EZHF 2202 MCR03 EZHJ 105 MCR03 EZHJ 102 0662057A79 0662057B18 N/A 0662057B34 0662057B47 0662057B47 NA NA N/A 0662057A97 N/A N/A 0662057B22 0662057A49 0662057A65 N/A N/A N/A N/A 0662057A69 0662057A69 0662057A97 0662057A97 0662057A97 0662057A97 0662057B18 0662057A73 N/A 0662057A89 0662057A51 0662057A65 0662057A97 0662057A65 0662057B10 0662057B47 0662057A79 0662057A79 0662057B18 0662057B47 99R85452E01-O 8-47 Circuit Ref R648 R649 R650 R651 R652 R655 R656 R657 R658 R659 R660 R661 R663 R664 R665 R666 R667 R668 R669 R701 R702 R703 R704 R705 R706 R707 R708 R709 R710 R711 R712 R713 R714 R715 R716 R717 R913 R914 R928 R929 R930 R934 R935 RV601 RV602 SP701 SW201 99R85452E01-O Description 470 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 680 Kohm; 0.1W; +-5% 4.7 Kohm; 0.1W; +-5% 100 ohm; 0.1W; +-5% 0 ohm; 0.1W; +-5% 820 ohm; 0.1W; +-5% 12 Kohm; 0.1W; +-5% NU 10 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 6.8 Kohm; 0.1W; +-5% 1 Mohm; 0.1W; +-5% 68 Kohm; 0.1W; +-5% 680 Kohm; 0.1W; +-5% 1 Kohm; 0.1W; +-5% 0 ohm; 0.1W; +-5% 2.2 Kohm; 0.1W; +-5% 1.5 Kohm; 0.1W; +-5% 330 Kohm; 0.1W; +-5% 47 Kohm; 0.1W; +-5% 22 ohm; 0.1W; +-5% 470 ohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 2.2 Kohm; 0.1W; +-5% 0.27 ohm; 0.125W; +-5% 100 ohm; 0.1W; +-5% 2.2 Kohm; 0.1W; +-5% 1 Kohm; 0.1W; +-5% 2.2 Kohm; 0.1W; +-5% 2.2 Kohm; 0.1W; +-5% 4.7 Kohm; 0.1W; +-5% 0 ohm; 0.1W; +-5% 0 ohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 150 Kohm; 0.1W; +-5% 151 Kohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 100 Kohm; 0.1W; +-5% 1 Kohm; 0.1W; +-5% 4.7 Kohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% 10 Kohm; 0.1W; +-5% Speaker Potentiometers Vendor Vendor Part Number Motorola Equivalent Part Number Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm MCR03 EZHJ 474 MCR03 EZHJ 104 MCR03 EZHJ 104 MCR03 EZHJ 104 MCR03 EZHJ 684 MCR03 EZHJ 472 MCR03 EZHJ 101 MCR03 EZHJ 000 MCR03 EZHJ 821 MCR03 EZHJ 123 0662057B14 0662057A97 0662057A97 0662057A97 0662057B18 0662057A65 0662057A25 0662057B47 0662057A47 0662057A51 Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Rohm Orient sound Tocos MCR03 EZHJ 103 MCR03 EZHJ 104 MCR03 EZHJ 682 MCR03 EZHJ 105 MCR03 EZHJ 683 MCR03 EZHJ 684 MCR03 EZHJ 102 MCR03 EZHJ 000 MCR03 EZHJ 222 MCR03 EZHJ 152 MCR03 EZHJ 334 MCR03 EZHJ 473 MCR03 EZHJ 220 MCR03 EZHJ 471 MCR03 EZHJ 103 MCR03 EZHJ 222 MCR10 EZHJ R27 MCR03 EZHJ 101 MCR03 EZHJ 222 MCR03 EZHJ 102 MCR03 EZHJ 222 MCR03 EZHJ 222 MCR03 EZHJ 472 MCR10 EZH J 000 MCR10 EZH J 000 MCR03 EZHJ 103 MCR03 EZHJ 151 MCR03 EZHJ 151 MCR03 EZHJ 103 MCR03 EZHJ 104 MCR03 EZHJ 102 MCR03 EZHJ 472 MVR22 HXBR N 103 MVR22 HXBR N 103 K028NA TP76N17N A10Kohm 10SK 0662057A73 0662057A97 0662057A69 0662057B22 0662057A93 0662057B18 0662057A49 0662057B47 0662057A57 0662057A53 0662057B10 0662057A89 0662057A09 0662057A41 0662057A73 0662057A57 0662057C02 0662057A25 0662057A57 0662057A49 0662057A57 0662057A57 0662057A65 0662057C01 0662057C01 0662057A73 N/A N/A 0662057A73 0662057A97 0662057A49 0662057A65 N/A N/A N/A DSVR010008 Circuit Ref Description Vendor X301 Crystal Nikko Denshi X501 Crystal Nikko Denshi Vendor Part Number TOP-B 14.4MHz RANK-2 TOP-B 44.645MHz +10ppm, +-4ppm Motorola Equivalent Part Number DSXT181002 DSXT181006 August 30, 2002 8-48 This Page Intentionally Left Blank August 30, 2002 99R85452E01-O Glossary of Terms Glossary Term Definition Active Scan State The state when the radio is in Scan Mode, and when the radio is rapidly moving through the Scan List Member channels looking for eligible transmission activity. If BCL is activated, the radio will check for channel activity before transmitting. If activity is detected, transmission is prohibited. For carrier squelch mode, radio will not transmit, if it is receiving carrier. For coded squelch mode, it will not transmit, if it is receiving carrier with different PL/DPL code. An electromagnetic signal that is transmitted on a selected frequency for the purpose of carrying voice or data transmissions along with it. Carrier can then be received by all radios listening on that frequency. When the carrier energy exceeds the carrier energy threshold, known as the Squelch Level, the radio unmutes. Compact Disk. A single path separated by frequency or time divisions used for transmitting and/or receiving voice and/or data. Channel Aliases are radio-user descriptions for the radio’s channels. Alphabets, numbers, spaces, “+”, “-”, and “/” can be used. Examples: EMT-001, 500, SECURITY. The channel spacing when operating on the current channel. Busy Channel Lockout (BCL) Carrier Carrier Squelch (CSQ) CD Channel Channel Alias Channel Bandwidth Channel Enabled Coded Squelch Codeplug Communications Port (COM Port) CPS CSQ CTCSS When selected, the channel is enabled and accessible. When the channel receives incoming message that contains the same PL or DPL code as its Rx PL/DPL code, the radio unmutes. A solid-state chip inside a radio where the radio’s personality data is stored. A serial hardware interface connection at the back of a computer used to communicate with other hardware devices, such as radios, modems, and printers. Also known as a Serial Port. COM Ports are designated by slot positions such as Port1, Port2, Port3, Port4. When programming a radio, the computer is connected to the radio with a RIB cable via the COM port. The computer’s CPS Com Port settings are independent of each other and apply to the Read and Write features. Acronym for Customer Programming Software. Licensed Motorola software used to program two-way radios with a unique set of features. Carrier Squelch. Acronym for Continuous Tone Coded Squelch System. A generic term for sub-audible tone/ code used to create communications groups. Also see PL. Glossary-2 Term Definition Digital Private Line (DPL) DPL is a digital format transmitted along with the carrier. DPL allows for more use and privacy on a frequency. DPL is transmitted at a sub-audible (not able to be heard) frequency. Digital Private-Line™ Dual-Tone Multi-frequency. A Signaling System protocol widely used in the telephone industry. Two tones are transmitted simultaneously at different amplitudes for each keypad key press. A sequential series of Dual Tones makes a data word. DTMF Tx Tone Duration is the amount of time that a DTMF tone is transmitted for a single digit. Once this Tx Tone Duration ends, the DTMF Tx Tone Interval begins, and vice-versa. DTMF Tx Tone Interval is the amount of time that the radio waits between DTMF digits. Once Tx Tone Interval ends, the DTMF Tx Tone Duration begins, and vice-versa. Electronically Erasable/Programmable Read-Only Memory: used by the radio to store its personality. Software, or a software/hardware combination of computer programs and data, with a fixed logic configuration stores in a read-only memory. Information cannot be altered or reprogrammed. Frequency Generation Unit. (a) The location of the center of a channel of operation in the radio spectrum. Measured in Megahertz (MHz). (b) A computer speed. Measured in Megahertz (MHz). Hardware potentiometer for adjustment of parameter settings. The channel where scan is started. When the radio is in Scan Mode, and once Active Scan finds an eligible Scan List Member channel/call to receive or unmute to, the radio is then in Landed Scan State. Also, once both Transmit and Receive activity has ceased, and while the Scan Hang Timer is counting down, the radio is still in Landed Scan Mode. The most recent version number of codeplug information that was loaded into the radio. This is stored in the radio’s codeplug. Liquid Crystal Display: a module used to display the radio’s current operating channel info or status message. Function that is invoked if the button is pressed and released after one second. The lower limit that VFO will scan. DPL DTMF DTMF Tx Tone Duration DTMF Tx Tone Interval EEPROM Firmware FGU Frequency Hard Pot Home Channel Landed Scan State Latest Codeplug Version LCD Long Press Function Lower Scan Frequency Maximum Frequency August 30, 2002 The highest frequency setting at which the radio is allowed to operate. The radio’s frequency range is defined as being between, or equal to, the Minimum and Maximum frequencies. This information is stored in the radio’s codeplug. 99R85452E01-O Glossary-3 Term Definition Minimum Frequency The lowest frequency setting at which the radio is allowed to operate. The radio’s frequency range is defined as being between, or equal to, the Minimum and Maximum frequencies. This information is stored in the radio’s codeplug. The model number identifies the type of radio. This information is stored in the radio’s codeplug. For Normal Scan, the radio assigns equal priority to all members in the Scan List selected for the current channel. When the radio is scanning a Scan List (Active Scan), all scan list members (including the Home Channel) will be allocated equal time to be scanned. For example, if the Home Channel is H1, and the Scan List Members are Nn, then the scanning sequence is: N1, N2, N3, ..., H1, N1, N2, ..., etc. If Tx Offset is set to Positive, this frequency will be added to the VFO Rx Frequency when radio is transmitting. It will be subtracted from the VFO Rx Frequency if Tx Offset is set to Negative. The first version number of codeplug information that was loaded into the radio. This is stored in the radio’s codeplug. Printed Circuit Board. The 16 digit Access Code for establishing connection to a telephone line and subsequent dial tone. The 16 digit De-access Code for disconnecting from a phone call. Model Number Normal Scan Offset Frequency Original Codeplug Version PC Board Phone Access Code Phone De-access Code Phone List PL PLL Pretime Priority Scan 99R85452E01-O A list of phone numbers (up to nine phone numbers) that can be preprogrammed into the radios. Each phone number can contain 16 characters made up by alphabets (A, B, C, D), numbers (0-9), spaces, “#” and “*”. Private-Line® tone squelch: a continuous sub-audible tone that is transmitted along with the carrier. Phase-Locked Loop: a circuit in which an oscillator is kept in phase with a reference, usually after passing through a frequency divider. Selects the amount of time between PTT button press and the first digit of ID transmission. This time allows the receiving radio to stabilize before receiving data. For Priority Scan, the radio assigns the highest priority to the first member in the Scan List selected for the current channel. When the radio is scanning a Scan List (Active Scan), 50% of the scans are targeted at the Priority #1 Member channel. For example, if the Priority #1 Member is P1, and the non-priority Scan List Members are Nn, then the scanning sequence is: P1, N1, P1, N2, P1, N3, P1, N4, P1, N5, etc. August 30, 2002 Glossary-4 Term Definition Priority #1 Scan List Member The first member in the current Scan List. When the radio is scanning a Scan List (Active Scan), 50% of the scans are targeted at the Priority #1 Member channel. Example: If the Priority #1 Member is P1, and the non-priority Scan List Members are Nn, then the scanning sequence is: P1 N1, P1 N2, P1 N3, P1 N4, P1 N5, etc. Note: When the radio’s speaker is unmuted to a non-priority call (Landed Scan mode), the radio continues to mute at a specific time interval (the Scan Interval Time), and scan for transmission activity on the Priority #1 Member channel. If the radio discovers a valid Priority #1 transmission, it drops the current transmission, and unmutes to the Priority #1 call. Priority Scan has to be enabled (per channel) for this feature to function. The amount of time that the radio will stay idle in another channel before reverting back to the Prime Channel. A sub-audible tone/code used to create unique/private communication groups while operating in Conventional Dispatch mode. A generic term for Tone Private Line (TPL), or Digital Private Line (DPL). The transfer of CPS information from the computer’s temporary memory (RAM) to the radio. Push-To-Talk: the switch located on the left side of the radio which, when pressed, causes the radio to transmit. If PTT ID is activated for the channel, then PTT ID will be sent following the PTT ID Transmission Type. PTT Short Sidetone causes the radio to sound one short alert tone, after the PTT button is pressed, and immediately following the ID being transmitted. The purpose is to indicate to the radio-user when voice may be initiated. A temporary storage space used by a computer to operate a software program currently running. Anything stored in RAM is lost when the computer is turned off. Short-term data-storage circuits within the microcontroller. Remote transmit/receive facility that retransmits received signals to improve communications coverage. Reset line: an input to the microcontroller that restarts execution. Radio Frequency Power Amplifier. Used to connect a personal computer to a radio for the purpose of communication between the two. The RIB consists of level-shifting circuits that convert from the standard RS-232 voltage levels of the computer asynchronous serial interface (COM Port) to the single-ended voltage levels present on the Serial Bus contacts of the radio’s connector. The RIB must have an appropriate RIB-to-radio and RIB-to-computer Radio Interface Cable for communication and radio programming to occur. A designated frequency used when receiving carrier for the current channel. Prime Channel Return Hang Time Private Line (PL) Program PTT PTT ID Select PTT Short Sidetone Random Access Memory (RAM) Registers Repeater RESET RF PA Radio Interface Box (RIB) Receive Frequency August 30, 2002 99R85452E01-O Glossary-5 Term Definition Reverse Burst / Turn Off Code Causes a Tone Private Line (TPL) or Digital Private Line (DPL) code to be transmitted at the end of a transmission - once PTT is released, and while operating on the current channel. This sub-audible tone causes the receiving radio to mute its speaker before loss of a carrier is detected. Muting the speaker eliminates unwanted noise (squelch tail) during loss of carrier detection. Read Only Memory. Received Signal-Strength Indicator: a dc voltage proportional to the received RF signal strength. Repeater/Talk-Around. The specific code accepted when receiving Digital Private Line (DPL) encoding, while operating on the current channel. Setting Rx DPL Invert causes Digital Private Line (DPL) signals to be inverted when they are received by the radio, while operating on the current channel. Inverted coding allows for more traffic/usage on frequencies. A designated frequency used when receiving Tone Private Line (TPL), while operating on the current channel. This frequency can directly correlate to the Rx TPL Code field; however, non standard code frequencies may also be selected. The Scan List determines which channels the radio scans, when operating in the Scan Mode, on the current channel. The Scan List allows you to select the grouping of channels that make up the current Scan List Member channels. This grouping of Scan List Member channels can then be scanned for transmission activity - one at a time, when the radio is in Scan Mode. A Scan List can have a maximum of 16 Scan List Members. Scan List Member scanning priority is definable. A Scan List can be assigned to a channel. Three Scan Lists are available. A Scan List can be assigned to more than one channel. When the radio is in one of the two Scan States: Active Scan and Landed Scan. This mode is initiated when the programmable SCAN button is pressed. There are two types of scanning available on the current Conventional Personality: Normal Scan or Priority Scan. Each radio has its own unique serial number. This information is stored in the radio’s codeplug. Function that is invoked if the button is pressed and released within one second. Software Potentiometer: a computer-adjustable electronic attenuator. Computer programs, procedures, rules, documentation, and data pertaining to the operation of a system. Muting of audio circuits when received signal levels fall below a predetermined value. ROM RSSI RPT/TA Rx DPL Code Rx DPL Invert Rx TPL Frequency Scan List Scan List Member Scan Mode Scan Type Serial Number Short Press Function Softpot Software Squelch 99R85452E01-O August 30, 2002 Glossary-6 Term Definition Squelch Level The amount of carrier energy required to unmute the radio’s speaker upon satisfying the selected Carrier Squelch threshold. Low level allows more transmissions with less clarity to unmute the radio’s speaker. High level increases the squelch threshold causing a stronger carrier signal to be required before the radio’s speaker will unmute. This helps to reduce unwanted noise. Transmitted when the receiving radio is to only receive calls from radios with specific TPL codes, this creates communications groups while operating in Conventional Dispatch mode. TPL allows for more use and privacy on a frequency. TPL is transmitted at a sub-audible (not able to be heard) frequency. Also known as CTCSS. Time-Out Timer: a timer that limits the length of a transmission. Tone Private-line. The Digital Private Line (DPL) code that transmits while operating on the current channel. Setting Tx DPL Invert causes Digital Private Line (DPL) signals to be inverted before they are transmitted from the radio, while operating on the current channel. Inverted coding allows for more traffic/usage on frequencies. A designated frequency used when transmitting carrier for the current channel. The offset that will be added to the VFO Rx Frequency when radio transmits in VFO mode. Available options are: None (transmits using Rx Frequency), Pos (transmits using Rx Frequency + Offset Frequency), Neg (transmits using Rx Frequency - Offset Frequency), User (transmits using the User Defined Tx Frequency). The transmit power level while operating on the current channel. High: Used when a stronger signal is needed to extend transmission distances. Low: Used when communicating in close proximity, and to keep the radio from transmitting into other geographical groups operating on the same frequency. Economy Low: Used when communicating distance is close, e.g., within the same warehouse, stadium, etc. A designated frequency used to transmit Tone Private Line (TPL) encoding, while operating on the current channel. This frequency can directly correlate to the Tx TPL Code field; however, non standard code frequencies may also be selected. Microcontroller. Ultra High Frequency. A radio unmutes, when it opens its speaker to receive audio. Microprocessor. The upper limit that VFO will scan. Tone Private Line (TPL) TOT TPL Tx DPL Code Tx DPL Invert Tx Frequency Tx Offset Tx Power Tx TPL Frequency µC UHF Unmuting µP Upper Scan Frequency August 30, 2002 99R85452E01-O Glossary-7 Term Definition User Defined PL Frequency VCO You can customize up to three non standard PL frequencies to provide more choices for PL. Voltage-Controlled Oscillator: an oscillator whereby the frequency of oscillation can be varied by changing a control voltage. Variable Frequency Operation. The radio user chooses frequencies instead of preprogrammed channels to operate the radio. Radio scans the preprogrammed frequency range defined by VFO Upper Scan Frequency and Lower Scan Frequency in the increment defined by Frequency Step Size. Very High Frequency. Voltage Standing Wave Ratio. VFO VFO Scan VHF VSWR 99R85452E01-O August 30, 2002 Glossary-8 This Page Intentionally Left Blank August 30, 2002 99R85452E01-O Motorola, Inc. 8000 West Sunrise Boulevard Ft. Lauderdale, FL 33322 MOTOROLA and the Stylized M Logo are registered in the U.S. Patent and Trademark Office. All other product or service names are the property of their respective owners. © Motorola, Inc. 2002. All rights reserved. Printed in U.S.A. *9985452E01* 99R85452E01-O