No category

Download service manual personal audio system

Transcript

ZS-D5
SERVICE MANUAL
US Model
Canadian Model
AEP Model
UK Model
E Model
Ver 1.3 2000.2
With SUPPLEMENT (9-923-270-82)
CD
Model Name Using Similar Mechanism New
Section
Optical Pick-up Name
Tape deck
Model Name Using Similar Mechanism PMC-303
Section
Tape Transport Mechanism Type
KSM-213CDM/M-S
MF-D55-144
SPECIFICATIONS
AUDIO POWER SPECIFICATIONS
POWER OUTPUT AND TOTAL
HARMONIC DISTORTION
With 3-ohm load, both channel driven from
150 - 15,000 Hz; rated 3 W per channelminimum RAM power, with no more than
10 % total harmonic distortion in AC
operation.
Other Specifications
CD player section
System
Compact disc digital audio system
Laser diode properties Material: GaALAs
Wave length : 780 nm
Emission duration: Continuous
Laser output: Less than 44.6 µW (This output is
the value measured at a distance of about 200 mm
from the objective lens surface on the optical
pick-up block with 7 mm aperture.)
Spindle speed
200 r/min (rpm) to 500 r/min (rpm) (CLV)
Number of channels 2
Frequency response
20 - 20,000 Hz +0/-1dB
Wow and flutter
Below measurable limit
Radio section
Frequency range
US, Canadian
AEP, UK, E
Aerials
MICROFILM
FM: 87.6 - 108 MHz
AM: 530 - 1,710 kHz
FM: 87.5 - 108 MHz (Italy)
FM: 87.6 - 107 MHz (Other countries)
MW: 531 - 1,602 kHz
LW: 153 - 279 kHz
FM: Telescopic aerial
AM: Built-in ferrite bar aerial
Cassette-corder section
Recording system
4-track 2 channel stereo
Fast winding time
Approx. 120s (sec.) with Sony cassette C-60
Frequency response
TYPE1 (normal): 50 - 15,000 Hz
General
Speaker
Full range: 8 cm (3 1/4in.) dia., 3 Ω,
cone type x 2
Input
LINE IN jack (stereo minijack)
Minimum input level 250 mV
Outputs
Headphones jack (stereo minijack)
For 16 - 68 Ω impedance headphones
LINE OUT jack (stereo minijack)
Rated output level 250 mV at load impedance
47 kΩ
OPTICAL DIGITAL OUT (CD) (optical output
connector)
Wavelength: 630 - 690 nm
Power output (excluding U.S. model)
4.5 W + 4.5 W (3 ohms at 10 % harmonic
distortion in DC operation)
Power requirements
For personal component system:
120 V AC, 60 Hz
12 V DC, 8 size D (R20) batteries
For memory back-up:
6 V DC, 4 size AA (R6) batteries
For remote commander:
3 V DC, 2 size AA (R6) batteries
Power consumption
AC 25 W
— Continued on next page —
PERSONAL AUDIO SYSTEM
TABLE OF CONTENTS
SAFETY CHECK-OUT
1. SERVICE NOTE ............................................................... 3
After correcting the original service problem, perform the
following safety checks before releasing the set to the customer:
Check the antenna terminals, metal trim, “metallized” knobs, screws,
and all other exposed metal parts for AC leakage. Check leakage as
described below.
2. GENERAL .......................................................................... 4
3. DISASSEMBLY
3-1.
3-2.
3-3.
3-4.
3-5.
3-6.
Front Cabinet Assy ........................................................... 12
Mechanisum Assy ............................................................. 13
Control Board, Lump Board, H/P Board .......................... 14
CD Block Assyt, Handole ................................................ 14
Main Board, Optical Pick up ............................................ 15
Tuner Board, Power Board, Rear Cabinet ........................ 15
4. TEST MODE ..................................................................... 16
LEAKAGE
The AC leakage from any exposed metal part to earth ground
and from all exposed metal parts to any exposed metal part having
a return to chassis, must not exceed 0.5 mA (500 microamperes).
Leakage current can be measured by any one of three methods.
5. MECHANICAL ADJUSTMENTS ............................. 16
1.
A commercial leakage tester, such as the Simpson 229 or RCA
WT-540A. Follow the manufacturers’ instructions to use these
instruments.
2.
A battery-operated AC milliammeter. The Data Precision 245
digital multimeter is suitable for this job.
3.
Measuring the voltage drop across a resistor by means of a
VOM or battery-operated AC voltmeter. The “limit” indication
is 0.75 V, so analog meters must have an accurate low-voltage
scale. The Simpson 250 and Sanwa SH-63Trd are examples of
a passive VOM that is suitable. Nearly all battery operated
digital multimeters that have a 2V AC range are suitable. (See
Fig. A)
6. ELECTRICAL ADJUSTMENTS ............................... 17
7. DIAGRAMS
7-1.
7-2.
7-3.
7-4.
7-5.
7-6.
7-7.
7-8.
7-9.
7-10.
7-11.
7-12.
7-13.
7-14.
7-15.
7-16.
7-17.
7-18.
Circuit Boards Location ................................................... 20
Brock Diagrams – Tuner/CD Section – ........................... 21
Brock Diagrams – TC Section – ...................................... 23
Printed Wiring Board —Main Section — ........................ 26
Schematic Diagram —Main Section (1/2) — .................. 29
Schematic Diagram —Mainl Section (2/2) — ................. 32
Printed Wiring Board —Power Section — ...................... 35
Schematic Diagram —Power Section — ......................... 37
Printed Wiring Board —Control/Switch Section — ........ 39
Schematic Diagram —Control/Switch Section — ........... 43
Printed Wiring Board
—Tuner Section (US, CND model) — ............................ 45
Schematic Diagram
—Tuner Section (US, CND model) — ............................ 47
Schematic Diagram
—Tuner Section (AEP, IT, UK, E model) — ................... 50
Printed Wiring Board
—Tuner Section (AEP, IT, UK, E model) — ................... 53
Schematic Diagram —TC Section — .............................. 55
Printed Wiring Board —TC Section — ........................... 57
IC Pin Function ................................................................ 58
IC Brock Diagrams ........................................................... 60
To Exposed Metal
Parts on Set
8. EXPLODED VIEWS
8-1.
8-2.
8-3.
8-4.
8-5.
8-6.
0.15 µF
Cabinet Section ................................................................. 64
Rear Cabinet Section ........................................................ 65
CD Mechanism (KSM-213CDM/M-S) ............................ 66
Optical Pick up ................................................................. 67
Cassette Mechanism Deck Section-1 (MF-D55-144) ...... 68
Cassette Mechanism Deck Section-2 (MF-D55-144) ...... 69
1.5 kΩ
AC
Voltmeter
(0.75 V)
Earth Ground
9. ELECTRICAL PARTS LIST ........................................ 70
Fig. A. Using an AC voltmeter to check AC leakage.
Battery life
For CD radio cassette-corder
FM recording
Sony R20P: approx. 6 h
Sony alkaline LR20: approx. 12h
Tape playback
Sony R20P: approx. 3h
Sony alkaline LR20: approx. 6h
CD playback
Sony R20P: approx. 1.5 h
Sony alkaline LR20: approx. 3h
Dimmensions (incl. projecting parts)
Approx. 416 x 198.5 x 246 mm (w/h/d)
(16 1/2 x 7 7/8 x 9 3/4 inches)
Mass (incl. batteries) Approx. 5.2 kg (11 lb. 7 oz)
Supplied accessories AC power cord (1)
Remote commander (1)
Design and specifications are subject to change without notice.
SAFETY-RELATED COMPONENT WARNING!!
COMPONENTS IDENTIFIED BY MARK ! OR DOTTED LINE WITH
MARK ! ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS
LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE
COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS
APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS
PUBLISHED BY SONY.
ATTENTION AU COMPOSANT AYANT RAPPORT
À LA SÉCURITÉ!
LES COMPOSANTS IDENTIFÉS PAR UNE MARQUE ! SUR LES
DIAGRAMMES SCHÉMATIQUES ET LA LISTE DES PIÈCES SONT
CRITIQUES POUR LA SÉCURITÉ DE FONCTIONNEMENT. NE
REMPLACER CES COMPOSANTS QUE PAR DES PIÈSES SONY
DONT LES NUMÉROS SONT DONNÉS DANS CE MANUEL OU
DANS LES SUPPÉMENTS PUBLIÉS PAR SONY.
—2—
SECTION 1
SERVICING NOTE
NOTES ON HANDLING THE OPTICAL PICK-UP
BLOCK OR BASE UNIT
The laser component in this product is
capable of emitting radiation exceeding the
limit for Class 1.
The laser diode in the optical pick-up block may suffer electrostatic
breakdown because of the potential difference generated by the
charged electrostatic load, etc. on clothing and the human body.
During repair, pay attention to electrostatic breakdown and also use
the procedure in the printed matter which is included in the repair
parts.
The flexible board is easily damaged and should be handled with
care.
This appliance is classified as a CLASS 1
LASER product. The CLASS 1 LASER
PRODUCT MARKING is located on the rear
exterior.
NOTES ON LASER DIODE EMISSION CHECK
The laser beam on this model is concentrated so as to be focused on
the disc reflective surface by the objective lens in the optical pickup block. Therefore, when checking the laser diode emission,
observe from more than 30 cm away from the objective lens.
The following caution label is located inside the
unit.
CHUCK PLATE JIG ON REPAIRING
On repairing CD section, playing a disc without the CD lid, use
Chuck Plate Jig.
• Code number of Chuck Plate Jig : X-4918-255-1
CAUTION
Use of controls or adjustments or performance of procedures
other than those specified herein may result in hazardous radiation
exposure.
LASER DIODE AND FOCUS SEARCH OPERATION
CHECK
1.
2.
3.
4.
Press CD open knob.
Open the lid for CD.
Push on SWITCH as following figure.
Confirm the laser diode emission while observing the objecting
lens. When there is no emission, Auto Power Control circuit or
Optical Pick-up is broken.
Objective lens moves up and down once for the focus search.
Insert a precision screw driver
and push SWITCH
—3—
SECTION 2
GENERAL
This section is extracted
from instruction manual.
LOCATION OF PARTS AND CONTROLS
12345678
@™
@¡
@º
!•
!§
9
!ª
!¡
!¶
!º
!™
!∞
!¢
1
2
3
4
5
6
7
8
9
0
!¡
!£
MEGA BASS button
SOUND button
STANDBY button
SLEEP button
CLOCK button
PROGRAM AUTO
PRESET CHECK button
MODE MONO/ST ISS button
CANSEL button
VOL button
EDIT button
DISPLAY ENTER button
!™
!£
!¢
!∞
!§
!¶
!•
!ª
@º
@¡
@™
TUNE/TIME SET button
MD (LINE) button
OPTICAL DIGITAL OUT (CD)
r/P button
COUNTER RESET button
DIR MODE button
TIMER button
Remote sensor
OPR/BATT lamp
POWER button
2
@£
@∞
@¢
@§
@¶
@§ TAPE buttons
@¶ PUSH OPEN/CLOSE (CASSETTE)
@£ PUSH OPEN/CLOSE (CD)
@¢ CD button
@∞ RADIO buttons
—4—
—5—
—6—
—7—
—8—
—9—
— 10 —
— 11 —
SECTION 3
DISASSEMBLY
ZS-D5
FRONT CABINET ASSY
CD BLOCK ASSY, HANDLE
MECHANISM DECK ASSY
MAIN BOARD,
OPTICAL PICK UP
CONTROL BOARD, LAMP BOARD, H/P BOARD
TUNER BOARD, POWER BOARD, REAR CABINET
Note : Follow the disassembly procedure in the numerical order given.
3-1.
FRONT CABINET ASSY
6 Front cabinet assy
3 Connector(CN306)
4 Connector (CN801)
2 Screws
(+BVTP 3 ×12)
2 Screws
(+BVTP 3 ×12)
5 Rear cabinet assy
1 Battery lid
2 Screws
(+BVTP 3 ×12)
— 12 —
3-2.
MECHANISM ASSY
Rear cabinet assy
9 Screws
(+BVTP 3 ×10)
!£ MD chassis
!º TC board
2 Connector (CN301)
8 Connector
(CN402)
!™ MF-D55-144
9 Screws
(+BVTP 3 ×10)
!¡ Screws
(+BVTP 3 ×10)
5 Connector (CN401)
4 Connector (CN442)
3 Connector (CN441)
1 Screw
(+BVTP 3 ×10)
7 Terminal board
6 Screws
(+BVTP 2.6 ×10)
— 13 —
3-3.
CONTROL BOARD, LAMP BOARD, H/P BOARD
Rear cabinet assy
0 H/P board
8 Connector (CN305)
9 Screw
(+BVTP 3 ×10)
7 LANB board
5 Screws
(+BVTP 2.6 ×10)
6 Connector (CN804)
2 Connector (CN802)
3 Screws
(+BVTP 2.6 × 10)
4 CONTROL board
1 Connector (CN803)
3-4.
CD BLOCK ASSY, HANDLE
1 Screws
(+BVTP 3 ×10)
2 CD block assy
4 Handle
3 Screws
(+BVTP 3 ×10)
— 14 —
3-5.
MAIN BOARD, OPTICAL PICK UP
4 Screws
(+BVTP 3 ×10)
4 Screws (+BVTP 3 ×10)
5 MAIN board
1 Connector (CN701)
2 Connector
(CNP703)
Optical pick up
KSM-213CDM
3 Connector
(POSH SWITCH)
CD chassis
3-6. TUNER BOARD, POWER BOARD, REAR CABINET
7 Connector (CN904)
0 Rear cabinet
3 Screws (+BVTP 3 ×10)
5 TU cassis
4 TUNER board
2 Connector (CN1)
8 Screws
(+BVTP 3 ×10)
6 Connector (CN901)
1 Screws (+BVTP 3 ×10)
9 POWER board
8 Screws
(+BVTP 3 ×10)
— 15 —
SECTION 4
TEST MODE
SECTION 5
MECHANICAL ADJUSTMENT
1. HOW TO ENTER THE TEST MODE
PRECAUTION
1.
Turn on the main power. While the machine is in the CD STOP
state, short-circuit JW824 and JW825 on the SWITCH board once.
(Turn off the main power to exit the test mode.)
[SWITCH Board] – Soldering Side –
2.
3.
4.
Clean the following parts with a denatured-alchool-moistened
swab:
record/playback head
pinch roller
erase head
rubber belts
capstans
Do not use a magnetized screwdriver for the adjustments.
After the adjustments, apply suitable locking compound to the
parts adjusted.
The adjustments should be performed with the raged power
supply voltage unless otherwise noted.
Torque Measurement
Mode
Torque Meter
FWD
FWD
back tension
JW825 JW824
2. RF Level and Jitter Check
• Measurement Point
MAIN board (see page 9)
Vref (JW126) and RF Signal (JW135)
(Confirm by oscilloscope)
REV
REW
back tension
FF • REW
• Procedure
(1) Press the CD key → Press the DISPLAY ENTER MEMORY
key.
(2) Confirm that display on LCD changes as follows.
F–
–F
CHECK
CQ-102RC
CQ-201B
Torque Meter
ALL
88 88
FWD
CQ-403A
REV
CQ-403R
(Indication that automatic adjustment is completed)
(3) Press the EDIT key. (APC OFF)
36 to 61 g•cm
(0.504 to 0.854 oz•inch)
2 to 6 g•cm
(0.028 to 0.084 oz•inch)
36 to 61 g•cm
(0.504 to 0.854 oz•inch)
2 to 6 g•cm
(0.028 to 0.084 oz•inch)
61 to 143 g•cm
(0.854 to 2.002 oz•inch)
Tape Tension Measurement
Mode
CHECK
CQ-102C
Meter Reading
88 88 The display ALL disappears.
(4) Confirm that jitter is 9.0 ns or less. Confirm also that the
RF level is from 0.9 to 1.3 Vp-p.
0.9 to 1.3 Vp-p
0V
3. Traverse Signal Check
• Measurement Point:
MAIN board (see page 9)
Vref (JW126) and TE Signal (IC701 pin $¶)
(Confirm by oscilloscope)
• Procedure
(1) Press the = or + key.
(2) Check that the traverse level is from 0.3 to 0.5 Vp-p.
A=B
A+B=
0.3 to 0.5 Vp-p
— 16 —
Meter Reading
more than 100 g•cm
(more than 1.38 oz • inch)
more than 100 g•cm
(more than 1.38 oz • inch)
ZS-D5
SECTION 6
ELECTRICAL ADJUSTMENT
PRECAUTION
1. Perform adjustments in the test mode.
2. Demagnetize the record/playback head with a head
demagnetizer.
3. Do not use a magnetized screwdriver for the adjustments.
4. After the adjustments, apply suitable locking compound to the
parts adjust.
5. The adjustments should be performed with the rated power
supply voltage unless otherwise noted.
6. The adjustments should be performed in the order given in this
service manual. (As a general rule, playback circuit adjustment
should be completed before performing recording circuit
adjustment.)
7. The adjustments should be performed for both L-CH and RCH.
•
Standard Record:
Deliver the standard input signal level to the input jack and set the
VOLUME +/– keys to obtain the standard input and output signal
level.
•
within
1dB
output
level
Screw
position
R-CH
peak
Put the lead-wire antenna
close to the set.
+
LINE OUT
L-CH
peak
Screw
position
R-CH
peak
3.
3. Phase Check
Mode: REV playback
oscilloscope
H.P OUT
32
0.10 V (-18 dB)
FM
Tracking
• FM section
H
L4: AM Reception
Frequency coverage
22.5 kHz frequency
deviation by 400 Hz
signal
47 kΩ
[AEP/IT/UK/E model]
Output level: as low as possible
Oscilloscope Lissajous pattern
Test Tape
P-4-A100
WS-48A
in phase
Signal
Used for
REC/PB/ERASE Head azimuth
10 kHz, -10 dB
and phase adjustment.
3 kHz, 0 dB
Tape speed adjustment
TAPE RECODER SECTION
0 dB = 0.775V
Record/Playback Head Azimuth Adjustment
Note: • Start adjustment after head has changed the direction.
(When head is positioned in the FWD direction of tape
running, start adjustment with REV .)
• The adjustment must be ended with cw turning of
adjustment screw.
45°
good
LW Tracking
VTVM
90°
135°
CT5
4. Repeat steps 1 to 3 FWD playback mode.
5. Check that phase difference between L-CH and R-CH is from o
to 90 degrees.
6. After the adjustments, apply suitable locking compound to the
pats adjusted.
HEADPHONES
•
Repeat the proceduresin each adjustment several times for the
maximum level meter indication.
The frequency coverage and tracking adjustments should be
finally done by the trimmer capacitors.
•
(
CT3: LW Reception
Frequency
Coverage
CT1
FM
Tracking
L1
IC701
JW135
) : US/Canadian model
JW126
MW/AM RECEPTION FREQUENCY COVERAGE CHECK
531 kHz
1,611 kHz
Frequency indication
(530 kHz)
(1,710 kHZ)
Digital voltmeter reading
Adjustment Location:
Adjustment
0.6 to 1.2 V
(0.9 to 1.0 V)
L4
4.5 to 5.5 V
(5.2 to 6.2 V)
check
L2: FM Reception
Frequency Coverage
LW RECEPTION FREQUENCY COVERAGE CHECK
Frequency indication
151 kHz
273 kHz
Digital voltmeter reading
0.6 to 0.7 V
4.7 to 5.7 V
Adjustment
CT3
check
level meter
47
kΩ
+
–
Adjustment screw
(FWD)
LINE OUT
— 17 —
Adjustment screw
(REV)
(
) : US/Canadian model
MW/AM TRACKING ADJUSTMENT
Adjust for a maximum defection of level meter.
L3
CT2
621 kHz (620 kHz)
1,404 kHz (1,400 kHz)
— 18 —
CT2
L4
MW Reception
Frequency Coverage
AEP/Italian/UK/E model
test tape
P-4-A100
(10KHz, –10dB)
CT4 L3 (MW)
–
wrong
Note: Adjustment must be completed by cw turning of adjustment
screw.
After the adjustment, lock the screws with locking
compound.
L3 (LW)
MW Tracking
+
set
180°
Procedure:
1. Mode : REV playback
set
CT1
Measurement Point: MAIN board (Side B)
LINE
Test tape
CT2
FM RF SSG
32 Ω
•
L3
L1
to FM RF (FM IN)
L-CH
AM Tracking
FM RECEPTION FREQUENCY COVERAGE CHECK
Frequency indication
87.5 MHz
108 MHz
Digital voltmeter reading
0.9 to 1.3 V
3.4 to 4.4 V
Adjustment
L2
check
FM TRACKING ADJUSTMENT
Adjust for a maximum defection of level meter.
L1
CT1
87.5 MHz
108 MHz
Output level: as low as possible
set
Standard output level
L2: FM Reception
Frequency coverage
30% amplitude
modulation by
400 Hz signal
Playback the standard tape in FWD mode.
Adjust the variable resistor of the motor (M691) until frequency
counter reading is from 2,985 to 3,015 Hz.
Confirm that the freqency difference between the tape top and
end is within 3 %.
47 kΩ
V
10 kΩ
0.25 V (–9.8 dB)
1.
2.
[US/CND Model]
• AM Section
–
R-CH
SP OUT (L, R)
3.2
0.775 V (0 dB)
LW TRACKING ADJUSTMENT
Adjust for a maximum defection of level meter.
L3
CT5
162 kHz
261kHz
AM RF SSG
set
Adjustment Location: TUNER board (Side A)
AEP/Italian/UK/E model
0 dB = 1µV
frequency counter
100 kΩ
LINE IN
Output Pin
Load impedance
Output signal level
TUNER SECTION
[Setting during adjustment]
Function mode: RADIO
VOLUME: Maximum
within
1dB
L-CH
peak
Standard input level
Input Pin
Tape Speed Adjustment
Procedure:
Mode : FWD playback
test tape
WS-48B
(3 kHz, 0 dB)
test tape P-4-A100
(100 kHz, –10 dB)
Signal source impedance
Input signal level
•
2. Turn the adjustment screw and check output peaks. If the peaks
do not match for L-CH and R-CH, turn the adjustment screw
so that outputs match within 1dB of peak.
— 19 —
ZS-D5
7-2.
BLOCK DIAGRAM
— TUNER/CD SECTION —
CIRCUIT BOARD LOCATION
AU7.5V
CF3
FM/AM FRONT-END
IC1
ANT1
FM
TELESCOPIC
ANTENNA
CF4
9
13
CD MOTOR board
5
VCC1 VCC2
Q23(AEP,IT,UK,E)
Q18(US,CND)
FL1
B.P.F
1
L1
MAIN board
22
VCO
QUAD
AU7.5V
23
FM RF I
MIX OUT
FM
MIX
CF1
3
CF2
RF IF
AMP
6
FM IF
FM
DET
FM RF O
FM/AM
BUFFER
CFT1
D1
7
AM IF
MPX
17
FM
MPX
16
L-CH
11
MUTE
12
A
TO
TC SECTION
R-CH
AM
DET
ST IND
FM OSC
BAND
PLL
14
IC2(AEP,IT,UK,E)
Q12(AEP,IT,
IC3(US,CND)
UK,E)
Q3(US,CND)
15
D2
L2
AEP,IT,UK,E Model
L3
FERRITE-ROD
ANTENNA
L3
FERRITE-ROD
ANTENNA
24
Q1
BUFFER
Q13
PD1
24
AM RF
19
17 FM
AM
MIX
P1
16 AM
D5
AU7.5V
Q5
LAMP board
18 VDD
22
Q4
22
AM OSC
AM
OSC
AM OSC
MUTE
SWITCH Q18
Q10(AEP,IT,
UK,E)
Q2(US,CND)
CD 7
DA 6
PLL
L.P.F
Q21
21 PD1
CK
5
CE 4
Q19(US,CND)
Q14(AEP,IT,UK,E)
TC board
+B
TU7.5V
H FREQ
CUT
AEP,IT,UK,E
Q11(AEP,IT,UK,E)
Q4(US,CND)
2 XI
Q3
LW-H
8
Q9(AEP,IT,UK,E)
Q1(US,CND)
IF 14
X1
75kHz
Q13(AEP,IT,UK,E)
Q17(US,CND)
US,CND Model
Q6
AU7.5V
1 XO
AU7.5V
MW-H Q22
P0
Q16
MUTE
AU7.5V
9
TU5V
Q2
Q15
MUTE
18
D3
IC 1
SW board
OSC
AM RF
10
IF
BUFFER
FM
OSC
MO/ST
CONTROL board
21
PD1
MW-H
Q22
INV.
10 MW-L
LW-H
INV.
11 LW-L
CD
Q17(AEP,IT,UK,E)
Q15(US,CND)
DA
CK
TU5V
CE
Q21
TERMINAL board
AEP,IT,UK,E Model
OPTICAL PICK-UP
BLOCK
(KSM-213CDM/M-S)
CD5V
CD5V
CD RF/SERVO
PROSSESOR
IC701
VCC
18
CD5V
PCMD
PD1
33
44
27
23
24
14
25
13
RF
SERIAL/
PARALLEL
CONVERTER
DECODER
F
F
41
Q701
LD
LD/POWER
CONTROL
36
F
DATA
TTL
IIL
LD
XLT
CLK
XRST
LOCK
15
21
16
37
PD
FOCUS PHASE
COMPENSATION
CN
SE
SUB CODE
PROSSESOR
CLV
SERVO
B
TO
TC SECTION
R-CH
XTAI 89
DAT
CPU I/F
CLK
17
23
100 XRST
19
29
22
XTAO 90
XLT
20
18
PD
95
L-CH
X701
22
COMAND
APC
AR
84
FOK
26
27
GND
PWM
AL
LOCK
MDP
DIGITAL
CLV
XLON
SPOA
TRACKING PHASE
COMPENSATION
9 75
SYSM
TTL
SENS 2
73
PWM
SERIAL
I/F
10 11 12 7
8
6
5
8 11
12 9
1
7
B MUTE
FE
AMP
SENS 1
72
SENS
E
51
SCOR
42
55
50
C SCOR
E
53
54
SQSO
IIL
E
52
C SENSE1
FOK
C OUT
CLOCK
PD2
D
SQCK
39
D
EMPH
EFM
DEMO.
XLAT
RFO
B
B
BCK
LRCK
C CLK
RF
AMP
C
DATA
38
D/A
I/F
C
BATTERY(S)board
1 D IN
C XLAT
H/P board
71
3 GND
51 VC
A
BATTERY(L)board
D OUT
VCC
VC
A
POWER board
IC441
2 VDD
CD DIGITAL
SIGNAL PROCESSOR
IC702
C DATA
80
VR
F/T COIL
SL/SP MOTOR
DRIVER
IC703
TEO
13
SLO
16
10 F+
F IN 11
F
9 F
21 R ST
T+
TRACKING
COIL
7
T+
T IN 4
T
16
6
CD
DA
T
CK
SWITCH board
CE
TUNER board
M702
SLED
MOTOR
25 R CONT
:CD
:DIGITAL OUT
24 R CE
IC801(1/2)
SYSTEM CONTROL
13 C SENSE2
22 SP+
SP IN 25
M
21 SP
MUTE 15
S701
LIMIT
— 20 —
— 21 —
• R-CH:Same as L-CH
• Abbreviation
4 C XRST
M701
SPINDOL
MOTOR
:FM
22 R CLK
SL IN 29
27 SL
• SIGNAL PATH
23 R DATA
28 SL+
M
C SQSO
F+
FOCUS
COIL
FEO
6
C SQCK
7-1.
SECTION 7
DIAGRAMS
— 22 —
CND
: Canadian
IT
: Italian
OPTICAL
DIGITAL
OUT
ZS-D5
— TC SECTION —
LINE AMP
IC305
5
J441
LINE IN
Q105
Q103
MUTE
CONTROL
A
B
LINE OUT
• SIGNAL PATH
:FM
MUTE
PB/REC
FUNCTION
IC401
Q320,329
FROM
TUNER/CD
SECTION
J442
R-CH
7
Q107
R-CH
SOUND/VOLUME
IC302
4
TU L
22
CD L
24
Q104
6
7
8
Q106
MUTE
CONTROL
MUTE
D441
:CD
S441
LINE
:PB (MD)
TAPE
L
20
9
VR
2
12
TAPE
D304
:LINE
J301
R-CH
MATRIX
SURROUND
2
:REC (MD)
POWER AMP
IC304
TONE
LINE
Q321
CD/LINE
CONTROL
5
Q326,327
RADIO
PHONES
• R-CH :Same as L-CH
STBY
17 LINE/TUNER
12
5
D303
CD5V
Q325
13
NAB
5
D401
16
23
T401
CLK
TAPE
15
R
Q313,314
STBY
SWITCH
19 20 18
D811
Q324
D402
AU7.5V
AUDIO
MUTE
PB/REC
SWITCH
ERASE
DATA
REC
21
Q406,408,409
Q411,413
VC
R-CH
L
SPEAKER
4
R-CH
D306
BASS
DET
21
14
REC
L-CH
BC
CONTROL
LATCH
M/D HEAD
Q403
4
Q328
OPR/
BATT
AMS
IC303
S817,825-830
FUNCTION
SWITCH
6
AMS
MUTE
BIAS
OSC
1
LOGIC
2
Q405,410
S818-823
FUNCTION
SWITCH
5
Q401
D301
R+B
S809-816
BIAS
SWITCH
FUNCTION
SWITCH
Q402
+B
(IC304)
S801-807
AU7.5V
FUNCTION
SWITCH
ISS CONTROL
CD 8.5V
MO 8.5V
REG
Q902
AU 7.5V
REG
Q901
D803
Q101
Q323
S691
HALF
Q301
D809
D810
RA5V
D361
Q322
PM691
LED
DRIVE
D807
LED
DRIVE
D805
Q362
Q363
Q365
PL
DRIVE
MO 8.5V
BU +B
PH691
END DET
COM5V
3
BACK-UP
5V REG
2
1
3
RESET
IC803
SXXX
OPEN/CLOSE
1
S696
HEAD
POSITION
1
REG
Q315
COM5V
2
IR
RECEIVER
T901
POWER
D901-904 TRANSFORMER
Q316,317
IC802
Q361
IC309
WAKE-UP
CONTROL
MOTOR
DRIVE
D806
CD5V
BU +B
Q805
S695
ERASE PROOF
(SIDE B)
M
Q318,319
D801
S694
ERASE PROOF
(SIDE A)
M691
TAPE
SPEED
D808
D802
S692
TYPE II
(CrO2)
PB EQ
SWITCH
RMC +B
REG CHK
2
D314
OSC
Q803,804
VR DATA
VR CLK
P CONT
8.5V CHK
A MUTE
34
REG CHK
T MOTOR CONT
2
RMC
TAPE END
3
RESET
PL CONT
WP
TAPE
39 OSC OUT
38
IC801(2/2)
SYSTEM CONTROL
40 OSC IN
D905
D907
MAIN
BATT
UM1.5Vx8
12V
Q311,312
B/L CONT 84
37 R SHIFT
X801
4.21MHz
27 33 32 31 30 99
KEY1
REC
93 CLK IN
17
KEY2
CD
92 CLK OUT
X802
32.768kHz
16 19 20 28
KEY3
10
AMS
96 97 98
SEG0
54
SEG26
80
COM0
50
COM3
53
B/L
SWITCH
PL801,802
LCD
BACK LIGHT
D906
BACK-UP
BATT
UM1.5Vx4
6V
LCD801
LIQUID CRYSTAL
DISPLAY PANEL
16
— 23 —
— 24 —
AC IN
D313
3
KEY4
95
T HEAD POS
14
EP(B)
100
CD OP/CL
15
HALF
86
EP(A)
83
VR CE
88 87
J901
RECT
D311
85
RADIO
BLOCK DIAGRAM
LINE
7-3.
— 25 —
7-17. IC PIN FUNCTION DESCRIPTION
• IC801 CXP83124A-021Q
Pin No.
Pin Name
I/O
1
C-SCOR
I
Description
2
REG-CHK
I
3
RMC
I
Remote control input signal
4
C-XRST
O
CD-system reset
5
C-XLAT
O
CD DSP for command latch
6
C-DATA
O
CD DSP command date output
7
B-MUTE
O
CD and TUNER mute output
8
C-CLK
O
CD DSP for command CLK output
CD DSP command date output
9
C-SENSE 1
I
CD SENSE input
10
P-CONT
O
Regulator control
11
C-SQCK
O
CD SUB-Q read-out clock
12
C-SQSO
O
CD-SQSO data input
13
C-SENSE 2
I
CD SENSE input
14
T-MOTOR CONT
O
15
PL-CONT
O
16
HALF (M/D)
I
17
T-HEAD POS
I
18
NC
–
Not used (open)
19
Write protect (A)
I
Write protect (A)
20
Write protect (B)
I
Write protect (B)
Tape exist/not exist check
21
R-ST
I
Tuner stereo receive signal
22
R-CLK
O
PLL IC clock output
23
R-DATA
O
PLL IC data output
24
R-CE
O
PLL IC chip enable output
25
R-CONT
I
PLL IC data input
26
–
–
Not used (open)
27
AMS
I
28
CD-OP/CL
O
29
NC
–
Not used (open)
30
KEY 1
I
Key input
31
KEY 2
I
Key input
32
KEY 3
I
Key input
33
KEY 4
I
Key input
34
+8.5V-CHK
I
DC voltage check
35
INIT
I
INITIAL
36
Destination
I
Destination Radio destination read-in input
37
R-SHIFT
O
38
RESET
I
Reset
39
OSC-OUT
I
4.19 MHz input
40
OSC-IN
O
4.19 MHz input
41
GND
–
Ground
42
NC
–
Not used (open)
43
NC
–
Not used (open)
44
V REF
I
45
GND
–
Ground
46
VDDL
I
LCD drive bias control terminal
47
VDD3
I
Bias power source supply terminal for LCD drive
48
VDD2
I
Bias power source supply terminal for LCD drive
49
VDD1
I
Bias power source supply terminal for LCD drive
50
COM0
O
LCD common output
— 58 —
Pin No.
Pin Name
I/O
51
COM1
O
LCD common output
Description
52
COM2
O
LCD common output
53
COM3
O
LCD common output
54 to 80
SEG0 to SEG26
O
LCD common output
81
NC
–
Not used (open)
82
NC
–
Not used (open)
83
REC
O
Record bias power source supply
84
B/L-CONT
O
B/L-CONTROL
85
LINE
O
LIFE FUNCTION output
86
TAPE
O
TAPE FUNCTION output
87
RADIO
O
RADIO FUNCTION output
88
CD
O
CD FUNCTION output
89
VDD
I
Power supply
90
NC
I
Not used (connected to VDD)
91
GND
–
Ground
92
CLK OUT
–
32 kHz output
93
CLK IN
–
32 kHz output
94
NC
–
Not used (open)
95
A-MUTE
O
AUDIO MUTE terminal
96
VR-DATA
O
VOLUME DATA output
97
VR-CLK
O
VOLUME CKL output terminal
98
VR-CE
O
VOLUME ENABLE output terminal
99
WP
I
µ-COM WAKE UP terminal
100
TAPE END
I
Tape end check
— 59 —
12
13
14
15
16
REG OUT
MUTE
FIN
VO1(–)
11
REG-B
VO1(+)
10
RESET
VIN1
9
VIN2
VIN1
8
VO2(+)
7
VO2(–)
6
GND
5
IC302 BH3854AS
— 60 —
LEVEL
SHIFT
REGULATOR
BIAS
T.S.D.
MONITOR
LEVEL
SHIFT
–
50K
+
10K
+
REGULATOR
13.3K
13.3K
LEVEL
SHIFT
10K
+
BIAS
+
100
D.BUF
4
D.BUF
D.BUF
3
BIAS IN
+
–
–
D.BUF
2
Vcc
–
+
–
–
13.3K
13.3K
10K
1
NC
10K
D.BUF
D.BUF
D.BUF
D.BUF
10K
FIN
Vcc
VIN4
VIN4
VO4(–)
VO4(+)
NC
OP IN(–)
OP OUT
GND
VO3(–)
VO3(+)
VIN3
VIN3
GND
NC
7-18. BLOCK DIAGRAMS
IC703 BA6898S
32
31
30
29
28
27
26
25
24
23
22
21
20
19
18
17
LEVEL
SHIFT
OP-AMP
–
DRIVER-MUTE
50K
+
IC3 BU2615S
IC1 TA2008AN
24
23
22
21
AM
OSC
FM
OSC
20
19
18
17
BUFF
IF
BUFF
AF
BUFF
16
15
14
13
FM MPX
AM
RF
BUFF
AM/FM
ST/MONO
SW
1/801V
FM
MIX
AM
DET
AM
MIX
AGC
FM
RF
1
2
3
4
5
FM
IF
AM
IF
LEVEL
DET
FM
DET
ST
DET
6
7
8
9
10
— 61 —
MUTE
11
12
FSTT 69
C4M 70
D/A
Interface
EFM
demodurator
SYSM
BCKI
PCMDI
Serial-In
Interface
ASYI 46
ASYE 48
73 51 53 55 80
Error
Corrector
RF 44
ASYO 47
LRCKI
BCK
62 63 49 50 52 54
EMPHI
PCMD
31
LRCK
RFCK
WDCK
TES0
65 66 67
osc
Clock
Generator
C2PO
MNT0
68 34 33 35 36 37 58 59 61 72 74
MNT1
MNT3
WFCK
EMPH
GFS
XUGF
GTOP
VCTL
V16M
VCKI
VPCO2
VPCO1
XTSL
IC702 CDX2529Q
Asymmetry
Corrector
6
XPCK 60
Digital
PLL
FILI 40
PCO 38
3rd-Order
Noise Shaper
Digital
OUT
Sub Code
Processor
PWM
CLTV 42
CPU
Interface
LOUT2
AIN2
LOUT1
AOUT1
— 62 —
AOUT2
DOUT
IC303 LA2010
PWMI
85 84
XROF
86
LOCK
94 95
MDS
93
MDP
26 27 28 29 64 30 71
MON
EXCK
SQSO
SBSO
SCOR
XLON
SPOA~D
CLOK
XLAT
DATA
7
SQCK
Digital
CLV
9 10 11 12 18~21 22 75 76 77 8
SENS
CLKO
15 16 17
XLTO
CNIN 14
Servo
Auto
Sequencer
DATO
FOK 23
SEIN 13
PWM
AIN1
FILO 39
LMUT
90 XTAO
Over Sampling
Digital Filter
16K
RAM
RMUT
3
89 XTAI
Timing
Logic
BIAS 45
4
CKOUT
RF_I
CP
CB
CC1
CC2
FOK
36
35
34
33
32
31
30
29
28
27
+
–
+
–
–
+
–
+
–
+
RF SUMMING AMP
+
–
PD1 IV
AMP
PD2 IV
AMP
VEE
RF_O
37
RF_M
PD0
38
RFTC
PD1
39
LD
PD2
IC701 CXA1992BR
+
–
APC
VCC
SENS1
24
C OUT
23
XRST
22
DATA
21
XLT
20
CLK
19
LOCK
18
VCC
17
ISET
16
SL_O
15
SL_M
14
SL_P
TTL
+
–
FE AMP
+
–
+
–
VCC
–
+
25
IIL
VEE
LASER POWER CONTROL
F IV AMP
E 42
SENS2
+
–
+
–
–
+
F 41
26
+
–
VCC
+
–
FE_BIAS 40
VCC
+
–
E IV AMP
VEE
BAL3
VEE
IFB6
IFB5
IFB4
IFB3
IFB2
+
–
VEE
TOG4
IIL
TRK GAIN
WINDOW COMP
FOK
TTL
–
+
FOH
FOL
TGH
TGL
BALH
BALL
ATSC
TZC
FZC
ATSC
WINDOW
COMP
TZC COMP
–
+
TZC 49
DFCT1
CC1
MIRR
TGFL
LDON
+
–
LPC
E-F BALANCE
WINDOW COMP
–
+
ATSC 48
IIL
MIRR
+
–
+
–
TEI 47
VCC
LPCL
TOG3
VEE
+
–
+
–
+
–
TTL
+
–
TOG2
FO BIAS
WINDOW
COMP
TEO 45
+
–
VEE
LEVEL 9
+
–
TOG1
+
–
VEE 44
LPF1 46
DFCT
+
–
TGFL
BAL2
+
–
+
–
BAL1
IFB1
BAL4
+
–
+
–
EI 43
IIL DATA REGISTER
INPUT SHIFT REGISTER
SENS SELECTOR
OUTPUT DECODER
VCC
ISET
DFCT
TM1
TRACKING
PHASE COMPENSATION
TDFCT 50
DFCTO
TG1
VCC
IFB1-6
BAL1-4
TOG1-4
FS1-4
TG1-2
TM1-7
PS1-4
VCC
TM4
+
–
VEE
FOCUS
PHASE COMPENSATION
–
+
TM3
VEE
FS1
VEE
TM2
DFCT
FDFCT
FGD
FLB
FE_O
8
— 63 —
VEE
9
10
11
12
13
TA_O
FEI
7
TA_M
6
FSET
5
TG2
4
TG2
TGU
3
SRCH
2
Charge
up
FE_M
1
FSET
FS2
+
–
FS4
+
–
FZC COMP
FEO
FZC 52
TM7
VCC
TM5
VCC
TM6
+
–
VC 51
VCC
Ver 1.2 1999.10
SECTION 8
EXPLODED VIEWS
NOTE:
• -XX, -X mean standardized parts, so they may
have some differences from the original one.
• Items marked “*” are not stocked since they
are seldom required for routine service. Some
delay should be anticipated when ordering these
items.
• Abbreviation
CND : Canadian
IT
: Italian
•
•
The mechanical parts with no reference number
in the exploded views are not supplied.
Hardware (# mark) list and accessories and
packing materials are given in the last of this
parts list.
When indicating parts by reference number,
please include the board name.
The components identified by mark ! or
dotted line with mark ! are critical for safety.
Replace only with part number specified.
Les composants identifiés par une marque !
sont critiques pour la sécurité.
Ne les remplacer que par une pièce portant
le numéro spécifié.
8-1. FRONT CABINET SECTION
7
6
#5
#5
#5
19
#4
#1
10 #1
5
#5
#2
13
#2
15
17
12
14
18
#1
16
#3
11
3
4
1
9
2
5
8
20
Ref. No.
Part No.
Description
1
2
3
4
5
X-3376-357-1
X-3376-361-1
3-017-465-01
X-3375-359-1
1-505-742-11
CABINET SUB ASSY, FRONT
HOLDER SUB ASSY, JACK
SPRING, CASSETTE OPEN
HOLDER SUB ASSY, CASSETTE
SPEAKER (8CM)
Remarks
6
7
8
9
* 10
1-501-480-11
3-017-470-01
3-017-473-01
3-017-877-11
A-3321-154-A
ANTENNA, TELESCOPIC
LID, BATTERY CASE
WINDOW, AZIMUTH
PLATE (P), JACK
SWITCH BOARD, COMPLETE (US,CND,E)
* 10
* 11
12
A-3321-191-A SWITCH BOARD, COMPLETE (AEP,IT,UK)
3-017-462-01 BRACKET, JACK
3-351-377-11 GEAR, DAMPER
Ref. No.
Part No.
Description
13
13
14
15
* 16
3-017-456-41
3-017-456-51
X-3376-363-1
3-017-457-11
3-017-461-01
BUTTON, POWER (US,E)
BUTTON, POWER (AEP,UK)
BUTTON SUB ASSY, CONTROL
BUTTON, VOLUME
BRACKET, OP/CLOSE
17
18
19
20
3-939-030-01
3-939-031-01
1-782-632-11
X-3374-296-1
3-014-503-01
CATCHER, PUSH
SPRING, PUSH CATCHER RETURN
WIRE, PARALLEL (FFC) (12 CORE)
WINDOW SUB ASSY, LCD
FOOT
*
— 64 —
3-703-044-26 LABEL, CAUTION (US,CND)
3-839-640-00 CUSHION
Remarks
8-2. REAR CABINET SECTION
54
55
64
#1
65
71 56
72
#1
52
70
F901
J301
57
#1
#4
T901
61 62
58
63
53
#2
70
#1
#2
#1
68
73
#2
66
67
#6
#1
73
73
60
not supplied
#1
59
#1
51
73
MF-D55-144
#1
#2
Ref. No.
Part No.
Description
Ref. No.
Part No.
Description
51
51
52
52
53
1-666-855-11
1-666-855-21
A-3321-150-A
A-3293-875-A
1-666-856-11
TERMINAL BOARD (US,CND)
TERMINAL BOARD (AEP,IT,UK,E)
POWER BOARD, COMPLETE (US,CND)
POWER BOARD, COMPLETE (AEP,IT,UK,E)
H/P BOARD (US,CND)
* 63
64
65
66
66
1-667-132-21
3-017-440-01
3-017-449-01
3-017-436-01
3-017-436-11
LAMP BOARD (AEP,IT,UK,E)
BRACKET (L), HANDLE
BRACKET (R), HANDLE
CABINET, REAR (AEP,IT,UK,E)
CABINET, REAR (US,CND)
* 53
54
* 55
* 55
* 56
1-666-856-21
3-017-448-01
1-666-860-11
1-666-860-21
1-666-861-11
H/P BOARD (AEP,IT,UK,E)
HANDLE
BATTERY (L) BOARD (US,CND)
BATTERY (L) BOARD (AEP,IT,UK,E)
BATTERY (S) BOARD (US,CND)
67
* 68
* 68
70
71
3-017-441-01
A-3293-842-A
A-3293-869-A
1-533-233-21
3-017-439-01
TERMINAL, ANT
TC BOARD, COMPLETE (US,CND)
TC BOARD, COMPLETE (AEP,IT,UK,E)
HOLDER, FUSE
SPRING (-) (L), BATTERY
* 56
57
58
* 59
* 59
1-666-861-21
3-017-438-01
3-017-437-01
A-3321-151-A
A-3321-189-A
BATTERY (S) BOARD (AEP,IT,UK,E)
SPRING (+.-) (S), BATTERY
SPRING (+.-) (L), BATTERY
TUNER BOARD, COMPLETE (US,CND)
TUNER BOARD, COMPLETE (AEP,IT,UK,E)
72
73
! F901
! F901
! T901
3-939-057-01 SPRING (-), BACK UP
3-831-441-99 CUSHION, SPEAKER
1-532-505-31 FUSE (5A 250V) (AEP,IT,UK,E)
1-533-420-11
FUSE, GLASS CYLINDRICAL(DIA.5) (5A 125V)
(US,CND)
1-431-483-11 TRANSFORMER, POWER (US,CND)
60
* 61
* 61
62
* 63
3-017-445-01
A-3321-148-A
A-3321-186-A
3-017-443-01
1-667-132-11
CHASSIS, TU
CONTROL BOARD, COMPLETE(US,CND)
CONTROL BOARD, COMPLETE (AEP,IT,UK,E)
BUTTON, SOUND
LAMP BOARD (US,CND)
! T901
J301
1-431-484-11 TRANSFORMER, POWER (AEP,IT,UK,E)
1-566-891-11 JACK (H/P JACK)
*
*
*
*
*
Remarks
— 65 —
The components identified by
mark ! or dotted line with mark
! are critical for safety.
Replace only with part number
specified.
Remarks
Les composants identifiés par
une marque ! sont critiques
pour la sécurité.
Ne les remplacer que par une
pièce portant le numéro spécifié.
8-3. CD MECHANISM SECTION (KSM-213CDM/M-S)
102
104
#1
103
#1
118
101
118
#1
#1
105
not supplied
112
118
118
106
109
KSM-213
CDM
#1
111
111
107
110
117
#7
108
116
100
115
#1
114
#1
113
Ref. No.
Part No.
Description
Part No.
Description
* 100
* 100
101
102
103
A-3293-850-A
A-3293-877-A
3-938-884-01
3-017-878-01
1-692-960-11
MAIN BOARD, COMPLETE (US,CND)
MAIN BOARD, COMPLETE (AEP,IT,UK,E)
SPRING, CD COIL
SLIDER, PUSH
SWITCH, PUSH (1 KEY)
Remarks
Ref. No.
109
110
111
112
113
3-351-377-11
3-931-379-21
3-931-379-31
3-910-116-01
1-782-629-11
GEAR, DAMPER
RUBBER, VIBRATION PROOF
RUBBER, VIBRATION PROOF
COVER, CD
WIRE, PARALLEL (FFC) (14 CORE)
104
105
106
107
108
3-017-450-01
3-017-472-11
1-452-732-11
3-016-397-01
3-911-135-01
SPRING, CD OPEN
LID, CD
MAGNET
PLATE (KSM-213-CDM), CHUCKING
SCREW (2.6X10), (+PWH) TAPPING
114
115
116
117
118
1-782-630-11
1-782-627-11
1-782-628-11
1-782-631-11
3-831-441-99
WIRE, PARALLEL (FFC) (13 CORE)
WIRE, PARALLEL (FFC) (27 CORE)
WIRE, PARALLEL (FFC) (20 CORE)
WIRE, PARALLEL (FFC) (16 CORE)
CUSHION, SPEAKER
— 66 —
Remarks
8-4. OPTICAL PICK UP SECTION
155
151
not supplied
152
#8
153
154
M702
Ref. No.
Part No.
! 151
152
153
8-848-483-05 OPTICAL, PIC-UP KSS-213C/Q-RP
2-627-003-02 GEAR (B) (RP)
2-626-908-01 SHAFT, SLED
Description
Remarks
Ref. No.
154
155
M702
Part No.
Description
The components identified by
mark ! or dotted line with mark
! are critical for safety.
Replace only with part number
specified.
— 67 —
Remarks
X-2626-202-1 CHASSIS ASSY (MB) (RP), MOTOR
2-626-907-01 GEAR (A)
X-2625-769-1 GEAR ASSY (MB), MOTOR
Les composants identifiés par
une marque ! sont critiques
pour la sécurité.
Ne les remplacer que par une
pièce portant le numéro spécifié.
8-5. CASSETTE MECHANISM DECK SECTION-1 (MF-D55-144)
216
215
214
209
211
208
HRPE101
213
207
217
212
210
220
205
206
204
222
221
223
218
227
203
202
Ref. No.
224
226
201
219
225
Part No.
Description
Remarks
Ref. No.
Part No.
Description
201
202
203
204
205
3-938-905-01
3-938-940-01
3-938-941-01
3-938-906-01
3-017-432-01
HEAD, LEVER
SPRING (L)
SCREW (A)
AZIMUTH, SPRING
SPRING (A)
*
*
*
*
215
216
217
218
219
3-938-916-01
3-938-914-01
3-938-913-01
3-938-909-01
3-938-944-01
BRAKE, ARM
FRAME (C)
FRAME (B)
LOCK, EJECT
SCREW (D)
206
* 207
208
209
210
3-938-901-01
3-938-904-01
3-938-902-01
3-938-903-01
3-938-935-01
HEAD, HOLDER
HEAD, FRAME
WASHER
SCREW
SPRING (G)
220
221
222
* 223
224
3-017-591-01
3-938-937-01
3-938-938-01
3-938-911-01
3-938-907-01
ARM (PINCH R) ASSY
SPRING (I)
SPRING (J)
HEAD (B), CHASSIS
HEAD, GEAR ARM
211
212
213
214
X-3374-292-1
3-938-933-01
3-017-592-01
3-938-934-01
ASSIST ASSY, LEVER
SPRING (E)
ARM (PINCH L) ASSY
SPRING (F)
225
3-938-943-01
226
3-938-942-01
227
1-662-743-11
HRPE101 1-500-480-11
— 68 —
SCREW (C)
SCREW (B)
HEAD BOARD
HEAD, MAGNETIC (REC/PB/ERASE)
Remarks
8-6. CASSETTE MECHANISM DECK SECTION-2 (MF-D55-144)
267
M691
269
268
263
262
261
PM691
270
264
261
273
265
260
275
271
274
266
272
276
275
259
277
258
286
257
285
278
284
255
279
280
253
255
251
254
252
283
not
supplied
282
281
256
Ref. No.
Part No.
Description
251
252
253
254
255
3-938-949-01
3-938-951-01
3-938-936-01
3-938-930-01
3-938-910-01
WASHER (B)
WASHER (D)
SPRING (H)
SPRING (B)
REEL, CAP
* 256
257
258
259
260
3-938-912-01
3-938-952-01
3-938-948-01
3-938-932-01
3-938-908-01
ARM (UD)
WASHER (E)
WASHER (A)
SPRING (D)
CASSETTE, SPRING
261
262
263
* 264
265
3-938-945-01
3-017-428-01
3-938-920-01
3-938-918-01
3-938-931-01
266
* 267
268
269
3-938-921-01
1-662-742-11
3-938-954-01
3-938-947-01
Remarks
Ref. No.
Part No.
Description
270
271
272
273
274
3-017-431-01
3-017-430-01
3-017-596-01
3-017-434-01
3-017-595-01
BRACKET (MM)
BELT
FLYWHEEL (R) ASSY
SCREW (H)
FLYWHEEL (L) ASSY
275
276
277
* 278
279
3-938-950-01
3-017-433-01
3-938-946-01
3-938-919-01
3-017-435-01
WASHER (C)
SPRING (K)
SCREW (F)
ARM (FR)
REFLECTOR
SCREW (E)
FRAME (D)
PLUNGER, K
TRIGGER, ARM
SPRING (C)
280
281
282
283
284
3-017-429-01
3-938-917-01
3-938-924-01
3-938-923-01
X-3374-293-1
GEAR (REF)
GEAR (A)
GEAR (P)
GEAR (FR)
CLUTCH ASSY
GEAR (REEL)
SW BOARD
WASHER (G)
SCREW (G)
285
286
M691
PM691
3-938-925-01
3-938-922-01
X-3374-291-1
1-454-806-11
GEAR (IDL)
GEAR (CAM)
MOTOR ASSY
SOLENOID, PLUNGER
— 69 —
Remarks
BATTERY (L)
CD MOTOR
BATTERY (S)
SECTION 9
ELECTRICAL PARTS LIST
CONTROL
NOTE:
•
When indicating parts by reference number,
please include the board name.
The components identified by mark ! or
dotted line with mark ! are critical for safety.
Replace only with part number specified.
•
Les composants identifiés par une marque
! sont critiques pour la sécurité.
Ne les remplacer que par une pièce portant
le numéro spécifié.
•
•
Abbreviation
CND : Canadian
IT
: Italian
•
Due to standardization, replacements in the
parts list may be different from the parts
specified in the diagrams or the components
used on the set.
-XX, -X mean standardized parts, so they may
have some difference from the original one.
Items marked “*” are not stocked since they
are seldom required for routine service. Some
delay should be anticipated when ordering these
items.
CAPACITORS:
uF: µF
Ref. No.
Part No.
*
1-666-860-11 BATTERY (L) BOARD (US,CND)
*****************
1-666-860-21 BATTERY (L) BOARD (AEP,IT,UK,E)
*****************
*
Description
Remarks
3-017-439-01 SPRING (-) (L), BATTERY
************************************************************
1-666-861-11 BATTERY (S) BOARD (US,CND)
*****************
1-666-861-21 BATTERY (S) BOARD (AEP,IT,UK,E)
*****************
*
*
3-939-057-01 SPRING (-), BACK UP
< CONNECTOR >
CN903 1-564-505-11 PLUG, CONNECTOR 2P
CN904 1-564-506-11 PLUG, CONNECTOR 3P
************************************************************
1-639-678-12 CD MOTOR BOARD
****************
*
1-564-722-11 PIN, CONNECTOR (SMALL TYPE) 6P
1-572-085-11 SWITCH, LEAF
************************************************************
A-3321-148-A CONTROL BOARD, COMPLETE (US,CND)
*************************
A-3321-186-A CONTROL BOARD, COMPLETE (AEP,IT,UK,E)
*************************
*
*
3-017-444-01 HOLDER, LCD
3-019-236-01 ILLUMINATOR (LCD)
7-685-535-14 SCREW +BTP 2.6X10 TYPE2 N-S
Ref. No.
•
•
•
RESISTORS
All resistors are in ohms.
METAL: metal-film resistor
METAL OXIDE: Metal Oxide-film resistor
F: nonflammable
COILS
uH: µH
SEMICONDUCTORS
In each case, u: µ, for example:
uA...: µA... , uPA... , µPA... ,
uPB... , µPB... , uPC... , µPC... ,
uPD..., µPD...
Part No.
Description
C820
C822
C823
C824
C825
1-102-960-00
1-162-294-31
1-162-294-31
1-162-294-31
1-136-165-00
CERAMIC
CERAMIC
CERAMIC
CERAMIC
FILM
24PF
0.001uF
0.001uF
0.001uF
0.1uF
5%
10%
10%
10%
5%
Remarks
50V
50V
50V
50V
50V
C826
C827
C828
C829
C830
1-162-294-31
1-162-294-31
1-162-294-31
1-162-294-31
1-162-294-31
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.001uF
0.001uF
0.001uF
0.001uF
0.001uF
10%
10%
10%
10%
10%
50V
50V
50V
50V
50V
C831
C832
C833
C834
C835
1-162-294-31
1-162-294-31
1-162-294-31
1-162-294-31
1-162-294-31
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.001uF
0.001uF
0.001uF
0.001uF
0.001uF
10%
10%
10%
10%
10%
50V
50V
50V
50V
50V
C836
C837
C838
C839
C841
1-162-294-31
1-162-294-31
1-162-294-31
1-162-294-31
1-162-294-31
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.001uF
0.001uF
0.001uF
0.001uF
0.001uF
10%
10%
10%
10%
10%
50V
50V
50V
50V
50V
C842
C843
C844
C845
1-162-294-31
1-162-294-31
1-162-294-31
1-162-294-31
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.001uF
0.001uF
0.001uF
0.001uF
10%
10%
10%
10%
C846
C847
C848
C849
C850
1-162-282-31
1-162-282-31
1-162-294-31
1-162-282-31
1-162-306-11
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
100PF
100PF
0.001uF
100PF
0.01uF
10%
10%
10%
10%
30%
C851
1-162-282-31 CERAMIC
100PF
10%
C852
1-162-306-11 CERAMIC
0.01uF
C853
1-162-282-31 CERAMIC
100PF
< CAPACITOR >
C800
C801
C803
C806
C807
1-164-159-21
1-164-159-21
1-162-306-11
1-126-967-11
1-126-964-11
CERAMIC
CERAMIC
CERAMIC
ELECT
ELECT
0.1uF
0.1uF
0.01uF
47uF
10uF
30%
20%
20%
50V
50V
16V
10V
50V
C808
C809
C810
C811
C812
1-102-514-11
1-102-516-11
1-162-282-31
1-162-282-31
1-102-960-00
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
22PF
27PF
100PF
100PF
24PF
5%
5%
10%
10%
5%
50V
50V
50V
50V
50V
C813
C815
C817
C818
C819
1-102-960-00
1-136-165-00
1-162-306-11
1-162-306-11
1-102-960-00
CERAMIC
FILM
CERAMIC
CERAMIC
CERAMIC
24PF
0.1uF
0.01uF
0.01uF
24PF
5%
5%
30%
30%
5%
50V
50V
16V
16V
50V
1-691-071-31
1-695-381-31
1-695-388-21
1-564-704-11
HOUSING, CONNECTOR 12P
PIN, CONNECTOR (PC BOARD) 20P
PIN, CONNECTOR (PC BOARD) 27P
PIN, CONNECTOR (SMALL TYPE) 2P
< DIODE >
D801
D802
D803
D804
— 70 —
8-719-991-33
8-719-991-33
8-719-991-33
8-719-991-33
DIODE
DIODE
DIODE
DIODE
1SS133T-77
1SS133T-77
1SS133T-77
1SS133T-77
50V
50V
50V
50V
16V
50V
(US,CND)
30%
16V
(AEP,IT,UK,E)
10%
50V
< CONNECTOR >
CN801
* CN802
CN803
* CN804
50V
50V
50V
50V
(US,CND)
CONTROL
Ref. No.
Part No.
Description
Remarks
Ref. No.
< IC >
IC801
IC801
IC803
8-752-890-50 IC CXP83124A-021Q (US,CND)
8-752-894-98 IC CXP83124A-027Q (AEP,IT,UK,E)
8-759-430-16 IC PST600I
< COIL >
L803
L804
1-410-509-11 INDUCTOR
1-410-509-11 INDUCTOR
10uH
10uH
Part No.
Description
R837
R838
R839
R840
R841
1-249-417-11
1-249-417-11
1-249-417-11
1-249-417-11
1-249-417-11
CARBON
CARBON
CARBON
CARBON
CARBON
R842
R843
R844
H/P
Remarks
1K
1K
1K
1K
1K
5%
5%
5%
5%
5%
1-249-417-11 CARBON
1-249-437-11 CARBON
1-249-415-11 CARBON
1K
47K
680
5%
5%
5%
R844
1-249-422-11 CARBON
2.7K
R845
1-249-417-11 CARBON
1K
1/4W F
1/4W
1/4W F
(US,CND)
5%
1/4W F
(AEP,IT,UK,E)
5%
1/4W F
R846
R847
R848
R849
R850
1-249-425-11
1-247-885-00
1-249-441-11
1-247-883-00
1-247-883-00
CARBON
CARBON
CARBON
CARBON
CARBON
4.7K
180K
100K
150K
150K
5%
5%
5%
5%
5%
1/4W F
1/4W
1/4W
1/4W
1/4W
R851
R852
R853
R854
R855
1-249-413-11
1-249-429-11
1-249-417-11
1-249-425-11
1-249-415-11
CARBON
CARBON
CARBON
CARBON
CARBON
470
10K
1K
4.7K
680
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R856
R857
R858
R859
R860
1-249-416-11
1-249-418-11
1-249-420-11
1-247-843-11
1-249-427-11
CARBON
CARBON
CARBON
CARBON
CARBON
820
1.2K
1.8K
3.3K
6.8K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R861
R890
R891
R894
R896
1-249-432-11
1-249-417-11
1-249-437-11
1-247-843-11
1-247-887-00
CARBON
CARBON
CARBON
CARBON
CARBON
18K
1K
47K
3.3K
220K
5%
5%
5%
5%
5%
1/4W
1/4W F
1/4W
1/4W
1/4W
R897
1-247-895-91 CARBON
470K
5%
1/4W
< LIQUID CRYSTAL DISPLAY >
1/4W
1/4W
1/4W
1/4W
1/4W
F
F
F
F
F
LCD801 1-801-874-11 DISPLAY PANEL, LIQUID CRYSTAL
< PILOT LAMP >
PL801
PL802
1-517-487-11 LAMP, PILOT
1-517-487-11 LAMP, PILOT
< TRANSISTOR >
Q803
Q804
Q805
8-729-922-66 TRANSISTOR 2SC2410SN
8-729-922-66 TRANSISTOR 2SC2410SN
8-729-029-49 TRANSISTOR DTA143TSA-TP
< RESISTOR >
R801
R803
R804
R805
R806
1-249-417-11
1-247-807-31
1-249-417-11
1-249-417-11
1-249-417-11
CARBON
CARBON
CARBON
CARBON
CARBON
1K
100
1K
1K
1K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
F
R807
R808
R809
R810
R811
1-249-417-11
1-249-417-11
1-249-417-11
1-249-417-11
1-249-417-11
CARBON
CARBON
CARBON
CARBON
CARBON
1K
1K
1K
1K
1K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
F
F
F
F
F
R812
R813
R814
R815
R816
1-247-807-31
1-249-417-11
1-249-417-11
1-249-417-11
1-249-417-11
CARBON
CARBON
CARBON
CARBON
CARBON
100
1K
1K
1K
1K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
F
F
F
F
R817
R818
R819
R820
R821
1-249-417-11
1-249-417-11
1-249-417-11
1-249-417-11
1-249-417-11
CARBON
CARBON
CARBON
CARBON
CARBON
1K
1K
1K
1K
1K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
F
F
F
F
F
R822
R823
R824
R825
R826
1-249-417-11
1-249-417-11
1-249-417-11
1-249-417-11
1-249-417-11
CARBON
CARBON
CARBON
CARBON
CARBON
1K
1K
1K
1K
1K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
F
F
F
F
F
R827
R828
R829
R830
R831
1-249-417-11
1-249-417-11
1-249-426-11
1-249-417-11
1-249-417-11
CARBON
CARBON
CARBON
CARBON
CARBON
1K
1K
5.6K
1K
1K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
F
F
R832
R833
R834
R835
R836
1-249-417-11
1-249-417-11
1-249-417-11
1-249-417-11
1-249-417-11
CARBON
CARBON
CARBON
CARBON
CARBON
1K
1K
1K
1K
1K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
F
F
F
F
F
F
F
F
F
F
F
F
F
F
F
F
< SWITCH >
S801
S802
S803
S804
S805
1-554-088-00
1-554-088-00
1-554-088-00
1-554-088-00
1-554-088-00
SWITCH, KEY BOARD (STBY)
SWITCH, KEY BOARD (SLEEP)
SWITCH, KEY BOARD (CLOCK)
SWITCH, KEY BOARD (PGM SET AUTI PRESET)
SWITCH, KEY BOARD (PLAY MODE MONO/ST)
S806
S807
S808
1-554-088-00 SWITCH, KEY BOARD (CANCEL)
1-554-088-00 SWITCH, KEY BOARD (SOUND)
1-554-088-00 SWITCH, KEY BOARD (MEGABASS)
< VIBRATOR >
X801
1-767-184-11 VIBRATOR, CERAMIC (4.21MHz)
X802
1-567-098-41 VIBRATOR, CRYSTAL (32.768kHz)
************************************************************
*
*
F
F
1-666-856-11 H/P BOARD (US,CND)
**********
1-666-856-21 H/P BOARD (AEP,IT,UK,E)
**********
3-831-441-99 CUSHION, SPEAKER
< CONNECTOR >
* CN305
* CN306
— 71 —
1-564-507-11 PLUG, CONNECTOR 4P
1-564-519-11 PLUG, CONNECTOR 4P
H/P
Ref. No.
LAMP
Part No.
MAIN
Description
Remarks
< JACK >
J301
1-566-891-11 JACK (H/P JACK)
< COIL >
L101
L201
L304
1-410-314-11 INDUCTOR
1-410-314-11 INDUCTOR
1-410-314-11 INDUCTOR
0.47uH
0.47uH
0.47uH
< RESISTOR >
R170
1-249-407-11 CARBON
150
5%
1/4W F
R270
1-249-407-11 CARBON
150
5%
1/4W F
*************************************************************
1-667-132-11 LAMP BOARD (US,CND)
************
1-667-132-21 LAMP BOARD (AEP,IT,UK,E)
************
*
*
< PILOT LAMP >
PL801 1-517-487-11 LAMP, PILOT
PL802 1-517-487-11 LAMP, PILOT
*************************************************************
A-3293-850-A MAIN BOARD, COMPLETE (US,CND)
*********************
A-3293-877-A MAIN BOARD, COMPLETE (AEP,IT,UK,E)
*********************
*
*
1-782-627-11
1-782-628-11
1-782-629-11
1-782-630-11
7-685-646-79
WIRE, PARALLEL (FFC) (27 CORE)
WIRE, PARALLEL (FFC) (20 CORE)
WIRE, PARALLEL (FFC) (14 CORE)
WIRE, PARALLEL (FFC) (13 CORE)
SCREW +BVTP 3X8 TYPE2 IT-3
< CAPACITOR >
C101
C107
C109
C110
C111
1-162-215-31
1-126-963-11
1-162-215-31
1-126-960-11
1-161-061-11
CERAMIC
ELECT
CERAMIC
ELECT
CERAMIC
47PF
4.7uF
47PF
1uF
0.068uF
5%
20%
5%
20%
10%
50V
50V
50V
50V
50V
C112
C113
C114
C115
C118
1-161-061-11
1-162-837-11
1-126-964-11
1-161-055-00
1-126-927-11
CERAMIC
CERAMIC
ELECT
CERAMIC
ELECT
0.068uF
0.0068uF
10uF
0.022uF
2200uF
10%
10%
20%
10%
20%
50V
16V
50V
50V
10V
C119
C120
C121
C126
C132
1-136-165-00
1-126-960-11
1-126-967-11
1-136-153-00
1-126-960-11
FILM
ELECT
ELECT
FILM
ELECT
0.1uF
1uF
47uF
0.01uF
1uF
5%
20%
20%
5%
20%
50V
50V
10V
50V
50V
C134
C135
C201
C207
C209
1-126-933-11
1-162-286-21
1-162-215-31
1-126-963-11
1-162-215-31
ELECT
CERAMIC
CERAMIC
ELECT
CERAMIC
100uF
220PF
47PF
4.7uF
47PF
20%
10%
5%
20%
5%
10V
50V
50V
50V
50V
C210
C211
C212
C213
C214
1-126-960-11
1-161-061-11
1-161-061-11
1-162-837-11
1-126-964-11
ELECT
CERAMIC
CERAMIC
CERAMIC
ELECT
1uF
0.068uF
0.068uF
0.0068uF
10uF
20%
10%
10%
10%
20%
50V
50V
50V
16V
50V
Ref. No.
Part No.
Description
C215
C218
C219
C220
C221
1-161-055-00
1-126-927-11
1-136-165-00
1-126-960-11
1-126-967-11
CERAMIC
ELECT
FILM
ELECT
ELECT
0.022uF
2200uF
0.1uF
1uF
47uF
10%
20%
5%
20%
20%
50V
10V
50V
50V
10V
C226
C232
C234
C235
C302
1-136-153-00
1-126-960-11
1-126-933-11
1-162-286-21
1-126-967-11
FILM
ELECT
ELECT
CERAMIC
ELECT
0.01uF
1uF
100uF
220PF
47uF
5%
20%
20%
10%
20%
50V
50V
10V
50V
10V
C310
C311
C312
C313
C314
1-161-055-00
1-126-933-11
1-126-967-11
1-126-967-11
1-126-933-11
CERAMIC
ELECT
ELECT
ELECT
ELECT
0.022uF
100uF
47uF
47uF
100uF
10%
20%
20%
20%
20%
50V
10V
10V
10V
10V
C315
C316
C318
C319
C320
1-126-967-11
1-126-933-11
1-126-934-11
1-126-963-11
1-128-551-11
ELECT
ELECT
ELECT
ELECT
ELECT
47uF
100uF
220uF
4.7uF
22uF
20%
20%
20%
20%
20%
10V
10V
10V
50V
25V
C321
C322
C323
C325
C326
1-162-851-11
1-162-851-11
1-126-963-11
1-126-933-11
1-162-306-11
CERAMIC
CERAMIC
ELECT
ELECT
CERAMIC
0.1uF
0.1uF
4.7uF
100uF
0.01uF
10%
10%
20%
20%
30%
16V
16V
50V
10V
16V
C327
C330
C331
C332
C333
1-126-934-11
1-162-294-31
1-162-292-31
1-161-055-00
1-124-252-00
ELECT
CERAMIC
CERAMIC
CERAMIC
ELECT
220uF
0.001uF
680PF
0.022uF
0.33uF
20%
10%
10%
10%
20%
10V
50V
50V
50V
50V
C334
C335
C336
C337
C338
1-126-963-11
1-126-962-11
1-126-961-11
1-126-964-11
1-126-934-11
ELECT
ELECT
ELECT
ELECT
ELECT
4.7uF
3.3uF
2.2uF
10uF
220uF
20%
20%
20%
20%
20%
50V
50V
50V
50V
10V
C339
C342
C345
C346
C347
1-128-551-11
1-104-666-11
1-130-499-00
1-126-959-11
1-161-055-00
ELECT
ELECT
MYLAR
ELECT
CERAMIC
22uF
220uF
0.22uF
0.47uF
0.022uF
20%
20%
5%
20%
10%
25V
25V
50V
50V
50V
C348
C349
C350
C351
C352
1-161-055-00
1-126-967-11
1-126-933-11
1-162-851-11
1-136-153-00
CERAMIC
ELECT
ELECT
CERAMIC
FILM
0.022uF
47uF
100uF
0.1uF
0.01uF
10%
20%
20%
10%
5%
50V
10V
10V
16V
50V
C362
C399
C700
C701
C702
1-126-960-11
1-136-165-00
1-162-302-11
1-136-153-00
1-162-851-11
ELECT
FILM
CERAMIC
FILM
CERAMIC
1uF
0.1uF
0.0022uF
0.01uF
0.1uF
20%
5%
30%
5%
10%
50V
50V
16V
50V
16V
C703
C704
C705
C706
C707
1-162-851-11
1-126-963-11
1-130-489-00
1-130-486-00
1-162-199-31
CERAMIC
ELECT
MYLAR
MYLAR
CERAMIC
0.1uF
4.7uF
0.033uF
0.018uF
10PF
10%
20%
5%
10%
5%
16V
50V
50V
50V
50V
C708
C709
C710
C711
C712
1-126-962-11
1-130-493-00
1-162-215-31
1-130-489-00
1-162-306-11
ELECT
MYLAR
CERAMIC
MYLAR
CERAMIC
3.3uF
0.068uF
47PF
0.033uF
0.01uF
20%
5%
5%
5%
30%
50V
50V
50V
50V
16V
— 72 —
Remarks
MAIN
Ref. No.
Part No.
Description
C713
C714
C715
C716
C717
1-136-153-00
1-130-493-00
1-126-960-11
1-162-199-31
1-126-967-11
FILM
MYLAR
ELECT
CERAMIC
ELECT
0.01uF
0.068uF
1uF
10PF
47uF
5%
5%
20%
5%
20%
50V
50V
50V
50V
10V
Remarks
C718
C719
C720
C721
C722
1-162-294-31
1-130-491-00
1-162-305-11
1-101-005-00
1-162-306-11
CERAMIC
MYLAR
CERAMIC
CERAMIC
CERAMIC
0.001uF
0.047uF
0.0068uF
22000PF
0.01uF
10%
5%
30%
50V
50V
16V
50V
16V
C723
C724
C725
C726
C727
1-162-600-11
1-162-851-11
1-101-005-00
1-126-964-11
1-162-306-11
CERAMIC
CERAMIC
CERAMIC
ELECT
CERAMIC
0.0047uF
0.1uF
22000PF
10uF
0.01uF
30%
10%
20%
30%
16V
16V
50V
50V
16V
C728
C729
C730
C731
C732
1-126-934-11
1-162-306-11
1-126-967-11
1-136-153-00
1-126-967-11
ELECT
CERAMIC
ELECT
FILM
ELECT
220uF
0.01uF
47uF
0.01uF
47uF
20%
30%
20%
5%
20%
10V
16V
10V
50V
10V
C733
C734
C735
C736
C737
1-126-959-11
1-162-306-11
1-162-290-31
1-162-286-21
1-162-306-11
ELECT
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.47uF
0.01uF
470PF
220PF
0.01uF
20%
30%
10%
10%
30%
50V
16V
50V
50V
16V
C738
C739
C740
C742
C743
1-130-499-00
1-162-306-11
1-162-302-11
1-162-199-31
1-162-199-31
MYLAR
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.22uF
0.01uF
0.0022uF
10PF
10PF
5%
30%
30%
5%
5%
50V
16V
16V
50V
50V
C745
C747
C748
C749
C750
1-162-302-11
1-126-964-11
1-162-851-11
1-126-967-11
1-126-924-11
CERAMIC
ELECT
CERAMIC
ELECT
ELECT
0.0022uF
10uF
0.1uF
47uF
330uF
30%
20%
10%
20%
20%
16V
50V
16V
10V
10V
C751
C752
C753
C755
C760
1-136-153-00
1-162-306-11
1-126-935-11
1-162-294-31
1-126-963-11
FILM
CERAMIC
ELECT
CERAMIC
ELECT
0.01uF
0.01uF
470uF
0.001uF
4.7uF
5%
30%
20%
10%
20%
50V
16V
16V
50V
50V
C761
C762
C763
C770
C771
1-162-290-31
1-162-290-31
1-162-306-11
1-126-963-11
1-162-294-31
CERAMIC
CERAMIC
CERAMIC
ELECT
CERAMIC
470PF
470PF
0.01uF
4.7uF
0.001uF
10%
10%
30%
20%
10%
50V
50V
16V
50V
50V
C772
C773
C797
C798
C799
1-162-306-11
1-162-851-11
1-162-306-11
1-162-294-31
1-162-294-31
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.01uF
0.1uF
0.01uF
0.001uF
0.001uF
30%
10%
30%
10%
10%
16V
16V
16V
50V
50V
30%
< CONNECTOR >
* CN301
* CN302
CN303
CN304
CN701
1-695-337-31
1-695-381-31
1-695-388-21
1-695-336-31
1-774-975-11
PIN, CONNECTOR (PC BOARD) 14P
PIN, CONNECTOR (PC BOARD) 20P
PIN, CONNECTOR (PC BOARD) 27P
PIN, CONNECTOR (PC BOARD) 13P
CONNECTOR, FFC/FPC 16P
Ref. No.
Part No.
Description
Remarks
< DIODE >
D301
D302
D303
D304
D306
8-719-991-33
8-719-991-33
8-719-991-33
8-719-991-33
8-719-991-33
DIODE
DIODE
DIODE
DIODE
DIODE
1SS133T-77
1SS133T-77
1SS133T-77
1SS133T-77
1SS133T-77
D310
D311
D313
D314
D361
8-719-109-89
8-719-991-33
8-719-991-33
8-719-991-33
8-719-991-33
DIODE
DIODE
DIODE
DIODE
DIODE
RD5.6ESB2
1SS133T-77
1SS133T-77
1SS133T-77
1SS133T-77
D702
8-719-991-33 DIODE 1SS133T-77
< FERRITE BEAD >
FB701
FB702
FB703
FB704
FB705
1-410-397-21
1-410-397-21
1-410-397-21
1-410-397-21
1-410-397-21
FERRITE BEAD INDUCTOR
FERRITE BEAD INDUCTOR
FERRITE BEAD INDUCTOR
FERRITE BEAD INDUCTOR
FERRITE BEAD INDUCTOR
< IC >
IC302
IC303
IC304
IC305
IC309
8-759-432-41
8-759-800-71
8-759-820-22
8-759-076-15
8-759-479-70
IC
IC
IC
IC
IC
BH3854AS
LA2010
LA4597
KIA4558P
S-81250SGY-Z
IC701
IC702
IC703
8-752-082-14 IC CXA1992BR
8-752-380-64 IC CXD2529Q
8-759-478-60 IC BA6898S
< COIL >
L301
L302
L303
L701
1-410-509-11
1-410-509-11
1-410-509-11
1-412-852-11
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
10uH
10uH
10uH
47uH
< TRANSISTOR >
Q101
Q101
Q103
Q104
Q105
8-729-115-80
8-729-029-72
8-729-905-50
8-729-905-50
8-729-905-50
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
BA1A4P
DTC114YS-TP
DTC343TS
DTC343TS
DTC343TS
Q106
Q107
Q201
Q203
Q204
8-729-905-50
8-729-905-50
8-729-115-80
8-729-905-50
8-729-905-50
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
DTC343TS
DTC343TS
BA1A4P
DTC343TS
DTC343TS
Q205
Q206
Q207
Q301
Q311
8-729-905-50
8-729-905-50
8-729-905-50
8-729-115-80
8-729-036-86
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
DTC343TS
DTC343TS
DTC343TS
BA1A4P
KTC3203Y-AT
Q312
Q312
Q313
Q314
Q315
8-729-115-82
8-729-030-10
8-729-920-94
8-729-115-80
8-729-036-86
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
BA1L4L-TP
DTC144WS-TP
DTA123YS
BA1A4P
KTC3203Y-AT
— 73 —
MAIN
Ref. No.
Part No.
Description
Part No.
Description
Q316
Q316
Q317
Q318
Q319
8-729-037-34
8-729-902-80
8-729-036-89
8-729-801-84
8-729-115-80
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
KRA107M
DTA114YS
KTC3198GR-AT
2SB1013-4
BA1A4P
Remarks
R212
R213
R214
R215
R216
1-249-427-11
1-249-419-11
1-249-417-11
1-249-417-11
1-249-441-11
CARBON
CARBON
CARBON
CARBON
CARBON
6.8K
1.5K
1K
1K
100K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
Q320
Q321
Q321
Q322
Q322
8-729-115-80
8-729-037-34
8-729-902-80
8-729-037-34
8-729-902-80
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
BA1A4P
KRA107M
DTA114YS
KRA107M
DTA114YS
R217
R218
R219
R220
R223
1-249-435-11
1-249-429-11
1-249-429-11
1-249-420-11
1-249-401-11
CARBON
CARBON
CARBON
CARBON
CARBON
33K
10K
10K
1.8K
47
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W F
1/4W F
Q323
Q323
Q324
Q325
Q326
8-729-037-34
8-729-902-80
8-729-036-89
8-729-036-89
8-729-037-34
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
KRA107M
DTA114YS
KTC3198GR-AT
KTC3198GR-AT
KRA107M
R224
R225
R231
R232
R233
1-249-387-11
1-249-421-11
1-249-431-11
1-247-843-11
1-249-437-11
CARBON
CARBON
CARBON
CARBON
CARBON
3.3
2.2K
15K
3.3K
47K
5%
5%
5%
5%
5%
1/4W F
1/4W F
1/4W
1/4W
1/4W
Q326
Q327
Q328
Q329
Q329
8-729-902-80
8-729-036-89
8-729-115-80
8-729-037-34
8-729-902-80
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
DTA114YS
KTC3198GR-AT
BA1A4P
KRA107M
DTA114YS
R234
R301
1-249-425-11 CARBON
1-247-807-31 CARBON
4.7K
100
5%
5%
R301
1-249-417-11 CARBON
1K
Q361
Q362
Q363
Q365
Q701
8-729-115-80
8-729-801-84
8-729-115-80
8-729-036-86
8-729-037-02
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
BA1A4P
2SB1013-4
BA1A4P
KTC3203Y-AT
KTA1266Y-AT
R313
R314
1-249-426-11 CARBON
1-247-891-00 CARBON
5.6K
330K
1/4W F
1/4W
(US,CND)
5%
1/4W F
(AEP,IT,UK,E)
5%
1/4W
5%
1/4W
R315
R316
R317
R318
R319
1-249-441-11
1-249-429-11
1-249-430-11
1-247-903-00
1-247-903-00
CARBON
CARBON
CARBON
CARBON
CARBON
100K
10K
12K
1M
1M
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
< RESISTOR >
Ref. No.
Remarks
F
F
F
F
R101
R102
R107
R108
R109
1-249-417-11
1-249-431-11
1-247-843-11
1-249-429-11
1-249-426-11
CARBON
CARBON
CARBON
CARBON
CARBON
1K
15K
3.3K
10K
5.6K
5%
5%
5%
5%
5%
1/4W F
1/4W
1/4W
1/4W
1/4W
R320
R321
R323
R324
R325
1-249-441-11
1-249-432-11
1-249-401-11
1-249-429-11
1-249-429-11
CARBON
CARBON
CARBON
CARBON
CARBON
100K
18K
47
10K
10K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W F
1/4W
1/4W
R110
R111
R112
R113
R114
1-249-425-11
1-249-401-11
1-249-427-11
1-249-419-11
1-249-417-11
CARBON
CARBON
CARBON
CARBON
CARBON
4.7K
47
6.8K
1.5K
1K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
F
F
F
F
F
R326
R327
R328
R329
R330
1-249-429-11
1-249-421-11
1-247-843-11
1-247-903-00
1-249-429-11
CARBON
CARBON
CARBON
CARBON
CARBON
10K
2.2K
3.3K
1M
10K
5%
5%
5%
5%
5%
1/4W
1/4W F
1/4W
1/4W
1/4W
R115
R116
R117
R118
R119
1-249-417-11
1-249-441-11
1-249-435-11
1-249-429-11
1-249-429-11
CARBON
CARBON
CARBON
CARBON
CARBON
1K
100K
33K
10K
10K
5%
5%
5%
5%
5%
1/4W F
1/4W
1/4W
1/4W
1/4W
R331
R332
R334
R335
R336
1-249-429-11
1-249-425-11
1-249-429-11
1-249-407-11
1-247-895-91
CARBON
CARBON
CARBON
CARBON
CARBON
10K
4.7K
10K
150
470K
5%
5%
5%
5%
5%
1/4W
1/4W F
1/4W
1/4W F
1/4W
R120
R123
R124
R125
R131
1-249-420-11
1-249-401-11
1-249-387-11
1-249-421-11
1-249-431-11
CARBON
CARBON
CARBON
CARBON
CARBON
1.8K
47
3.3
2.2K
15K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
F
F
F
F
R337
R338
R340
R341
R342
1-249-437-11
1-249-429-11
1-249-425-11
1-249-418-11
1-247-903-00
CARBON
CARBON
CARBON
CARBON
CARBON
47K
10K
4.7K
1.2K
1M
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W F
1/4W F
1/4W
R132
R133
R134
R201
R202
1-247-843-11
1-249-437-11
1-249-425-11
1-249-417-11
1-249-431-11
CARBON
CARBON
CARBON
CARBON
CARBON
3.3K
47K
4.7K
1K
15K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W F
1/4W F
1/4W
R344
R345
R346
R350
R361
1-249-401-11
1-249-425-11
1-249-429-11
1-249-441-11
1-249-417-11
CARBON
CARBON
CARBON
CARBON
CARBON
47
4.7K
10K
100K
1K
5%
5%
5%
5%
5%
1/4W F
1/4W F
1/4W
1/4W
1/4W F
R207
R208
R209
R210
R211
1-247-843-11
1-249-429-11
1-249-426-11
1-249-425-11
1-249-401-11
CARBON
CARBON
CARBON
CARBON
CARBON
3.3K
10K
5.6K
4.7K
47
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W F
1/4W F
R362
R363
R364
R365
R366
1-249-441-11
1-249-441-11
1-249-441-11
1-249-441-11
1-249-435-11
CARBON
CARBON
CARBON
CARBON
CARBON
100K
100K
100K
100K
33K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
— 74 —
MAIN
Ref. No.
POWER
Part No.
Description
Remarks
Ref. No.
Part No.
R367
R368
R369
R370
R371
1-249-441-11
1-249-441-11
1-249-417-11
1-249-413-11
1-249-441-11
CARBON
CARBON
CARBON
CARBON
CARBON
100K
100K
1K
470
100K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W F
1/4W F
1/4W
*
A-3321-150-A POWER BOARD, COMPLETE (US,CND)
***********************
A-3293-875-A POWER BOARD, COMPLETE (AEP,IT,UK,E)
***********************
R377
R700
R701
R702
R703
1-249-437-11
1-249-429-11
1-247-843-11
1-247-899-11
1-249-441-11
CARBON
CARBON
CARBON
CARBON
CARBON
47K
10K
3.3K
680K
100K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R704
R705
R706
R707
R708
1-247-896-11
1-249-439-11
1-249-441-11
1-249-437-11
1-249-441-11
CARBON
CARBON
CARBON
CARBON
CARBON
510K
68K
100K
47K
100K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R709
R710
R711
R712
R713
1-249-432-11
1-247-887-00
1-249-435-11
1-249-430-11
1-249-429-11
CARBON
CARBON
CARBON
CARBON
CARBON
18K
220K
33K
12K
10K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R714
R716
R718
R719
R720
1-247-903-00
1-249-411-11
1-249-393-11
1-249-441-11
1-249-441-11
CARBON
CARBON
CARBON
CARBON
CARBON
1M
330
10
100K
100K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W F
1/4W
1/4W
R721
R722
R723
R724
R725
1-249-441-11
1-249-441-11
1-249-440-11
1-249-440-11
1-247-891-00
CARBON
CARBON
CARBON
CARBON
CARBON
100K
100K
82K
82K
330K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R726
R727
R728
R731
R732
1-247-883-00
1-247-883-00
1-247-887-00
1-249-437-11
1-249-437-11
CARBON
CARBON
CARBON
CARBON
CARBON
150K
150K
220K
47K
47K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R733
R734
R735
R736
R737
1-247-843-11
1-249-417-11
1-249-429-11
1-247-903-00
1-249-429-11
CARBON
CARBON
CARBON
CARBON
CARBON
3.3K
1K
10K
1M
10K
5%
5%
5%
5%
5%
1/4W
1/4W F
1/4W
1/4W
1/4W
R738
R739
R740
R745
R746
1-247-887-00
1-249-417-11
1-249-417-11
1-249-417-11
1-249-435-11
CARBON
CARBON
CARBON
CARBON
CARBON
220K
1K
1K
1K
33K
5%
5%
5%
5%
5%
1/4W
1/4W F
1/4W F
1/4W F
1/4W
R747
R748
R749
R750
R751
1-247-863-91
1-249-437-11
1-247-843-11
1-249-417-11
1-249-430-11
CARBON
CARBON
CARBON
CARBON
CARBON
22K
47K
3.3K
1K
12K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W F
1/4W
R752
R754
R799
1-247-852-11 CARBON
1-249-437-11 CARBON
1-249-429-11 CARBON
7.5K
47K
10K
5%
5%
5%
1/4W
1/4W
1/4W
*
Description
Remarks
1-533-233-21 HOLDER, FUSE
7-685-646-79 SCREW +BVTP 3X8 TYPE2 IT-3
< CAPACITOR >
C900
C901
C902
C903
C904
1-128-548-11
1-101-005-00
1-101-005-00
1-101-005-00
1-101-005-00
C905
ELECT
CERAMIC
CERAMIC
CERAMIC
CERAMIC
4700uF
22000PF
22000PF
22000PF
22000PF
20%
25V
50V
50V
50V
50V
1-136-165-00 FILM
0.1uF
5%
C906
C907
C908
C909
1-161-055-00
1-161-055-00
1-126-967-11
1-126-934-11
CERAMIC
CERAMIC
ELECT
ELECT
0.022uF
0.022uF
47uF
220uF
50V
(AEP,IT,UK,E)
10%
50V
10%
50V
20%
10V
20%
10V
C910
C911
C912
C913
1-161-055-00
1-161-055-00
1-126-934-11
1-126-933-11
CERAMIC
CERAMIC
ELECT
ELECT
0.022uF
0.022uF
220uF
100uF
10%
10%
20%
20%
50V
50V
10V
10V
< CONNECTOR >
CN901
1-564-510-11 PLUG, CONNECTOR 7P
< DIODE >
D901
D902
D903
D904
D905
8-719-046-07
8-719-046-07
8-719-046-07
8-719-046-07
8-719-991-33
DIODE
DIODE
DIODE
DIODE
DIODE
2A02M
2A02M
2A02M
2A02M
1SS133T-77
D906
D907
D908
D909
D910
8-719-991-33
8-719-981-95
8-719-110-14
8-719-110-09
8-719-991-33
DIODE
DIODE
DIODE
DIODE
DIODE
1SS133T-77
MTZJ-2.7B
RD9.1ES-B3
RD8.2ES-B3
1SS133T-77
D911
8-719-991-33 DIODE 1SS133T-77
< FUSE >
! F901
! F901
1-532-505-31 FUSE (5A 250V) (AEP,IT,UK,E)
1-533-420-11 FUSE ,GLASS CYLINDRICAL (DIA.5) (5A 125V)
(US, CND)
< JACK >
! J901
! J901
1-540-009-11 INLET, AC (⁄ AC IN) (US,CND)
1-526-838-11 INLET, AC 2P (⁄ AC IN) (AEP,IT,UK,E)
< TRANSISTOR >
Q901
Q902
8-729-209-15 TRANSISTOR 2SD2012
8-729-209-15 TRANSISTOR 2SD2012
< VIBRATOR >
X701
1-767-226-11 VIBRATOR, CRYSTAL (16.9344NHz)
*************************************************************
— 75 —
The components identified by
mark ! or dotted line with mark
! are critical for safety.
Replace only with part number
specified.
Les composants identifiés par
une marque ! sont critiques
pour la sécurité.
Ne les remplacer que par une
pièce portant le numéro spécifié.
POWER
Ref. No.
RETAINER
Part No.
SW
SWITCH
Description
Remarks
Ref. No.
Part No.
< RESISTOR >
! R901
1-211-757-11 FUSIBLE
1
5%
1/2W F
! R902
1-211-757-11 FUSIBLE
1
5%
1/2W F
R903
1-249-410-11 CARBON
270
5%
1/4W F
R904
1-249-414-11 CARBON
560
5%
1/4W F
R905
1-249-421-11 CARBON
2.2K
5%
1/4W F
*************************************************************
1-666-862-11 RETAINER BOARD (US,CND)
***************
1-666-862-21 RETAINER BOARD (AEP,IT,UK,E)
***************
*
*
*************************************************************
1-662-742-11 SW BOARD
********
*
< CONNECTOR >
CN691
Description
Remarks
< IC >
1-580-170-11 PIN,CONNECTOR (PC BOARD) 9P
IC802
8-742-012-11 HY B IC SBX1976-51
< RESISTOR >
R862
R863
R864
R865
R866
1-249-425-11
1-249-415-11
1-249-416-11
1-249-418-11
1-249-420-11
CARBON
CARBON
CARBON
CARBON
CARBON
4.7K
680
820
1.2K
1.8K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
F
F
F
F
F
R867
R869
R870
R871
R872
1-247-843-11
1-249-427-11
1-249-432-11
1-249-425-11
1-249-415-11
CARBON
CARBON
CARBON
CARBON
CARBON
3.3K
6.8K
18K
4.7K
680
5%
5%
5%
5%
5%
1/4W
1/4W F
1/4W
1/4W F
1/4W F
R873
R874
R875
R876
R877
1-249-416-11
1-249-418-11
1-249-420-11
1-247-843-11
1-249-427-11
CARBON
CARBON
CARBON
CARBON
CARBON
820
1.2K
1.8K
3.3K
6.8K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R878
R879
R880
R881
R882
1-249-432-11
1-249-425-11
1-249-415-11
1-249-416-11
1-249-418-11
CARBON
CARBON
CARBON
CARBON
CARBON
18K
4.7K
680
820
1.2K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R883
R884
R885
R886
R887
1-249-420-11
1-247-843-11
1-249-427-11
1-249-410-11
1-249-432-11
CARBON
CARBON
CARBON
CARBON
CARBON
1.8K
3.3K
6.8K
270
18K
5%
5%
5%
5%
5%
1/4W F
1/4W
1/4W F
1/4W F
1/4W
R893
R895
1-249-407-11 CARBON
1-249-407-11 CARBON
150
150
5%
5%
1/4W F
1/4W F
F
F
F
F
< PHOTO INTERUPTER >
PH691
1-801-455-11 PHOTO REFLECTOR
< PLUNGER SOLENOID >
PM691
1-454-806-11 SOLENOID, PLUNGER
< RESISTOR >
R691
F
F
F
F
1-247-822-11 RES,CARBON (SMALL) 430
< SWITCH >
S691
1-762-811-11 SWITCH,LEAF (HALF)
S692
1-762-811-11 SWITCH,LEAF (CrO2)
S694
1-762-811-11 SWITCH,LEAF (ERASE PROOF A)
S695
1-762-811-11 SWITCH,LEAF (ERASE PROOF B)
S696
1-762-810-11 SWITCH,LEAF (HEAD POSITION)
*************************************************************
A-3321-154-A SWITCH BOARD, COMPLETE (US,CND,E)
***********************
A-3321-191-A SWITCH BOARD, COMPLETE (AEP,IT,UK)
***********************
*
*
1-782-632-11 WIRE, PARALLEL (FFC) (12 CORE)
< CONNECTOR >
* CN805
1-695-373-31 PIN, CONNECTOR (PC BOARD) 12P
< DIODE >
DIODE
DIODE
DIODE
DIODE
DIODE
SLR-342MGTC7 (CD ^)
SLR-342MGTC7 (CD p)
SLR-342MGTC7 (RADIO BOARD)
SLR-342MGTC7 (PRESET(+))
SLR-342MGTC7 (TAPE p)
D805
D806
D807
D808
D809
8-719-067-05
8-719-067-05
8-719-067-05
8-719-067-05
8-719-067-05
D810
D811
8-719-067-05 DIODE SLR-342MGTC7 (TAPE ”)
8-719-058-48 DIODE SLR-342VRTH7 (OPR/BATT)
< SWITCH >
S809
S810
S811
S812
S813
1-692-014-11
1-692-014-11
1-692-014-11
1-692-014-11
1-692-014-11
SWITCH, KEY BOARD (POWER)
SWITCH, KEY BOARD (TMER)
SWITCH, KEY BOARD (CD ^)
SWITCH, KEY BOARD (CD p)
SWITCH, KEY BOARD (DISPLAY/ENTER)
S814
S815
S816
S817
S818
1-692-014-11
1-692-014-11
1-692-014-11
1-692-014-11
1-692-014-11
SWITCH, KEY BOARD (EDIT)
SWITCH, KEY BOARD (VOL(–))
SWITCH, KEY BOARD (VOL(+))
SWITCH, KEY BOARD (RADIO BAND)
SWITCH, KEY BOARD (PRESET(–))
S819
S820
S821
S822
S823
1-692-014-11
1-692-014-11
1-692-014-11
1-692-014-11
1-692-014-11
SWITCH, KEY BOARD (PRESET(+))
SWITCH, KEY BOARD (TUNER(–))
SWITCH, KEY BOARD (TUNER(+))
SWITCH, KEY BOARD (TC-AMS(+))
SWITCH, KEY BOARD (TC-AMS(–))
S825
S826
S827
S828
S829
1-692-014-11
1-692-014-11
1-692-014-11
1-692-014-11
1-692-014-11
SWITCH, KEY BOARD (TAPE ”)
SWITCH, KEY BOARD (TAPE “)
SWITCH, KEY BOARD (TAPE p)
SWITCH, KEY BOARD (r/P)
SWITCH, KEY BOARD (DIR/MODE)
S830
1-692-014-11 SWITCH, KEY BOARD (COUNTER RESET)
*************************************************************
— 76 —
The components identified by
mark ! or dotted line with mark
! are critical for safety.
Replace only with part number
specified.
Les composants identifiés par
une marque ! sont critiques
pour la sécurité.
Ne les remplacer que par une
pièce portant le numéro spécifié.
TC
Ref. No.
Part No.
*
A-3293-842-A TC BOARD, COMPLETE (US,CND)
*******************
A-3293-869-A TC BOARD, COMPLETE (AEP,IT,UK,E)
*******************
*
Description
Remarks
Ref. No.
Part No.
Description
Remarks
< DIODE >
D401
D402
D403
8-719-991-33 DIODE 1SS133T-77
8-719-991-33 DIODE 1SS133T-77
8-719-991-33 DIODE 1SS133T-77
< CAPACITOR >
< IC >
C401
1-130-481-00 MYLAR
0.0068uF 5%
C401
1-130-482-00 MYLAR
0.0082uF 5%
C402
1-130-469-00 MYLAR
680PF
5%
C402
1-130-471-00 MYLAR
0.001uF
5%
C403
1-130-471-00 MYLAR
0.001uF
5%
C404
C405
C406
C407
C408
1-126-967-11
1-162-306-11
1-130-481-00
1-130-479-00
1-162-306-11
47uF
0.01uF
0.0068uF
0.0047uF
0.01uF
20%
30%
5%
5%
30%
10V
16V
50V
50V
16V
(US,CND)
C409
1-162-306-11 CERAMIC
0.01uF
30%
C410
C411
C412
C413
1-126-963-11
1-126-934-11
1-126-967-11
1-161-020-11
ELECT
ELECT
ELECT
CERAMIC
4.7uF
220uF
47uF
0.039uF
20%
20%
20%
10%
16V
(US,CND)
50V
10V
10V
25V
C414
C415
C416
C417
C418
1-126-964-11
1-126-966-11
1-126-964-11
1-126-967-11
1-126-967-11
ELECT
ELECT
ELECT
ELECT
ELECT
10uF
33uF
10uF
47uF
47uF
20%
20%
20%
20%
20%
C419
1-126-967-11 ELECT
47uF
20%
C420
1-126-967-11 ELECT
C499
C501
C502
1-136-165-00 FILM
1-162-301-11 CERAMIC
1-126-967-11 ELECT
10V
(AEP,IT,UK,E)
47uF
20%
10V
(AEP,IT,UK,E)
0.1uF
5%
50V
0.0015uF 20%
16V
47uF
20%
10V
C503
C504
C505
C506
C508
1-161-020-11
1-162-301-11
1-126-963-11
1-126-959-11
1-126-963-11
CERAMIC
CERAMIC
ELECT
ELECT
ELECT
0.039uF
0.0015uF
4.7uF
0.47uF
4.7uF
10%
30%
20%
20%
20%
C509
C510
C601
C602
C603
1-126-964-11
1-162-282-31
1-162-301-11
1-126-967-11
1-161-020-11
ELECT
CERAMIC
CERAMIC
ELECT
CERAMIC
10uF
100PF
0.0015uF
47uF
0.039uF
C604
C605
C606
C608
C609
1-162-301-11
1-126-963-11
1-126-959-11
1-126-963-11
1-126-964-11
CERAMIC
ELECT
ELECT
ELECT
ELECT
C610
1-162-282-31 CERAMIC
ELECT
CERAMIC
MYLAR
MYLAR
CERAMIC
50V
(AEP,IT,UK,E)
50V
(US,CND)
50V
(US,CND)
50V
(AEP,IT,UK,E)
50V
8-759-264-71 IC TA2068N
< COIL >
L501
L502
L601
L602
1-414-146-31
1-414-146-31
1-414-146-31
1-414-146-31
INDUCTOR
INDUCTOR
INDUCTOR
INDUCTOR
2.2uH
2.2uH
2.2uH
2.2uH
< TRANSISTOR >
Q401
Q402
Q403
Q405
Q406
8-729-036-80
8-729-036-80
8-729-036-86
8-729-115-80
8-729-115-80
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
KRC110M
KRC110M
KTC3203Y-AT
BA1A4P
BA1A4P
Q408
Q409
Q410
Q411
Q413
8-729-036-86
8-729-036-86
8-729-037-02
8-729-115-80
8-729-037-02
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
KTC3203Y-AT
KTC3203Y-AT
KTA1266Y-AT
BA1A4P
KTA1266Y-AT
< RESISTOR >
R401
R402
R403
R404
R405
1-249-393-11
1-249-401-11
1-249-429-11
1-249-425-11
1-249-393-11
CARBON
CARBON
CARBON
CARBON
CARBON
10
47
10K
4.7K
10
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R406
R407
R408
R409
R410
1-249-419-11
1-249-419-11
1-249-441-11
1-247-791-91
1-249-429-11
CARBON
CARBON
CARBON
CARBON
CARBON
1.5K
1.5K
100K
22
10K
5%
5%
5%
5%
5%
1/4W F
1/4W F
1/4W
1/4W
1/4W
25V
16V
50V
50V
50V
R411
R412
R413
R414
R416
1-249-429-11
1-247-843-11
1-247-843-11
1-247-843-11
1-247-903-00
CARBON
CARBON
CARBON
CARBON
CARBON
10K
3.3K
3.3K
3.3K
1M
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
20%
10%
20%
20%
10%
50V
50V
16V
10V
25V
R417
R418
R419
1-249-437-11 CARBON
1-249-425-11 CARBON
1-249-417-11 CARBON
47K
4.7K
1K
5%
5%
5%
R420
1-249-417-11 CARBON
1K
0.0015uF
4.7uF
0.47uF
4.7uF
10uF
30%
20%
20%
20%
20%
16V
50V
50V
50V
50V
R501
1-249-431-11 CARBON
15K
1/4W
1/4W F
1/4W F
(AEP,IT,UK,E)
5%
1/4W F
(AEP,IT,UK,E)
5%
1/4W
100PF
10%
50V
R502
R503
R504
R505
R506
1-249-403-11
1-249-440-11
1-247-843-11
1-249-417-11
1-249-417-11
CARBON
CARBON
CARBON
CARBON
CARBON
68
82K
3.3K
1K
1K
5%
5%
5%
5%
5%
1/4W F
1/4W
1/4W
1/4W F
1/4W F
R601
R602
R603
R604
R605
1-249-431-11
1-249-403-11
1-249-440-11
1-247-843-11
1-249-417-11
CARBON
CARBON
CARBON
CARBON
CARBON
15K
68
82K
3.3K
1K
5%
5%
5%
5%
5%
1/4W
1/4W F
1/4W
1/4W
1/4W F
< CONNECTOR >
* CN401
CN402
50V
16V
50V
10V
10V
IC401
1-695-337-31 PIN, CONNECTOR (PC BOARD) 14P
1-564-707-11 PIN, CONNECTOR (SMALL TYPE) 5P
— 77 —
F
F
F
F
TC
Ref. No.
R606
TERMINAL
Part No.
TUNER
Description
1-249-417-11 CARBON
1K
5%
Remarks
Ref. No.
Part No.
Description
1/4W F
C8
C9
C10
C11
C12
1-162-201-31
1-102-821-00
1-162-851-11
1-102-820-00
1-126-964-11
CERAMIC
CERAMIC
CERAMIC
CERAMIC
ELECT
12PF
360PF
0.1uF
330PF
10uF
5%
20%
50V
50V
16V
50V
50V
C13
C14
C15
C16
C17
1-162-306-11
1-161-061-11
1-161-024-00
1-161-024-00
1-126-963-11
CERAMIC
CERAMIC
CERAMIC
CERAMIC
ELECT
0.01uF
0.068uF
0.082uF
0.082uF
4.7uF
30%
10%
10%
10%
20%
16V
50V
25V
25V
50V
C18
C19
C22
C23
C24
1-126-967-11
1-162-306-11
1-162-306-11
1-161-055-00
1-161-055-00
ELECT
CERAMIC
CERAMIC
CERAMIC
CERAMIC
47uF
0.01uF
0.01uF
0.022uF
0.022uF
20%
30%
30%
10%
10%
16V
16V
16V
50V
50V
C26
C27
C28
C29
C44
1-162-306-11
1-104-666-11
1-126-963-11
1-126-963-11
1-161-051-00
CERAMIC
ELECT
ELECT
ELECT
CERAMIC
0.01uF
220uF
4.7uF
4.7uF
0.01uF
30%
20%
20%
20%
10%
16V
25V
50V
50V
50V
C45
C46
C47
C48
C49
1-136-177-00
1-126-964-11
1-162-306-11
1-126-964-11
1-162-306-11
FILM
ELECT
CERAMIC
ELECT
CERAMIC
1uF
10uF
0.01uF
10uF
0.01uF
5%
20%
30%
20%
30%
50V
50V
16V
50V
16V
C50
C51
C53
C54
C55
1-162-294-31
1-162-294-31
1-162-294-31
1-102-518-11
1-162-199-31
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.001uF
0.001uF
0.001uF
33PF
10PF
10%
10%
10%
5%
5%
50V
50V
50V
50V
50V
C57
C58
C59
C62
C63
1-162-282-31
1-162-306-11
1-162-306-11
1-162-294-31
1-162-306-11
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
100PF
0.01uF
0.01uF
0.001uF
0.01uF
10%
30%
30%
10%
30%
50V
16V
16V
50V
16V
C64
C66
C67
C68
C69
1-162-198-31
1-161-051-00
1-162-294-31
1-162-215-31
1-162-306-11
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
8.2PF
0.01uF
0.001uF
47PF
0.01uF
10%
10%
10%
5%
30%
50V
50V
50V
50V
16V
C71
C72
C73
C74
1-162-294-31
1-162-294-31
1-136-177-00
1-162-306-11
CERAMIC
CERAMIC
FILM
CERAMIC
0.001uF
0.001uF
1uF
0.01uF
10%
10%
5%
30%
50V
50V
50V
16V
< TRANSFORMER >
T401
1-433-372-11 TRANSFORMER, BIAS OSCILLATION
*************************************************************
1-666-855-11 TERMINAL BOARD (US,CND)
***************
1-666-855-21 TERMINAL BOARD (AEP,IT,UK,E)
***************
*
*
< CAPACITOR >
C421
C441
C442
1-162-294-31 CERAMIC
1-126-964-11 ELECT
1-162-851-11 CERAMIC
0.001uF
10uF
0.1uF
10%
20%
10%
50V
50V
16V
< CONNECTOR >
CN441
* CN442
1-564-723-11 PIN, CONNECTOR (SMALL TYPE) 7P
1-564-719-11 PIN, CONNECTOR (SMALL TYPE) 3P
Remarks
5%
5%
< DIODE >
D441
8-719-067-15 DIODE SLR-342MGTH7 (MD LINE)
< FERRITE BEAD >
FB401
1-410-397-21 FERRITE BEAD INDUCTOR
< IC >
IC441
8-749-921-12 IC GP1F32T
< JACK >
J441
J442
1-566-891-21 JACK (LINE IN)
1-566-891-21 JACK (LINE OUT)
< COIL >
L401
L402
1-410-509-11 INDUCTOR
1-410-509-11 INDUCTOR
10uH
10uH
< RESISTOR >
R441
1-249-407-11 CARBON
150
5%
1/4W F
< SWITCH >
S441
1-570-940-11 SWITCH, KEY BOARD (MD LINE)
*************************************************************
< FILTER >
A-3321-151-A TUNER BOARD, COMPLETE (US,CND)
**********************
*
CF1
CF2
CF3
CF4
1-533-313-11 HOLDER, FUSE
1-760-127-11
1-760-127-11
1-760-127-11
1-579-762-11
FILTER, CERAMIC
FILTER, CERAMIC
FILTER, CERAMIC
VIBRATOR, CERAMIC
< CAPACITOR >
< COMPOSITION CIRCUIT BLOCK >
C2
C3
C4
C5
C7
1-162-294-31
1-162-306-11
1-102-514-11
1-162-203-31
1-161-055-00
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.001uF
0.01uF
22PF
15PF
0.022uF
10%
30%
5%
5%
10%
50V
16V
50V
50V
50V
CFT1
1-239-173-11 ENCAPSULATED COMPONENT
< CONNECTOR >
* CN1
— 78 —
1-695-374-31 PIN, CONNECTOR (PC BOARD) 13P
TUNER
Ref. No.
Part No.
Description
Remarks
Ref. No.
< TRIMMER >
CT1
CT2
1-141-411-11 CAP, ADJ 20PF
1-141-411-11 CAP, ADJ 20PF
Part No.
Description
R26
R27
R28
R29
R30
1-249-425-11
1-249-429-11
1-249-437-11
1-249-415-11
1-249-412-11
CARBON
CARBON
CARBON
CARBON
CARBON
4.7K
10K
47K
680
390
5%
5%
5%
5%
5%
1/4W F
1/4W
1/4W
1/4W F
1/4W F
Remarks
R35
R35
R37
R38
R39
1-249-417-11
1-249-421-11
1-249-429-11
1-249-421-11
1-249-429-11
CARBON
CARBON
CARBON
CARBON
CARBON
1K
2.2K
10K
2.2K
10K
5%
5%
5%
5%
5%
1/4W F
1/4W F
1/4W
1/4W F
1/4W
R40
R41
R42
R43
R46
1-249-429-11
1-249-417-11
1-249-417-11
1-249-437-11
1-249-437-11
CARBON
CARBON
CARBON
CARBON
CARBON
10K
1K
1K
47K
47K
5%
5%
5%
5%
5%
1/4W
1/4W F
1/4W F
1/4W
1/4W
R55
R56
R57
R58
R59
1-249-421-11
1-249-407-11
1-249-399-11
1-249-411-11
1-249-437-11
CARBON
CARBON
CARBON
CARBON
CARBON
2.2K
150
33
330
47K
5%
5%
5%
5%
5%
1/4W F
1/4W F
1/4W F
1/4W
1/4W
R60
R66
1-249-425-11 CARBON
1-249-437-11 CARBON
4.7K
47K
5%
5%
1/4W F
1/4W
< DIODE >
D1
D2
D3
D6
D7
8-719-050-72
8-719-050-72
8-719-050-69
8-719-991-33
8-719-991-33
DIODE
DIODE
DIODE
DIODE
DIODE
KV1370NT
KV1370NT
KV1520N
1SS133T-77
1SS133T-77
< FILTER >
FL1
1-236-022-11 FILTER, BAND PASS
< IC >
IC1
IC3
8-759-386-02 IC TA2008AN
8-759-290-61 IC BU2615S
< JUMPER RESISTOR >
JW22
1-249-421-11 CARBON
2.2K
5%
1/4W F
< COIL >
< VIBRATOR >
L1
L2
L3
L4
L5
1-409-905-31
1-409-905-31
1-501-762-11
1-411-234-21
1-410-336-11
COIL, FM RF
COIL, FM RF
ANTENNA, FERRITE-ROD (MW)
COIL, AM OSC
INDUCTOR
220uH
L7
L8
1-410-336-11 INDUCTOR
1-410-509-11 INDUCTOR
X1
1-760-130-11 VIBRATOR, CRYSTAL (75kHz)
*************************************************************
A-3321-189-A TUNER BOARD, COMPLETE (AEP,IT,UK,E)
***********************
*
220uH
10uH
1-533-313-11 HOLDER, FUSE
< TRANSISTOR >
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
< CAPACITOR >
Q1
Q2
Q3
Q4
Q15
8-729-115-80
8-729-115-80
8-729-115-80
8-729-115-80
8-729-422-57
BA1A4P
BA1A4P
BA1A4P
BA1A4P
UN4111
Q17
Q18
Q19
8-729-012-83 TRANSISTOR 2SK679A
8-729-922-66 TRANSISTOR 2SC2410SN
8-729-106-07 TRANSISTOR 2SK514-H
< RESISTOR >
C1
C2
C3
C4
C5
1-162-294-31
1-162-306-11
1-102-960-00
1-162-203-31
1-101-005-00
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.001uF
0.01uF
24PF
15PF
22000PF
C6
C7
C8
C9
C10
1-101-005-00
1-161-055-00
1-162-195-31
1-102-973-00
1-102-823-11
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
22000PF
0.022uF
4.7PF
100PF
430PF
10%
30%
5%
5%
10%
10%
5%
5%
50V
16V
50V
50V
50V
50V
50V
50V
50V
50V
R1
R2
R3
R4
R5
1-249-441-11
1-247-887-00
1-249-431-11
1-249-429-11
1-249-428-11
CARBON
CARBON
CARBON
CARBON
CARBON
100K
220K
15K
10K
8.2
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W F
C11
C12
C14
C15
C16
1-162-199-31
1-136-013-11
1-162-851-11
1-161-494-00
1-126-963-11
CERAMIC
FILM
CERAMIC
CERAMIC
ELECT
10PF
360PF
0.1uF
0.022uF
4.7uF
5%
5%
20%
50V
50V
16V
25V
50V
R6
R7
R8
R9
R10
1-247-887-00
1-249-411-11
1-247-863-91
1-249-421-11
1-249-425-11
CARBON
CARBON
CARBON
CARBON
CARBON
220K
330
22K
2.2K
4.7K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W F
1/4W F
C17
C18
C19
C20
C21
1-162-288-31
1-162-306-11
1-126-964-11
1-162-849-11
1-162-850-11
CERAMIC
CERAMIC
ELECT
CERAMIC
CERAMIC
330PF
0.01uF
10uF
0.068uF
0.082uF
10%
30%
20%
10%
10%
50V
16V
50V
16V
16V
R11
R14
R18
R19
R25
1-247-815-91
1-247-807-31
1-249-417-11
1-249-417-11
1-249-429-11
CARBON
CARBON
CARBON
CARBON
CARBON
220
100
1K
1K
10K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W F
1/4W F
1/4W
C22
C23
C24
C25
C26
1-162-850-11
1-161-053-00
1-161-053-00
1-162-306-11
1-162-306-11
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.082uF
0.015uF
0.015uF
0.01uF
0.01uF
10%
10%
10%
30%
30%
16V
50V
50V
16V
16V
— 79 —
TUNER
Ref. No.
Part No.
Description
C27
C28
C29
C30
C31
1-126-933-11
1-102-518-11
1-162-199-31
1-162-306-11
1-162-306-11
ELECT
CERAMIC
CERAMIC
CERAMIC
CERAMIC
100uF
33PF
10PF
0.01uF
0.01uF
20%
5%
5%
30%
30%
10V
50V
50V
16V
16V
Remarks
C32
C33
C34
C35
C36
1-162-306-11
1-162-306-11
1-162-294-31
1-162-294-31
1-162-294-31
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.01uF
0.01uF
0.001uF
0.001uF
0.001uF
30%
30%
10%
10%
10%
16V
16V
50V
50V
50V
C37
C38
C39
C40
C41
1-126-964-11
1-162-306-11
1-126-964-11
1-162-306-11
1-136-177-00
ELECT
CERAMIC
ELECT
CERAMIC
FILM
10uF
0.01uF
10uF
0.01uF
1uF
20%
30%
20%
30%
5%
50V
16V
50V
16V
50V
C42
C44
C45
C52
C53
1-130-483-00
1-126-963-11
1-126-963-11
1-162-306-11
1-162-306-11
MYLAR
ELECT
ELECT
CERAMIC
CERAMIC
0.01uF
4.7uF
4.7uF
0.01uF
0.01uF
5%
20%
20%
30%
30%
50V
50V
50V
16V
16V
C55
C56
C59
C60
C61
1-162-306-11
1-162-306-11
1-162-306-11
1-162-282-31
1-162-306-11
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.01uF
0.01uF
0.01uF
100PF
0.01uF
30%
30%
30%
10%
30%
16V
16V
16V
50V
16V
C63
C64
C67
C68
C69
1-162-294-31
1-162-294-31
1-162-195-31
1-162-306-11
1-162-215-31
CERAMIC
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.001uF
0.001uF
4.7PF
0.01uF
47PF
10%
10%
10%
30%
5%
50V
50V
50V
16V
50V
C71
C72
C80
C81
1-126-933-11
1-162-306-11
1-162-294-31
1-162-306-11
ELECT
CERAMIC
CERAMIC
CERAMIC
100uF
0.01uF
0.001uF
0.01uF
20%
30%
10%
30%
16V
16V
50V
16V
Ref. No.
Part No.
Description
Remarks
< DIODE >
D1
D2
D3
D4
D5
8-719-991-33
8-719-991-33
8-719-050-72
8-719-050-72
8-719-050-69
DIODE
DIODE
DIODE
DIODE
DIODE
1SS133T-77
1SS133T-77
KV1370NT
KV1370NT
KV1520N
< FILTER >
FL1
1-236-022-11 FILTER, BAND PASS
< IC >
IC1
IC2
8-759-386-02 IC TA2008AN
8-759-290-61 IC BU2615S
< COIL >
L1
L2
L3
L4
L6
1-409-905-11
1-409-904-11
1-501-752-11
1-411-199-31
1-410-336-11
COIL, FM RF
COIL, FM OSC
ANTENNA, FERRITE-ROD (LW.MW)
COIL, MW/LW OSC
INDUCTOR
220uH
L7
L11
L20
1-410-521-11 INDUCTOR
1-410-517-11 INDUCTOR
1-410-509-11 INDUCTOR
100uH
47uH
10uH
< TRANSISTOR >
< FILTER >
CF1
CF2
CF3
CF4
1-760-468-11
1-760-468-11
1-760-468-11
1-579-762-11
FILTER, CERAMIC
FILTER, CERAMIC
FILTER, CERAMIC
VIBRATOR, CERAMIC
Q1
Q2
Q3
Q4
Q5
8-729-119-32
8-729-922-66
8-729-922-66
8-729-905-50
8-729-178-62
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SK193
2SC2410SN
2SC2410SN
DTC343TS
2SC2786-L
Q6
Q9
Q10
Q11
Q12
8-729-922-66
8-729-029-72
8-729-029-72
8-729-029-72
8-729-029-72
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC2410SN
DTC114YS-TP
DTC114YS-TP
DTC114YS-TP
DTC114YS-TP
Q13
Q14
Q15
Q16
Q17
8-729-012-83
8-729-106-07
8-729-029-72
8-729-029-72
8-729-902-80
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SK679A
2SK514-H
DTC114YS-TP
DTC114YS-TP
DTA114YS
Q18
Q21
Q22
Q23
8-729-029-72
8-729-422-57
8-729-422-57
8-729-922-66
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
DTC114YS-TP
UN4111
UN4111
2SC2410SN
< COMPOSITION CIRCUIT BLOCK >
CFT1
1-239-173-11 ENCAPSULATED COMPONENT
< CONNECTOR >
* CN1
1-695-374-31 PIN, CONNECTOR (PC BOARD) 13P
< TRIMMER >
CT1
CT2
CT3
CT4
CT5
1-141-411-11
1-141-411-11
1-141-459-11
1-141-486-11
1-141-411-11
CAP, ADJ 20PF
CAP, ADJ 20PF
CAP, TRIMMER (SEAL TYPE) 45PF
CAP, ADJ 10PF
CAP, ADJ 20PF
< RESISTOR >
R1
R2
R3
R4
R5
1-247-887-00
1-249-441-11
1-249-431-11
1-249-413-11
1-249-417-11
CARBON
CARBON
CARBON
CARBON
CARBON
220K
100K
15K
470
1K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W F
1/4W F
R6
R7
R9
R10
R11
1-249-425-11
1-249-425-11
1-249-425-11
1-249-429-11
1-247-887-00
CARBON
CARBON
CARBON
CARBON
CARBON
4.7K
4.7K
4.7K
10K
220K
5%
5%
5%
5%
5%
1/4W F
1/4W F
1/4W F
1/4W
1/4W
— 80 —
TUNER
Ref. No.
Part No.
Description
R12
R13
R14
R19
R20
1-249-425-11
1-247-807-31
1-249-427-11
1-249-421-11
1-247-863-91
CARBON
CARBON
CARBON
CARBON
CARBON
4.7K
100
6.8K
2.2K
22K
5%
5%
5%
5%
5%
1/4W F
1/4W
1/4W F
1/4W F
1/4W
Remarks
R21
R22
R23
R24
R25
1-249-404-00
1-249-429-11
1-249-421-11
1-249-429-11
1-249-429-11
CARBON
CARBON
CARBON
CARBON
CARBON
82
10K
2.2K
10K
10K
5%
5%
5%
5%
5%
1/4W F
1/4W
1/4W F
1/4W
1/4W
R26
R27
R28
R29
R34
1-249-417-11
1-249-417-11
1-249-429-11
1-249-429-11
1-249-415-11
CARBON
CARBON
CARBON
CARBON
CARBON
1K
1K
10K
10K
680
5%
5%
5%
5%
5%
1/4W F
1/4W F
1/4W
1/4W
1/4W F
R35
R36
R37
R38
R39
1-249-412-11
1-249-437-11
1-249-417-11
1-249-427-11
1-249-429-11
CARBON
CARBON
CARBON
CARBON
CARBON
390
47K
1K
6.8K
10K
5%
5%
5%
5%
5%
1/4W F
1/4W
1/4W F
1/4W F
1/4W
R40
R42
R43
R44
R49
1-249-421-11
1-249-437-11
1-249-437-11
1-249-429-11
1-249-421-11
CARBON
CARBON
CARBON
CARBON
CARBON
2.2K
47K
47K
10K
2.2K
5%
5%
5%
5%
5%
1/4W F
1/4W
1/4W
1/4W
1/4W F
R50
R51
R52
R53
R54
1-249-417-11
1-249-441-11
1-249-441-11
1-249-441-11
1-249-413-11
CARBON
CARBON
CARBON
CARBON
CARBON
1K
100K
100K
100K
470
5%
5%
5%
5%
5%
1/4W F
1/4W
1/4W
1/4W
1/4W F
R55
R56
R57
R58
R59
1-249-437-11
1-249-411-11
1-247-791-91
1-247-883-00
1-249-421-11
CARBON
CARBON
CARBON
CARBON
CARBON
47K
330
22
150K
2.2K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W F
R60
R70
R71
R72
R73
1-249-407-11
1-247-887-00
1-247-815-91
1-249-417-11
1-249-417-11
CARBON
CARBON
CARBON
CARBON
CARBON
150
220K
220
1K
1K
5%
5%
5%
5%
5%
1/4W F
1/4W
1/4W
1/4W F
1/4W F
R75
R77
1-249-404-00 CARBON
1-249-429-11 CARBON
82
10K
5%
5%
1/4W F
1/4W
< VIBRATOR >
X1
1-760-130-11 VIBRATOR, CRYSTAL (75kHz)
*************************************************************
Ref. No.
Part No.
Description
Remarks
MISCELLANEOUS
***************
5
6
103
106
117
1-505-742-11
1-501-480-11
1-692-960-11
1-452-732-11
1-782-631-11
! 151
8-848-483-05
HRPE101 1-500-480-11
J301
1-566-891-11
M691
X-3374-291-1
M702
X-2625-769-1
SPEAKER (8CM)
ANTENNA, TELESCOPIC
SWITCH, PUSH (1 KEY)
MAGNET
WIRE, PARALLEL (FFC) (16 CORE)
OPTICAL, PIC-UP KSS-213C/Q-RP
HEAD, MAGNETIC (REC/PB/ERASE)
JACK (H/P JACK)
MOTOR ASSY
GEAR ASSY (MB), MOTOR
! T901
1-431-483-11 TRANSFORMER, POWER (US,CND)
! T901
1-431-484-11 TRANSFORMER, POWER (AEP,IT,UK,E)
*************************************************************
ACCESSORIES & PACKING MATERIALS
********************************
1-590-147-11
1-690-952-21
1-696-820-21
1-770-019-11
3-704-222-11
!
!
!
!
CORD, POWER (CND)
CORD, POWER (US)
CORD, POWER (AEP,IT,UK,E)
ADAPTOR, CONVERSION PLUG 3P (UK)
LABEL, SERIAL NUMBER (PRINTER)
3-860-693-11 MANUAL, INSTRUCTION (US,CND) (ENGLISH)
3-860-693-21 MANUAL, INSTRUCTION (CND) (FRENCH)
3-860-693-31 MANUAL, INSTRUCTION (AEP,UK,E)
(ENGLISH,SPANISH)
3-860-693-41 MANUAL, INSTRUCTION (AEP,E)
(FRENCH,GERMAN)
3-860-693-51 MANUAL, INSTRUCTION (AEP)
(DUTCH,PORTUGUESE)
3-860-693-61 MANUAL, INSTRUCTION (AEP)
(SWEDISH,FINNISH)
3-860-693-71 MANUAL, INSTRUCTION (IT) (ITALIAN)
4-991-047-01 LID, BATTERY CASE
(FOR REMOTE COMMANDER)
8-917-611-90 REMOCON RMT-CD5AD SET (AEP,IT,UK,E)
8-917-612-90 REMOTE COMMANDER RMT-CD5A SET
(US,CND)
*************************************************************
**************
HARDWARE LIST
**************
#1
#2
#3
#4
#5
7-685-647-79
7-685-535-14
7-685-533-14
7-682-549-09
7-685-649-79
SCREW +BVTP 3X10 TYPE2 IT-3
SCREW +BTP 2.6X10 TYPE2 N-S
SCREW +BTP 2.6X6 TYPE2 N-S
SCREW +B 3X10
SCREW +BVTP 3X14 TYPE2 N-S
#6
#7
#8
7-685-903-31 SCREW +PTPWH 3X10 TYPE2
7-685-533-19 SCREW +BTP 2.6X6 TYPE2 N-S
7-685-646-79 SCREW, TAPPING +BV 3X8
The components identified by
mark ! or dotted line with mark
! are critical for safety.
Replace only with part number
specified.
— 81 —
Les composants identifiés par
une marque ! sont critiques
pour la sécurité.
Ne les remplacer que par une
pièce portant le numéro spécifié.
ZS-D5
Sony Corporation
9-923-270-11
Personal A&V Products Company
— 82 —
98C1690-1
Printed in Japan ©1998.3
Published by Quality Engineering Dept.
(Shibaura)
ZS-D5
Ver 1.3 2000.2
US Model
Canadian Model
AEP Model
UK Model
E Model
SERVICE MANUAL
1998.11
SUPPLEMENT-1
File this supplement-1 with the Service Manual.
• The following parts are changed to the new parts
from the serial numbers as described below.
The new and former parts have different colors.
(SPM-98011)
Destination
US Model
AEP Model
UK Model
E Model
Serial No.
7136231 to
7136531 to
7138299 to
7122176 to
: indicates changed portion
Page
OLD
Ref. No.
64
Part No.
NEW
Description
Remarks
Ref. No.
Description
Remarks
1
X-3375-238-1 CABINET SUB ASSY, FRONT
1
X-3376-357-1 CABINET SUB ASSY, FRONT
2
X-3375-236-1 HOLDER SUB ASSY, JACK
2
X-3376-361-1 HOLDER SUB ASSY, JACK
4
X-3375-239-1 HOLDER SUB ASSY, CASSETTE
4
X-3376-359-1 HOLDER SUB ASSY, CASSETTE
13
3-017-456-11 BUTTON, POWER (US,CND,E)
13
3-017-456-41 BUTTON, POWER (US,E)
13
3-017-456-21 BUTTON, POWER (AEP,IT,UK)
13
3-017-456-51 BUTTON, POWER (AEP,UK)
14
X-3375-237-1 BUTTON SUB ASSY, CONTROL
14
X-3376-363-1 BUTTON SUB ASSY, CONTROL
15
3-017-457-01 BUTTON, VOLUME
15
3-017-457-11 BUTTON, VOLUME
Sony Corporation
9-923-270-82
Part No.
Personal A&V Products Company
98K1690-1
Printed in Japan ©1998.11
Published by Quality Engineering Dept.
(Shibaura)

Top types

Top brands

Top types

Top brands

Top types

Top brands

Top types

Top brands

Top types

Top brands

Top types

Top brands

Top types

Top brands

Top types

Top brands

Top types

Top brands

Top types

Top brands

Top types

Top brands

Top types

Top brands

Top types

Top brands

Download service manual personal audio system