1
Download Sanyo VCC9615P User's Manual
Transcript
FILE NO. SERVICE MANUAL COLOUR CCD Camera VCC-9615P (Product Code : 117 047 15) (Europe) SPECIFICATIONS TV system : PAL standard (625 TV lines, 25 frames/sec.) Scanning system : 625 TV lines, 50 field/sec., 2:1 interlace Image device : Interline transfer method, 1/3 inch solid state CCD Picture elements : 795 (Horizontal) x 596 (Vertical) Effective picture elements : 752 (Horizontal) x 582 (Vertical) Synchronization system : Internal sync. Resolution : 480 TV lines horizontally, 400 TV lines vertically Video output signal level : 1.0 Vp-p/75 Ω (screw-on terminal) S/N ratio : More than 48 dB Minimum required illumination : 1.8 lux (F 1.6 lens) White balance : A (Automatic: TTL system)/M (Manual) manual switching Backlight compensation : 1 (On)/0 (Off) manual switching, Active-zone light measuring system Backlight compensation iris level adjustment : Manual LEVEL volume control Aperture : 1 (High)/0 (Normal) manual switching Gain control : Automatic MONITOR output pin : 1.0 Vp-p/75 Ω, test point pin Lens : F1.6 ~ 2.3, f=2.6 ~ 6.0 mm, varifocal lens, manual zoom and focus adjustment Iris system : Mechanical auto iris Operational environmental conditions : Temperature: -10 °C ~ + 50 °C Humidity: less than 90 % Storage environmental conditions : Temperature: -20 °C ~ + 60 °C Humidity: less than 70 % Power supply : 12-15 V DC/ 24 V AC, 50 Hz Power consumption : 3.5 W Weight : Approx. 420 g CONTENTS 1. DISASSEMBLY, VR AND TP LOCATION AND BOARD LOCATION .................... 2 2. ADJUSTMENT .....................................3 3. PARTS LIST ......................................... 5 CIRCUIT DIAGRAM & PRINTED WIRING BOARDS ................. C1 PRODUCT SAFETY NOTICE The components designated by a symbol ( ! ) in this schematic diagram designates components whose value are of special significance to product safety. Should any component designated by a symbol need to be replaced, use only the part designated in the Parts List. Do not deviate from the resistance, wattage, and voltage ratings shown. NOTE : 1. Parts order must contain model number, part number, and description. 2. Substitute parts may be supplied as the service parts. 3. N. S. P. : Not available as service parts. Design and specification are subject to change without notice. L5AR2/XE REFERENCE No. SM5310516 1. DISASSEMBLY, VR AND TP LOCATION AND BOARD LOCATION 1. Dec window 2. Four screws 2 x 5 3. Four screws 2.6 x 4 4. Lid 5. Four screws 2 x 5 3 6. Two FPCs 7. Connector 9 8. CA2 board 9. Two screws 2 x 5 10 10. CA3 board 11. Two screws 3 x 8 2 12. Two Pipes 13. Two special washers 11 14. Cover front 15. Cover back 12 7 5 13 4 6 16. Food iris 17. Two screws 2 x 6 12 18. Connector 19. CA1 board 2 8 2 15 11 13 17 16 18 1 17 14 19 CT232 CA2 board VR244 TP200 TP200 CA1 board CA3 board CA-2 board (Side B) VR303 VR302 CA-3 board (Side A) –2– 2-3-1. Computer screen during adjustment 2. ADJUSTMENT 2-1. ADJUSTMENT CONDITION x ADJUSTMENT (VHJ_0159) Ver.1.00 1. Use the 5,100K viewer for the subject. 2. Set the trigger signal of oscilloscope to VIDEO OUT, and apply H sync unless specified. 3. Set S3001 (CA-3) to the all OFF position. 4. In adjustments without direction to display charts, shield light with a lens cap to provide dark condition. 5. Connect the video output to a video monitor with an input impedance of 75 Ω. 6. Ground test point is TP200 (CA-2). SCHEDULE Rom Clear(Others Adj Value) Adj.WhiteClip Awb.Off(Manual White Balance) Agc Off(AutoIrisLens Adj) Adj.Agc Adj.Chroma Wait Inkey Adj.CCD White Defect Detection START NEXT STOP + – 5,100 K viewer STATUS CCD camera H CLOSE L CS mount surface L= (H + h)2 From 2-4. to 2-9. adjustments are continuous adjustment by adjustment software. x f – 12.5 mm Hxh L: Distance from CS mount to pattern (mm) H: Pattern height (mm) 2-4. White Clip Adjustment Adjustment location: Measuring location: VIDEO OUT Measuring equipment: Oscilloscope Subject: No designation Adjusting method: 1. Click the adjustment software installed from the personal computer, and the adjustment window will be displayed. 2. Click the start button. Rom clear to be white clip adjustment. 3. Display the viewer 2-10 µsec at the edge of the screen. f : Lens focal length (standard 12 mm) h: Height (4.8 mm) of CCD imaging surface Note : The video monitor should be an under-scan TV. 2-2. PREPARATION 1. Install the adjustment software (VHJ-0157) in a computer running the Windows operating system. 2. Use the adjustment tool (VHJ-0127) to connect the camera to be adjusted to the serial port of the computer with RS232C cross cable, and then turn on the power for the computer and the camera. 3. Use COM1 serial port on the computer. 4. Adjust (+) and (-) button so that the adjustment value is 830 ± 10 mVp-p. 2~10 µsec 2-3. TABLE FOR SERVICING TOOLS Name Ref. No. 830 ± 10 mVp-p Part code J-1 Color viewer VJ8-0007 J-2 Adjustment jig VHJ-0127 J-3 Calibration software VHJ-0159 J-4 Chart for color adjustment VJ8-0155 VIDEO OUT 2-5. White Balance Adjustment Adjustment location: VR302, VR303 (CA-3) Measuring location: VIDEO OUT Measuring equipment: Oscilloscope, Vectorscope Subject: Color bar chart Adjusting method: 1. Display the color bar chart at designated picture angle. 2. Click the “NEXT” button to be white balance adjustment. 3. Adjust VR302 and VR303 so that the luminescent spot representing white is overlapping with the crosshair mark in the center of the vectorscope. –3– 30 µsec 30 µsec VIDEO OUT VIDEO OUT After finishing AGC level adjustment, start Hue and chroma adjustment automatically. cy g R MG 2-8. Hue and Chroma Adjustment v Adjustment location: Computer screen Measuring location: VIDEO OUT Measuring equipment: Oscilloscope, vectorscope, color bar chart Subject: Color bar chart (Display the color bar chart at designated picture angle.) 1. Adjust “Adj.Chroma” in the adjustment window. 75% 100% YL b U yl B G Cy mg 2-6. Iris Level Adjustment Adjustment location: VR244 (CA-1) Measuring location: VIDEO OUT Measuring equipment: Oscilloscope, color bar chart Subject: Gray scale chart Adjusting method: 1. Display the color bar chart at designated picture angle. 2. Click the “NEXT” to be “Agc Off(AutoIrisLens Adj)” in the adjustment window. 3. Turn the VR244 to the right so that the white level is maximum. 4. Turn the VR244 to the left so that the output level is 550 ± 20 mVp-p. 30 µsec VIDEO OUT 2-9. CCD White Point Defect Detect Adjustment Measuring location: VIDEO OUT Measuring equipment: Monitor display Adjustment method: 1. After finishing Hue and Chroma adjustment, shield light with a lens cap to provide dark condition. 2. Click the “NEXT” button to be CCD White Point Defect Detect Adjustment. 3. After completing this adjustment, it comfirms that white point can not be seen on the monitor display. 4. “OK” will display in the “STATUS”. 5. Click the “CLOSE” in the adjustment window, and complete the adjustment window. 550 ± 20 mVp-p 30 µsec VIDEO OUT 2-10. 28 MHz VCO Voltage ADJUSTMENT Adjustment location: CT232 (CA-2) Measuring location: TP232 (CA-2) Measuring equipment: Digital voltmeter Subject: No designation Adjusting method: 1. Adjust with CT232 to 6.0 ± 0.2 V. 2-7. AGC Level ADJUSTMENT Adjustment location: Computer screen Measuring location: VIDEO OUT Measuring equipment: Oscilloscope, color bar chart Subject: Gray scale chart Adjusting method: 1. Display the color bar chart at designated picture angle. 2. Click the “NEXT” to be “Adj.Agc” in the adjustment window. –4– 3. PARTS LIST LOCATION PARTS NO. DESCRIPTION LOCATION 6020 6021 6022 6023 6027 6028 6030 6035 6050 8000 8001 8002 CA1 CA2 CA3 NJ506 NJ510 NJ515 NJ600 NJ615 NJ620 NJ625 NJ630 NJ635 NJ640 ACCESSORIES & PACKING MATERIALS 9102 9103 9201 7001 7002 7010 613 200 9003 613 201 6414 411 073 6705 613 200 8983 613 182 2375 613 139 4896 INSTRUCTION MANUAL, English, French INSTRUCTION MANUAL,German, Chinese SCR TPG PAN 4X35 CARTON CASE INNER CUSHION P.E COVER CABINET & CHASSIS PARTS 5005 5010 5015 5016 5017 6005 6006 6007 6010 6011 6012 6013 6014 6015 636 044 4706 636 044 4980 636 052 2138 636 029 7876 636 045 0059 613 179 1848 613 179 1855 613 180 9376 613 179 1862 613 163 5258 613 194 2813 613 194 1199 613 179 6027 613 180 9383 CABINET DEC WINDOW TERMINAL BASE TERMINAL EARTH COVER FRONT COVER BACK HOOD LENS OPTICAL BASE SPACER HOLDER CCD SPACER INSULATOR HOLDER CCD HOOD IRIS PARTS NO. 636 051 6236 636 044 9213 636 044 8278 613 179 3958 613 183 0349 613 201 3048 636 045 5641 636 051 6243 636 070 7788 645 045 7654 645 002 7079 409 495 7400 613 200 9324 613 200 9331 613 200 9348 411 163 1504 411 122 1309 412 046 4704 411 129 5102 411 158 9409 411 002 5908 411 063 1307 411 001 9006 412 057 3802 411 030 7202 DESCRIPTION ARM ARMREST SPRING PLATE PIPE EARTH DEC PLATE SPRING PLATE LID SHIELD TAPE EMC-SX591 ASSY,LENS OPTICAL FILTER IC ICX409AK-A ,IC101 COMPL PWB,CA-1 COMPL PWB,CA-2 COMPL PWB,CA-3 SCR SET 2X5 SCR BIN 3X6 SPECIAL SCREW-3.0X8.0 SCR PAN+SW+W 2X5 SCR PAN PCS 2.6X6 SCR PAN 2.6X4 SCR SET HEX-SCT 2.6X4 SCR BIN 3X8 SPECIAL WASHER 43X0.2 SCR BIN 2X6 NJ515 NJ510 5016 5015 NJ620 6035 5016 5017 NJ515 5016 NJ600 NJ506 NJ620 NJ600 NJ600 5010 CA2 NJ620 NJ600 CA3 6021 6027 NJ506 5005 6022 6030 6023 NJ630 NJ615 NJ615 6028 NJ635 6050 6020 6030 6006 6005 NJ615 NJ635 6023 NJ630 CA1 6007 6013 6012 8002 6014 6011 6010 8001 NJ640 6015 NJ625 8000 CH-L5AR2/XE(MS) 5 ELECTRICAL PARTS Note: 1. Materials of Capacitors and Resistors are abbreviated as follows ; Resistors Capacitors MT-FILM Metallized Film Resistor MT-POLYEST MT-GLAZE Metallized Glaze Resistor MT-COMPO OXIDE-MT Oxide Metallized Film Resistor TA-SOLID AL-SOLID NP-ELECT OS-SOLID 2. 3. 4. 5. Metallized Polyester Capacitor Metallized Composite Capacitor Tantalum Solid Capacitor Aluminum Solid Capacitor Non-Polarized Electrolytic Capacitor Aluminum Solid Capacitors with Organic Semiconductive Electrolytic Capacitor DL-ELECT Double Layered Electrolytic Capacitor Tolerance of Capacitor (10pF over) and Resistor are noted with follow symboles. F ............1% G ............2% J ............5% K ............10% M ..........20% N ..........30% Z ..........+80% ~ -20% Capacitors P : pF U : µF Inductors MH : mH UH : µH N.S.P. : Not available as service parts. LOCATION PARTS NO. DESCRIPTION COMPL PWB,CA-1 613 200 9324 Q1011 Q1012 405 045 8200 405 079 6302 IC102 IC103 IC104 409 446 8708 409 525 5901 409 427 7805 D1001 D1011 407 113 5609 407 113 5609 L1011 L1101 L1102 L1103 L1201 645 043 5881 645 043 5881 645 043 5881 645 043 5881 645 018 9326 C1001 C1002 C1003 C1004 C1005 C1011 C1012 C1013 C1014 C1015 C1016 C1101 C1102 C1103 C1104 C1105 C1106 C1107 C1108 C1111 C1112 C1113 C1114 C1115 C1116 C1117 C1118 C1119 C1120 403 346 2309 403 285 6406 403 381 4702 403 164 0204 403 164 0204 403 155 1807 403 311 7605 403 155 1807 403 376 6902 403 164 0204 403 346 2309 403 285 6802 403 346 2309 403 285 6802 403 346 2309 403 346 2309 403 346 2309 403 346 2309 403 164 0204 403 285 6802 403 346 2309 403 346 2309 403 346 2309 403 346 2309 403 346 2309 403 346 2309 403 283 6309 403 283 6309 403 346 2309 R1001 R1002 R1011 R1012 401 224 8900 401 225 0903 401 225 1504 401 224 9600 (SEMICONDUCTORS) TR 2SK443-6-TB TR 2SC4399-5 (INTEGRATED CIRCUITS) IC CXD3400N IC AD9848AKST IC TC74ACT32FT (DIODES) DIODE DSH015 DIODE DSH015 (INDUCTORS) INDUCTOR,10U J INDUCTOR,10U J INDUCTOR,10U J INDUCTOR,10U J INDUCTOR,1000 OHM (CAPACITORS) CERAMIC 0.1U K 10V TA-SOLID 1U M 35V ELECT 22U M 16V CERAMIC 0.1U Z 25V CERAMIC 0.1U Z 25V CERAMIC 0.01U K 25V CERAMIC 2200P K 50V CERAMIC 0.01U K 25V TA-SOLID 3.3U M 25V CERAMIC 0.1U Z 25V CERAMIC 0.1U K 10V TA-SOLID 10U M 6.3V CERAMIC 0.1U K 10V TA-SOLID 10U M 6.3V CERAMIC 0.1U K 10V CERAMIC 0.1U K 10V CERAMIC 0.1U K 10V CERAMIC 0.1U K 10V CERAMIC 0.1U Z 25V TA-SOLID 10U M 6.3V CERAMIC 0.1U K 10V CERAMIC 0.1U K 10V CERAMIC 0.1U K 10V CERAMIC 0.1U K 10V CERAMIC 0.1U K 10V CERAMIC 0.1U K 10V CERAMIC 1U Z 10V CERAMIC 1U Z 10V CERAMIC 0.1U K 10V (RESISTORS) MT-GLAZE 100K JA 1/16W MT-GLAZE 82K JA 1/16W MT-GLAZE 3.9K JA 1/16W MT-GLAZE 2.7K JA 1/16W LOCATION R1013 R1014 R1015 R1016 R1017 R1031 R1032 R1033 R1034 R1035 R1101 R1102 R1103 R1104 R1105 R1106 R1107 R1108 R1109 R1110 R1111 PARTS NO. 401 224 9402 401 224 8900 401 225 8107 401 225 8107 401 224 8801 401 226 1503 401 226 1503 401 226 1503 401 226 1503 401 226 1503 401 225 8107 401 224 8801 401 224 8801 401 224 8801 401 224 8801 401 224 8801 401 224 8801 401 224 8801 401 224 8801 401 224 8801 401 224 8801 CN101 CN102 CN121 645 060 3129 645 060 3112 645 023 0578 DESCRIPTION MT-GLAZE 1.0M JA 1/16W MT-GLAZE 100K JA 1/16W MT-GLAZE 10 JA 1/16W MT-GLAZE 10 JA 1/16W MT-GLAZE 100 JA 1/16W MT-GLAZE 0.000 ZA 1/16W MT-GLAZE 0.000 ZA 1/16W MT-GLAZE 0.000 ZA 1/16W MT-GLAZE 0.000 ZA 1/16W MT-GLAZE 0.000 ZA 1/16W MT-GLAZE 10 JA 1/16W MT-GLAZE 100 JA 1/16W MT-GLAZE 100 JA 1/16W MT-GLAZE 100 JA 1/16W MT-GLAZE 100 JA 1/16W MT-GLAZE 100 JA 1/16W MT-GLAZE 100 JA 1/16W MT-GLAZE 100 JA 1/16W MT-GLAZE 100 JA 1/16W MT-GLAZE 100 JA 1/16W MT-GLAZE 100 JA 1/16W (CONNECTORS) SOCKET,FFC 30P (N.S.P) SOCKET,FFC 24P (N.S.P) PLUG,4P (N.S.P) COMPL PWB,CA-2 613 200 9331 6 Q2121 Q2152 Q2154 Q2161 Q2165 Q2227 Q2231 Q2232 Q2233 Q2234 Q2236 Q2237 Q2401 Q2501 Q2511 Q2512 Q2521 Q2541 OR Q2561 405 014 4509 405 137 2000 405 092 4101 405 092 4101 405 137 2000 405 137 2000 405 137 2000 405 092 4101 405 137 2000 405 092 4101 405 092 4101 405 092 4101 405 129 7808 405 131 4505 405 133 8907 405 133 8907 405 169 1101 405 128 9605 405 035 5905 405 141 0603 IC201 IC213 410 388 5106 409 246 9707 (SEMICONDUCTORS) TR 2SC2412K-R TR 2SA1576A-R TR 2SC4081-R TR 2SC4081-R TR 2SA1576A-R TR 2SA1576A-R TR 2SA1576A-R TR 2SC4081-R TR 2SA1576A-R TR 2SC4081-R TR 2SC4081-R TR 2SC4081-R TR UMG2N TR 2SD1767Q TR DTC114EUA TR DTC114EUA TR 2SK3617 TR 2SC2411K-Q TR 2SC2411K-R TR 2SA1037AK-R (INTEGRATED CIRCUITS) IC SCC0020 IC LA6358NM LOCATION IC227 IC235 IC238 IC239 IC241 IC242 IC243 IC251 IC253 IC254 IC255 IC256 PARTS NO. 409 475 2005 409 246 9707 409 320 9104 409 323 9002 410 494 0606 409 541 4803 409 479 2803 409 506 8907 409 528 1405 409 528 1405 409 531 8507 409 521 3703 D2223 D2224 D2304 D2401 D2501 D2503 D2511 D2512 D2521 D2531 D2533 D2541 OR D2551 D2561 OR D2562 407 206 5400 407 206 5400 407 151 0406 407 113 5609 407 103 0409 407 218 7409 407 208 9703 407 173 1108 407 231 0005 407 231 0005 407 207 7700 407 226 3905 407 199 4909 407 167 3101 407 226 3905 407 199 4909 407 218 7706 X2001 X2301 X2401 645 036 9872 645 007 6947 645 046 1415 VR244 OR 645 000 0232 645 017 2922 CT232 645 051 7655 L2001 L2002 L2003 L2011 L2012 L2013 L2121 L2221 L2236 L2241 L2301 L2302 L2401 L2531 L2541 L2551 L2561 645 043 5881 645 043 5881 645 043 5881 645 018 9326 645 018 9326 645 018 9326 645 043 5881 645 043 5881 645 043 7380 645 055 3134 645 043 5881 645 043 5898 645 043 5881 645 052 4264 645 050 7489 645 052 4264 645 050 7489 T2521 645 053 8223 C2001 C2002 C2003 C2004 C2005 C2006 C2007 C2008 C2009 C2010 C2011 C2012 C2013 C2014 C2015 C2016 C2120 C2121 403 285 6802 403 346 2309 403 346 2309 403 346 2309 403 346 2309 403 346 2309 403 285 6802 403 346 2309 403 285 6802 403 346 2309 403 346 2309 403 346 2309 403 285 6802 403 346 2309 403 346 2309 403 346 2309 403 382 1908 403 164 0204 DESCRIPTION IC BA7664FV IC LA6358NM IC TC7SU04FU IC TC7S04FU IC MB90F654APFV-G IC BD4829G IC BR24C04F-W IC FA7700V IC TLV431ASNT1 IC TLV431ASNT1 IC MC78L12ABD IC BA00BC0WF (DIODES) ZENER DIODE UDZS8.2B ZENER DIODE UDZS8.2B VARACTOR DI HVU200A DIODE DSH015 DIODE DBB08C ZENER DIODE UDZS15B ZENER DIODE UDZS5.6B PHOTO COUPLE TLP181-GB DIODE 1SR159-200 DIODE 1SR159-200 ZENER DIODE PTZ3.9B DIODE RSD376 DIODE 1SS376 DIODE D1FS6 DIODE RSD376 DIODE 1SS376 ZENER DIODE UDZS20B-TE17 (OSCILLATORS) OSC,CRYSTAL 17.73447MHZ OSC,CRYSTAL 28.375KHZ OSC,CERAMIC 4.00MHZ (VARIABLE RESISTORS) VR,SEMI,10K S VR,SEMI,10K S (TRIMMER) TRIMMER,30PF (INDUCTORS) INDUCTOR,10U J INDUCTOR,10U J INDUCTOR,10U J INDUCTOR,1000 OHM INDUCTOR,1000 OHM INDUCTOR,1000 OHM INDUCTOR,10U J INDUCTOR,10U J INDUCTOR,33U J INDUCTOR,68U J INDUCTOR,10U J INDUCTOR,47U J INDUCTOR,10U J INDUCTOR,100U N INDUCTOR,100U K INDUCTOR,100U N INDUCTOR,100U K (TRANSFORMER) TRANS,POWER,PULSE (CAPACITORS) TA-SOLID 10U M 6.3V CERAMIC 0.1U K 10V CERAMIC 0.1U K 10V CERAMIC 0.1U K 10V CERAMIC 0.1U K 10V CERAMIC 0.1U K 10V TA-SOLID 10U M 6.3V CERAMIC 0.1U K 10V TA-SOLID 10U M 6.3V CERAMIC 0.1U K 10V CERAMIC 0.1U K 10V CERAMIC 0.1U K 10V TA-SOLID 10U M 6.3V CERAMIC 0.1U K 10V CERAMIC 0.1U K 10V CERAMIC 0.1U K 10V ELECT 47U M 16V CERAMIC 0.1U Z 25V 7 LOCATION C2122 C2123 C2124 C2126 C2133 C2134 C2161 C2162 C2224 C2225 C2227 C2231 C2245 C2246 C2247 C2253 C2254 C2255 C2256 C2257 C2258 C2259 C2263 C2268 C2283 C2308 C2309 C2310 C2311 C2313 C2315 C2316 C2317 C2327 C2331 C2332 C2333 C2402 C2403 C2404 C2405 C2406 C2500 C2501 C2504 C2505 C2506 C2509 C2510 C2511 C2512 C2514 C2521 C2522 C2525 C2532 C2534 C2535 C2536 C2542 C2543 C2544 C2545 C2546 C2547 C2552 C2553 C2554 C2555 C2562 C2563 C2564 C2565 PARTS NO. 403 381 4702 403 164 0204 403 164 0204 403 383 7602 403 346 2309 403 285 6802 403 285 3504 403 285 7809 403 285 7700 403 382 5807 403 382 5807 403 346 2309 403 311 7506 403 317 2307 403 311 3409 403 311 7506 403 311 7506 403 305 0001 403 384 8905 403 382 5807 403 382 1809 403 285 4006 403 285 5003 403 346 2309 403 311 3409 403 311 3409 403 311 3409 403 346 2309 403 285 5003 403 384 5201 403 346 2309 403 346 2309 403 285 3603 403 285 3603 403 346 2309 403 311 4505 403 311 4505 403 285 6802 403 346 2309 403 346 2309 403 346 2309 403 285 6802 403 379 7104 403 377 2804 403 070 0909 403 381 4603 403 298 9609 403 379 7104 403 379 7104 403 372 4506 403 189 0807 403 325 6304 403 376 9309 403 379 2703 403 357 3302 403 333 3609 403 333 3609 403 189 0807 403 298 9609 403 372 4506 403 372 4506 403 298 9609 403 189 0807 403 372 4506 403 189 0807 403 333 3609 403 333 3609 403 298 9609 403 333 3609 403 372 4506 403 372 4506 403 372 4506 403 298 9609 R2001 R2002 R2011 R2012 401 226 1503 401 224 8801 401 226 1503 401 226 1503 DESCRIPTION ELECT 22U M 16V CERAMIC 0.1U Z 25V CERAMIC 0.1U Z 25V NP-ELECT 0.47U M 50V CERAMIC 0.1U K 10V TA-SOLID 10U M 6.3V TA-SOLID 3.3U M 6.3V TA-SOLID 0.47U M 35V TA-SOLID 10U M 16V ELECT 100U M 10V ELECT 100U M 10V CERAMIC 0.1U K 10V CERAMIC 22P J 50V CERAMIC 20P J 50V CERAMIC 0.01U K 16V CERAMIC 22P J 50V CERAMIC 22P J 50V TA-SOLID 10U M 10V ELECT 220U M 25V ELECT 100U M 10V ELECT 47U M 6.3V TA-SOLID 4.7U M 10V TA-SOLID 1U M 25V CERAMIC 0.1U K 10V CERAMIC 0.01U K 16V CERAMIC 0.01U K 16V CERAMIC 0.01U K 16V CERAMIC 0.1U K 10V TA-SOLID 1U M 25V NP-ELECT 4.7U M 16V CERAMIC 0.1U K 10V CERAMIC 0.1U K 10V TA-SOLID 4.7U M 6.3V TA-SOLID 4.7U M 6.3V CERAMIC 0.1U K 10V CERAMIC 1000P K 50V CERAMIC 1000P K 50V TA-SOLID 10U M 6.3V CERAMIC 0.1U K 10V CERAMIC 0.1U K 10V CERAMIC 0.1U K 10V TA-SOLID 10U M 6.3V CERAMIC 1000P K 630V ELECT 470U M 50V CERAMIC 0.1U K 50V ELECT 22U M 35V CERAMIC 0.1U K 16V CERAMIC 1000P K 630V CERAMIC 1000P K 630V CERAMIC 2.2U K 25V CERAMIC 0.1U K 25V CERAMIC 0.22U K 10V CERAMIC 0.047U K 250V CERAMIC 470P J 200V CERAMIC 0.01U K 630V POS-SOLID 33U M 10V POS-SOLID 33U M 10V CERAMIC 0.1U K 25V CERAMIC 0.1U K 16V CERAMIC 2.2U K 25V CERAMIC 2.2U K 25V CERAMIC 0.1U K 16V CERAMIC 0.1U K 25V CERAMIC 2.2U K 25V CERAMIC 0.1U K 25V POS-SOLID 33U M 10V POS-SOLID 33U M 10V CERAMIC 0.1U K 16V POS-SOLID 33U M 10V CERAMIC 2.2U K 25V CERAMIC 2.2U K 25V CERAMIC 2.2U K 25V CERAMIC 0.1U K 16V (RESISTORS) MT-GLAZE 0.000 ZA 1/16W MT-GLAZE 100 JA 1/16W MT-GLAZE 0.000 ZA 1/16W MT-GLAZE 0.000 ZA 1/16W LOCATION R2013 R2014 R2015 R2016 R2017 R2018 R2019 R2121 R2122 R2123 R2124 R2125 R2126 R2131 R2132 R2136 R2150 R2151 R2153 R2155 R2156 R2161 R2162 R2164 R2165 R2168 R2170 R2224 R2226 R2227 R2228 R2232 R2233 R2234 R2235 R2237 R2239 R2240 R2242 R2243 R2244 R2246 R2248 R2249 R2250 R2251 R2252 R2253 R2256 R2284 R2286 R2311 R2312 R2313 R2314 R2315 R2316 R2317 R2336 R2339 R2340 R2341 R2401 R2402 R2403 R2404 R2405 R2406 R2407 R2412 R2414 R2416 R2417 R2418 R2423 R2424 R2426 R2431 PARTS NO. 401 226 1503 401 226 1503 401 226 1503 401 226 1503 401 226 1503 401 226 1503 401 226 1503 401 038 6307 401 038 6307 401 038 6307 401 224 9402 401 225 0507 401 225 0705 401 225 0606 401 225 0101 401 225 8107 401 224 8900 401 225 1207 401 224 9303 401 225 1207 401 225 1207 401 225 1207 401 224 9303 401 225 1207 401 224 9303 401 224 8900 401 224 8900 401 261 9601 401 261 9601 401 225 1603 401 225 1603 401 224 9303 401 224 9303 401 224 9907 401 225 0507 401 224 9303 401 224 9303 401 225 0200 401 225 3805 401 225 1405 401 225 1405 401 224 9303 401 224 9105 401 224 9105 401 225 0507 401 224 9907 401 224 9303 401 225 2006 401 225 3805 401 224 9402 401 226 1503 401 224 9006 401 224 8900 401 225 1207 401 229 3900 401 225 1207 401 225 1207 401 224 9808 401 234 4800 401 224 9006 401 224 8900 401 224 9402 401 226 1503 401 224 9006 401 225 1207 401 224 9006 401 224 9006 401 224 9006 401 224 9006 401 226 1503 401 226 1503 401 226 1503 401 226 1503 401 226 1503 401 226 1503 401 226 1503 401 037 5004 401 224 9006 DESCRIPTION MT-GLAZE 0.000 ZA 1/16W MT-GLAZE 0.000 ZA 1/16W MT-GLAZE 0.000 ZA 1/16W MT-GLAZE 0.000 ZA 1/16W MT-GLAZE 0.000 ZA 1/16W MT-GLAZE 0.000 ZA 1/16W MT-GLAZE 0.000 ZA 1/16W MT-GLAZE 470 JA 1/10W MT-GLAZE 470 JA 1/10W MT-GLAZE 470 JA 1/10W MT-GLAZE 1.0M JA 1/16W MT-GLAZE 33K JA 1/16W MT-GLAZE 56K JA 1/16W MT-GLAZE 5.6K JA 1/16W MT-GLAZE 27K JA 1/16W MT-GLAZE 10 JA 1/16W MT-GLAZE 100K JA 1/16W MT-GLAZE 4.7K JA 1/16W MT-GLAZE 1K JA 1/16W MT-GLAZE 4.7K JA 1/16W MT-GLAZE 4.7K JA 1/16W MT-GLAZE 4.7K JA 1/16W MT-GLAZE 1K JA 1/16W MT-GLAZE 4.7K JA 1/16W MT-GLAZE 1K JA 1/16W MT-GLAZE 100K JA 1/16W MT-GLAZE 100K JA 1/16W MT-FILM 68 DD 1/16W MT-FILM 68 DD 1/16W MT-GLAZE 390 JA 1/16W MT-GLAZE 390 JA 1/16W MT-GLAZE 1K JA 1/16W MT-GLAZE 1K JA 1/16W MT-GLAZE 22K JA 1/16W MT-GLAZE 33K JA 1/16W MT-GLAZE 1K JA 1/16W MT-GLAZE 1K JA 1/16W MT-GLAZE 3.3K JA 1/16W MT-GLAZE 1.5K JA 1/16W MT-GLAZE 47K JA 1/16W MT-GLAZE 47K JA 1/16W MT-GLAZE 1K JA 1/16W MT-GLAZE 150 JA 1/16W MT-GLAZE 150 JA 1/16W MT-GLAZE 33K JA 1/16W MT-GLAZE 22K JA 1/16W MT-GLAZE 1K JA 1/16W MT-GLAZE 680 JA 1/16W MT-GLAZE 1.5K JA 1/16W MT-GLAZE 1.0M JA 1/16W MT-GLAZE 0.000 ZA 1/16W MT-GLAZE 10K JA 1/16W MT-GLAZE 100K JA 1/16W MT-GLAZE 4.7K JA 1/16W MT-GLAZE 180 JA 1/16W MT-GLAZE 4.7K JA 1/16W MT-GLAZE 4.7K JA 1/16W MT-GLAZE 220K JA 1/16W MT-GLAZE 3.3 JA 1/16W MT-GLAZE 10K JA 1/16W MT-GLAZE 100K JA 1/16W MT-GLAZE 1.0M JA 1/16W MT-GLAZE 0.000 ZA 1/16W MT-GLAZE 10K JA 1/16W MT-GLAZE 4.7K JA 1/16W MT-GLAZE 10K JA 1/16W MT-GLAZE 10K JA 1/16W MT-GLAZE 10K JA 1/16W MT-GLAZE 10K JA 1/16W MT-GLAZE 0.000 ZA 1/16W MT-GLAZE 0.000 ZA 1/16W MT-GLAZE 0.000 ZA 1/16W MT-GLAZE 0.000 ZA 1/16W MT-GLAZE 0.000 ZA 1/16W MT-GLAZE 0.000 ZA 1/16W MT-GLAZE 0.000 ZA 1/16W MT-GLAZE 0.000 ZA 1/10W MT-GLAZE 10K JA 1/16W LOCATION R2432 R2433 R2435 R2436 R2437 R2438 R2439 R2443 R2445 R2446 R2501 R2502 R2511 R2512 R2513 R2514 R2516 R2521 R2522 R2523 R2531 R2533 R2534 R2535 R2536 R2537 R2541 R2542 R2543 R2544 R2545 R2551 R2552 R2553 R2561 R2562 R2752 PARTS NO. 401 224 9006 401 224 9006 401 226 1503 401 226 1503 401 226 1503 401 224 9006 401 226 1503 401 226 1503 401 224 8900 401 226 1503 401 225 0200 401 240 9707 401 224 9907 401 261 8109 401 226 1503 401 224 9501 401 224 8801 401 302 7207 401 225 0309 401 225 0200 401 225 1801 401 226 5501 401 261 5306 401 261 4309 401 225 8107 401 261 5108 401 225 0200 401 226 2401 401 261 5108 401 261 2602 401 261 5108 401 261 5108 401 261 4101 401 261 5900 401 225 0200 401 224 9303 401 226 1503 F2301 645 006 3404 F2501 423 030 0800 CN201 CN202 CN211 CN241 CN251 645 060 3129 645 060 3112 645 003 2387 645 002 3057 645 026 6911 DESCRIPTION MT-GLAZE 10K JA 1/16W MT-GLAZE 10K JA 1/16W MT-GLAZE 0.000 ZA 1/16W MT-GLAZE 0.000 ZA 1/16W MT-GLAZE 0.000 ZA 1/16W MT-GLAZE 10K JA 1/16W MT-GLAZE 0.000 ZA 1/16W MT-GLAZE 0.000 ZA 1/16W MT-GLAZE 100K JA 1/16W MT-GLAZE 0.000 ZA 1/16W MT-GLAZE 3.3K JA 1/16W MT-GLAZE 820K JA 1/16W MT-GLAZE 22K JA 1/16W MT-FILM 33K DD 1/16W MT-GLAZE 0.000 ZA 1/16W MT-GLAZE 2.2K JA 1/16W MT-GLAZE 100 JA 1/16W MT-FILM 330 JE 1W MT-GLAZE 33 JA 1/16W MT-GLAZE 3.3K JA 1/16W MT-GLAZE 47 JA 1/16W MT-GLAZE 120 JA 1/16W MT-FILM 470 DU 1/16W MT-FILM 1.2K DU 1/16W MT-GLAZE 10 JA 1/16W MT-FILM 1.0K DU 1/16W MT-GLAZE 3.3K JA 1/16W MT-GLAZE 560 JA 1/16W MT-FILM 1.0K DU 1/16W MT-FILM 10K DU 1/16W MT-FILM 1.0K DU 1/16W MT-FILM 1.0K DU 1/16W MT-FILM 2.7K DU 1/16W MT-FILM 330 DU 1/16W MT-GLAZE 3.3K JA 1/16W MT-GLAZE 1K JA 1/16W MT-GLAZE 0.000 ZA 1/16W (FILTER) FILTER,EMI 470PF (FUSE) FUSE 125V 2A (CONNECTORS) SOCKET,FFC 30P (N.S.P) SOCKET,FFC 24P (N.S.P) PLUG,2P (N.S.P) PLUG,7P (N.S.P) PLUG,3P (N.S.P) COMPL PWB,CA-3 613 200 9348 D3001 D3002 407 206 5400 407 206 5400 VR301 VR302 VR303 645 005 5805 645 005 5805 645 005 5805 S3001 645 004 1532 CN302 645 002 3071 (DIODES) ZENER DIODE UDZS8.2B ZENER DIODE UDZS8.2B (VARIABLE RESISTORS) VR,SEMI,10K S VR,SEMI,10K S VR,SEMI,10K S (SWITCH) SWITCH,DIP 1P-1TX3, MODE (CONNECTORS) PLUG,9P (N.S.P) FLEXIBLE FLAT CABLES W0001 W0002 8 645 060 2177 645 063 4291 FLEXIBLE FLAT CABLE,CN101-CN201 FLEXIBLE FLAT CABLE,CN102-CN202 CIRCUIT DIAGRAMS & PRINTED WIRING BOARDS TABLE OF CONTENTS OVERALL WIRING, BLOCK DIAGRAM & CIRCUIT DIAGRAMS OVERALL WIRING C3 OVERALL CIRCUIT BLOCK DIAGRAM C4 IC101 & IC102 BLOCK DIAGRAMS CA-1 CIRCUIT C5 CA-1 CIRCUIT WAVEFORMS C6 IC103 & IC104 BLOCK DIAGRAMS CA-2 CIRCUIT WAVEFORMS CA-2 CIRCUIT C7 CA-3 CIRCUIT C12 PRINTED WIRING BOARDS (P.W.B.) CA-1 BOARD (SIDE A & B) C12 CA-3 BOARD (SIDE A & B) CA-2 BOARD (SIDE A) C13 CA-2 BOARD (SIDE B) C14 C1 NOTES: 1. All resistance values in "OHMS" unless otherwise noted. (K=1,000 ; M=1,000,000) 2. All capacitance values in "µF" unless otherwise noted. p=pico farad ; µ ,u or U=micro farad 3. All inductance values in "µH" unless otherwise noted. µ ,u or U=micro henry ; m=milli henry PRODUCT SAFETY NOTICE THE COMPONENTS DESIGNATED BY A SYMBOL ( ) IN THIS SCHEMATIC DIAGRAM DESIGNATES COMPONENTS WHOSE VALUE ARE OF SPECIAL SIGNIFICANCE TO PRODUCT SAFETY. SHOULD ANY COMPONENT DESIGNATED BY A SYMBOL NEED TO BE REPLACED, USE ONLY THE PART DESIGNATED IN THE PARTS LIST. DO NOT DEVIATE FROM THE RESISTANCE, WATTAGE AND VOLTAGE RATINGS SHOWN. EXPLANATORY NOTES (EXAMPLES) Resistor 10K:1/16J means 10kilo ohm ±5%, 1/16watt max. 1M:1/10K means 1mega ohm ±10%, 1/10watt max. Capacitor 0.047:F means 0.047micro farad, Ftype. Electrolytic capacitor 10:16 means 10micro farad, 16volt max. Inductor 330:J means 330micro henry ±5% 470:K means 470micro henry ±10% No description J or K means ±5% PAL-C-EX C2 OVERALL WIRING, BLOCK DIAGRAM & CIRCUIT DIAGRAMS K K OVERALL WIRING CA-1 J CN101 GND GND 5V 5V CCD0 CCD1 CCD2 CCD3 CCD4 CCD5 CCD6 CCD7 CCD8 CCD9 GND GND GND AGC_CS AGC_CLK AGC_DATA VD ADCK CLP 3.3V 3.3V 3.3V 3.3V GND GND GND CCD & IRIS I H G F CN121 1 2 3 4 BLAKE+ BLAKEDRIVEDRIVE+ TO LENS CA-2 CA-3 MAIN PROCESS, MICON & POWER SW & VR J CN201 1 FFC 30 2 29 3 28 4 27 5 26 6 25 7 24 8 23 9 22 10 21 11 20 12 19 13 18 14 17 15 16 16 15 17 14 18 13 19 12 20 11 21 10 22 9 23 8 24 7 25 6 26 5 27 4 28 3 29 2 30 1 GND GND 5V 5V CCD0 CCD1 CCD2 CCD3 CCD4 CCD5 CCD6 CCD7 CCD8 CCD9 GND GND GND AGC_CS AGC_CLK AGC_DATA VD ADCK CLP 3.3V 3.3V 3.3V 3.3V GND GND GND I W2003 AWB/MWB BLC OFF BLC LEVEL MANUAL R MANUAL B 3.3V GND MONITOR AP CN302 1 WIRE 1 2 2 3 3 4 4 5 5 6 6 7 7 8 8 9 9 AWB/MWB BLC OFF BLC LEVEL MANUAL R MANUAL B 3.3V GND MONITOR AP H G F W1-04715/L5AR2-XE CN102 E GND GND 15V 15V 15V V1 V2 V3 V4 VSUB GND GND GND GND XSG1 XSG2 -7V -7V -7V IRIS BLAKEIRIS DRIVE+ IRIS BLAKE+ GND GND D C B 1 FFC 24 2 23 3 22 4 21 5 20 6 19 7 18 8 17 9 16 10 15 11 14 12 13 13 12 14 11 15 10 16 9 17 8 18 7 19 6 20 5 21 4 22 3 23 2 24 1 CN202 CN211 GND GND 15V 15V 15V V1 V2 V3 V4 VSUB GND GND GND GND XSG1 XSG2 -7V -7V -7V IRIS BLAKEIRIS DRIVE+ IRIS BLAKE+ GND GND VIDEO OUT GND E 1 2 CN251 AC24V/DC+ FG AC24V/DC- D 1 2 3 C CN241 3.3V GND RS232IN MD0 RS232OUT RESET MD2 1 2 3 4 5 B 6 7 A A 1 2 3 4 5 6 7 8 9 10 11 C3 12 13 14 15 16 17 18 19 K K OVERALL CIRCUIT BLOCK DIAGRAM VOUT VGG GND 1 2 3 4 VSS V V V V IC101 BLOCK DIAGRAM (ICX409AK) J 8 7 6 5 4 3 2 1 I Cy G Cy Mg G Mg Ye Mg Ye G Cy G Cy I Ye V REGISTER Cy Cy V REGISTER V REGISTER V REGISTER H Mg Ye J Mg G Ye Mg Ye G (NOTE) H 16 2 VL 15 H SUB (NOTE 14 1 GND G 13 H 12 1 11 LH 10 RG 9 VDD H REGISTER : PHOTO SENSOR) F G F IC102 BLOCK DIAGRAM (CXD3400N) VDD E 20 SHT 1 Input Buffer XSHT 2 19 V3B XV3 3 18 VL XSG3B 4 17 V3A XSG3A 5 16 V1B XV1 6 15 VH XSG1B 7 14 V1A XSG1A 8 13 V4 XV4 9 12 V2 XV2 10 11 GND D E D C B C B CXD3400N A A 1 2 3 4 5 6 7 8 9 10 11 C4 12 13 14 15 16 17 18 19 CA-1 CIRCUIT K K CN102 B XSG3A V1B 16 6 XV1 7 XSG1B V1A 14 8 XSG1A V4 13 9 XV4 V2 12 10 XV2 GND 11 R1032 0 1608 C1004 0.1;F 7 8 3 1608 C1011 0.01;B R1012 2.7K VDD R1014 100K D1011 DSH015 CT-B2 C1014 3.3;25-T 14.5 C1013 0.01;B 13.2 -7.0 C1012 2200P L1103 10;J L1102 10;J R1013 1M G CT-A C1111 10;6.3-T 1.5 9 C1108 0.1;F 1608 3.24 1608 0.1;B C1117 AGCCS 2 C1118 C1119 1 C1114 0.1;B C1113 0.1;B C1112 0.1;B 1608 1;F L1101 10;J 1;F C1116 0.1;B C1115 0.1;B 24 4.0 R1034 0 4.3 16 15 14 13 12 11 10 22 H R1011 3.9K 6 CCD 21 23 Q1012 2SC4399 9.9 5 NC 4 1608 20 H2 R1002 82K 19 3 VOUT ICX409AK-A 18 2 NC IC101 17 1 GND V,SUB DRIVER VSUB XSG2 -0.2 XSG1 16 V1 15 0.1 GND V2 I Q1011 2SK443AJ6 VL V4 14 C1001 0.1;B 13 3.0 RG 3.2 XSG1 VH 15 -6.7 0.1 11 12 L1011 10;J 5 CE-C -0.2 V1 40 CLPDM DVDD1 21 2 41 HBLK 3 42 PBLK 21 VD 22 ADCK 23 CLP D7 1608 C1015 0.1;F CT-A 5.0 R1035 0 C1016 0.1;B D6 C1103 10;6.3-T D5 4.0 2.4 D9 DVDD2 10 11 12 D8 DVSS2 9 8 3Y 9 3A 2Y 6 10 3B 2B 5 11 4Y 2A 4 12 4A 1Y 3 13 4B 1B 2 14 VCC 1A 1 GND 7 E IC104 D C ADCK 100 100 100 100 R1108 R1109 R1110 R1111 H DRIVER CCD9 100 R1107 CCD8 AGCDATA 8 CCD7 20 7 CCD6 AGCCS 6 CCD5 17 AGCCLK 5 C1102 0.1;B 16 19 4 2.6 C1104 0.1;B TC74ACT32FT 15 18 D4 CCD9 D3 14 3 100 CCD8 2 R1106 CCD7 13 1 CCD4 12 H1 13 CCD3 CCD6 48 NC 100 11 H2 14 R1105 CCD5 DVSS0 15 47 NC D2 10 46 DVDD3 D1 CCD4 DVDD0 16 D0 9 C1120 0.1;B 45 DVSS3 100 CCD3 4.3 H4 18 H3 17 100 CCD2 8 RG 20 DVSS1 19 CDS,AGC,A/D R1104 7 44 HD 100 CCD1 43 VD R1103 6 VD CLP CT-A CCD0 C1101 10;6.3-T 5 IC103 AD9848A C1105 0.1;B F R1017 100 1 10 23 AVSS0 22 R1016 CL1 39 CLPOB 4 C1106 0.1;B AVDD0 24 38 SCK 10 AVSS1 AVDD1 BYP1 BYP2 CCDIN BYP3 AVDD2 C1107 0.1;B R1015 37 SDI AVSS2 SL L1201 A102S R1101 10 AGCDATA CMLEVEL 36 35 34 33 32 31 30 29 28 27 26 25 4 CCD0 C V3A 17 0.0 V2 XSG2 AGCCLK D XSG3B C1003 22;16 V3 V4 VSUB CN101 E 4 CT-B2 NC 9 10 TO LENS GND GND 5V 5V CCD0 CCD1 CCD2 CCD3 CCD4 CCD5 CCD6 CCD7 CCD8 CCD9 GND GND GND AGC CS AGC CLK AGC DATA VD ADCK CLP 3.3V 3.3V 3.3V 3.3V GND GND GND VL 18 3.0 R1102 F V3B 19 XV3 J H1 V3 XSHT 3 R1001 100K -6.7 8 2 1.5 C1002 1;35-T V4 V3 SHT 20 R1033 0 VSUB V2 VDD 1608 V1 7 1 C1005 0.1;F 6 CN121 BLAKE+ BLAKEDRIVEDRIVE+ 3.3 5 TO CA-2 CN202 G CXD3400N R1031 0 4 REFB H D1001 DSH015 IC102 3 CCD2 I 2 REFT J 1 CCD1 GND GND 15V 15V 15V V1 V2 V3 V4 VSUB GND GND GND GND XSG1 XSG2 -7V -7V -7V IRIS BLAKEIRIS DRIVE+ IRIS BLAKE+ GND GND 24 25 26 B 27 28 CA-1 29 30 C1-04715/L5AR2-XE TO CA-2 CN201 A A 1 2 3 4 5 6 7 8 9 10 11 C5 12 13 14 15 16 17 18 19 K K CA-1 CIRCUIT WAVEFORMS TEST POINT LOCATION IC103 BLOCK DIAGRAM (AD9848A) TEST POINT LOCATION WAVEFORM IC104 BLOCK DIAGRAM (TC74ACT32FT) WAVEFORM J IC101-1 IC101-15 35 VREF 2 to 36 dB 2V/div 10 or 12 CCDIN 50ns/div H1 V4 29 CDS PxGA VGA CLAMP RG IC101-16 IC101-2 H 34 AD9848 4–6 dB 2V/div 20µs/div I J REFT REFB H1-H4 CLAMP INTERNAL CLOCKS 20 13 PRECISION TIMING TM CORE HORIZONTAL DRIVERS 14 1-5 8-12 DOUT CCD0-9 39 CLPOB ADC 40 CLPDM 42 PBLK 23 CL1 I H 17 18 20µs/div V3 G H2 44 43 HD VD 36 38 37 SL SCK SDATA G IC103-29 IC101-3 F INTERNAL REGISTERS SYNC GENERATOR 2V/div 50ns/div 5V/div 5V/div 20µs/div 0.5V/div 10µs/div V2 CCD IN F CA-2 CIRCUIT WAVEFORMS TEST POINT LOCATION TEST POINT LOCATION WAVEFORM WAVEFORM E E IC101-4 D IC103-43 5V/div 2V/div 20µs/div V1 20µs/div VD B 1V/div 200mV/div 10µs/div 5ms/div VD YA OUT 2V/div 2V/div 50ns/div RG 10ms/div HD D IC201-79 IC201-42 IC103-44 IC101-13 C IC201-47 IC201-55 C 200mV/div 10µs/div 1V/div 50ns/div CA OUT ADCK B WF-CA1-L5AR2XE WF-CA2-L5AR2XE A A 1 2 3 4 5 6 7 8 9 10 11 C6 12 13 14 15 16 17 18 19 CA-2 CIRCUIT K K D2531 1SR159-200 C2536 0.1 C2534 33;10-U C2501 470;50 C2535 0.1 * TLV431 5 R2537 1K (0.5%) R2521 330 4 J 5 * 8 * * * 12V L2221 10;J 7 8 C2514 0.22 IC256 BA00BC0WF C2246 20P;CH REG. L2241 68;J D2512 TLP181(GB) H 1.7 R2286 0 R2256 1.5K R2251 22K R2253 680 C2257 100;10 C2283 0.01;B CN211 1 (0.5%) CE-D Q2227 2SA1576A(R) 2 I VIDEO OUT GND VIDEO OUT C2227 100;10 CE-D R2226 68 C2268 0.1 (0.5%) MUTEA Vcc 1 -7V L2561 100U * TP221 VIDEO OUT R2224 68 C2225 100;10 Q2234 2SC4081(R) 2.3 Q2233 2SA1576A(R) R2562 1K C2563 2.2 10 R2561 3.3K D2561 1SS376 -7V C2258 CE-C 47;6.3 R2239 1K C2247 0.01;B 2.3 1.7 3 * CT-B2 CE-D 6 R2249 150 C2224 10;16-T CT-A 1.3 5.0 R2243 47K 5 R2551 1K (0.5%) 4 1.9 CE-E C2256 220;25 R2246 1K CTL R2244 47K NC GND 1.5K OUT GND R2242 R2513 0 C2512 0.1 (0.5%) R2512 33K NC C R2240 3.3K 4 VCC C2565 0.1 3 4 C2564 2.2 2 3 D2562 UDZS20B 1 R2514 2.2K FB R2516 100 Q2512 DTC114EUK IN- C2511 2.2 R2511 22K D2511 UDZS5.6B Q2511 DTC114EUK REF 2 R2552 2.7K SWITCHING CONTROL FA7700V RT 1 (0.5%) IC251 C2555 33;10-U GND R2553 330 OUT (0.5%) VCC 5V C2554 0.1 CS * C2553 33;10-U 5 C2552 33;10-U 6 C2562 2.2 I 7 Q2232 2SC4081(R) R2248 150 2.2 3 8 2.8 Q2237 2SC4081(R) C2263 1;25-T 3.1 Q2236 2SC4081(R) D2223 UDZS8.2B L2551 100U C2253 22P;CH D2551 D1FS6 C2254 22P;CH * +6.5V L2236 33;J C2245 22P;CH * 9 VIN1 C2255 10;10-T CT-A R2228 390 4 5 2.0 D2224 UDZS8.2B Q2231 2SA1576A(R) 1.4 * R2252 1K 5V 3 R2237 1K R2250 33K 8 CT-A VIN 7 C2259 4.7;10-T GND 6 R2234 22K GND 5 R2233 1K R2543 1K (0.5%) (0.5%) C2545 0.1 NC R2227 390 TLV431 GND 4 NC R2284 1M R2523 3.3K C2506 0.1 3 GND R2235 33K REG. IC254 2 GND C2547 0.1 R2522 33 C2544 0.1 1 VOUT R2545 1K (0.5%) 1 * R2544 10K * 3 15V REG. Q2541 2SC2411 R2541 3.3K 2 C2505 22;35 C2543 2.2 * C2546 2.2 * * 2 Q2521 2SK3617 R2502 820K 7 1 D2503 UDZS15B Q2501 2SD1767 IC255 MC78L12AB R2232 1K +15V VIN2 L2541 100U R2542 560 R2501 3.3K D2541 1SS376 C2542 2.2 ~ - C2510 1000P * C2521 0.047 2 3 4 C2522 470P 3 C2509 1000P * REG. IC253 4 * D2521 1SR159-200 2 R2533 120 2 C2504 0.1 J 1 C2500 1000P AC24V/DC+ FG AC24V/DC- C2532 33;10-U * D2501 DBB08C ~ + 1 3 F2501 2A DC60V/AC125V CN251 R2536 10 D2512 1 R2535 1.2K CEE156 D2533 PTZ3.9B R2531 47 R2534 470 3.3V L2531 100U * (0.5%) 6 (0.5%) +3.3V T2521 2.0 Q2561 2SA1037K 2.0 C2525 0.01 2 YIN 3 GND 4 CIN 8 OUT1 7 OUT2 6 MUTEB 5 1.0 0.9 H IC227 BA7664FV YC-MIX,75DRIVER VD AGND 41 3 B 85 PBLK 8 86 VCC1 3.3V 6 V1 R2013 0 87 V1 V2 R2014 0 88 V2 IC201 SCC0020 CAMERA ASIC C 4 0 0 0 R2416 R2414 R2412 R2424 0 0 R2417 BLC1 0 R2418 R2423 WB 0 10K R2431 0 10K R2432 0 10K 0 R2435 R2433 10K SIMOP0 SIMOP1 NTSC/PAL SIMOP2 VARIOP ATW/MTW BLC MODE1 BLC MODE0 AI/EI INT/LL(ES/FL) APERTURENOR/SHP MOTOR+ RESERVE VIDEO(D/A) MOTOR- SHUTTER0 C/BW LEVEL SHUTTER1 SHUTTER2 AGC ON/OFF EXT-C EXT-BW GAMMA CTL RESETIN C 5 79 VSS MD0 47 80 X IN FLD 46 FLD 81 X OUT VDO 45 VD 82 VDD 44 83 DB0 43 84 DB1 42 DB2 85 DB2 GND 40 DB3 86 DB3 GND2 39 DB4 87 DB4 VCC2 38 DB5 88 DB5 DB6 89 DB6 DB7 90 DB7 0 89 V3 R2016 0 90 V4 EXTSCI 36 R2017 0 91 XSG1 ADJSCI 35 91 35 2 XSG2 R2018 0 92 XSG2 SCI 34 92 34 1 VSUB R2019 0 93 VSUB SCO 33 GND2 32 PLLCTL2 X2001 17.734475MHZ L2001 10;J 1 2 3 4 5 6 E2PROM DATA PLLCTL1 AGC CS 99 100 AGC CLK 2 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 VCC OUT GND 1 VDD 28 AGC DATA VCC ZCS DB7 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 DB6 9 DB5 8 DB4 7 DB3 6 CPUCK 5 SMC 4 DB2 3 DB1 2 DB0 GND 1 ALE PCOVD R2446 0 27 E2PROM 26 CLK E W2003 WB 1 BLC1 2 REFI 3 WBR 4 WBB 5 6 3.3V R2001 0 7 8 9 AP AGCCS AGCCLK AGCDATA 232O 232I ZRD ZWR ALE DB7 DB6 DB5 DB4 DB3 DB2 DB1 14 DB0 C2003 0.1;B 3.3V ALE VSUB PCOHD 15 SCK V4 VRST 16 HRST V3 GND 17 CKI2 V2 CT-A V1 18 C2001 10;6.3-T 19 CKI1 20 VCC INH 30 98 VSS 26 3 VSS 29 RS232C OUT 27 GND 4 31 97 RS232C IN GND 32 ZWR 99 GND 100 GND 15V 21 33 IRIS VCA IRIS REF OUT VSS 28 WBR 96 ZRD GND2 WBB MANU WB R 36 95 ALE 98 VCC1 F ADJUSTMENT REFI MANU WB B 37 94 C2004 0.1;B 29 MICON 93 R2002 100 L2002 10;J C2005 0.1;B VCC2 ZWR 22 97 RG ZWR 23 30 ZRD C2016 0.1;B 24 CKSCO 31 CKSCI CT-A R2015 V4 96 H2 7 38 V3 95 H1 6 R2443 0 VSS 40 XSG1 94 GND 5 3.3V GND RS232IN MD0 RS232OUT RESET MD2 LLPHASE 39 IRIS REF IN 3 PCOSC 37 4 232O BLCLEVEL 41 IC241 * 4 5 3 R2407 10K 2 E X2 CAOUT 42 GND 1 B X1 43 Q2401 UMG2N R2752 0 C2015 0.1;B 9 R2437 CT-A C2402 10;6.3-T D2401 DSH015 R2402 10K CT-A C2009 10;6.3-T C2010 0.1;B VCC GND GND AVDD YAOUT GND GND AGND AMC TEB TMC2 BUNRI TMC1 ZRST CCDI0 CCDI1 AVDD 84 CLPOB 7 R2403 4.7K CCD0 CCD1 CCD2 CCD3 CCD4 CCD5 83 CLP AWB/MWB BLC OFF BLC LEVEL MANUAL R MANUAL B 3.3V GND MONITOR AP TO CA-3 CN302 13 D 11 10 XSG1 9 XSG2 8 L2401 10;J R2405 10K R2404 10K 12 3.3V -7V 2 1 1 2 VCC 4 R2316 4.7K R2314 180 R2312 100K 1 A0 VCC 8 2 A1 TEST 7 3 A2 SCL 6 4 GND SDA 5 R2311 10K EEPROM 6 5 GND C2404 0.1;B BR24C04F-W 3.3V C2315 0.1;B C2316 0.1;B CT-A IC243 L2302 47;J 8 7 3 TO CA-1 CN102 F2301 470P C2317 4.7;6.3-T LA6358NM 12V C2308 0.01;B A102S L2301 10;J C C2309 0.01;B L2013 IC235 C2310 0.1;B A102S CT-A A102S L2012 R2313 4.7K 3 L2011 4.7K 4 C2313 4.7/16 NP-B 5 R2317 220K 6 C2311 1;25-T 7 R2315 C 44 232I VR244 10K 10 FLD 45 GND 2 MD1 48 R2445 100K 0 VD 46 GND 82 GND 1 3.3V R2406 10K MD2 49 CT-A R2012 47 FLD 81 SHP 3 CN241 TEST 50 VSS C2405 0.1;B AGCDATA VD 80 SHD LSI RESET 78 C2406 10;6.3-T 11 79 ADCK 2 C2403 0.1;B AGCCLK 76 77 1 DB1 AGCCS 12 DB0 14 48 TEST C2008 0.1;B 0 50 CSYNC 49 ZRD D GND 77 GND X2401 4MHz C2006 0.1;B 15 13 R2439 0 C2007 10;6.3-T R2011 G 75 74 73 72 71 70 69 68 67 66 65 64 63 62 61 60 59 58 57 56 55 54 53 52 51 78 VCC1 CN202 GND GND 15V 15V 15V V1 V2 V3 V4 VSUB GND GND GND GND XSG1 XSG2 -7V -7V -7V IRIS BLAKEIRIS DRIVE+ IRIS BLAKE+ GND GND 3.3V 76 GND C2014 0.1;B 16 TO CA-1 CN101 E CCDI2 CCD9 CCDI3 CCD8 17 CCD6 18 CCDI4 CCD7 CCD7 CCD6 19 CCDI5 CCD5 20 CCD8 21 R2426 0 V SW RESET 75 74 73 72 71 70 69 68 67 66 65 64 63 62 61 60 59 58 57 56 55 54 53 52 51 CCDI6 CCD4 VCC CCD3 22 CCDI8 CCD2 23 CCDI7 24 AP IC242 BD4829G L2003 10;J C2011 0.1;B CCDI9 CCD1 CT-A CCD0 25 3 C2012 0.1;B 26 CCD9 27 2 R2436 R2401 0 1 5V VCC F 28 4 OUT VCC GND 29 C2002 0.1;B G 5 30 C2013 10;6.3-T GND GND 5V 5V CCD0 CCD1 CCD2 CCD3 CCD4 CCD5 CCD6 CCD7 CCD8 CCD9 GND GND GND AGC_CS AGC_CLK AGC_DATA VD ADCK CLP 3.3V 3.3V 3.3V 3.3V GND GND GND R2438 CN201 28MHZ VCO LPF L2121 10;J R2136 10 CE-D 1 4 VCC R2341 1M GND 4 5 IC239 Q2121 2SC2412(R) TC7S04FU X2301 CT-A C2134 10;6.3-T R2126 56K R2131 5.6K R2153 1K 5 GND IRIS DRIVE 4 R2156 4.7K Q2152 2SA1576A B C2162 0.47;35-T BUFFER R2121 470 R2122 470 R2123 470 R2124 C2126 0.47/50 NP-B C2-04715/L5AR2-XE R2168 100K R2165 1K Q2161 2SC4081(R) C2231 0.1 C2161 3.3;6.3-T CA-2 1M 100K R2170 CT232 30P 28.63636MHZ R2164 4.7K C2333 1000P;B 6 2 28MHZ R2340 100K 7 R2132 27K C2123 0.1;F 8 3 R2161 4.7K GND 3 D2304 HVU200A C2332 1000P;B R2339 10K VCC 2 R2162 1K 3 28MHZ PLL B CT-A 5 1608 VCC 2 TP232 1 1608 1 C2124 0.1;F 28MHZ OSC R2125 33K LA6358NM R2155 4.7K IC238 TC7SU04FU C2327 4.7;6.3-T C2331 0.1;B R2336 3.3 C2133 0.1;B Q2154 2SC4081 IC213 R2150 100K 3.3V R2151 4.7K 1608 C2122 22;16 C2121 0.1;F 12V TP201 GND Q2165 2SA1576A A A 1 2 3 4 5 6 7 8 9 10 11 C7 12 13 14 15 16 17 18 19 CA-2 CIRCUIT [UPPER-LEFT] K K D2531 1SR159-200 C2536 0.1 CEE156 D2512 1 C2534 33;10-U C2535 0.1 R2537 1K (0.5%) * TLV431 5 5 * 8 * * * 12V Q2231 2SA1576A(R) 1.4 5 2.0 L2551 100U 8 IC256 C2514 0.22 BA00BC0WF R2551 1K (0.5%) REG. 20P;CH L2241 68;J C2247 0.01;B 10 D2512 TLP181(GB) F 2.3 Q2233 2SA1576A(R) R2562 1K R2561 3.3K D2561 1SS376 -7V * 1.7 R2286 0 G C2257 100;10 C2283 0.01;B C2268 0.1 -7V L2561 100U * Q2234 2SC4081(R) 2.3 1.7 3 4 R2251 22K R2253 680 5.0 C2246 CE-D CTL 7 H CT-A R2246 1K NC GND 6 R2243 47K OUT GND 1.5K NC C 5 R2240 3.3K VCC D2562 UDZS20B 4 C2564 2.2 3 C2565 0.1 R2513 0 C2512 0.1 (0.5%) R2512 33K R2514 2.2K 4 C2563 2.2 Q2512 DTC114EUK 3 R2516 100 Q2511 DTC114EUK 2 FB C2511 2.2 1 IN- C2562 2.2 R2511 22K D2511 UDZS5.6B G REF 2 (0.5%) SWITCHING CONTROL FA7700V RT 1 R2249 150 C2258 CE-C 47;6.3 5V IC251 1.9 CE-E C2256 220;25 1.3 R2239 1K * C2555 33;10-U GND (0.5%) OUT R2552 2.7K VCC R2553 330 CS C2554 0.1 5 C2553 33;10-U 6 C2552 33;10-U 7 Q2237 2SC4081(R) C2263 1;25-T 3.1 Q2236 2SC4081(R) Q2232 2SC4081(R) R2248 150 2.2 3 8 2.8 R2244 47K +6.5V C2255 10;10-T CT-A C2254 22P;CH D2551 D1FS6 C2253 22P;CH * L2236 33;J C2245 22P;CH * 9 VIN1 R2237 1K R2284 1M 4 R2252 1K 8 R2250 33K 7 CT-A 6 * R2234 22K 5 3 C2259 4.7;10-T 4 R2233 1K R2543 1K (0.5%) (0.5%) C2545 0.1 VIN R2256 1.5K TLV431 GND C2506 0.1 NC GND R2235 33K REG. IC254 R2523 3.3K R2544 10K C2544 0.1 3 GND GND R2242 R2522 33 1 2 GND NC C2547 0.1 * 1 VOUT R2545 1K (0.5%) 3 R2541 3.3K * C2505 22;35 C2543 2.2 * 2 I 15V REG. Q2541 2SC2411 C2546 2.2 * * 2 Q2521 2SK3617 R2502 820K MC78L12AB 7 1 D2503 UDZS15B Q2501 2SD1767 H VIN2 IC255 L2541 100U R2542 560 R2501 3.3K D2541 1SS376 +15V C2542 2.2 I 4 ~ - C2510 1000P C2509 1000P * R2521 330 2 3 4 D2521 1SR159-200 3 REG. IC253 4 * C2522 470P 2 J * C2521 0.047 C2500 1000P 1 R2533 120 2 C2504 0.1 CN251 AC24V/DC+ FG AC24V/DC- C2501 470;50 F2501 2A DC60V/AC125V C2532 33;10-U * D2501 DBB08C ~ + 1 3 R2232 1K J D2533 PTZ3.9B (0.5%) R2536 10 R2531 47 (0.5%) 3.3V L2531 100U * T2521 R2534 470 6 R2535 1.2K +3.3V MUTEA Vcc 1 2.0 Q2561 2SA1037K 2.0 C2525 0.01 8 2 YIN OUT1 7 3 GND OUT2 6 4 CIN MUTEB 5 1.0 F 0.9 IC227 BA7664FV YC-MIX,75DRIVER E E VD CN201 1 13 AGCCS 12 AGCCLK R2012 AGCDATA 11 0 C2015 0.1;B 9 8 CT-A C2402 10;6.3-T D2401 DSH015 R2402 10K CT-A C2009 10;6.3-T C2010 0.1;B FLD 46 FLD 81 SHP GND 45 82 GND GND 44 83 CLP AVDD 43 1 B CAOUT 42 2 E AGND 41 3 B 86 VCC1 GND V2 R2014 0 88 V2 5 V3 R2015 0 89 V3 V4 R2016 0 90 V4 6 7 CAMERA ASIC 9 11 C8 3 7 7 8 8 C 5 84 8 DB3 8 GND2 39 DB4 8 VCC2 38 DB5 8 DB6 8 DB7 9 36 12 13 14 15 16 17 B 83 40 PCOSC 37 10 2 DB2 EXTSCI 8 1 8 Q2401 UMG2N 85 PBLK IC201 SCC0020 X2 80 SHD GND VD 7 7 X1 47 6 5 VCC VD 87 V1 4 GND 79 ADCK 0 3 GND 48 R2013 4 AVDD AGND YAOUT GND GND AMC BUNRI TEB TMC2 TMC1 ZRST CCDI0 CCDI1 CCDI2 TEST V1 3.3V 7 R2403 4.7K CCD0 CCD1 CCD2 CCD3 CCD4 78 VCC1 84 CLPOB 10 2 49 C2403 0.1;B 14 50 CSYNC C 4 DB1 0 GND 77 GND DB0 R2011 15 76 GND CT-A 16 C X2401 4MHz C2008 0.1;B C2014 0.1;B CCDI3 CCD9 CCD5 CCD8 17 CCDI4 18 CCD6 CCD7 D RESET 75 74 73 72 71 70 69 68 67 66 65 64 63 62 61 60 59 58 57 56 55 54 53 52 51 CCDI5 19 CCD7 CCD6 CCDI6 CCD5 20 CCD8 CCD4 21 CCDI7 CCD3 22 CCD9 CCD2 23 CCDI8 24 3.3V C2011 0.1;B VCC CCD1 CT-A CCD0 25 3 C2012 0.1;B 26 2 IC242 BD4829G L2003 10;J C2007 10;6.3-T A 27 C2006 0.1;B B 1 5V 28 4 OUT VCC GND 29 CCDI9 C 30 C2013 10;6.3-T D R2401 0 5 GND GND 5V 5V CCD0 CCD1 CCD2 CCD3 CCD4 CCD5 CCD6 CCD7 CCD8 CCD9 GND GND GND AGC_CS AGC_CLK AGC_DATA VD ADCK CLP 3.3V 3.3V 3.3V 3.3V 18 19 A CA-2 CIRCUIT [UPPER-RIGHT] K K C2536 0.1 D2533 PTZ3.9B (0.5%) R2536 10 J R2537 1K (0.5%) J (0.5%) 3.3V 12V IC255 MC78L12AB 4 5V R2237 1K L2236 33;J C2255 10;10-T CT-A 2.8 C2245 22P;CH 1.9 CE-E C2256 220;25 CT-B2 1 C2225 100;10 (0.5%) CE-D 2 VIDEO OUT GND VIDEO OUT R2228 390 C2257 100;10 C2283 0.01;B R2246 1K 1.5K R2244 47K R2562 1K 1.7 R2286 0 R2227 390 Q2234 2SC4081(R) 2.3 Q2233 2SA1576A(R) C2565 0.1 C2247 0.01;B Q2227 2SA1576A(R) CE-D 20P;CH 2.3 R2242 1.7 R2243 47K R2240 3.3K D2562 UDZS20B C2564 2.2 G L2241 68;J CN211 R2224 68 5.0 C2246 H TP221 VIDEO OUT R2251 22K R2253 680 C2258 CE-C 47;6.3 R2239 1K C2254 22P;CH C2253 22P;CH R2249 150 C2224 10;16-T CT-A 1.3 2.2 5V Q2237 2SC4081(R) C2263 1;25-T 3.1 Q2236 2SC4081(R) Q2232 2SC4081(R) R2248 150 D2224 UDZS8.2B H 2.0 D2223 UDZS8.2B Q2231 2SA1576A(R) 1.4 R2284 1M 8 R2256 1.5K 7 R2252 1K 6 R2250 33K 5 CT-A VIN C2259 4.7;10-T 3 R2234 22K NC GND R2235 33K GND GND R2233 1K 2 GND NC L2221 10;J C2547 0.1 1 VOUT I 15V REG. R2232 1K I G C2227 100;10 CE-D R2226 68 C2268 0.1 (0.5%) 2.0 Q2561 2SA1037K F MUTEA Vcc 1 -7V 2.0 8 2 YIN OUT1 7 3 GND OUT2 6 4 CIN MUTEB 5 1.0 F 0.9 IC227 BA7664FV YC-MIX,75DRIVER E E VD 0 R2412 R2414 0 R2416 R2417 BLC1 0 R2423 R2439 0 R2418 10K WB 10K R2431 0 10K 0 R2432 0 R2435 R2433 0 CT-A C2402 10;6.3-T D2401 DSH015 R2403 4.7K R2402 10K CT-A C2009 10;6.3-T D RESET L2003 10;J 3.3V 0 0 BD4829G 3 R2436 2 10K 1 R2426 0 V SW R2437 D AP IC242 R2424 0 4 R2438 R2401 0 5 OUT VCC GND 3 C2403 0.1;B C2008 0.1;B B 1 B C 5 2 E 1 CT-A C2007 10;6.3-T C2006 0.1;B A DB1 C 4 DB0 3 B 2 3 4 5 6 7 NTSC/PAL SIMOP0 SIMOP1 SIMOP2 VARIOP BLC MODE1 ATW/MTW BLC MODE0 AI/EI INT/LL(ES/FL) VIDEO(D/A) MOTOR+ RESERVE MOTOR- C/BW LEVEL SHUTTER0 SHUTTER1 SHUTTER2 AGC ON/OFF GAMMA CTL C CN241 TEST 50 VSS MD1 48 79 VSS MD0 47 80 X IN FLD 46 FLD 81 X OUT VDO 45 VD 82 VDD 44 83 DB0 43 84 DB1 42 DB2 85 DB2 BLCLEVEL 41 DB3 86 DB3 DB4 87 DB4 DB5 88 DB5 DB6 89 DB6 DB7 90 DB7 8 2 232I 78 3.3V GND RS232IN MD0 RS232OUT RESET MD2 1 3.3V R2406 10K MD2 49 3 4 232O 5 6 R2407 10K X2 2 APERTURENOR/SHP GND 1 FLD Q2401 UMG2N LSI RESET 77 X1 VD 76 EXT-C RESETIN X2401 4MHz EXT-BW 75 74 73 72 71 70 69 68 67 66 65 64 63 62 61 60 59 58 57 56 55 54 53 52 51 C 7 B ADJUSTMENT R2443 0 REFI VSS 40 IC241 * LLPHASE 39 IRIS REF IN MICON 9 10 11 C9 12 38 MANU WB B 37 WBB MANU WB R 36 WBR 13 A 14 15 16 17 18 19 14 13 AGCCS 12 AGCCLK R2012 AGCDATA 11 0 C2015 0.1;B 9 8 VCC VD 47 VD 80 SHD FLD 46 FLD 81 SHP GND 45 82 GND GND 44 83 CLP AVDD 43 1 B 1 2 3 78 79 80 Q2401 UMG2N CAOUT 42 2 E 85 PBLK AGND 41 3 B 86 VCC1 GND IC201 SCC0020 77 X2 GND GND AVDD YAOUT GND AGND GND AMC TEB BUNRI TMC2 TMC1 ZRST CCDI0 CCDI1 CCDI2 CCDI3 CCDI4 CCDI5 79 ADCK 81 82 C 5 84 DB2 85 40 DB3 86 GND2 39 DB4 87 VCC2 38 DB5 88 DB6 89 DB7 90 C 4 V2 R2014 0 88 V2 5 V3 R2015 0 89 V3 V4 R2016 0 90 V4 EXTSCI 36 XSG1 R2017 0 91 XSG1 ADJSCI 35 91 2 XSG2 R2018 0 92 XSG2 SCI 34 92 1 VSUB R2019 0 93 VSUB SCO 33 93 94 GND GND2 32 30 97 RG VCC2 29 98 VCC1 GND2 28 99 GND GND 27 100 GND GND 26 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 ZCS C2007 10;6.3-T C2006 0.1;B CT-A 3 VCC INH OUT GND 1 2 H 99 100 X2001 G C2003 0.1;B DB7 DB6 DB5 DB4 DB3 DB2 VSUB 14 DB1 15 98 4 R2001 0 DB0 V4 96 17.734475MHZ L2001 10;J ALE 16 95 3.3V ZWR V3 ZRD V2 17 R2002 100 97 VCC 8 DB7 7 DB6 GND 6 DB5 PCOVD 5 DB4 PCOHD 4 DB3 SCK 3 CPUCK VRST 2 SMC HRST 18 CT-A V1 C2001 10;6.3-T 19 DB2 GND 1 20 DB1 CKI2 21 CKI1 15V 22 L2002 10;J C2005 0.1;B CKSCI I 94 C2004 0.1;B 96 H2 DB0 23 CKSCO 31 ALE C2016 0.1;B 24 95 H1 ZWR 3 ZRD 4 PCOSC 37 DB1 6 DB0 87 V1 CAMERA ASIC J 83 0 13 12 11 10 XSG1 9 XSG2 L2401 10;J F 3.3V -7V 1 2 7 3 6 TO CA-1 CN102 4 VCC GND L2302 47;J 3.3V C2315 0.1;B C2316 0.1;B CT-A LA6358NM 1 C2317 4.7;6.3-T A102S 2 F2301 470P C2308 0.01;B L2013 IC235 CT-A A102S 12V E 8 R2316 4.7K 5 R2314 180 R2312 100K R2311 10K C2309 0.01;B 3 L2012 L2301 10;J R2313 4.7K 4 A102S R2315 5 L2011 R2317 220K 6 C2310 0.1;B 7 4.7K 8 C2313 4.7/16 NP-B E 48 C2311 1;25-T F TEST R2013 CN202 G 78 VCC1 76 V1 3.3V 7 GND GND 15V 15V 15V V1 V2 V3 V4 VSUB GND GND GND GND XSG1 XSG2 -7V -7V -7V IRIS BLAKEIRIS DRIVE+ IRIS BLAKE+ GND GND 49 84 CLPOB 10 TO CA-1 CN101 H 50 CSYNC GND 0 GND 77 GND X1 R2011 15 76 GND C2403 0.1;B 16 K X2401 4MHz C2008 0.1;B C2014 0.1;B CCDI7 CCD9 CCDI6 CCD8 17 CCDI8 18 VCC CCD7 VCC I CCD6 19 C2002 0.1;B J 20 CCDI9 CA-2 CIRCUIT [LOWER-LEFT] CCD5 CCD6 CCD7 CCD8 CCD9 GND GND GND AGC_CS AGC_CLK AGC_DATA VD ADCK CLP 3.3V 3.3V 3.3V 3.3V GND GND GND K 28MHZ VCO LPF L2121 10;J D CE-D 1608 C2122 22;16 C2121 0.1;F 12V D IC238 VCC 3 1 GND 4 3 R2341 1M 5 6 4 GND IRIS DRIVE 4 C Q2121 2SC2412(R) TC7S04FU X2301 5 GND IC239 C2162 0.47;35-T BUFFER 28MHZ 28.63636MHZ CT232 30P C2333 1000P;B D2304 HVU200A C2332 1000P;B B R2340 100K VCC 2 28MHZ PLL R2339 10K CT-A 5 R2121 470 R2122 470 R2123 470 R2124 C2126 0.47/50 NP-B Q2161 2SC4081(R) C2231 0.1 C2161 3.3;6.3-T CA-2 1M C2-04715/L5AR2-XE A B R2161 4.7K 3 TP232 7 1608 1 2 C R2132 27K C2123 0.1;F 8 R2162 1K 28MHZ OSC VCC 2 1608 TC7SU04FU 1 C2124 0.1;F R2336 3.3 C2327 4.7;6.3-T C2331 0.1;B IC213 LA6358NM A 1 2 3 4 5 6 7 8 9 10 11 C10 12 13 14 15 16 17 18 19 SIMOP0 NTSC/PAL SIMOP1 SIMOP2 VARIOP BLC MODE1 BLC MODE0 AI/EI ATW/MTW INT/LL(ES/FL) VIDEO(D/A) MOTOR+ RESERVE MOTOR- C/BW LEVEL SHUTTER1 SHUTTER0 SHUTTER2 AGC ON/OFF EXT-C MD1 48 VSS MD0 47 80 X IN FLD 46 FLD 81 X OUT VDO 45 VD 82 VDD 44 83 DB0 43 84 DB1 42 DB2 85 DB2 BLCLEVEL 41 DB3 86 DB3 DB4 87 DB4 DB5 88 DB5 DB6 89 DB6 DB7 90 DB7 L2002 10;J IRIS REF IN MICON WBR 34 93 33 ADJUSTMENT I 32 95 IRIS VCA 31 96 IRIS REF OUT 30 R2446 0 VSS 29 W2003 VDD 28 PLLCTL2 E2PROM 26 CLK 1 2 3 4 5 6 7 8 9 AGC CS VCC VSS RS232C IN X2001 17.734475MHZ E2PROM DATA 100 AGC CLK 27 AGC DATA PLLCTL1 RS232C OUT 99 ZWR 2 R2407 10K WBB 92 VSS OUT GND 1 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 WB 1 BLC1 2 REFI 3 WBR 4 WBB 5 6 3.3V G 7 9 AP AGCCS AGCCLK AWB/MWB BLC OFF BLC LEVEL MANUAL R MANUAL B 3.3V GND MONITOR AP R2404 10K L2401 10;J F 1 A0 VCC 8 2 A1 TEST 7 3 A2 SCL 6 4 GND SDA 5 R2311 10K C2404 0.1;B BR24C04F-W 3.3V C2315 0.1;B C2316 0.1;B CT-A C2317 4.7;6.3-T C2308 0.01;B IC243 L2302 47;J E EEPROM C2309 0.01;B E G TO CA-3 CN302 3.3V F2301 470P H R2405 10K AGCDATA 232O 232I ZWR ZRD ALE 8 F J REFI MANU WB R 36 35 ZRD VCC INH 7 38 91 ALE C2005 0.1;B 3 6 R2443 0 MANU WB B 37 98 4 5 LLPHASE 39 97 C2004 0.1;B H 4 232O 3.3V GND RS232IN MD0 RS232OUT RESET MD2 VSS 40 IC241 * 94 R2002 100 3 232I R2752 0 CT-A C2007 10;6.3-T C2006 0.1;B I DB1 C 4 DB0 3 B VSS 79 VR244 10K 2 E 78 2 R2445 100K C 5 1 3.3V R2406 10K MD2 49 CT-A 1 B TEST 50 C2406 10;6.3-T X2 C2403 0.1;B C2008 0.1;B Q2401 UMG2N K CN241 C2405 0.1;B GND 3 APERTURENOR/SH X1 2 FLD J LSI RESET 77 1 VD 76 GAMMA CTL RESETIN X2401 4MHz EXT-BW CA-2 CIRCUIT [LOWER-RIGHT] K L2121 10;J R2136 10 CE-D 4 2 4 R2341 1M GND 5 CT-A C2134 10;6.3-T C2133 0.1;B R2126 56K Q2152 2SA1576A C Q2121 2SC2412(R) TC7S04FU R2155 4.7K 6 GND IRIS DRIVE 4 IC239 X2301 C2162 0.47;35-T BUFFER 28MHZ CT232 30P 28.63636MHZ R2121 470 R2122 470 R2123 470 R2124 C2126 0.47/50 R2165 1K Q2161 2SC4081(R) NP-B C2231 0.1 C2161 3.3;6.3-T B 1M R2168 100K B 100K R2170 D2304 HVU200A 5 R2164 4.7K GND VCC R2131 5.6K 3 1 3 C2333 1000P;B CT-A 5 R2161 4.7K VCC R2153 1K 7 R2162 1K 1 R2156 4.7K R2132 27K C2123 0.1;F 8 1608 3 R2340 100K VCC 2 2 C 1 D 1608 28MHZ OSC R2125 33K LA6358NM C2124 0.1;F TC7SU04FU C2327 4.7;6.3-T C2331 0.1;B IC238 R2150 100K 1608 Q2154 2SC4081 IC213 R2336 3.3 TP201 GND 3.3V R2151 4.7K D C2122 22;16 C2121 0.1;F 12V Q2165 2SA1576A A A 1 2 3 4 5 6 7 8 9 10 11 C11 12 13 14 15 16 17 18 19 PRINTED WIRING BOARDS (P.W.B.) K K CA-1 BOARD (SIDE B) 23 CN121 VR302 10K RED 6 7 VR303 10K BLUE F 8 9 D3002 UDZS8.2B D3001 UDZS8.2B G R1108 C1011 R1016 L1101 C1101 R1015 D1011 C1015 29 25 Q1012 R1018 R1011 R1019 5 37 40 15 IC103 48 1 L1103 + IC103 C1108 C1118 C1014 C1013 C1119 C1004 D1001 C1001 R1017 9 R1014 24 20 H 13 12 C1102 R1104 10 CN101 R1105 R1107 R1109 TO CA-2 W2003 30 R1111 G F GND TP302 E L5AR2/XE L5AR2/JP L5AR2/US L5AR1/JP D3001 D3002 L5AR2/XE L5AR2/JP L5AR2/US L5AR1/JP MONITOR TP301 VR302 VR303 B BLC MWBVR302 VR303 RED AWB D MONITOR TP301 CN302 C3-04715/L5AR2-XE 2 10 CA-3 BOARD (SIDE B) CA-3 BOARD (SIDE A) CA-3 20 CN101 GND TP302 E R1001 C1016 L5AR2/XE L5AR2/JP L5AR2/US L5AR1/JP R1102 R1106 R1101 C1003 + C1111 L1102 R1103 IC104 R1035 30 C1103 25 36 CN302 5 16 R1110 4 IC101 + 3 C1104 C1107 C1112 C1113 C1114 C1115 C1116 2 9 10 VR301 10K BLC C1106 C1105 R1034 16 I R1012 C1117 CL115 1 H AWB/MWB BLC OFF BLC LEVEL MANUAL R MANUAL B 3.3V GND MONITOR AP IC101 CL116 Q1011 CL108 CL104 + CN302 1 L5AR2/XE L5AR2/JP L5AR2/US L5AR1/JP CL103 C1012 6 CL102 8 14 5 CL101 AWB L1011 SIDE-B 1 8 4 PWB,CA-1 1AC4B10C1206AA TP302 GND 2 10 R1032 + IC104 MONITOR IC102 11 TP301 1 R1031 C1005 8 MODE I TP100 L1201 C1002 PWB,CA-1 1AC4B10C1206AA SIDE-A 3 R1002 R1033 2 24 20 IC102 7 1 CN121 AP J CN102 20 S3001 BLC CN102 10 MWB TP100 1 4 1 J 1 5 15 C1120 CA-1 BOARD (SIDE A) R1013 CA-3 CIRCUIT 1 C VR304 PWB,CA-3 SIDE-B 1AC4B10C1206CA VR301 VR301 VR304 PWB,CA-3 B BLC 1AC4B10C1206CA S3001 S3001 C D B A A 1 2 3 4 5 6 7 8 9 10 11 C12 12 13 14 15 16 17 18 19 K K CA-2 BOARD (SIDE A) J J C2256 I C2268 C2257 C2258 I C2247 R2252 R2253 R2223 C2225 R2430 H R2443 R2442 Q2227 D2221 R2225 F + C2531 R2516 C2513 R2515 C2511 D2512 C2626 1 CN211 C2523 C C2524 D2511 R2570 R2511 Q2511 R2514 R2513 C2512 R2512 D T2521 C2514 Q2512 1 4 R2502 C2601 C2605 T2521 C2551 1 D2551 IC251 8 5 C2506 C + C2510 C2504 F2501 C2505 C2503 C2507 C2502 F2501 IC251 2A DC60V/AC125V C2501 CN251 C2509 C2500 E W2003 D2531 10 C2541 C2606 + D2541 C2561 C2563 C2604 C2532 L2541 L2561 + D2501 R2628 R2629 7 CN241 1 R2561 D Q2625 D2624 R2627 R2630 R2631R2632 + C2624 Q2624 Q2622 Q2623 D2623 R2624R2623 Q2621 D2622 D2621 C2621 R2126 C2129 R2125 C2623 C2534 Q2127 + L2551 - G C2625 R2626 R2625 C2552 C2527 L5AR2/XE L5AR2/JP L5AR2/US L5AR1/JP R2226 C2533 C2134 C2133 L2551 R2622 C2603 C2542 E L2531 C2562 R2136 2 10 L2531 C2543 20 R2127 R2163 Q2165 C2122 CN201 30 R2128 1 5 Q2152 D2561 29 R2152 R2165 R2164 2 10 15 Q2128 C2305 20 R2156 Q2161 C2313 R2166 C2131 R2131 R2132 CN202 CN202 24 CN201 1 + F 5 R2154 R2155 + 15 R2161 Q2154 R2150R2151 R2153 C2231 23 D2224 D2223 C2622 R2169 C2128 R2170R2168 C2161 R2621 R2224 X2301 G C2227 D2222 C2120 C2126 R2227 R2228 L2241 R2222 5 C2259 R2250 + R2256 Q2237 IC227 8 Q2236 C2224 Q2234 R2242 R2244 R2243 4 R2246 Q2233 C2246 Q2232 R2240 + 1 C2283 R2287 R2286 C2250 R2234 R2248 R2249 R2239 R2015 R2016 R2019 R2018 R2017 C2263 L2221 C2255 R2233 + R2014 R2013 H C2253 C2254 L2236 Q2231 C2245 R2237 R2232 R2235 R2284 + R2251 PWB,CA-2 1AC4B10C1206BA SIDE-A C2526 B B A A 1 2 3 4 5 C13 6 7 8 9 K K CA-2 BOARD (SIDE B) R2411 C2014 L2003 L2012 + C2009 X2001 C2005 X2001 R2162 C2124 C2123 R2313 R2314 R2317 R2315 C2306 R2311 L2013 R2002 C2127 + C2311 R2318 1 C2314 R2334 F C2555 C2565 D2562 D2502 R2562 E R2571 + CN251 C2716 L2301 R2543 R2722 R2723 PWB,CA-2 1AC4B10C1206BA C2564 SIDE-B 8 5 F2502 F2502 D2504 1 C2721 R2732 Q2722 4 2A DC60V/AC125V R2726 R2701 R2501 D C2501 D2503 Q2501 R2521 Q2521 C2522 TP201 TP201 C2312 TP231 IC239 1 IC238 L2121 R2322 R2320 C2319 R2332 C2320 R2301 1 C2325 Q2541 IC256 + R2724 D2521 G L2011 R2321 C2521 C R2124 C2125 1 4 C2554 R2572 IC273 C2525 CN211 Q2121 C2310 1 Q2561 R2533 C2723 C2162 C2307 C2309 C2308 R2341 C2553 Q2703 Q2604 R2608 R2609 R2610 R2612 R2542 C2544 R2728 R2733 C2720 R2730 R2734 R2720 R2721 R2725 C2722 R2316 R2312 IC235 R2545 C2724 + C2608 C2015 VR244 L2001 C2001 C2725 1 C2335 4 R2121 R2122 R2123 H C2121 R2727 R2605 R2604 C2607 R2611 IC236 D2341 IC255 R2729 C2535 R2607 R2606 8 5 C2334 R2553 R2552 5 R2323 IC256 R2551 IC253 C2545 1 R2544 1 IC255 IC254 R2531 R2534 R2532 Q2603 R2541 4 C2536 C2602 1 W2003 D CT232 5 1 TP231 8 R2331 C2333 1 R2536 R2535 L2304 CT232 L2002 IC213 8 X2301 IC213 R2319 C2547 1 C2654 + D2301 C2546 10 E TP232 4 IC265 + C2301 C2324 20 10 D2304 R2657 C2651 R2651 R2652 D2533 C2653 8 Q2602 Q2601 R2602 R2601 L2601 R2338 C2329 C2331 R2337 R2336 L2401 5 C2652 R2603 + 4 Q2304 C2004 R2001 C2003 25 1 C2002 R2731 C2726 C2727 Q2652 Q2651 1 IC265 R2653 L5AR2/XE L5AR2/JP L5AR2/US L5AR1/JP TP232 C2316 C2317 R2654 CN241 F F2301 IC243 + R2656 R2655 7 C2315 26 + Q2303 IC243 + G 5 C2404 30 1 8 C2406 C2007 + C2016 C2318 R2330 R2404 10 25 L2302 20 IC201 90 IC237 26 100 1 1 TP221 Q2401 C2327 1 IC242 C2405 C2008 40 C2006 100 30 R2405 + VR244 R2537 R2403 R2402 R2401 R2446 R2445 TP221 90 C2401 C2402 80 R2751 R2753 R2752 R2444 40 IC241 51 50 76 R2012 R2441 C2332 + R2339 R2342 R2340 C2341 X2401 X2401 80 I C2011 R2011 R2407 R2406 C2403 D2401 TP200 50 C2010 60 75 D2303 60 IC241 76 H TP200 R2415 R2413 R2420 R2416 R2414 R2412 51 IC201 70 C2012 R2333 C2323 C2322 C2321 70 + C2013 D2711 75 R2424 R2425 R2421 R2418 R2417 R2438 R2437 R2436 R2435 R2439 R2434 R2433 R2432 R2423 R2431 R2422 I R2426 AP V SW J + J R2523 C R2522 B B A A 1 2 3 4 5 C14 6 7 8 9 Jun./’03 SANYO Electric Co., Ltd. Osaka, Japan
